4 cylinders + 6 cylinders 4 cylinders + 6 cylinders - Steyr Motors

More documents

Recommendations

Info

ToC 06 ELECTRICAL SYSTEM SERVICE MANUAL MARINE ENGINES 06.01.03 Technical data of alternator For 6 cyl. engines only (old version till eng. no. 68224418) Model ....................................................................................................PRESTOLITE LEECE-Neville .............................................................................................................. 8RG2043 Minimum speed for voltage generation ................................................. 580 1/min Controlled voltage range ....................................................................... 13,9 - 14,2 V Output current ....................................................................................... 90 A Governor ............................................................................................... integrated base governor Charge capacity at 750 r.p.m. .......................................................................................... approx. 34 A at 2500 r.p.m ......................................................................................... maximum charge capacity Condensor capacity .............................................................................. 2,2 µF 01.03 ill.1 Charging circuit - scheme 1 ...... battery 2 ..... Z2, ground connection on engine 3 ..... red 4 ..... fuse 50 A 5 ..... starter engine 6 ..... red 7 ..... plug (engine electrics/instrument cable) 8 ..... fuse 10 A 9 ..... starter key lock 10 ..... 15000-xx 11 ..... red 16 mm² 12 ..... generator 13 ..... charging controll (L1) 14 ..... 61000-02 (18-pole connecting cable No.: 11) 15 ..... relay K10 16 ..... blocking diode (1N4007) Page ELECTRICAL SYSTEM - 6 Z001019/0_6_July 2008
ToC SERVICE MANUAL MARINE ENGINES 06 ELECTRICAL SYSTEM For 6 cyl. engines only (old version till eng. no. 68224418) circuit diagr.: Governor 01.03 ill.2 01.03 ill.3 Check of alternator and connections: With engine stopped, measure voltage on alternator (+output and -output). Measured voltage may be lower than the battery voltage by (up to) 1 volt only. Where appropriate, test wiring of cables and connections. Check of control voltage and/or alternator voltage: NOTE: For these works, the battery's state of charge should be 95% at least. Check tension of belt on alternator drive and make sure that cables are perfectly connected. 1. Disconnect all electrical consuming devices and adjust engine to a speed of approx. 1000 rpm. 2. Connect voltmeter to alternator output "B +". 3. Remove plastic screw on governor and apply screw driver with fine blade on adjusting screw. ATTENTION: The adjusting screw has a min./max. stop. There is danger to damage the governor when turning by force the adjusting screw so far that it overtravels the specified control range. 4. Turn screwdriver clockwise to increase the operating voltage and/or anticlockwise to lower the operating voltage. Adjust voltage range between 14,0 and 14,2 volt (28,0 to 28,4 volt for 24-volt plants). ATTENTION: Do not turn adjusting screw so far that it overtravels the stop, to prevent damages to the governor. 5. After adjustment, remove screwdriver and voltmeter and lock the governor by means of removed plastic screw. If voltage cannot be set to specified value, replace governor and/or alternator. Check of slip pistons: Disconnect battery and/or main switch. Unscrew governor. Clean slip ring and wipers; where appropriate, replace wipers. Z001019/0_6_July 2008 Page ELECTRICAL SYSTEM - 7
Page 1 and 2:
STEYR MARINE ENGINES 4 CYLINDERS +
Page 3 and 4:
PREFACE STEYR MOTORS GmbH has devel
Page 5 and 6:
TABLE OF CONTENTS (MAIN ASSEMBLY GR
Page 7 and 8:
05 Cooling system 05.01 Cooler, hea
Page 9 and 10:
ToC SERVICE MANUAL MARINE ENGINES G
Page 11 and 12:
Page 13 and 14:
ToC SERVICE MANUAL MARINE ENGINES A
Page 15 and 16:
Page 17 and 18:
Page 19 and 20:
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
Page 27 and 28:
ToC SERVICE MANUAL MARINE ENGINES O
Page 29 and 30:
Page 31 and 32:
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
Page 39 and 40:
Page 41 and 42:
Page 43 and 44:
Page 45 and 46:
Page 47 and 48:
Page 49 and 50:
Page 51 and 52:
Page 53 and 54:
Page 55 and 56:
Page 57 and 58:
Page 59 and 60:
Page 61 and 62:
Page 63 and 64:
ToC SERVICE MANUAL MARINE ENGINES 0
Page 65 and 66:
Page 67 and 68:
Page 69 and 70:
Page 71 and 72:
Page 73 and 74:
Page 75 and 76:
Page 77 and 78:
Page 79 and 80:
Page 81 and 82:
Page 83 and 84:
Page 85 and 86:
Page 87 and 88:
Page 89 and 90:
Page 91 and 92:
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
Page 99 and 100:
Page 101 and 102:
Page 103 and 104:
Page 105 and 106:
Page 107 and 108:
Page 109 and 110:
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
Page 117 and 118:
Page 119 and 120:
Page 121 and 122:
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
Page 143 and 144:
Page 145 and 146:
Page 147 and 148:
Page 149 and 150:
Page 151 and 152:
Page 153 and 154:
Page 155 and 156:
ToC SERVICE MANUAL MARINE ENGINES R
Page 157 and 158:
SERVICE MANUAL MARINE ENGINES 03 FU
Page 159 and 160:
Page 161 and 162:
Page 163 and 164:
Page 165 and 166:
Page 167 and 168:
Page 169 and 170:
Page 171 and 172:
Page 173 and 174:
Page 175 and 176:
Page 177 and 178:
Page 179 and 180:
Page 181 and 182:
Page 183 and 184:
Page 185 and 186:
Page 187 and 188:
Page 189 and 190:
Page 191 and 192: SERVICE MANUAL MARINE ENGINES 03 FU
Page 193 and 194: SERVICE MANUAL MARINE ENGINES 03.14
Page 195 and 196: ToC SERVICE MANUAL MARINE ENGINES 0
Page 201 and 202: SERVICE MANUAL MARINE ENGINES 05 CO
Page 241: ToC SERVICE MANUAL MARINE ENGINES 0
Page 269 and 270: L J 6 5 4 2 3 1 23 ToC SERVICE MANU
Page 285 and 286: ToC SERVICE MANUAL MARINE ENGINES I
Page 287 and 288: ToC SERVICE MANUAL MARINE ENGINES E
Page 289 and 290: ToC SERVICE MANUAL MARINE ENGINES E
Page 291 and 292: ToC SERVICE MANUAL MARINE ENGINES I
Page 293 and 294:
ToC SERVICE MANUAL MARINE ENGINES E
Page 295 and 296:
Page 297 and 298:
Page 299 and 300:
°C °F 250 80 40 100 120 0 L MAIN
Page 301 and 302:
°C °F 250 80 40 100 120 0 MAIN RP
Page 303 and 304:
Page 305 and 306:
Page 307 and 308:
Page 309 and 310:
Page 311 and 312:
Page 313 and 314:
Page 315 and 316:
Page 317 and 318:
Page 319 and 320:
Page 321 and 322:
Page 323 and 324:
Page 325 and 326:
Page 327 and 328:
Page 329 and 330:
Page 331:
show all

4 cylinders + 6 cylinders 4 cylinders + 6 cylinders - Steyr Motors

Create successful ePaper yourself

Delete template?

Save as template?