4 cylinders + 6 cylinders 4 cylinders + 6 cylinders - Steyr Motors

More documents

Recommendations

Info

ToC ELECTRICAL SYSTEM SERVICE MANUAL MARINE ENGINES 06.08.01 Potentiometer Accelerator, B13 1 Remove plug housing. 2 Unscrew hexagon nut of accelerator lever, remove lever. 3 Loosen 2 hexagon screws. Remove accelerator. Throttle potentiometer B13 (accelerator) (= connector X13) In case of defective potentiometer accelerator B13, service codes 23, 24 or 29 will flash. 08.01 ill.1 NOTE: First check cables and connections. R1 Resistance between terminals 3 and 1; approximately 1,2 kOhm resistance value switch to infinetely after moving throttle lever from idle position. Switch contact should open within the first 10% of throttle lever (pedal) movement. 1 2 3 4 5 R2 R3 Resistance between terminals 5 and 4; 1,2 kOhm Resistance between terminals 5 and 2; 2,2 kOhm for normal position of potentiometer accelerator ; 1,4 kOhm at "full speed " max. throttle position. 08.01 ill.2 Wiring Circuit - Potentiometer P/N 2176860/0 ~1k 1 ~9 3 R1 5 + ~1k - ~1k 2 4 R3 R2 08.01 ill.3 Page ELECTRICAL SYSTEM - 74 Z001019/0_6_July 2008
ToC SERVICE MANUAL MARINE ENGINES ELECTRICAL SYSTEM 06.08.02 Voltage regulator 24V-12V equalizer Powersupply to equalizer recomandet wire gauge size. Starter must be connecting by customer use a wire min. AWG 0 (50 mm²) connect a red wire AWG 8 (6 mm²) at battery "A" positiv terminal +12V connect a red wire AWG 6 (10 mm²) at battery "B" positiv terminal +24V connect a black wire AWG 6 (10 mm²) directly at battery "A" negativ terminal. Battery equalizer GND +24V BLACK AWG 6 RED AWG 6 25A 20A (*) 30A 12V Protected Output RED AWG 8 OUT 12V 24V LOAD (STARTER , ALTERNATOR, power supply glow , .....) “A” * Note:......Mainswitsches are mechanically interlinked. “B” 08.02 ill.1 X21 ARMATUREN PLUG 6-POLE: --> USE ONLY 12 VOLT INSTRUMENTS pin1 pin2 pin3 pin4 pin5 pin6 Note: 60810--> check engine lampe (12V/2W) 60616--> glow lamp (12V/2W) 60614--> temperature instruments (12V) 60613--> engine speed instruments (12V) 50000--> starter terminal 50 (detection of start) 15000--> ignition connect it to the ignition-switch of the vehicle (protect with 5 Amp fuse) The glow lamp has 2 functions --> at first it works as glow lamp after start it works as oil pressure lamp. ALTERNATOR B+ must be connection by customer --> use a wire AWG 6 (10 mm²) charging control --> must be connecting by customer. ATTENTION: Please observer and follow Original inclosed manufactures recommentation! 08.02 ill.2 Z001019/0_6_July 2008 Page ELECTRICAL SYSTEM - 75
Page 1 and 2:
STEYR MARINE ENGINES 4 CYLINDERS +
Page 3 and 4:
PREFACE STEYR MOTORS GmbH has devel
Page 5 and 6:
TABLE OF CONTENTS (MAIN ASSEMBLY GR
Page 7 and 8:
05 Cooling system 05.01 Cooler, hea
Page 9 and 10:
ToC SERVICE MANUAL MARINE ENGINES G
Page 11 and 12:
Page 13 and 14:
ToC SERVICE MANUAL MARINE ENGINES A
Page 15 and 16:
Page 17 and 18:
Page 19 and 20:
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
Page 27 and 28:
ToC SERVICE MANUAL MARINE ENGINES O
Page 29 and 30:
Page 31 and 32:
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
Page 39 and 40:
Page 41 and 42:
Page 43 and 44:
Page 45 and 46:
Page 47 and 48:
Page 49 and 50:
Page 51 and 52:
Page 53 and 54:
Page 55 and 56:
Page 57 and 58:
Page 59 and 60:
Page 61 and 62:
Page 63 and 64:
ToC SERVICE MANUAL MARINE ENGINES 0
Page 65 and 66:
Page 67 and 68:
Page 69 and 70:
Page 71 and 72:
Page 73 and 74:
Page 75 and 76:
Page 77 and 78:
Page 79 and 80:
Page 81 and 82:
Page 83 and 84:
Page 85 and 86:
Page 87 and 88:
Page 89 and 90:
Page 91 and 92:
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
Page 99 and 100:
Page 101 and 102:
Page 103 and 104:
Page 105 and 106:
Page 107 and 108:
Page 109 and 110:
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
Page 117 and 118:
Page 119 and 120:
Page 121 and 122:
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
Page 143 and 144:
Page 145 and 146:
Page 147 and 148:
Page 149 and 150:
Page 151 and 152:
Page 153 and 154:
Page 155 and 156:
ToC SERVICE MANUAL MARINE ENGINES R
Page 157 and 158:
SERVICE MANUAL MARINE ENGINES 03 FU
Page 159 and 160:
Page 161 and 162:
Page 163 and 164:
Page 165 and 166:
Page 167 and 168:
Page 169 and 170:
Page 171 and 172:
Page 173 and 174:
Page 175 and 176:
Page 177 and 178:
Page 179 and 180:
Page 181 and 182:
Page 183 and 184:
Page 185 and 186:
Page 187 and 188:
Page 189 and 190:
Page 191 and 192:
Page 193 and 194:
SERVICE MANUAL MARINE ENGINES 03.14
Page 195 and 196:
Page 197 and 198:
Page 199 and 200:
Page 201 and 202:
SERVICE MANUAL MARINE ENGINES 05 CO
Page 203 and 204:
Page 205 and 206:
Page 207 and 208:
Page 209 and 210:
Page 211 and 212:
Page 213 and 214:
Page 215 and 216:
Page 217 and 218:
Page 219 and 220:
Page 221 and 222:
Page 223 and 224:
Page 225 and 226:
Page 227 and 228:
Page 229 and 230:
Page 231 and 232:
Page 233 and 234:
Page 235 and 236:
Page 237 and 238:
Page 239 and 240:
Page 241 and 242:
Page 243 and 244:
Page 245 and 246:
Page 247 and 248:
Page 249 and 250:
Page 251 and 252:
Page 253 and 254:
Page 255 and 256:
Page 257 and 258:
Page 259 and 260: ToC SERVICE MANUAL MARINE ENGINES 0
Page 269 and 270: L J 6 5 4 2 3 1 23 ToC SERVICE MANU
Page 285 and 286: ToC SERVICE MANUAL MARINE ENGINES I
Page 287 and 288: ToC SERVICE MANUAL MARINE ENGINES E
Page 291 and 292: ToC SERVICE MANUAL MARINE ENGINES I
Page 299 and 300: °C °F 250 80 40 100 120 0 L MAIN
Page 301 and 302: °C °F 250 80 40 100 120 0 MAIN RP
Page 309: ToC SERVICE MANUAL MARINE ENGINES E
Page 331: ToC SERVICE MANUAL MARINE ENGINES E
show all

4 cylinders + 6 cylinders 4 cylinders + 6 cylinders - Steyr Motors

Create successful ePaper yourself

Delete template?

Save as template?