silo 3 - U.S. Department of Energy

More documents

Recommendations

Info

A&RS CCTV DOE FCP FEMP FMPC HEPA HVAC MRS nd PD PPE PRS PVS RCRA TSR U LPA VWMS '0 1. :*. . 4l ., Access and Retrieval Strategy for the Silo 3 Project Document No. 40430-PL-0002, Rev. 1 September 2003 ACRONYMS Access and Retrieval Strategy Closed-circuit television U.S. Department of Energy Fernald Closure Project Fernald Environmental Management Project Feed Materials Production Center High efficiency particulate air Heating, ventilation, and air conditioning Mechanical Retrieval System Not dated Process Description for the Silo 3 Project Personal protective equipment Pneumatic Retrieval System Process Vent System Resource Conservation and Recovery Act of 1976 Technical Safety Requirements Ultra low penetrating air Vacuum Wand Management System V 5069
Access and Retrieval Strategy for the Silo 3 Project Document No. 40430-PL-0002, Rev. 1 September 2003 * _. , ’; : 0 I .o INTRODUCTION 5069 This Access and Retrieval Strategy (A&RS) document describes the strategies, systems, and equipment for accessing and retrieving material from Silo 3. The silo is located at the U.S. Department of Energy (DOE) Fernald Closure Project (FCP) site in Fernald, Ohio. Previously, the site has been named the Feed Materials Production Center (FMPC) and the Fernald Environmental Management Project (FEMP). As part of the remediation of Operable Unit 4 at the FCP, approximately 5,100 yd3 of byproduct metal oxide materials stored in Silo 3 will be removed, conditionedltreated, packaged, and transported to an offsite facility for disposal. 0 0 The A&RS is limited to access and retrieval operations only and is not intended to describe the subsequent handling, conditioning/treatment, packaging, and transport of the Silo 3 material. These activities are covered in the Process Description for the Silo 3 Project (FEMP 2003). 1.1 OVERVIEW OF ACCESS AND RETRIEVAL SYSTEMS 1.1.1 PRELIMINARY ACTIVITIES Access and retrieval of the Silo 3 material will be accomplished by using both pneumatic and mechanical systems. Before the silo is accessed for retrieval operations, the radon concentration in the silo headspace will be reduced to an acceptable level. In preparation for mechanical retrieval, a reinforced concrete framework has been installed on the east silo wall (during Silo 3 Project construction), and a section of the silo wall will be removed (after initial pneumatic retrieval operations). 1.1.2 PNEUMATIC RETRIEVAL SYSTEM x. Pneumatic retrieval involves vacuuming material through the existing man ways on the Silo 3 dome. The system is used to remove flowable material in a controlled manner from top to bottom and from behind the silo wall before creating the wall opening. The Pneumatic Retrieval System (PRS) transfers the material to the Process Building, where the material is conditionedhreated and packaged. The PRS will be operated initially since the material height is into the dome space. 1.1.3 MECHANICAL RETRIEVAL SYSTEM In addition to pneumatic retrieval, a Mechanical Retrieval System (MRS) is used to access and remove the compacted material from Silo 3. A mechanical excavator transfers Silo 3 material to a bin located in the Excavator Room. An inclined belt conveyor feeds the material to the Process Building. It is also expected that the excavator will be used as necessary to manipulate a vacuum wand end effector to retrieve material using the PRS. The excavator can also be used specifically to loosen compacted material, which then could be vacuumed by the PRS vacuum wands located inside the silo.
Page 1 and 2:
SILO 3' PROJECT REMEDIAL DESIGN / R
Page 3 and 4:
~-~~ /, - DRAWINGS I . 1' Civil Dra
Page 5 and 6:
e e 1.0 Purpose and Scope t ?: 5069
Page 7 and 8:
0 assumed 0 0 - 5069. , *. , , .-i
Page 9 and 10:
1 5 1 Silo 3 RD/RA Package, 40430-R
Page 11 and 12: 0 characteristics. 0 5049 Silo 3 RD
Page 13: * ACTIVITY / DELIVERABLE Submit Sil
Page 16 and 17: e Revision Date Prepared By Checked
Page 18 and 19: . ..... . . '_ Process Description
Page 20 and 21: .e . . . . b.1 . .. , 8 , . ". 3 .i
Page 22 and 23: e .L 0 .;- REFERENCE DRAWINGS (cont
Page 24 and 25: 0 Process Description for the Silo
Page 26 and 27: P . .. m C 4 0 d r 0 E a .m ii 0000
Page 28 and 29: Proces's Description for the Silo 3
Page 30 and 31: - B-2 'fi' 2.1.5 'Pneumatic Retriev
Page 32 and 33: Process Description for the Silo 3
Page 34 and 35: I < :,i,' ;1 'e 1 t . (,, : . RCV:2
Page 36 and 37: i: >! {i.Fk . 4 .... < - . " , Proc
Page 38 and 39: .i\ . . + Q :.h- '2. *L * .f .a ..*
Page 41 and 42: Process Description tor the Silo 3
Page 43 and 44: ;, I't I: - . Process Description f
Page 45 and 46: * Process Description for the Silo
Page 47 and 48: . .- a ” 4.0;. .. 5.2.1 Sodium Li
Page 49 and 50: a 6.0 ': SUPPORT SYSTEMS - 6.1 HEAT
Page 51 and 52: 8 . tic 2,J * ' ' \3 cy!,; rrocess
Page 53 and 54: a a , 0 Miscellaneous filters, afte
Page 55 and 56: a Process Description for the Silo
Page 57 and 58: R ni 2
Page 59 and 60: -_______ , f Revision 0 1 Date 711
Page 61: Access and Retrieval Strategy for t
Page 65 and 66: .r t :: I-. a ,J d+ Access and Retr
Page 67 and 68: @ 1.4 LOAD LIMITATIONS ON SILO 3 Ac
Page 69 and 70: I' .\ I . I . a . ; 2.0 ACCESS AND
Page 71 and 72: a 3.0' PNEUMATIC RETRIEVAL SYSTEM 3
Page 73 and 74: 0 o h i, , :, f , -4 \ 1. t- Access
Page 75 and 76: 0 Break up compacted material withi
Page 77 and 78: . I: r, !*; \.I 5- Access and Retri
Page 79 and 80: . I . 4 . . r hir 1' I Access and R
Page 81 and 82: - :, :!,:- Access and Retrieval Str
Page 83 and 84: ,. .. . . .. . .. . _.. ,
Page 85 and 86: I Revision I BS PROCESS CONTROL PLA
Page 87 and 88: l!!EI,.~COSS r e ,I t,i TABLE OF CO
Page 89 and 90: * c . . BHJACOBS .. f ,'. !) . - LI
Page 91 and 92: 'e - B: . I ., e? if < \ (1 ,!- REF
Page 93 and 94: Process Control Plan for the Silo 3
Page 95 and 96: e 0 0 .-. ,? . :' .. _, Drag Flight
Page 97 and 98: 1/ . .I 1 , ir. A . r. /.Sa L Table
Page 99 and 100: I!HJACOBS September Process Control
Page 101 and 102: ~ ~~~ Process Control Plan for the
Page 103 and 104: - e e e - 0 al al E .- a . LO ._ .
Page 105 and 106: __ __ __ Process Control Plan for t
Page 107 and 108: e a ., i . 5U69 ' . Table 2-3 PRS S
Page 110 and 111: __ --- B-S- Process Control Pian fo
Page 112 and 113:
- m.’!aBsL- __ - 5-0-69 - ~ Proce
Page 114 and 115:
5069 y. 0 al 0 .- a a a 5 .- C 0, w
Page 116 and 117:
23 24 25 26 27 28 29 30 38 41 42 Ta
Page 118 and 119:
FLT-19-52048 FAN-1 9-520644 FAN-1 9
Page 120 and 121:
50 69 000117
Page 122 and 123:
0 Packaging Frames do not come into
Page 124 and 125:
l9 All setpoints will be reviewed a
Page 126 and 127:
__ . m:JjA!!oBs- 0 run time hour me
Page 128 and 129:
__ -- BS-- 0 motor overload, and 0
Page 131 and 132:
0 8.3.1 Receipt, Storage, and Trans
Page 133 and 134:
50 69 Process Control Plan for the
Page 135 and 136:
0 TNK-44-5002 BN K-44-5004A TNK-44-
Page 137 and 138:
.- c 0 CI Q c, 5 E - E =I c, tn e E
Page 139 and 140:
9.6 WASTEWATER SYSTEM DATA ARCHIVIN
Page 141 and 142:
000138 5 - 0 - 9
Page 143 and 144:
-- 5069 000140 e
Page 145 and 146:
I woo20-a H0020-2 H0020-3 H0022-'8
Page 147 and 148:
H0026-2 ACU-70-5702 DPW-70-6016 DBR
Page 149 and 150:
Process Control Plan for the Silo 3
Page 151 and 152:
12.0 . CCTV SYSTEM (SYSTEM 95) 12.1
Page 154 and 155:
Silo 3 Environmental Control Plan 4
Page 156 and 157:
ALARA BAT CFR DOE DPC EDE FEMP FTL
Page 158 and 159:
- __ - 5069 Silo 3-Environmental-C-
Page 160 and 161:
2.1.2 Emission Control During Retri
Page 162 and 163:
I----- . - line radon concentration
Page 164 and 165:
Silo 3 Environmental Control Plan 4
Page 166 and 167:
- 5069 Silo 3 Environmental Control
Page 168 and 169:
4.0 FUGITIVE DUST CONTROL PLAN - 50
Page 170 and 171:
e e e 7- 5069 Silo 3 Environmental
Page 172 and 173:
.. . e ,,. * ’ +- 5069 Silo 3 Env
Page 174 and 175:
, . c .a F- 5069 - Silo 3 Environme
Page 176 and 177:
. .. )r 50 -~ ~ 5.6 WASTE CONTAINER
Page 178 and 179:
-' . . . .J ' . 6 .O 1. 2. 3. 4. 5.
Page 180 and 181:
. . SECTION Fence Silt Fence 10' p-
Page 182 and 183:
Dam Height (feet) 1 2 3 Specificati
Page 184 and 185:
. . 50 69
Page 186 and 187:
, i. 1. 2. 3. 4. 5. 6. 7. 8. OFF-HO
Page 188 and 189:
_. t . Date of Response: Time of Fi
Page 190 and 191:
.- tu ti c, g* m T 5- 5069
Page 192 and 193:
.. , ESTIMATE OF WASTE DURING CONST
Page 194 and 195:
0 0 a *. ' i' .. . 5069 B
Page 196:
- 5069 m
Page 199:
L a r I-. a . z '0 c m - v) a) 0 I
Page 202 and 203:
000197
Page 204 and 205:
- 5069 000199
Page 206 and 207:
' ' .,j ! 500 0 0 - 5069
Page 210 and 211:
c) C a dB00205
Page 212 and 213:
2 a QI CI n U 5069
Page 214 and 215:
I 3 2 5069
Page 216 and 217:
c Calculation Nuclear Engineering .
Page 218 and 219:
, "I 4 ; . c: ," ir f 5069 Descript
Page 220 and 221:
GaDeuPation Inputs:. Polorhm-218 Ra
Page 222 and 223:
0 . Q Calculation Section: 1. Parti
Page 224 and 225:
2. Radon Release Rate 35H19605 The
Page 226 and 227:
3. Convevor Tor> and Bottom EN G I
Page 228 and 229:
3. Total Release Rate Calculation N
Page 230 and 231:
E N G I N E E R I N GQ Project: 35H
Page 232 and 233:
* nACOBS E N 0 I N E E R I N G@ Dos
Page 234 and 235:
m w E N G I N E E R I N G@ AllACHME
Page 236 and 237:
t' 0 AITACHMENT A JACOBS E N G I N
Page 238 and 239:
E N G I N E E R I N GQD AITACHMENT
Page 240 and 241:
. . ..
Page 242 and 243:
I Approved BY I TIMEQ ESTIMATE OF S
Page 244 and 245:
Timed Estimate of Secondary Waste f
Page 246 and 247:
__ __- - Timed Estimate of Secondar
Page 248 and 249:
2.'2 Mechanical Retrieval System Ti
Page 250:
,: 'L - ~~ *' j :- 0 - -~~____ Time
Page 253 and 254:
I 00 x n 2 U C m
Page 255 and 256:
I. - .- c 0 c m a t t cu T- 5069 0
Page 257 and 258:
Signature Page I SILOS PROJECTS ENV
Page 259 and 260:
issue Authorization Date Effective
Page 261 and 262:
SECTION SILOS PROJECTS Silos Projec
Page 263 and 264:
F 33 Silos Project Environmental Mo
Page 265 and 266:
e 1 2 3 4 5 6 7 8 9 10 11 12 13 . i
Page 267 and 268:
L 3 4 5 6 7 8 9 10 11 12 13 14 15 1
Page 269 and 270:
2 3 4 5 6 7 8 9 10 11 12 13 14 15 1
Page 271 and 272:
A I 8 I 7 I 6 I 5 0 4 I 3 I 2 I' 1
Page 273:
SEE DRAWING 94X-5500-SK-5527 . .. .
Page 276 and 277:
a. This document has been reviewed
Page 278 and 279:
I r tp t 1 m f z 0 0 3 0 0 0 EL c c
Page 281 and 282:
1 5 5 L - m P f 0 0 -!I 4. 0 .- or
Page 283 and 284:
L 5 - m Q, I d v- 0 3 4 0 0 * I 506
Page 285 and 286:
E 0 B I- O 4 I 50 69
Page 287 and 288:
: ."! . * , _ -- 5069
Page 289 and 290:
i- 't ',- ? . 50 69 000.280
Page 291 and 292:
! 4 z 0 0 .- A< 1 - 5069
Page 293:
I 506
Page 297 and 298:
a a I I I---. .._ 7 I 2 I 3 I 4 I I
Page 299 and 300:
W n U
Page 301 and 302:
+ I I 2 I 3 I 4 I 5 I 6 I 7 I a STR
Page 303 and 304:
FROM SUPPLY FROM EUlLOlNG HVAC SYST
Page 305 and 306:
a I 1 I _ -- _ -.._..____..-.. - -.
Page 307 and 308:
Piping and Instrumentation Diagrams
Page 309 and 310:
I I 2 I 3 I 4 I INSTRUMENT FUNCTION
Page 311 and 312:
P 81 I I I I I I 2 n STACK EOUlPMEN
Page 313 and 314:
EXC-11-5050 DKCHbRCE EXCAVATOR FROU
Page 315 and 316:
I I 2 I 3 I 4 I 5 I 6 I 7 I 8 SlLC
Page 317 and 318:
I FROY PACKAGE LOADING STAHD A I I
Page 319 and 320:
I I 2 I 3 I 4 I 5 I 6 PROCESS HEPA
Page 321 and 322:
NOTE 2 1 I I .J I U I I 1 tl T IA-4
Page 323 and 324:
I E C D E F .. .. I. . . . . . I I
Page 325 and 326:
I - I 2 I 3 I 4 I 5 I 6 I 7 I 8 I F
Page 328:
I OPERATIONS SUPPORT TRNLER Lu '0 I
Page 331 and 332:
I I I 2 I 3 I 4 I 5 I 6 I 7 I 8 EQU
Page 333 and 334:
575 OUT PUB NR 575 OUT u1B UR I I 4
Page 335 and 336:
E E FROM PROCESS EULMNC EXHWST HOOD
Page 337 and 338:
.- STORAGE AND WASTEWATFR TANK #REA
Page 339 and 340:
I 100% OUTmE ALlslENl YR 5750 CFU l
Page 341 and 342:
a DPR-70-6019 W-70-6020 FC FROM PAC
Page 343 and 344:
a a FROM PACKAGWG MEA AND NRLOCKIDO
Page 345 and 346:
FAN-77-5790A ! HTR-77-57404 SET 0 5
Page 347:
I I F - I GEcLEBbl THE sno 3 WAC SY
Page 350 and 351:
a e REF I I 2 I 3 I 4 I 5 I 6 r 0 I
Page 352 and 353:
0 0 0 0 0 0 I I 7 I 8 I GENERAL NOT
Page 354 and 355:
.. I I 2 I 3 I 4 I I I KXA-44-5000
Page 356 and 357:
I ! ! ! ! ! ! ! ! ! ! ! - I 2 I 3 I
Page 358 and 359:
I E ! ! ! ! ! ! I 2 3 I 4 I 5 I 6 !
Page 360 and 361:
a _-
Page 362 and 363:
2 W I- fr ,. . . . I :; .. b' . z f
show all

silo 3 - U.S. Department of Energy

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?