siemens - Public Service Commission

More documents

Recommendations

Info

Progress Energy Crystal River Unit 3 Request for Proposal for Engineering Services to Upgrade Secondary System 6/25/2007 Two EC packages are required, one to procure the two new Feedwaler Booster pumps and motors, and a separate EC package to install these new pumps and motors in the plant. Procedure EGR-NGGC-0005, Engineering Change describes the steps necessary to prepare an EC package. 38 PEF-NCR-02004
Progress Energy Crystal River Unit 3 Request for Proposal for Engineering Services to Upgrade Secondary System 6/25/2007 1.9.1 1 Feedwater Control Valves and Feedwater Control System Stability Feedwater flow is regulated by feedwater pump speed and the Startup FW control valves, FWV.39 8 FWV-40, from 0 to 15% flow, by feedwater pump speed and the Low-Load Flow Control Valves, FWV-37 8 FW-38, from 15 to 50%and by opening Feedwater Block Valves, FWV-29 & FWV-30, and feedwater pump speed above 50% flow. The switch over to the low-load flow control valves will be at the same mass flow rate flow but at a slightly lower percentage of total feedwater flow. The block valves opening will be at the same mass flow rate (6x10' Ibmhr) flow but at a slightly lower percentage of total feedwater flow. The valve will pulse open to 15% and them ramp full open. When the loop feedwater flow demand decreases to 45% of the loop flow range, the associated main block valve will receive a close signal. The valve Wil ramp closed to 17% open and then pulse to full dosed. The block valves dose of a main feedwater isolation actuation signal. The initial assessment is that the feedwater flow control and block valves are adequate for EPU conditions. The developed feedwater pressure exiting !he feedwater pumps is being raised from 1013 psia to 1092 psia. A hydraulic evaluation of the feedwater system (FATHOM or equal) is being performed as part of the Phase 1 detailed design. Verification of proper operation of the feedwater isolation valves at the maximum differential pressure is required after the hydraulic analysis is complete. The feedwater control and block valves require furlher evaluation of the MFP runback set point and control oscillations after the final PEPSE and hydraulic models are complete. The proposal for this task should include 1) an evaluation of the feedwater control system setpoints and 2) an evaluation of the stability of the feedwater control system and valves over the operating range of the system at EPU conditions. 1.9.1 2 Condenser Performance and Flow-Induced Vibration Calculations Condenser performance requires evaluation using the final PEPSE results for 3030 MWt including CW pump flow of 207,400 gpm each. In addition, a baseline case should be evaluated for 2568 MWt and existing CW flow for baseline comparisons against current plan1 data. A condenser flow-induced vibration evaluation is required using the final 3030 MWt results. These evatuations are to be sub contracted to Heat Exchanger Services. The proposal should include the cost for the HES analysis. 39 PEF-NCK-02005
Page 1 and 2:
EXAMPLE August 23,2007 Mr. Jim Gann
Page 3 and 4:
TABLE OF CONTENTS Cover Letter & In
Page 5 and 6:
GENERAL INFORMATION In the evcnt th
Page 7 and 8:
SCOPE AND OTHER REQUIREMENTS I. Bac
Page 9 and 10:
Appendix B program. The technical d
Page 11 and 12:
Telephone: Email: (352) 795-0504 x6
Page 13 and 14:
Summary Report. lhe selected Vendor
Page 15 and 16:
limitations. Identify the fire prot
Page 17 and 18:
for receiving bids. WP documents sh
Page 19 and 20:
Attachment B. Alternatives Analysis
Page 21 and 22:
PEF Safety Plan PEF-NCR-0060 1
Page 23 and 24:
TABLE OF CONTENTS SECTION PAGE 1.0
Page 25 and 26:
1.0 PURPOSE This procedure provides
Page 27 and 28:
2.0 REFERENCES 2.46 2.47 2.48 2.49
Page 29 and 30:
4.0 RESPONSIBILITIES 4.1 Site Vice-
Page 31 and 32:
9.3 General Rules 9.3.5 Red and bla
Page 33 and 34:
9.4 Personal Safety Protection 9.4.
Page 35 and 36:
~~ 9.5 Hearing Conservation 9.5.1 9
Page 37 and 38:
9.9 Lead 9.9.1 Lead removal shall b
Page 39 and 40:
9.14 Handling, Use, and Storage of
Page 41 and 42:
9.17 Fall Protection 9.17.1 Fall pr
Page 43 and 44:
9.19 Scaffolding 9.19.1 All scaffol
Page 45 and 46:
9.23 Compressed Air Use 9.23.3 Job-
Page 47 and 48:
9.29 Job Safety Analysis 9.29.1 Job
Page 49 and 50:
ATTACHMENT 1 Sheet 2 of 5 29 CFR 19
Page 51 and 52:
ATTACHMENT 1 Sheet 4 of 5 29 CFR 19
Page 53 and 54:
ATTACHMENT 2 Sheet 1 of 5 HNP Perso
Page 55 and 56:
ATTACHMENT 2 Sheet 3 of 5 HNP Perso
Page 57 and 58:
191 0.1 36 FOOT PROTECTION ATTACHME
Page 59 and 60:
ATTACHMENT 3 Sheet 2 of 5 RNP Perso
Page 61 and 62:
ATTACHMENT 3 Sheet 4 of 5 RNP Perso
Page 63 and 64:
ATTACHMENT 4 Sheet 1 of 2 HE&EC Per
Page 65 and 66:
ATTACHMENT 5 Sheet 1 of 5 CR3 Perso
Page 67 and 68:
ATTACHMENT 5 Sheet 3 of 5 CR3 Perso
Page 69 and 70:
1910.136 FOOT PROTECTION ATTACHMENT
Page 71 and 72:
ATTACHMENT 6 Sheet 2 of 2 NGG Hazar
Page 73 and 74:
~~ ATTACHMENT 8 Sheet 1 of 1 Person
Page 75 and 76:
~~ ____ Section Description of Chan
Page 77 and 78:
Site Land Use Classification Map PE
Page 79 and 80:
Applicable Sections of the Site Cer
Page 81 and 82:
June 2007 2-2 0738953 1 limits the
Page 83 and 84:
June 2007 1 0738953 SECTION 3 3.0 T
Page 85 and 86:
June 2007 3-2 0738953 1 3.1.1 Descr
Page 87 and 88:
June 7007 3 -4 0738953 I 3.4 Air Em
Page 89 and 90:
June 2007 3 -6 073899 1 emission ra
Page 91 and 92:
June 2007 3-8 0738953 I designed to
Page 93 and 94:
June 2007 3-10 0738953 1 1 1.4 perc
Page 95 and 96:
June 2007 I 0738953 1 SECTION 5 5.0
Page 97 and 98:
June 2007 5- 1 0738953 1 5.0 EFFECT
Page 99 and 100:
June 2007 5 -3 0738953 I 5.1.3 Biol
Page 101 and 102:
Figure 2.3.4-5 Once Through Cooling
Page 103 and 104:
Helper Cooling Tower Performance Cu
Page 105 and 106:
Modular Cooling Tower Performance C
Page 107 and 108:
Local Annual Windrose
Page 109 and 110:
5/24/2007 2 3 7-2 TPA Winter Windro
Page 111 and 112:
5/24/2007 2.3.7-4 TPA Surnrner Wind
Page 113 and 114:
RFI Number: Discharge Canal Thermal
Page 115 and 116:
Inhattsverzeichnis I Table of conte
Page 117 and 118:
Qu alitats p r u f blattlQuality Te
Page 119 and 120:
Qualit~tsprufbla~Quality Test Sheet
Page 121 and 122:
Kennwort: Job "0: AuRrags-N.: etm m
Page 123 and 124:
QualitSts pr UfblatUQuality I Test
Page 125 and 126:
SIEMENS McdernaalKm prolecf CONFIDE
Page 127 and 128:
SUSQUEHANNA STEAM ELECTRIC STATION
Page 129 and 130:
OTHER LONG TERM RELIABILITY ISSUES
Page 131 and 132:
Figure 1 -Advanced Disc Design LP T
Page 133 and 134:
stainless steel inner casing constr
Page 135 and 136:
Figure 2 - HP Turbine Comparison (U
Page 137 and 138:
~ ~~ SCOPE OF SUPPLY - HARDWARE SIE
Page 139 and 140:
SIEMENS CONF Mdernaalion Roied PAGE
Page 141 and 142:
SIEMENS co ~N FI DENTI At DO USE 7H
Page 143 and 144:
SIEMENS Modernnation Prolect ADril
Page 145 and 146:
SCOPE OF SUPPLY - HARDWARE SIEMENS
Page 147 and 148:
SIEMENS co Modernizetion Proled ..
Page 149 and 150:
Moderncalfon Pmpd PAGE5 SCOPE OF SU
Page 151 and 152:
SIEMENS Modernnebon Propa April 16
Page 153 and 154:
COMPATIBILITY WITH EXISTING PLANT S
Page 155 and 156:
SIEMENS Scope of Supply GENERATOR S
Page 157 and 158:
SIEMENS Mcdemnahon Pnyect Page 3 Ap
Page 159 and 160:
Supply of Equipment Contracts for n
Page 161 and 162:
e e Interface with the customer, co
Page 163 and 164:
CRAFT LABOR EXTRA WORK RATES SIEMEN
Page 165 and 166:
SIEMENS Modernnabon Projecl Pdge 2
Page 167 and 168:
SIEMENS Request No SKI22037 Use thi
Page 169 and 170:
Use rhJ documenr solely for rhe pur
Page 171 and 172:
SIEMENS ,. ._ - _. . - . . , April
Page 173 and 174:
a Siemens Contract #I 45569 Work Au
Page 175 and 176:
iemens Contra roiect Schedule C 0 :
Page 177 and 178:
ontrac t Sum mar Savings ($000's) A
Page 180 and 181:
Warranty PEF-NCR-00762
Page 182 and 183:
Limits of Liability
Page 184 and 185:
Siemens Contract Summary: 201 I Del
Page 186 and 187:
0 Siemens Contract Summary: Proiect
Page 188:
Alstom Initial ProuosalS-ummaw: ..
Page 191 and 192:
02/28/2607 12:24 412-374-4011 I~ I.
Page 193 and 194:
Siemens Scope of Supply Comments Ge
Page 195 and 196:
2P Pg. 1 of 3 iemens Proposal #SD22
Page 197 and 198:
a Pg. 2 of 3 Turbine Testing: Propo
Page 199 and 200:
iemens Proposal #SD22007, CR3 Turbi
Page 201 and 202:
f I Crystal River 3 Generator Cross
Page 203 and 204:
Siemens Generator Workshop Feb 57,2
Page 205 and 206:
0 H2 gland seal rings Bearing refur
Page 207 and 208:
0 Advanced Hydrogen Cooled Stator D
Page 209 and 210:
February 16,2007 Siemens Power Gene
Page 211:
OPC ST 1 POD #1 080009 BATES NOS. P
Page 215 and 216:
Quality Management Manual (QMM 602)
Page 217 and 218:
Page 219 and 220:
Page 221 and 222:
Page 223 and 224:
Page 225:
Page 228 and 229:
Progress Energy Florida, Inc. Cryst
Page 230 and 231:
GENERAL INFORMATION In the event th
Page 232 and 233:
SCOPE AND OTHER REQUIREMENTS I. Bac
Page 234 and 235:
Appendix B program. The technical d
Page 236 and 237:
Telephone: Email: (352) 795-0504 x6
Page 238 and 239:
Summary Report. The selected Vendor
Page 240 and 241:
limitations. Identify the fire prot
Page 242 and 243:
for receiving bids. RFP documents s
Page 244 and 245:
1. 2. 3. 4. 5. 6. Attachment 6. Alt
Page 246 and 247:
PEF Safety Plan 18
Page 248 and 249:
Applicable Sections of the Site Cer
Page 250 and 251:
Helper Cooling Tower Performance Cu
Page 252 and 253:
Local Annual Windrose 24
Page 254 and 255:
April 10, 2008 Attn: Subject : Prog
Page 256 and 257:
ACKNOWLEDGEMENT To: Deborah Hanna P
Page 258 and 259:
Contractor's License Number (if app
Page 260 and 261:
schedule for the Project’s implem
Page 262 and 263:
. 3 90 O F Design Outlet Temperatur
Page 264 and 265:
0 Projected EAC 0 Accomplishments 0
Page 266 and 267:
October 13,2006 AR WA-06-2792 Mr. D
Page 268 and 269:
AREVA NP InC. Proposal #4 161084 PR
Page 270 and 271:
AREVA NP Inc. Proposal #4167084 - E
Page 272 and 273:
AREVA NP Inc. Proposal #4161084 PRO
Page 274 and 275:
AREVA NP Inc. Proposal #416 1084 PR
Page 276 and 277:
Page 278 and 279:
AREVA NP Iflc. Proposal #4161084 PR
Page 280 and 281:
CR-3 Power Uprate Project a Progres
Page 282 and 283:
Page 284 and 285:
AREVA NP lnc. Proposal #4161084 PRO
Page 286 and 287:
AREVA NP Inc. Proposal #4 161084 PR
Page 288 and 289:
AREVA Inc. Proposal #4161084 PROPRI
Page 290 and 291:
AREVA Inc. Proposal#4161084 PROPRIE
Page 292 and 293:
CR-3 Power Uprate Project 20 Progre
Page 294 and 295:
AREVA Inc. Proposal #4 161084 PROPR
Page 296 and 297:
Page 298 and 299:
AREVA Inc. Proposal #4 I6 7084 PROP
Page 300 and 301:
CR-3 Power Uprate Project 28 Ppgres
Page 302 and 303:
AREVA Inc. Proposal #47 61084 PROPR
Page 304 and 305:
Page 306 and 307:
Page 308:
A REVd inc. Proposal #47 67084 PROP
Page 311 and 312:
AREVA NP Inc P ROPRl ETARY - PENG07
Page 313 and 314:
ktum this Propsat, If requested. Pa
Page 315 and 316:
AREVA NP inc PROPRl ETARY PENG07-13
Page 317 and 318:
OPC 1 st POD #1 080009 BATES NOS. P
Page 319 and 320:
SIEMENS Modernnabon Pwnf Apnl 16 xx
Page 321 and 322:
I .- . -.. .,. Awl 16. 2007 Pqress
Page 325 and 326:
w a
Page 327 and 328:
SIEMENS Mcdwnaafion Roj& April 16,
Page 329 and 330:
SIEMENS PAOE 2 Semens Confidential
Page 331 and 332:
Mcdernuabon Projecl PPQE4 Generala
Page 333 and 334:
Modernnabon hied Apnll6, XO7 PAGE6
Page 335 and 336:
SEMENS Mcdernaabon proled Aprrl 16.
Page 337 and 338:
SIEMENS McdwnrzeOon Prolecl PAOE 10
Page 339 and 340:
MODERNIZED EXPERIENCE LIST SIEMENS
Page 341 and 342:
MODERNIZED EXPERIENCE LIST SIEMENS
Page 343:
SIEMENS
Page 349 and 350:
-1 F: i= Lu P w
Page 351 and 352:
All requests for clarifications, in
Page 353 and 354:
GENERAL IhTORMATION PROGRESS ENERGY
Page 355 and 356:
SCOPE AND OTHER REOUIREMENTS PROGRE
Page 357 and 358:
sizc or quantity. Further, in the e
Page 359 and 360:
Schedule Risk: agreement to h ish s
Page 361 and 362:
..ll-.l-l_l..--l.-l-- I - Progress
Page 363 and 364:
OPC ST 1 POD #1 080009 BATES NOS. P
Page 365 and 366:
Spec Page Crystal River Unit 3 Nucl
Page 367 and 368:
Spec Page # Nuclear Power Station R
Page 369 and 370:
Spec Page I Crystal River Unit 3 Nu
Page 371 and 372:
Section Reference Replacement Turbi
Page 373 and 374:
Crystal River Unit 3 Nuclear Power
Page 376 and 377:
Page 378 and 379:
Section Reference 1.11.11 1.11.12 1
Page 380 and 381:
Page 382 and 383:
Section Reference / d Crystal River
Page 384 and 385:
Spec Page # Crystal River Unit 3 Nu
Page 386 and 387:
~ Spec Page # 29 _. 29 - 29 - 29 29
Page 388 and 389:
~ - Spec Page # 'I Crystal River Un
Page 390 and 391:
spec Page # Section Reference Cryst
Page 392 and 393:
Spec Page # Section Reference I I C
Page 394:
t E E, 0 0 z c n 6 e h I1 n
Page 397 and 398:
f c ALST6)M I Power Systems May 30,
Page 399 and 400:
Alstom Power Inc. 2800 Waterford La
Page 401 and 402:
” . . v 111 Crystal River Nuclear
Page 403 and 404:
c Commercial Volume (U n pr iced) 2
Page 405 and 406:
Alstom Proposal # SD22007, CR3 EPU
Page 407 and 408:
Page 409 and 410:
Page 411 and 412:
Page 413 and 414:
I ' Our proposal offers a strong te
Page 415 and 416:
ENERCON SERVICES, INC. Proprietary
Page 418 and 419:
ENERCON SERVICES, INC. 5.0 ORGANIZA
Page 420 and 421:
CR3 Extended Power Uprate, Secondar
Page 422 and 423:
CR3 Extended Power Uprate, secondar
Page 424 and 425:
CR3 Extended Power Uprate, Secondar
Page 426 and 427:
September 4,2007 Page 2 Addendum to
Page 429:
CONFIDENTlF.? September 4,2007 Page
Page 437:
CONFIDEMTIP,!.
Page 445 and 446:
Daie TU; 9/4/07 Milestone Project S
Page 447:
1 Dace Tue 9/4/07 Milestone Prqed S
Page 453 and 454:
D Computer Model Updates o PEPSE- h
Page 455 and 456:
D D D D D D D Feedwater Control Val
Page 458 and 459:
D AREVA has full time employees wit
Page 460 and 461:
I W
Page 462 and 463:
~ AREVA - has a proven track record
Page 464 and 465:
Per the reement #I 01659, the LOL c
Page 466 and 467:
CR3 Extended Power Uprste, Secondar
Page 468 and 469:
. - * CR3 Extended Power Umate, Sec
Page 470 and 471:
(IHJ i3dendecl I'ower Ulirate, Seco
Page 473 and 474:
CONFIDENTlP!-
Page 475:
a CONFIDENTIP.!m PEF-NCR-01659
Page 480 and 481:
PROPRIETARY 20440-1 2 f3/30/2006) T
Page 482 and 483:
-- AREVA NP Inc. PROPRIETARY a CONF
Page 484 and 485:
July 27,2005 PROGRESS ENERGY SERVIC
Page 486 and 487:
Attachment A to Request No. KS12007
Page 488 and 489:
.. Clarlflcation on the 1CS system:
Page 490 and 491:
June 6,2007 Attention : PROGRESS EN
Page 492 and 493:
ACKNOWLEDGEMENT Mr. Tony Owen Progr
Page 494 and 495: In accordance with the Federal Acqu
Page 496 and 497: SCOPE AND OTHER REOUIREMENTS PROGRE
Page 498 and 499: place in the proposal at the expens
Page 500 and 501: other information provided in its p
Page 502 and 503: a ProgressEnergy Contractor's Safet
Page 504 and 505: 1 P96 I O-XJN-d3d
Page 506 and 507: ~ ____, Crystal River Unit 3 Nuclea
Page 508 and 509: Progress Energy Crystal River Unit
Page 528 and 529: P Progress Energy Crystal River Uni
Page 550 and 551: Progress Energy Crystat River Unit
Page 553 and 554: April 10,2008 PROGRESS ENERGY SERVI
Page 555 and 556: Attachment A to Request No. KS12007
Page 557 and 558: Clarification on the ICs system: At
Page 559 and 560: CR3 Extended Power Uprate, Secondar
Page 563 and 564: Proposal for Design Engineering of
Page 565 and 566: Tech Com International 440 Goddard
Page 569 and 570: Tech Coin International 440 Goddard
Page 573 and 574: ~ ~~~ Tech Com Intern ation a1 440
Page 577 and 578: ~~~ ~ ~ ~~ ~ ~~~ ~ Tech Com Interna
Page 579 and 580: PEF-NCR-02039
Page 581 and 582: Spec Page tt section Reference Crys
Page 583 and 584: Comments I 1 I I I I I I I and 18 t
Page 585 and 586: Spec Page # Mion Reference Crystal
Page 588 and 589: N B 00
Page 594 and 595:
.. CR3 Extended Power Uerate, Secon
Page 596 and 597:
Mr. Tony Owen Progress Energy Augus
Page 610 and 611:
JOB NO. PROPOSAL "RADIUSED HOLE" MS
Page 613 and 614:
ARRANGEMENT FOR STACKING AND JACKIN
Page 617 and 618:
a CONFIDENTlrl!
Page 619 and 620:
n a. TlEi Document Number: 07-924 P
Page 621 and 622:
1. Outline Drawings ....... 19 2. D
Page 623 and 624:
OPC ST 1 POD 080009 BATES NOS. PEF-
Page 625 and 626:
‘El Contract Summary on tents: a
Page 627 and 628:
TEI Contract Summary Payment Milest
Page 630 and 631:
TEI Contract Summary Performance Li
Page 632:
REDACTED Corrective Measures: - - -
Page 635 and 636:
'El Contract Sumrr iar roject Revie
Page 637 and 638:
Document Number: 07-248 Proposal Nu
Page 639 and 640:
Page 4.0 TECHNICAL 4.1 Performance
Page 641 and 642:
Finally, this unsolicited proposal
Page 643 and 644:
1. 2. 3. 4. 5. 6. 7. 8. On the spot
Page 645 and 646:
The TEI resources provisions are: a
Page 649 and 650:
4.0 TECHNICAL 4.1 Performance The p
Page 651 and 652:
8. The 4-pass box redesign assures
Page 653 and 654:
The design incorporates the state-o
Page 655 and 656:
e e e A higher structural integrity
Page 657 and 658:
4.4 MSR Performance Tests 4.4.1 Sco
Page 660:
n .L a W 2
Page 668 and 669:
Lfl CONFIDENTIFr!. JOB NO. PROPOSAL
Page 670 and 671:
PROPOSAL FUNCTION OF BY-PASS RESTRI
Page 674 and 675:
-1 r. m N N ? e: ? w" a
Page 676 and 677:
a CONFIDENTIAL PEF-NCR-02239
show all

siemens - Public Service Commission

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?