Daelim S4 50cc Service Manual - Mojo

More documents

Recommendations

Info

TRANSMISSION/CRANKSHAFT/CRANKCASECRANK CASE INSTALLATION● Install the dowel pins and a new gasket.● Pulling the cam chain and check to see if thecrankshaft installed correctly.● Install the RH. Crankcase to the LH. crank case.NOTE•Make sure that the gasket is completely attachedwithout any clearance.● Assemble one RH. Crank case flange bolt.FLANGE BOLT● Regarding the installing the engine assy, refer to themanual.● Install the engine to the frame(-> section 6).
MEMO
Page 3:
CONTENTS Contents of this manual an
Page 6 and 7:
SERVICE INFORMATIONSPECIFICATIONDIM
Page 8 and 9:
SERVICE INFORMATIONTORQUE VALUESENG
Page 10 and 11:
SERVICE INFORMATIONLUBRICATION OILE
Page 12 and 13:
SERVICE INFORMATIONWINKER RELAYHORN
Page 14 and 15:
SERVICE INFORMATIONBATTERY CABLESAI
Page 16 and 17:
SERVICE INFORMATION3. Store the par
Page 18 and 19:
SERVICE INFORMATION19. Install the
Page 20 and 21:
SERVICE INFORMATION•Turn off the
Page 22 and 23:
SERVICE INFORMATION•In case that
Page 24 and 25:
INSPECTIONS / ADJUSTMENTSTORQUESPAR
Page 26 and 27:
INSPECTIONS / ADJUSTMENTSFUEL STRAI
Page 28 and 29:
INSPECTIONS / ADJUSTMENTSTURNCAUTIO
Page 30 and 31:
INSPECTIONS / ADJUSTMENTSBRAKE FLUI
Page 32 and 33:
INSPECTIONS / ADJUSTMENTSWHEELS / T
Page 34 and 35:
MEMO
Page 36 and 37:
EXTERNAL PARTSMAINTENANCE PROCEDURE
Page 38 and 39:
EXTERNAL PARTSTAPPING SCREWS● Loo
Page 40 and 41:
EXTERNAL PARTSFLOOR PANEL● Untie
Page 42 and 43:
EXTERNAL PARTSWASHER BOLTFRONT UNDE
Page 44 and 45:
MEMO
Page 46 and 47:
LUBRICATION SYSTEMTROUBLE SHOOTINGO
Page 48 and 49:
LUBRICATION SYSTEMOIL PUMPINSPECTIO
Page 50 and 51:
LUBRICATION SYSTEMASSEMBLY● Clean
Page 52 and 53:
MEMO
Page 54 and 55:
FUEL SYSTEMTROUBLESHOOTINGThe vehic
Page 56 and 57:
FUEL SYSTEM● Untie screws install
Page 58 and 59:
FUEL SYSTEMSLOW JET● Remove the m
Page 60 and 61:
FUEL SYSTEM● Assemble acceleratin
Page 62 and 63:
FUEL SYSTEMTHROTTLE STOP SCREW Exte
Page 64 and 65:
MEMO
Page 66 and 67:
ENGINE REMOVAL/INSPECTIONCARBURETOR
Page 68 and 69:
BELT TYPE CONTINUOUSLY VARIABLE TRA
Page 70 and 71:
BELT TYPE CONTINUOUSLY VARIABLE TRA
Page 72 and 73: BELT TYPE CONTINUOUSLY VARIABLE TRA
Page 84 and 85: A.C. GENERATOR /RH. CRANK CASE COVE
Page 90 and 91: CYLINDER HEAD / VALVES
Page 92 and 93: CYLINDER HEAD / VALVESTOOL-VALVE GU
Page 94 and 95: CYLINDER HEAD / VALVESCAM SHAFTCAM
Page 96 and 97: CYLINDER HEAD / VALVES● Remove th
Page 98 and 99: CYLINDER HEAD / VALVESVALVE GUIDE R
Page 100 and 101: CYLINDER HEAD / VALVESCYLINDER HEAD
Page 102 and 103: CYLINDER HEAD / VALVES● Install f
Page 104 and 105: CYLINDER / PISTON
Page 106 and 107: CYLINDER / PISTONCYLINDERCYLINDERRE
Page 108 and 109: CYLINDER / PISTONPISTON RINGFEELER
Page 110 and 111: CYLINDER / PISTON● Install the ne
Page 112 and 113: TRANSMISSION/CRANKSHAFT/CRANKCASE
Page 114 and 115: TRANSMISSION/CRANKSHAFT/CRANKCASETO
Page 116 and 117: TRANSMISSION/CRANKSHAFT/CRANKCASEIN
Page 124 and 125: FRONT WHEEL / FRONT BRAKE / FRONT F
Page 148 and 149: REAR WHEEL / REAR BRAKE / REAR CUSH
Page 156 and 157: CHARGING SYSTEMWINKER RELAYMAGNETIC
Page 158 and 159: CHARGING SYSTEMTROUBLE SHOOTINGNo p
Page 160 and 161: CHARGING SYSTEMBATTERY TERMINALCAUT
Page 162 and 163: IGNITION SYSTEMWINKER RELAYFUEL TAN
Page 164 and 165: IGNITION SYSTEMTROUBLE SHOOTINGSpar
Page 166 and 167: IGNITION SYSTEMIGNITION COIL INSPEC
Page 168 and 169: STARTING SYSTEMWINKER RELAYMAGNETIC
Page 170 and 171: STARTING SYSTEMTROUBLE SHOOTINGStar
Page 172 and 173:
STARTING SYSTEMBRUSH● the brush s
Page 174 and 175:
STARTING SYSTEMSTARTER MAGNETIC SWI
Page 176 and 177:
LIGHTS// SWITCHES / HORNHEADLIGHT B
Page 178 and 179:
LIGHTS// SWITCHES / HORNSPEEDOMETER
Page 180 and 181:
LIGHTS// SWITCHES / HORNRELEASE THE
Page 182 and 183:
ENGINE STALLS, HARD TO START, ROUGH
Page 184 and 185:
POOR OPERATIONCLUTCH DRIVE / DRIVEN
Page 186 and 187:
MEMO
Page 188:
SM62-1003-01E
show all

Daelim S4 50cc Service Manual - Mojo

Create successful ePaper yourself

Delete template?

Save as template?