Puritan Bennett 560 Ventilator User's Manual - Covidien

More documents

Recommendations

Info

Ventilator Overview Target Operators The ventilator may be operated by: • Respiratory therapists • Doctors • Nurses • Homecare providers • Patient and patient’s families Warning This ventilator must be used only under the responsibility and on the prescription of a doctor. 2.2 Contraindications This ventilator is not for use with anesthetic gases, and is not intended for use as an emergency transport ventilator. 2.3 Operational Use The Puritan Bennett 560 Portable Ventilator uses a micro-turbine to provide ventilatory support to patients. Clinicians may use a variety of interfaces to connect patients to the ventilator: nasal masks or full face masks; endotracheal or tracheotomy tubes. User-selectable ventilation modes are: • Assisted Controlled Volume (V A/C) • Assisted Controlled Pressure (P A/C) • Volume Synchronised Intermittent Mandatory Ventilation (V SIMV) • Pressure Synchronised Intermittent Mandatory Ventilation (P SIMV) • Continuous Positive Airway Pressure (CPAP) • Pressure Support Ventilation with apnea ventilation (PSV/ST) Safety Net Incorporated in the ventilator design is an alarm system that continuously monitors both patient and machine for signs of specific errors or faults that could lead to an unsafe condition. Should any of these errors or faults be detected, the alarm system announces the specific alarm condition both audibly and visually. The machinerelated alarm conditions are factory set, whereas the patient-related alarm conditions are defined by alarmthreshold values selected by an operator (a clinician or a caregiver). For more information, refer to chapter 3, “Alarms and Troubleshooting” Settings A software key, known as the “Locking Key,” restricts access to ventilation parameter settings and ventilation mode changes in order to distinguish between “clinician” usage and “patient” usage. Oxygen Enrichment Oxygen may be supplied from an external, low pressure source, but the oxygen flow must be limited to 15 lpm (50 kPa, 500 mbar). The ventilator automatically compensates for the extra flow created by the external oxygen supply (refer to chapter 4, “Installation and Assembly”) Breathing Circuit The ventilator can be used with a single or double limb patient circuit. If exhaled volume monitoring is required (such as ventilator dependant patients), use the double-limb circuit for exhaled tidal volume monitoring. For more information, refer to section 4.4, “Patient Circuit”. 2-2 User’s Manual
Warning Ventilator Overview Users must always possess an additional breathing circuit and exhalation valve while using the Device name. 2.4 Device Classification The ventilator’s IEC / EN 60601-1classification is as follows: • Protection/Insulation class (electric shock): Class II • Protection index of enclosure: IP31 • Medical device directive classification: II B • Degree of protection against risk of electric shock: BF • Power: External (AC – mains, or DC – cigarette lighter) or internal (DC – battery) • Operation mode: Continuous operation For additional information, refer to section A, “Specifications.” User’s Manual 2-3
Page 1 and 2: User’s Manual Puritan Bennett 560
Page 3 and 4: Contents Purpose of This Manual . .
Page 5 and 6: Contents B Modes of Ventilation . .
Page 7 and 8: Figures SECTION Figure 1-1. Locatio
Page 9 and 10: Tables SECTION Table 1-1. Ventilato
Page 11 and 12: Preface Purpose of This Manual This
Page 13 and 14: Technical Service Contacts: Covidie
Page 15 and 16: 1 Safety Information 1.1 Definition
Page 17 and 18: Safety Information To minimise the
Page 19 and 20: Safety Information The exhalation b
Page 21 and 22: Safety Information Do not conduct t
Page 23 and 24: Safety Information To connect the v
Page 25 and 26: 1.3 Symbols and Markings Table 1-1.
Page 27 and 28: Table 1-1. Ventilator Symbols (Cont
Page 29 and 30: Safety Information 1.4 Labels / Ide
Page 31 and 32: 6 Figure 1-2. Locations of Labels -
Page 33: 2 Ventilator Overview 2.1 Indicatio
Page 37 and 38: 2.6 Back Panel 1 2 3 4 5 6 11 Ergon
Page 39 and 40: 2.8 Ventilation Menu Ventilation me
Page 41 and 42: 1 2.10 Waveforms Menu Ventilator Ov
Page 43 and 44: 3 Alarms and Troubleshooting Warnin
Page 45 and 46: 3.2 Alarm Display During operation,
Page 47 and 48: To dismiss the Alarm Logs screen ma
Page 49 and 50: 3.6 Re-activating Alarms Alarms and
Page 51 and 52: Table 3-1. Overview of Alarms (Cont
Page 57 and 58: 3.8 Troubleshooting Warning Alarms
Page 59 and 60: Table 3-2. Alarms and Corrective Ac
Page 69 and 70: 4 Installation and Assembly Warning
Page 71 and 72: Installation and Assembly that is i
Page 73 and 74: Installation and Assembly Note: An
Page 75 and 76: Installation and Assembly After ass
Page 77 and 78: 11 10 9 8 12 5 7 6 Installation and
Page 79 and 80: 4.5 Filters Warning Installation an
Page 81 and 82: Installation and Assembly water tra
Page 83 and 84: To connect the oxygen supply system
Page 85 and 86:
4.9 Fitting the Ventilator into the
Page 87 and 88:
Installation and Assembly 4.11 Moun
Page 89 and 90:
5 Operating Procedures 5.1 Turning
Page 91 and 92:
To skip the Welcome Menu: • Press
Page 93 and 94:
• The cursor changes to the plus/
Page 95 and 96:
5.3 Starting Ventilation Operating
Page 97 and 98:
Operating Procedures • A new mess
Page 99 and 100:
6 Internal Battery Warning Even tho
Page 101 and 102:
Figure 6-1. Internal Battery Indica
Page 103 and 104:
• The “INTERNAL BATTERY“ indi
Page 105 and 106:
7 Cleaning Warning A patient treate
Page 107 and 108:
8 Routine Maintenance Warning On a
Page 109 and 110:
Warning Routine Maintenance Note: F
Page 111 and 112:
A Specifications A.1 Physical Table
Page 113 and 114:
A.3 Indicators and Alarms Table A-5
Page 115 and 116:
Table A-10. Ventilator Range, Resol
Page 117 and 118:
Table A-10. Ventilator Range, Resol
Page 119 and 120:
A.10 Manufacturer’s Declaration S
Page 121 and 122:
Table A-22. Electromagnetic Immunit
Page 123 and 124:
Table A-24. Compliant Cables and Ac
Page 125 and 126:
B Modes of Ventilation B.1 Modes of
Page 127 and 128:
C Operational Verification Checklis
Page 129 and 130:
D Unpacking and Preparation The Pur
Page 131 and 132:
E Alarms Tests Before connecting th
Page 133 and 134:
Alarms Tests 7. Press and hold the
Page 135 and 136:
F Parts and Accessories Table F-1 p
Page 137 and 138:
G Glossary AC Power Alternating cur
Page 139 and 140:
Fraction of Inspired Oxygen (FIO 2
Page 141 and 142:
Patient Counter Counter of ventilat
Page 143 and 144:
Index A AC power connecting to . .
Page 145 and 146:
Front panel . . . . . . . . . . . .
Page 147 and 148:
mounting on a wheelchair . . . . .
Page 150:
Part No. 10066883 Rev. B 03/2012 CO
show all

Puritan Bennett 560 Ventilator User's Manual - Covidien

Create successful ePaper yourself

Delete template?

Save as template?