Show HSE plan - Hitachi Power Europe GmbH

Dok.-Nr. / Doc.-No.HPES-306-001-Standard HSE Plan englischAttaching lifting tools is forbidden. Exception: The instructions for installation and use expresslypermit this.3 part side protection must be provided on each working level.Essential elements for safe use are: The permissible load must be observed. Only move mobile catwalks slowly and on a level, obstacle-free surface that is able to bear theweight. Travelling rollers must be fixed with brake levers after the unit has been moved. Any impact is to be avoided. Only move in a longitudinal direction or diagonally. Before moving ensure that loose parts cannot fall off. Do not jump off the plank surfaces. Nobody must stay on mobile catwalks while they are moving. Should a storm be imminent (more than wind speed 6) and after work has finished mobile catwalksmust be secured so that they cannot topple over.3.4.16.3. Earth moving machinesGeneral Drivers of earth moving machines must- be trained,- be physically and mentally suitable,- be at least 18 years old,- be hired by the subcontractor and- have proven their capabilities to the subcontractor. The driver must be familiar with the operating instructions. The driver must have a valid driving licence if he goes on the public roads.Operation Before starting up check that it is in a condition that is safe to operate. Only perform such work as the machine is intended for in accordance with the regulations. The steps and access doors provided must be used to reach and leave the driver's seat. There is a risk of slipping if you get in and out using the chains. Keep entry surfaces and accesses so that they are safe to walk on. Use ear protection if the noise rating level is > 85 dB (A).Danger area Do not stand in the moving or pivoting area (danger area). In order to avoid the risk of crushing maintain a safety distance of at least 0.50 m betweenmoving machines and fixed parts of the surrounding area. If the minimum distance cannot be maintained cordon off the danger area. If the driver's line of sight is restricted, if necessary use banksmen. Use banksmen when reversing. The banksman must stand so that the driver can see him but outside the danger area.Safety distance Maintain a safe distance from obstructed trench edges. Maintain a safe distance from overhead electric lines. If the nominal voltage is not known,5.0 m. With chain equipment do not work parallel to the edge of a bank. Danger of tipping and toppling.Inspection and maintenance Carry out expert tests before initial commissioning and, if necessary, at least once a year.VOR180_1 Seite / Page 39 ÷ 56HPES-306-001-e-Standard HSE Plan Ausg. / Issue 03.2011