silo 3 - U.S. Department of Energy

More documents

Recommendations

Info

I . i.. ANSI A&RS AWWT CCTV CEM CSI FEMP HEPA HMI HVAC I/O I SA MRS P&l D PC PCP PD PFD PID PLC PRS PVS RF UNlD W E ACRONYMS' American National Standards Institute Access and Retrieval Strategy Advanced Wastewater Treatment closed-circuit television Continuous Emissions Monitor Construction Specifications Institute Fernald Environmental Management Project high-efficiency particulate air human-machine interface heating, ventilation, and air conditioning inputloutput Instrument Society of America Mechanical Retrieval System piping and instrument diagram personal computer Process Control Plan Process Description process flow diagram proportional-integral-derivative programmable logic controller Pneumatic Retrieval System Process Vent System Radio frequency unique identifier Vacuum Wand Enclosure 'Additional acronyms are provided in Tables 1-2 through Table 1-6. viii Process Control Pian for the Silo 3 Project Document No. 40430-PL-0003, Rev. 1 Jacobs Project Number 35H19605 September 5, 2003 000089 e - 5069 ' 9
Process Control Plan for the Silo 3 Project Document No. 40430-PL-0003, Rev. 1 Jacobs Project Number 35H19605 September 5, 2003 This Process Control Plan (PCP) addresses the instrumentation and control logic for equipment used in the Silo 3 Project at the U.S. Department of Energy Fernald Environmental Management Project (FEMP) site. As part of the remediation of Operable Unit 4 at the FEMP, approximately 5,100 yd3 of byproduct metal oxide materials stored in Silo 3 will be removed, conditioned, packaged, and transported to an off-site facility for I treatment and/or disposal. Two other documents are frequently referenced in the PCP. These are Process Descrr;Otion fur the Silo 3 Project (PD) (FEMP 2003a), which discusses the Silo 3 process systems and I equipment, and Access and Retrieval Strategy for the Silo 3 Project (A&RS) (FEMP 2002a), which describes the strategies used to remove material from Silo 3. The I A&RS also describes the history of generation of Silo 3 material and its quantity and characteristics (A&RS, Section 1.4). This PCP provides, on a system-by-system basis, descriptions of the following: 0 Control philosophy Interlocks 0 Setpoints and responses 0 Data archiving 1 .I SYSTEM NAMES AND NUMBERS The systems addressed in this PCP and the relevant section numbers are shown in Table 1-1: The same system names and numbers are also used in the Design Basis and Requirements Document (FEMP 2002b). 1.2 NON-SYSTEM NAMES AND NUMBERS Numbering systems for equipment, lines, valves, and instruments are defined in Project Procedure FF-103-01 (Jacobs Engineering 2002). These systems are described in the following sections: 1.2. I Equipment Numbering The equipment numbering system is as follows: XXXJJ-UZZ Where: 0 XXX represents the Equipment Designator (see Table 1-2). 0 JJ represents the System Number (see Table 1-1). 0 ZZZZ represents the Equipment Sequence Number. For Silo 3, this is in the range 5000-6999. All Silo 3 equipment numbers are provided in Silo 3 Project Equipment List (FEMP 2003b). 1-1
Page 1 and 2:
SILO 3' PROJECT REMEDIAL DESIGN / R
Page 3 and 4:
~-~~ /, - DRAWINGS I . 1' Civil Dra
Page 5 and 6:
e e 1.0 Purpose and Scope t ?: 5069
Page 7 and 8:
0 assumed 0 0 - 5069. , *. , , .-i
Page 9 and 10:
1 5 1 Silo 3 RD/RA Package, 40430-R
Page 11 and 12:
0 characteristics. 0 5049 Silo 3 RD
Page 13:
* ACTIVITY / DELIVERABLE Submit Sil
Page 16 and 17:
e Revision Date Prepared By Checked
Page 18 and 19:
. ..... . . '_ Process Description
Page 20 and 21:
.e . . . . b.1 . .. , 8 , . ". 3 .i
Page 22 and 23:
e .L 0 .;- REFERENCE DRAWINGS (cont
Page 24 and 25:
0 Process Description for the Silo
Page 26 and 27:
P . .. m C 4 0 d r 0 E a .m ii 0000
Page 28 and 29:
Proces's Description for the Silo 3
Page 30 and 31:
- B-2 'fi' 2.1.5 'Pneumatic Retriev
Page 32 and 33:
Process Description for the Silo 3
Page 34 and 35:
I < :,i,' ;1 'e 1 t . (,, : . RCV:2
Page 36 and 37:
i: >! {i.Fk . 4 .... < - . " , Proc
Page 38 and 39:
.i\ . . + Q :.h- '2. *L * .f .a ..*
Page 41 and 42: Process Description tor the Silo 3
Page 43 and 44: ;, I't I: - . Process Description f
Page 45 and 46: * Process Description for the Silo
Page 47 and 48: . .- a ” 4.0;. .. 5.2.1 Sodium Li
Page 49 and 50: a 6.0 ': SUPPORT SYSTEMS - 6.1 HEAT
Page 51 and 52: 8 . tic 2,J * ' ' \3 cy!,; rrocess
Page 53 and 54: a a , 0 Miscellaneous filters, afte
Page 55 and 56: a Process Description for the Silo
Page 57 and 58: R ni 2
Page 59 and 60: -_______ , f Revision 0 1 Date 711
Page 61 and 62: Access and Retrieval Strategy for t
Page 63 and 64: Access and Retrieval Strategy for t
Page 65 and 66: .r t :: I-. a ,J d+ Access and Retr
Page 67 and 68: @ 1.4 LOAD LIMITATIONS ON SILO 3 Ac
Page 69 and 70: I' .\ I . I . a . ; 2.0 ACCESS AND
Page 71 and 72: a 3.0' PNEUMATIC RETRIEVAL SYSTEM 3
Page 73 and 74: 0 o h i, , :, f , -4 \ 1. t- Access
Page 75 and 76: 0 Break up compacted material withi
Page 77 and 78: . I: r, !*; \.I 5- Access and Retri
Page 79 and 80: . I . 4 . . r hir 1' I Access and R
Page 81 and 82: - :, :!,:- Access and Retrieval Str
Page 83 and 84: ,. .. . . .. . .. . _.. ,
Page 85 and 86: I Revision I BS PROCESS CONTROL PLA
Page 87 and 88: l!!EI,.~COSS r e ,I t,i TABLE OF CO
Page 89 and 90: * c . . BHJACOBS .. f ,'. !) . - LI
Page 91: 'e - B: . I ., e? if < \ (1 ,!- REF
Page 95 and 96: e 0 0 .-. ,? . :' .. _, Drag Flight
Page 97 and 98: 1/ . .I 1 , ir. A . r. /.Sa L Table
Page 99 and 100: I!HJACOBS September Process Control
Page 101 and 102: ~ ~~~ Process Control Plan for the
Page 103 and 104: - e e e - 0 al al E .- a . LO ._ .
Page 105 and 106: __ __ __ Process Control Plan for t
Page 107 and 108: e a ., i . 5U69 ' . Table 2-3 PRS S
Page 110 and 111: __ --- B-S- Process Control Pian fo
Page 112 and 113: - m.’!aBsL- __ - 5-0-69 - ~ Proce
Page 114 and 115: 5069 y. 0 al 0 .- a a a 5 .- C 0, w
Page 116 and 117: 23 24 25 26 27 28 29 30 38 41 42 Ta
Page 118 and 119: FLT-19-52048 FAN-1 9-520644 FAN-1 9
Page 120 and 121: 50 69 000117
Page 122 and 123: 0 Packaging Frames do not come into
Page 124 and 125: l9 All setpoints will be reviewed a
Page 126 and 127: __ . m:JjA!!oBs- 0 run time hour me
Page 128 and 129: __ -- BS-- 0 motor overload, and 0
Page 131 and 132: 0 8.3.1 Receipt, Storage, and Trans
Page 133 and 134: 50 69 Process Control Plan for the
Page 135 and 136: 0 TNK-44-5002 BN K-44-5004A TNK-44-
Page 137 and 138: .- c 0 CI Q c, 5 E - E =I c, tn e E
Page 139 and 140: 9.6 WASTEWATER SYSTEM DATA ARCHIVIN
Page 141 and 142: 000138 5 - 0 - 9
Page 143 and 144:
-- 5069 000140 e
Page 145 and 146:
I woo20-a H0020-2 H0020-3 H0022-'8
Page 147 and 148:
H0026-2 ACU-70-5702 DPW-70-6016 DBR
Page 149 and 150:
Process Control Plan for the Silo 3
Page 151 and 152:
12.0 . CCTV SYSTEM (SYSTEM 95) 12.1
Page 154 and 155:
Silo 3 Environmental Control Plan 4
Page 156 and 157:
ALARA BAT CFR DOE DPC EDE FEMP FTL
Page 158 and 159:
- __ - 5069 Silo 3-Environmental-C-
Page 160 and 161:
2.1.2 Emission Control During Retri
Page 162 and 163:
I----- . - line radon concentration
Page 164 and 165:
Silo 3 Environmental Control Plan 4
Page 166 and 167:
- 5069 Silo 3 Environmental Control
Page 168 and 169:
4.0 FUGITIVE DUST CONTROL PLAN - 50
Page 170 and 171:
e e e 7- 5069 Silo 3 Environmental
Page 172 and 173:
.. . e ,,. * ’ +- 5069 Silo 3 Env
Page 174 and 175:
, . c .a F- 5069 - Silo 3 Environme
Page 176 and 177:
. .. )r 50 -~ ~ 5.6 WASTE CONTAINER
Page 178 and 179:
-' . . . .J ' . 6 .O 1. 2. 3. 4. 5.
Page 180 and 181:
. . SECTION Fence Silt Fence 10' p-
Page 182 and 183:
Dam Height (feet) 1 2 3 Specificati
Page 184 and 185:
. . 50 69
Page 186 and 187:
, i. 1. 2. 3. 4. 5. 6. 7. 8. OFF-HO
Page 188 and 189:
_. t . Date of Response: Time of Fi
Page 190 and 191:
.- tu ti c, g* m T 5- 5069
Page 192 and 193:
.. , ESTIMATE OF WASTE DURING CONST
Page 194 and 195:
0 0 a *. ' i' .. . 5069 B
Page 196:
- 5069 m
Page 199:
L a r I-. a . z '0 c m - v) a) 0 I
Page 202 and 203:
000197
Page 204 and 205:
- 5069 000199
Page 206 and 207:
' ' .,j ! 500 0 0 - 5069
Page 210 and 211:
c) C a dB00205
Page 212 and 213:
2 a QI CI n U 5069
Page 214 and 215:
I 3 2 5069
Page 216 and 217:
c Calculation Nuclear Engineering .
Page 218 and 219:
, "I 4 ; . c: ," ir f 5069 Descript
Page 220 and 221:
GaDeuPation Inputs:. Polorhm-218 Ra
Page 222 and 223:
0 . Q Calculation Section: 1. Parti
Page 224 and 225:
2. Radon Release Rate 35H19605 The
Page 226 and 227:
3. Convevor Tor> and Bottom EN G I
Page 228 and 229:
3. Total Release Rate Calculation N
Page 230 and 231:
E N G I N E E R I N GQ Project: 35H
Page 232 and 233:
* nACOBS E N 0 I N E E R I N G@ Dos
Page 234 and 235:
m w E N G I N E E R I N G@ AllACHME
Page 236 and 237:
t' 0 AITACHMENT A JACOBS E N G I N
Page 238 and 239:
E N G I N E E R I N GQD AITACHMENT
Page 240 and 241:
. . ..
Page 242 and 243:
I Approved BY I TIMEQ ESTIMATE OF S
Page 244 and 245:
Timed Estimate of Secondary Waste f
Page 246 and 247:
__ __- - Timed Estimate of Secondar
Page 248 and 249:
2.'2 Mechanical Retrieval System Ti
Page 250:
,: 'L - ~~ *' j :- 0 - -~~____ Time
Page 253 and 254:
I 00 x n 2 U C m
Page 255 and 256:
I. - .- c 0 c m a t t cu T- 5069 0
Page 257 and 258:
Signature Page I SILOS PROJECTS ENV
Page 259 and 260:
issue Authorization Date Effective
Page 261 and 262:
SECTION SILOS PROJECTS Silos Projec
Page 263 and 264:
F 33 Silos Project Environmental Mo
Page 265 and 266:
e 1 2 3 4 5 6 7 8 9 10 11 12 13 . i
Page 267 and 268:
L 3 4 5 6 7 8 9 10 11 12 13 14 15 1
Page 269 and 270:
2 3 4 5 6 7 8 9 10 11 12 13 14 15 1
Page 271 and 272:
A I 8 I 7 I 6 I 5 0 4 I 3 I 2 I' 1
Page 273:
SEE DRAWING 94X-5500-SK-5527 . .. .
Page 276 and 277:
a. This document has been reviewed
Page 278 and 279:
I r tp t 1 m f z 0 0 3 0 0 0 EL c c
Page 281 and 282:
1 5 5 L - m P f 0 0 -!I 4. 0 .- or
Page 283 and 284:
L 5 - m Q, I d v- 0 3 4 0 0 * I 506
Page 285 and 286:
E 0 B I- O 4 I 50 69
Page 287 and 288:
: ."! . * , _ -- 5069
Page 289 and 290:
i- 't ',- ? . 50 69 000.280
Page 291 and 292:
! 4 z 0 0 .- A< 1 - 5069
Page 293:
I 506
Page 297 and 298:
a a I I I---. .._ 7 I 2 I 3 I 4 I I
Page 299 and 300:
W n U
Page 301 and 302:
+ I I 2 I 3 I 4 I 5 I 6 I 7 I a STR
Page 303 and 304:
FROM SUPPLY FROM EUlLOlNG HVAC SYST
Page 305 and 306:
a I 1 I _ -- _ -.._..____..-.. - -.
Page 307 and 308:
Piping and Instrumentation Diagrams
Page 309 and 310:
I I 2 I 3 I 4 I INSTRUMENT FUNCTION
Page 311 and 312:
P 81 I I I I I I 2 n STACK EOUlPMEN
Page 313 and 314:
EXC-11-5050 DKCHbRCE EXCAVATOR FROU
Page 315 and 316:
I I 2 I 3 I 4 I 5 I 6 I 7 I 8 SlLC
Page 317 and 318:
I FROY PACKAGE LOADING STAHD A I I
Page 319 and 320:
I I 2 I 3 I 4 I 5 I 6 PROCESS HEPA
Page 321 and 322:
NOTE 2 1 I I .J I U I I 1 tl T IA-4
Page 323 and 324:
I E C D E F .. .. I. . . . . . I I
Page 325 and 326:
I - I 2 I 3 I 4 I 5 I 6 I 7 I 8 I F
Page 328:
I OPERATIONS SUPPORT TRNLER Lu '0 I
Page 331 and 332:
I I I 2 I 3 I 4 I 5 I 6 I 7 I 8 EQU
Page 333 and 334:
575 OUT PUB NR 575 OUT u1B UR I I 4
Page 335 and 336:
E E FROM PROCESS EULMNC EXHWST HOOD
Page 337 and 338:
.- STORAGE AND WASTEWATFR TANK #REA
Page 339 and 340:
I 100% OUTmE ALlslENl YR 5750 CFU l
Page 341 and 342:
a DPR-70-6019 W-70-6020 FC FROM PAC
Page 343 and 344:
a a FROM PACKAGWG MEA AND NRLOCKIDO
Page 345 and 346:
FAN-77-5790A ! HTR-77-57404 SET 0 5
Page 347:
I I F - I GEcLEBbl THE sno 3 WAC SY
Page 350 and 351:
a e REF I I 2 I 3 I 4 I 5 I 6 r 0 I
Page 352 and 353:
0 0 0 0 0 0 I I 7 I 8 I GENERAL NOT
Page 354 and 355:
.. I I 2 I 3 I 4 I I I KXA-44-5000
Page 356 and 357:
I ! ! ! ! ! ! ! ! ! ! ! - I 2 I 3 I
Page 358 and 359:
I E ! ! ! ! ! ! I 2 3 I 4 I 5 I 6 !
Page 360 and 361:
a _-
Page 362 and 363:
2 W I- fr ,. . . . I :; .. b' . z f
show all

silo 3 - U.S. Department of Energy

Create successful ePaper yourself

Delete template?

Save as template?