Navien NP Condensing Tankless Gas Water Heater - Service Manual

More documents

Recommendations

Info

Point Function Wire Color Normal Value Check K AC19V BLUE-BLUE AC 16~24 V Confirm output voltage. BLACK-RED DC 127V~184 V Confirm if voltage flows without any relations with the fan operating. L Fan Motor BLACK-YELLOW BLACK-ORANGE DC 15 V DC 0~7.5 V Confirm if voltage flows without any relations with the fan operating. Voltage changes as the fan operating. BLACK-WHITE 0 rpm~6500 rpm Check PULSE. M Power Input BLUE-BLACK AC 97~138 V Confirm approval of the 1st power resource. Confirm the FUSE. Confirm the circuit breaker. N Water Adjust Valve (CW) Water Adjust Valve (CCW) BLUE-YELLOW BLUE-ORANGE ON : AC 97~138 V OFF : 0V ON : AC 97~138 V OFF : 0V Confirm voltage as operating. Confirm voltage as operating. O Igniter BLUE-BLUE ON : AC 97~138 V OFF : 0V Confirm voltage asignition operating. P Pump BROWN-WHITE BROWN-BLACK ON : AC 97~138 V OFF : 0V ON : AC 97~138 V OFF : 0V Confirm voltage as operating. Confirm voltage as operating. BROWN-BROWN ON : DC 83~120 V OFF : 0V Confirm voltage as the Main Gas Valve operating. Q Gas Valve YELLOW-YELLOW ON : DC 83~120 V OFF : 0V Confirm voltage as the Gas Solenoid Valve 1 operating. RED-RED ON : DC 83~120 V OFF : 0V Confirm voltage as the Gas Solenoid Valve 2 operating. R P.E Flame Rod GREEN BLACK Protect Earth 0~20 uA Same to the case earth Protect Earth. Measure the currency as sensing flame. S Power trans AC150V Power trans AC120V RED-RED WHITE-BLACK AC 123~177 V AC 97~138 V Confirm output voltage. Confirm output voltage T Motorized 2-way Valve BLACK-BLUE-RED ON : AC 97~138 V OFF : 0 V Confirm voltage as Motorized 2-way Valve operating. ©Navien America Inc. 2010 42 NR/NP series service Manual Version 2.0
4.6. Key Components Description 4.6.1. PCB Navien Part No. NACR1GS32401 NACR1GS32410 Check Point N/A Function Failure Event Effects Error Code Diagnostic Color / Number of wires 1. To control each component and performance unit. 1. Malfunctioning PCB. 1. A component may not operate within the unit. In most cases of PCB failure, the whole unit does not operate at all. E015 1. Visual inspection: Connection and/or breakage of wires and or burn marks on the PCB N/A ©Navien America Inc. 2010 43 NR/NP series service Manual Version 2.0
Page 1: Service Manual Service Manual Servi
Page 4 and 5: 4.4.2. NP-A Model 37 4.4.3. NR Mode
Page 6 and 7: 8.2.8. Manifold 143 8.2.9. Main Gas
Page 8 and 9: Navien Warranty CAUTION This produc
Page 10 and 11: WARRANTY EXCLUSIONS This warranty d
Page 12 and 13: Abbreviation and Definition Abbrevi
Page 14 and 15: 1.4. Safety Precautions DANGER FLAM
Page 16 and 17: DANGER WHAT TO DO IF YOU SMELL GAS
Page 18 and 19: GAS TYPE and AC VOLTAGE WARNING Nav
Page 20 and 21: 2.2. Layout and Key Components 2.2.
Page 22 and 23: 2.2.3. NR Model No Description Navi
Page 24 and 25: 3. Technical Data 3.1. General Spec
Page 26 and 27: 3.2.2. NR, NP Model 1) Connection D
Page 28 and 29: 4.1.2. NP-A Model Exhaust pipe inta
Page 30 and 31: 4.1.3. NR Model Exhaust pipe Intake
Page 32 and 33: YES GPS normal? YES MGV ON NO Lock-
Page 34 and 35: B Lock-out Outlet Thermistor >= 208
Page 36 and 37: 4.3. Dip Switch Settings There are
Page 38 and 39: 4.4. Wiring Diagram 4.4.1. NR-A Mod
Page 40 and 41: 4.4.3. NR Model ©Navien America In
Page 42 and 43: 4.5. Electrical Diagnostic Points G
Page 46 and 47: 4.6.2. Thermal Fuse Navien Part No.
Page 48 and 49: 4.6.4. High Limit Switch or Exhaust
Page 50 and 51: 4.6.6. Fan motor Navien Part No. Fu
Page 52 and 53: 4.6.8. Ignition Transformer Navien
Page 54 and 55: 4.6.10. Manifold PABCR180AMF_001 Na
Page 56 and 57: 4.6.12. GPS Navien Part No. Functio
Page 58 and 59: 4.6.14. Water Adjustment Valve Navi
Page 60 and 61: 4.6.16. Primary Heat Exchanger Navi
Page 62 and 63: 4.6.18. Buffer Tank (“A” Series
Page 64 and 65: 4.6.20. Bypass Mixing Valve (“Non
Page 66 and 67: Error Code E021 Reason Cold water i
Page 68 and 69: Check method Error type Cause The m
Page 70 and 71: Scenario 1 Is the igniter normally
Page 72 and 73: Check method Error type Cause Check
Page 74 and 75: Solenoid valve Proportional valve A
Page 76 and 77: To the direction of air supply hose
Page 78 and 79: Check method Error type Flame befor
Page 80 and 81: Check method Error type Sensor erro
Page 82 and 83: Check method Error type Sensor erro
Page 84 and 85: Does the fan moter have normal oper
Page 86 and 87: 5.8. 10Error Error occurrence condi
Page 88 and 89: Check method Error type Cause Check
Page 90 and 91: 5.9. 12Error Error occurrence condi
Page 92 and 93: Off at switch of stage Defective ai
Page 94 and 95:
5.11. 16Error Error occurrence cond
Page 96 and 97:
Temperature fuse > < Check if the t
Page 98 and 99:
Page 100 and 101:
Page 102 and 103:
Page 104 and 105:
Page 106 and 107:
Page 108 and 109:
Emergency measures against closed f
Page 110 and 111:
Check method Error type Defective s
Page 112 and 113:
Page 114 and 115:
Page 116 and 117:
Page 118 and 119:
1. Drain water, and unfasten the up
Page 120 and 121:
Check method Error type Defective s
Page 122 and 123:
Check the connection of wire to wir
Page 124 and 125:
Page 126 and 127:
5.27. Troubleshooting guide by symp
Page 128 and 129:
5.27.2. Hot water Error Cause Remot
Page 130 and 131:
6. Inspection Check and clean the h
Page 132 and 133:
6.2.2. Adjusting the Gas-Air Ratio
Page 134 and 135:
7. Maintenance Describe precautions
Page 136 and 137:
7.3. Flushing the Heat Exchanger Fo
Page 138 and 139:
8.2. Components Replacement Instruc
Page 140 and 141:
8.2.3. Transformer 1. Turn off the
Page 142 and 143:
8.2.5. Flame Rod 1. Turn off the ga
Page 144 and 145:
8.2.7. APS 1. Turn off the gas supp
Page 146 and 147:
WARNING Failure to correctly assemb
Page 148 and 149:
WARNING Failure to correctly assemb
Page 150 and 151:
8.2.11. Condensation Trap 1. Turn o
Page 152 and 153:
8.2.13. Flow Sensor 1. Turn off the
Page 154 and 155:
8.2.15. Circulation Pump (“A”Se
Page 156 and 157:
8.2.16. 3-way Valve (“A” Series
Page 158 and 159:
8.2.18. Bypass Mixing Valve (“Non
Page 160 and 161:
NO Description Navien Part No. Rema
Page 162 and 163:
Page 164 and 165:
9.3. Water Way Disassemble (NR-A)
Page 166 and 167:
9.5. Water Way Disassemble (NP-A)
Page 168 and 169:
Page 170 and 171:
Page 172 and 173:
10.2. Inspection Report Inspection
Page 174 and 175:
Memo ©Navien America Inc. 2010 172
Page 176 and 177:
Page 178:
show all

Navien NP Condensing Tankless Gas Water Heater - Service Manual

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?