Telemecanique Altivar 56 manual - Northern Industrial

More documents

Recommendations

Info

L1 L2 L3TelemecaniqueT1 T2 T3L1 L2 L3TelemecaniqueT1 T2 T3NCNCNCNCBefore Servicing theBefore Servicingselected:Failure to observe these precautions will result in death orserious injury.234Drive Controller:Disconnect All Power.Place a "Do Not Turn On" label on Drive Controller.Lock Disconnect in Open Position.This equipment must be installed andserviced only by qualified electricalpersonnel.Turn off all power supplying thisequipment before working on or insideequipment.Always use a properly rated voltagesensing device to confirm power is off.Replace all devices, doors, and coversbefore turning on power to this equipment.Basic Power ConverterPerform all functions listed above.Measure Voltages at Disconnect Output to verify they are zero.Wait 1 minute to allow DC Bus to discharge, verify no voltage ispresent.Remove Line Fuses labeled FU1, FU2 and FU3 with toolprovided.Replace Cover, then close the disconnect.Before Servicing theBefore Servicingselected:Drive Controller:Disconnect All Power.Place a "Do Not Turn On" label on Drive Controller.Lock Disconnect in Open Position.Basic Power Converter98This equipment must be installed andserviced only by qualified electricalpersonnel.Turn off all power supplying thisequipment before working on or insideequipment.Always use a properly rated voltagesensing device to confirm power is off.Replace all devices, doors, and coversbefore turning on power to this equipment.Perform all functions listed above.Measure Voltages at Disconnect Output to verify they are zero.Wait 1 minute to allow DC Bus to discharge, verify no voltage ispresent.Remove Line Fuses labeled FU1, FU2 and FU3 with toolprovided.Replace Cover, then close the disconnect.Failure to observe these precautions will result in death orserious injury.23498ONTRAVAIL DELAYTELEMECANIQUEwhen Bypass iswhen Bypass isL1 L2 L3XXXXX-XXX-XX1,5-30sXXXXX-XXX-XX53 NO 63 NO53 NO 63 NOTELEMECANIQUE54 NO 64 NO54 NO 64 NOT1 T2 T3NCNCL1 L2 L3TELEMECANIQUET1 T2 T3Telemecanique2326TESTA322998 NO 9795 NC 96T1T2RA ESETNCNCBulletin No. 50006-519-01BDecember 1996Chapter 6 — Class 8839 ALTIVAR 56 Combination DevicesTerminal Strip LocationsTERMINAL STRIPLOCATIONSFigures 74 through 78 show terminal strip locations for Class 8839 ALTIVAR 56combination devices. Tables 48 through 51 list wire size and torque requirements.NOTE: Typicaldevice shownwith options.DANGERHAZARD OF ELECTRIC SHOCK OR BURNLINEL1, L2, L3(SW2)13521DRIVE ISOLATION HAZARDLC1D251001ON24622Fuse BlockFU1FU2FU3OFFLOADHAND1010OPENOFFMAINSAUTO567CLOSEControlTerminals1 - 16(QW1, QW2)12345678910111213141516SPTST1 T2 T31718192021222324252627ControlTerminals17 - 27 (SW1)T1, T2, T3(SW2)GNDGNDFigure 74: Terminal Strip Locations for 1 - 50 hp VT & 1 - 40 hp VTLN, 460 V;1 - 25 hp VT & VTLN, 208/230 V (Power Circuit W)NOTE: Typicaldevice shownwith options.Fuse Block121LC101D25102346522DANGERHAZARD OF ELECTRIC SHOCK OR BURNDRIVE ISOLATION HAZARDFU1 FU2 FU3LINE LOADONOFFL1, L2, L3(SW2)HAND1010AFCOFFOFFAUTO567BYPASSControlTerminals1 - 15(QW1, QW2)1234456789101112131415SPTS1LC1DXX023LA4 DT 2U01LC1DXX0LA1DNXXLA1DNXX45621221243LR2DXX01222 4 6 T356STOP21161718192021222324252627282930313233ControlTerminals16 - 33(SW1)T1, T2, T3(SW2)GNDGNDFigure 75: Terminal Strip Locations for 1 - 50 hp VT & 1 - 40 hp VTLN, 460 V;1 - 25 hp VT & VTLN, 208/230 V (Power Circuit Y or Z)© 1996 Square D All Rights Reserved131ηττπ://νιχοντρολσ.χοm
1 L1 3 L2 5 L3LC1DXX11Telemecanique2 T1 4 T2 6 T31 L1 3 L2 5 L3LC1DXX11Telemecanique2 T1 4 T2 6 T3A221NC13NO14NO22NCA2A221NC13NO14NO22NCA2HANDOFFAUTOHANDOFFAUTO123451234456789101112131415234151234456789101112131415166067079889OPENMAINSCLOSEAFCOFFBYPASS1LC1DXX11Telemecanique1718192021222324252627JJS-150161718192021222324252627282930313233JJS-150ONTRAVAILDELAYTELEMECANIQUE53 NO 63 NOTelemecaniqueLA1DN2054 NO 64 NO1,5-30sLA4 DT 2UL1 3 L2 5 L32 T1 4 T2 6 T3A221NC13NO14NO22NCA21 L1 2 L2 3 L3TelemecaniqueALR2D3361RA ESTOP STESTET23269829NO3297NC95 962 T1 4 T2 6 T31LC1DXX11TelemecaniqueTELEMECANIQUEL1 3 L2 5 L353 NO 63 NOTelemecaniqueLA1DN2054 NO 64 NO2 T1 4 T2 6 T3LA4 D4 2UA221NC13NO14NO22NCA2250AKAL36250XXM250AKAL36250XXM250ON250ONOFFOFFChapter 6 — Class 8839 ALTIVAR 56 Combination DevicesBulletin No. 50006-519-01BTerminal Strip Locations December 1996NOTE: Typicaldevice shownwith options.CIRCUIT BREAKERL1, L2, L3(SW2)10ControlTerminals1 - 16(QW1, QW2)10SPRTST1T2T3GNDControlTerminals17 - 27(SW1)T1, T2, T3(SW2)Fuse BlockGNDFigure 76: Terminal Strip Locations for 60 - 100 hp VT & 50 - 75 hp VTLN, 460 V;30 - 50 hp VT & 30 - 40 hp VTLN, 208/230 V (Power Circuit W)NOTE: Typicaldevice shownwith options.CIRCUIT BREAKERL1, L2, L3(SW2)10ControlTerminals1 - 15(QW1, QW2)10T1, T2, T3(SW2)ControlTerminals16 - 33 (SW1)GNDSPRTSFuse BlockGNDFigure 77: Terminal Strip Locations for 60 hp VT & 50 - 60 hp VTLN, 460 V(Power Circuit Y or Z)132 © 1996 Square D All Rights Reservedηττπ://νιχοντρολσ.χοm
Page 1 and 2:
Instruction Bulletin50006-519-01BDe
Page 3 and 4:
DANGERHAZARDOUS VOLTAGE• Read and
Page 5:
ALTIVAR 56 Fan and Pump Drive User
Page 8 and 9:
Bulletin No. 50006-519-01BDecember
Page 10 and 11:
Page 12 and 13:
Page 14 and 15:
Page 16 and 17:
Page 18 and 19:
Page 20 and 21:
Page 22 and 23:
Page 24 and 25:
Page 26 and 27:
Page 28 and 29:
AI2-UAI2-IAI2-UAI2-IAI2-UAI2-IAI2-U
Page 30 and 31:
Page 32 and 33:
Page 34 and 35:
Page 36 and 37:
Page 38 and 39:
Page 40 and 41:
Page 42 and 43:
Page 44 and 45:
Page 46 and 47:
Page 48 and 49:
Page 50 and 51:
Page 52 and 53:
AI2-UAI2-IAI2-UAI2-IBulletin No. 50
Page 54 and 55:
Page 56 and 57:
Page 58 and 59:
Page 60 and 61:
Page 62 and 63:
Page 64 and 65:
Page 66 and 67:
Page 68 and 69:
Bulletin No. 50006-519-01BChapter 5
Page 70 and 71:
Page 72 and 73:
Page 74 and 75:
Page 76 and 77:
Page 78 and 79:
Page 80 and 81:
Page 82 and 83:
Page 84 and 85:
Page 86 and 87:
Page 88 and 89:
Page 90 and 91: Bulletin No. 50006-519-01BChapter 5
Page 124 and 125: Bulletin No. 50006-519-01BDecember
Page 134 and 135: AUTOOFFHAND234510671098AFCOFFBYPASS
Page 136 and 137: HANDOFFAUTO241350678OPENMAINSCLOSEF
Page 142 and 143: 53 NO 61 NC 71 NO 83 NCTelemecaniqu
Page 168 and 169: Bulletin No. 50006-519-01BAppendix
show all

Telemecanique Altivar 56 manual - Northern Industrial

Create successful ePaper yourself

Delete template?

Save as template?