CONTROL MODULE PIN OUT INFORMATION ADAPTIVE DAMPING CONTROL MODULE 77 Pin Description 0 EM.58.1 INSTRUMENT PACK ADAPTIVE DAMPENING MIL 0 EM&-3 ACCELEROMETER COMMON GROUND SUPPLY D EM68-10 SERIAL COMMUNlCATiONS I Eb.468~11 IGNITION SWITCHED POWER SUPPLY 0 EM68-13 LH REAR DAMPER BA”ERY POWER SUPPLY 0 EM68-14 RH FRONT DAMPER BATTERY POWER SUPPLY 0 EM68-li RH REAR DAMPER BATrERY POWER SUPPLY 1 EM68-18 GROUND I EM68-20 FRONT LATERAL ACCELEROMETER FEEDBACK I EMSS-21 FRONTVERTICALACCELEROMETER FEEDBACK I EM%-22 REAR VERTICAL ACCELEROMETER FEEDBACK I EMSS-24 “EHiCLE SPEED SIGNAL 0 EM68-25 ACCELEROMETER COMMON VOLTAGE SUPPLY 1 EM68-26 BRAKE SWITCH I EM68-27 BATTERY POWER SUPPLY D EM&28 SERIAL COMMUNlCATlONS 0 EM68-30 LH FRONT DAMPER BATTERY POWER SUPPLY 0 EM@%31 LH FRONT DAMPER 0 EM68-32 LH REAR DAMPER 0 EM68-33 RH FRONT DAMPER 0 EM88-34 RH REAR DAMPER Active GROUND GROUND B+ B+ B+ B+ GROUND 4.8”
CONTROL MODULE PIN OUT INFORMATION BODY PROCESSOR MODULE 0 Pin Description DRIVER DOOR CONTROL v Pin Description lGNlT,ON SwlTCHED GROUND SEAT HEATER STATUS iLHD = PASSENGER, RHD = DRIVER) IGNITION SWITCHED GROUND SEAT HEATER REOUEST (LHD = PASSENGER. RHD = DRiVERi STARTER ENGAGE REOUEST SEAT HEATER STATUS iLHD = DRIVER. RHD = PASSENGER, BATTERY SUPPLY VOLTAGE SCP NETWORK SCP NETWORK SEAT HEATER REOUEST iLHD = DRIVER, RHO = PASSENGER, MODULE I DD10-1 BA”ERY POWER SUPPLY I DD10-8 LOGIC GROUND S DD,O-9 SCP NETWORK S DDIO-16 SCP NETWORK 0 DDll-2 SEAT MEMORY STATUS LED DRIVER REAR DOOR CONTROL 77 Pin Description BAVERY POWER SUPPLY LOGIC GROUND SCP NETWORK S RD10-16 SCP NE7WORK MODULE Active GROUND GROUND GROUND GROUND GROUND IMOMENTARY) ,CRANKINGl GROUND B- 2- 1800 HZ 2- ,800 HZ GROUND iMOMENTARYl B+ Active B- GROUND 2- ,600 HZ 2- 1800 HZ GROUND Active B+ (LED ONi Inactive Bt B+ B+ Bc B+ B+ B+ Inactive B+ GROUND B+ Inactive Bt GROUND COMPONENTS Component Connector I Type I Color Location I Access BODY PROCESSOR MODULE DOOR CONTROL MODULE- DRIVER DOOR CONTROL MODULE- DRIVER REAR ,NSTR”MENT PACK MEMORY SWITCHES (DRIVER DOOR SWITCH PACKI SEAT CONTROL MODULE - DRI”ER SEAT CUSHlON HEATERS - DRIVER SEAT HEATER SWITCH (CENTER CONSOLE SWITCH PACK1 SEAT LUMBAR SEAT MOTORS GROUND 2- ,600 Hz 2 - ,600 Hz RELAYS I RD,O-19 MODULE IDENTIFICAT,ON GROUND / RDll-5 MEMORY 1 I RD11~7 MODULE IDENTIFICATION / RDll-13 MEMORY SET I RDll-15 MEMORY 3 I RD11~22 MEMORY 2 DRIVER SEAT CONTROL v Pin Description 0 SM,-,D 0 SM1~2D 0 SMMD 0 SM,-40 0 SM,-SD 0 SM,-8D 0 SMI-7D 0 SMMD I SM,-SD I SMI-IOD I SMI-IlD I SM,-lZD I SM,-732 I SMI-l4D / SMI-15D I SMl-18D MODULE DRIVER SEAT SOUAB FORE, AFT RECLINE MOTOR SUPPLY DRIVER SEAT SOUAB FORE, AFT RECLINE MOTOR SUPPLY DRl”ER SEAT CUSHION RAlSE, LOWER FRONT MOTOR SUPPLY DRIVER SEAT CUSHION RAISE, LOWER FRONT MOTOR SUPPLY DRl”ER HEADREST RAlSE , LOWER MOTOR SUPPLY DRIVER HEADREST RAlSE, LOWER MOTOR SUPPLY DRIVER SEAT CUSHlON FORE /AFT MOTOR SUPPLY DRIVER SEAT CUSHlON FORE /AFT MOTOR SUPPLY DRIVER SEAT CUSHION FORE MOVEMENT REQUEST DRIVER SEAT CUSHION AFT MOVEMENT REOUEST DRIVER SEAT C”SH,ON LOWER REAR MOVEMENT REOUEST DRIVER SEAT CUSHiON RAiSE REAR MOVEMENT REOUEST DRIVER SEAT CUSHION RAISE FRONT MOVEMENT REOUEST DRIVER SEAT CUSHION LOWER FRONT MOVEMENT REOUES, DRIVER SEAT SOUAB AFT RECLINE MOVEMENT REOUEST DRIVER SEAT SOUAB FORE RECLINE MOVEMENT REQUEST 0 SMCID DRIVER SEAT CUSHION RE*R, SOUAB RECLINE MOTOR POT REF. GROUND 0 SM2-2D DRIVER SEAT CUSHION FORE, AFT MOTOR POT. REFERENCE GROUND 0 SM2-SD DRIVER SEAT CUSHION REAR, SOUAB RECLINE MOTOR POT. REF. VOLTAGE 0 SM2-8D DRIVER SEAT CUSHION FRONT MOTOR POT. REFERENCE VOLTAGE I SM2-8D DRIVER SEAT HEADREST MOTOR POTENTIOMETER FEEDBACK 1 SM2-9D DRl”ER SEAT CUSHlON FRONT MOTOR POTENTlOMETER FEEDBACK I SMZ-1OD DRIVER SEAT CUSHION REAR MOTOR POTENTIOMETER FEEDBACK I SMZ-l,D DRIVER SEAT SOUAB RECLINE MOTOR POTENTIOMETER FEEDBACK I SMZ-12D DRIVER SEAT CUSHlON FORE, AFT MOTOR POTENTIOMETER FEEDBACK 0 SM2-l4D DRIVER SEAT HEADREST MOTOR POTENTIOMETER REFERENCE GROUND 0 SM2-l5D DRi”ER SEAT CUSHION FRONT MOTOR POTENTIOMETER REFERENCE GROUND 0 SM2-,813 DRl”ER SEAT C”SHlON FORE, A” MOTOR POT. REFERENCE VOLTAGE 0 SM2-l9D DRIVER SEAT HEADREST MOTOR POTENTIOMETER REFERENCE VOLTAGE B+ GROUND B+ B+ GROUND GROUND GROUND GROUND GROUND PUMP-DRIVER - DRIVER SEAT SOUAB HEATERS - DRIVER SWlTCH PACK - DRIVER SEAT B+ HARNESS-TO-HARNESS CONNECTORS Active B+ B+ B+ El+ B+ B+ B+ B+ B+ B+ B+ B+ B+ B+ *+ B+ GROUND GROUND 5” ,O”=“P,,V=DOWN 10”=UP,1”=DOWN 10V=“P,l”=DOWN S”=FORE.ZV=AFT 2 V = FORE, 10 V = AFT GROUND GROUND 5” 5v Inactive GROUND GROUND GROUND GROUND GROUND GROUND GROUND GROUND GROUND GROUND GROUND GROUND GROUND GROUND GROUND GROUND GROUND GROUND FC,S,14-WAYAMPEEECIGREY DDlO, 22.WAY FORD 2.8 TIMER, BLUE DD, ,,22-WAY FORD 2.8 TIMER, BLACK RDlO, 22.WAY FORD 2.8 TIMER, BLUE RD, I, 22~WAY FORD 2.8 TMER , BLACK FC24!48-WAY AMP MODULE PC9 SIGNAL, BLACK FC25,24-WAY AMP MODULE PC9 SIGNAL, BLACK DD, , IS-WAY MOS-29, YELLOW Sk,,-D, ,&WAY FORD 2 8 TiMER i BLACK SMP-D ,26-WAY FORD IDC, BLACK SW-D, ,&WAY FORD 2 8 TIMER, BLACK BULKHEAD, BEHIND GLOVE BOX DOOR CASING, TRIM PANEL DOOR CASING, TRIM PANEL FASCIA DOOR TRiM PANEL DRlVER SEAT, UNDER SM7-D , SWAY MULTILOCK 070, YELLOW DRIVER SEAT cc,, 16.WAY FORD IDC S.” , BLACK SM10-D, O-WAY MULTILOCK 070 /YELLOW DRIVER SEAT SMl~D, B-WAY MULTILOCK 070, GREY DRlVER SEAT, UNDER SMG-D, B-WAY MULTlLOCK 070, YELLOW SM, ,~D, B-WAY MULTlLOCK 070, WHlTE SM,2-D, B-WAY MULTlLOCK 070, WHlTE SM,B-D , S-WAY MULTiLOCK 070, YELLOW 349-D , J-WAY MULTILOCK 070, GREY DRIVER SEAT SM%D, 18.WAY MULTlLOCK 040, BLACK DRIVER SEAT Relay Case Color Connector I Color Location / Access SEAT HEATER RELAY DRIVER BROWN SM14-D/BROWN FRONT SEAT RELAYS, UNDER SEAT Connector CA8 CA10 CA13 CA14 CA23 FC1 FC5 FC7 GROUNDS Ground CA25L CA25R CA26L CA26R CA33L CABSL ccx Type / Color *O-WAY MULTILOCK 070, WHITE B-WAY MULTILOCK 070, YELLOW S-WAY MULTlLOCK 070, WHITE B-WAY MULTlLOCK 070, WHITE I(1-WAY MULTILOCK 070, WHITE W-WAY THROUGH PANEL CONNECTOR, BLACK 54.WAY THROUGH PANEL CONNECTOR/BLACK 2%WAY MULTILOCK 070, WHITE Location I Type EYELET IPAIR) - PASSENGER SEAT GROUND STUD EYELET IPAIR) - PASSENGER SEAT GROUND STUD EYELET (PAIR, - DRIVER SEAT GROUND STUD EYELET (PAIR, - DRIVER SEAT GROUND STUD EYELET IPAIR, - RH ‘K POST GROUND SCREW EYELET (PAIR) - LH ‘A’ POST GROUND SCREW EYELET (PA,R) - RH FRONT BULKHEAD STUD, CABlN SIDE Location / Access DRlVER ‘I’ POST, DOOR HARNESS GAITER DRIVER ‘A’ POST, DOOR HARNESS GAITER DR,“ER ‘B,c’ POST, DOOR HARNESS GAITER DRIVER ‘Bit’ POST, DOOR HARNESS GAITER BELOW DRIVER SEAT CONTROL MODULE PIN OUT INFORMATION (FOLD OUT PAGE) BELOW PASSENGER SlDE AIR “ENT, GLOVE BOX ASSEMBLY BELOW DRIVER SIDE AIR VENT, COIN TRAY ABOVE DIMMER MODULE, COIN TRAY I SMB-1D I SMB-2D 0 SM3-3D 0 SM3-4D I SM3-5D / SM3-8D I SM3-8D S SM3-9D S SM3-lOD MODULE lDENTlFlCAT,ON POWER GROUND DRIVER SEAT RAISE, LOWER MOTOR SUPPLY DRIVER SEAT RAISE, LOWER MOTOR SUPPLY BATTERY POWER SUPPLY DRIVER SEAT HEADREST RAISE MOVEMENT REQUEST DRIVER SEAT HEADREST LOWER MOVEMENT REOUEST SW NETWORK SCP NETwORK GROUND GROUND B+ B+ Bc Bt B+ (DRIVER) GROUND GROUND GROUND B+ GROUND GROUND INSTRUMENT PACK c7 Pin Description S FC24-19 SCP NETWORK S FC24-20 SCP NETwORK C FC24-24 CAN NETWORK C FC24-47 CAN NETWORK Active Inactive NOTE: REFER TO THE APPENDIX AT THE REAR OF THIS BOOK FOR CAN AND SCP NETWORK MESSAGES. The following symbols are used to represent values for Control Module Pin Out data: I Input D Serial and encoded <strong>com</strong>munications B+ Battery voltage KHz Frequency x 1000 0 output C CAN (Network) V Voltage (DC) MS Milliseconds SG Signal Ground S SCP Network Hz Frequency MV Millivolts CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all <strong>com</strong>ponents connected and fitted. “Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF. REFER TO THE FRONT OF THE BOOK FOR ILLUSTRATIONS DETAILING THE LOCATION AND IDENTIFICATION OF COMPONENTS, RELAYS. CONNECTORS, HARNESSES, GROUNDS, VEHICLE CONTROL MODULES AND CONTROL MODULE PINS. DATE OF ISSUE: SEPTEMBER 1997
Change language