Pipelaying Tender-VOL I - WorleyParsons.com

More documents

Recommendations

Info

23Check for excessive temperature rise in control gearbox. WC S24Measure the illumination level of the area and comparewith the designed value WC Rw25 Measure power factor at the distribution board andcompare with specified value. WC RwINSTALLATION OF CABLESSlNo. ACTIVITY CONTRACTOR PMCPRELIMINARY CHECKS1 Check that cable parameters are as per specification. WC Rw2 Check the cable installation for routing, segregation,logical and neat installation in accordance with thedrawings WC S3 Inspect cables for supporting, clamping and fixing. WC S4 Check the cable route markers for correctness,availability and any physical damage. WC S5 Inspect cable no., type , core and size of cable,terminal no. & compare them with approved drawings. WC S6 Check availability of sleeves and / or kick plates andinspect it for any physical damage. WC S7 Inspect cable transits through walls, floors and ceilingsfor tightness, correct mounting and opening sealing. WC SInspect distance between different voltage gradecables. WC S89 Inspect for any damage or nicks on outer sheath orarmouring, lead sheath, insulation, copper / aluminiumwires etc. WC S10 Inspect cable glands and shrouds for damage, correctsize and tightness, WC S11 Check armour and / or shielding bonding and earthing. WC S12 Ensure bimetallic lugs are used whenever connectionsare made between diff. material (e.g. Al. and Cu.) WC S13 Inspect cable strand connection of the conductor (allstrands have been used) and correct size of cable lugs. WC S14 Check for tightness of end termination. WC S15 Check that all the material used are of approved and asper approved drawings. WC S16 Inspect the cable boxes / compartments for cleanliness& dryness. WC S17 Check depth of cable and availability of protectivecover over it in case of underground cabling. WC S18 Check cable tag availability, material and correctness. WC SCheck for excess tension on cable supports inside19 panel. WC S20 Check cable loop for proper bending radius. WC SMH2145-C000-PS-RFQ-0020Page 192 of 334
SlNo. ACTIVITY CONTRACTOR PMC21 Check for difference between actual laid length andscheduled length. If the difference found to be morethan 10% then the cable shall be referred back to PMCWCRwfor rechecking of voltage drop etc.PRE-COMMISSIONING TEST22 Check insulation resistance for the total run of cableincluding joints and end termination.(Attach report)WCRw23Check complete continuity for each core in the cable forits entire length of run.WCS24 Perform phase rotation test WC SNote : Each test shall be made only if the cable hassuccessfully passed the preceeding test.All results to be recorded and attached with this.MH2145-C000-PS-RFQ-0020Page 193 of 334
Page 1 and 2:
Hindustan Petroleum Corporation Ltd
Page 3 and 4:
CHAPTER 1REQUEST FOR QUOTATION (RFQ
Page 5 and 6:
Local ConditionsIt will be imperati
Page 7:
The tender details including EMD, B
Page 10 and 11:
his bid shall not be considered for
Page 12 and 13:
5) This prime member shall be solel
Page 14 and 15:
Note:1. All the information require
Page 16 and 17:
EMD submitted by the bidder for sub
Page 18 and 19:
however, bids in hard copies shall
Page 20 and 21:
7.0 A firm which is not a PSU or an
Page 22 and 23:
We are unable to bid for the reason
Page 24 and 25:
CUT-OUT SLIPDO NOT OPEN- THIS IS A
Page 26 and 27:
CUT-OUT SLIPDO NOT OPEN- THIS IS A
Page 28 and 29:
QUOTATION AGAINST TENDERENQUIRY (En
Page 30 and 31:
INDEXSR. NO.ARTICLE DESCRIPTION1.0
Page 32 and 33:
modify the Bid Document. The amendm
Page 34 and 35:
sealed and pasted with the enclosed
Page 36 and 37:
l. Declaration with the bid qualifi
Page 38 and 39:
Fax:91-22-67818080 in the presence
Page 40 and 41:
for Part-II. In case such bidder is
Page 42 and 43:
In case if the bidder quotes the ra
Page 44 and 45:
xv)xvi)xvii)Non Submission of decla
Page 46 and 47:
(c)When it is not possible to ascer
Page 48 and 49:
14.7.2 To offset Central Sales Tax
Page 50 and 51:
Where based on workability assessme
Page 52 and 53:
tender terms not in deviation sheet
Page 54 and 55:
INDEXSr. No. Article Description1.
Page 56 and 57:
GENERAL TERMS & CONDITIONS OF CONTR
Page 58 and 59:
2. 8 The "Drawings" shall include m
Page 60 and 61:
3.6 The quantities indicated in the
Page 62 and 63:
wherever required in the tender pap
Page 64 and 65:
For working on Sundays/Holidays, th
Page 66 and 67:
5.b COMMENCEMENT OF WORKThe contrac
Page 68 and 69:
Contractor or the BG (if LD is full
Page 70 and 71:
manufacture or fabrication or on th
Page 72 and 73:
a. defects, if any, to be rectified
Page 74 and 75:
payment of wages, salaries or other
Page 76 and 77:
6.e.INSURANCE AND LABOURContractor
Page 78 and 79:
iv. The contractor shall ensure tha
Page 80 and 81:
7. PAYMENT OF CONTRACTOR'S BILLS7.
Page 82 and 83:
shall be final and binding on the C
Page 84 and 85:
7.e.4.Manufacturer's certificate sh
Page 86 and 87:
accordance with the contract, the C
Page 88 and 89:
12.0 TERMINATION OF CONTRACT12.1 Th
Page 90 and 91:
Contractor to complete the job with
Page 92 and 93:
shall be entitled at any time to in
Page 94 and 95:
INDEX1. DEFINITION2. REFERENCE FOR
Page 96 and 97:
and scope of work (technical), GPC
Page 98 and 99:
In order to facilitate over-all exe
Page 100 and 101:
Dimensions :For every order and eve
Page 102 and 103:
26. CHANGESThe Owner has the option
Page 104 and 105:
34. TECHNICAL INFORMATIONDrawings,
Page 106 and 107:
Chapter: 4SPECIAL CONDITIONSOFCONTR
Page 108 and 109:
44.0 DRAWINGS AND DOCUMENTS45.0 HOU
Page 110 and 111:
viii) General Terms & Conditions of
Page 112 and 113:
duties levied by statutory authorit
Page 114 and 115:
stipulations including obtaining re
Page 116 and 117:
4.1.3 Unless otherwise stated the t
Page 118 and 119:
4.2.6 No Interest charges for delay
Page 120 and 121:
9.0 PROVIDENT FUND, LABOUR, LABOUR
Page 122 and 123:
not carried out work according to g
Page 124 and 125:
16.a7 The Arbitrator may give a com
Page 126 and 127:
19.0 Mobilization Advance19.1 Contr
Page 128 and 129:
persons/persons or bodies/companies
Page 130 and 131:
CONTRACTOR shall take all precautio
Page 132 and 133:
Employer/Consultant shall not provi
Page 134 and 135:
and return to the Contractor the st
Page 136 and 137:
the work as per standards and all c
Page 138 and 139:
42.0 COORDINATION WITH OTHER AGENCI
Page 140 and 141:
pipelines, cables etc., during cons
Page 142 and 143: Engineer-in-charge during execution
Page 144 and 145: 56.2 All the tests either on the fi
Page 146 and 147: The information to possible extent
Page 148 and 149: in part or in full.e) Functional Sc
Page 150 and 151: OWNER.66.4.4 Progress reports shall
Page 152 and 153: Order, or material of sub-standard
Page 154 and 155: 75.11 Co-ordination with appropriat
Page 156 and 157: 81.2 Contractor shall develop and s
Page 158 and 159: y them / Vendors shall be provided
Page 160 and 161: Contractor to note that it is their
Page 162 and 163: 3.0 APPENDICES TO SCCMH2145-C000-PS
Page 164 and 165: SCOPE OF WORK & SUPPLY(APPENDIX-I t
Page 166 and 167: MATHURARKPL Project OfficeHPCL Depo
Page 168 and 169: 12. Compensatory Afforestation as p
Page 170 and 171: TIME SCHEDULESr No Description Comp
Page 172 and 173: MEASUREMENT OF WORK(APPENDIX-III to
Page 174 and 175: The contractor shall submit the bil
Page 176 and 177: 5.0 ELECTRICAL WORKS5.1 Cables5.1.1
Page 178 and 179: TERMS OF PAYMENT(APPENDIX-IV to SCC
Page 180 and 181: B) 5% on completion of all works in
Page 182 and 183: 6.2.2 85% against completion of fou
Page 184 and 185: GENERAL NOTEBefore start of work, t
Page 186 and 187: 3.1.4 The bidder shall submit, alon
Page 188 and 189: methodologies which he is going to
Page 190 and 191: Bidder’s Quality PlanPO/ Contact
Page 194 and 195: LT MOTORSSlNo. ACTIVITY CONTRACTOR
Page 196 and 197: MLDB, LP AND PDBsSlNo. ACTIVITY CON
Page 198 and 199: PRELIMINARY CHECKS1 Check that cabl
Page 200 and 201: 1.0 INTRODUCTION2.0 SCOPEThis docum
Page 202 and 203: 4.4 TESTINGPrior to shop prefabrica
Page 204 and 205: 6.0 ATTACHMENT (WAIVER/DEVIATION PE
Page 206 and 207: TO BE COMPLETED BY CUSTOMER ‘TECH
Page 208 and 209: APPENDIX -VI TO SCCHSE MANAGEMENT P
Page 210 and 211: INDEX1. CONDITIONS FOR ISSUE OF MAT
Page 212 and 213: NOTE :1)Landed Rate shall be arrive
Page 214 and 215: own cost to Owner's stores. In case
Page 216 and 217: MINIMUM NO. OF SKILLED MANPOWER (AT
Page 218 and 219: NOTE :-(1) The details of estimated
Page 220 and 221: MINIMUM EQUIPMENT DEPLOYMENT PART W
Page 222 and 223: 22 Sand/Grit Blasting Cleaning M/c.
Page 224 and 225: 45 GPS /GIS M/c for taking the co-o
Page 226 and 227: 8 Excavator / Back Hoe (Ex 280/ 300
Page 228 and 229: 31 Dead Weight Tester(Ravika 0-400k
Page 230 and 231: (2) Meeting the requirement of depl
Page 232 and 233: EXPERIENCE CRITERIA FOR KEY PERSONN
Page 234 and 235: 1011LEAD WELDING /NDTENGINEERWAREHO
Page 236 and 237: 1. The Labour rates are "all inclus
Page 238 and 239: EQUIPMENT HIRING/RECOVERY RATES(APP
Page 240 and 241: 31. Pipe Trailers (FB / Semi Low Be
Page 242 and 243:
INSTRUMENTS1. ELECTRONICS TRANSMITT
Page 244 and 245:
16. SOLENOID VALVESA. AVCON CONTROL
Page 246 and 247:
1. CENTRIFUGAL PUMPS VERTICAL - GEN
Page 248 and 249:
G. UNIQUE INDUSTRIAL PACKINGSH. VIR
Page 250 and 251:
K. TORMENE GAS TECHNOLOGY SPA, ITAL
Page 252 and 253:
21. VALVE GLOBE FORGEDA. ASSOCIATED
Page 254 and 255:
2. CABLES-CONTROL - PVCA. CCIB. FIN
Page 256 and 257:
E. BHARTIA CUTLER HAMMER.F. CONTROL
Page 258 and 259:
33. PERMANENT REFERENCE ELECTRODESA
Page 260 and 261:
B. H & R JOHNSONC. BELL CERAMICSD.
Page 262 and 263:
HINDUSTAN PETROLEUM CORPORATION LIM
Page 264 and 265:
SR.No.A1234567BParticularsF13707 /C
Page 266 and 267:
1 RJ/15/568 (P5322) - 24/12/2012234
Page 268 and 269:
3NCR/GAS-O&M/DM(O&M)-152/2012/216 -
Page 270 and 271:
2 34091/05/12-IA/728 - 3/5/2012G12H
Page 272 and 273:
18192021222324252627282930313233342
Page 274 and 275:
CHAPTER-5BRIEF SUMMARY OFAGREED TER
Page 276 and 277:
(ix) Confirm acceptance of Liquidat
Page 278 and 279:
1. Annexure-A Bid Security FormCHAP
Page 280 and 281:
ANNEXURE-ABID SECURITY FORMBANK GUA
Page 282 and 283:
COMPOSITE BANK GUARANTEE FOR SECURI
Page 284 and 285:
writing.8. We, ....................
Page 286 and 287:
ANNEXURE--DDECLARATION (NOT BANNED)
Page 288 and 289:
ANNEXURE-FQUALIFICATION FORMAT - FO
Page 290 and 291:
ANNEXURE-GIntegrity Pact[KK1]MH2145
Page 292 and 293:
form part of this contract / supply
Page 294 and 295:
INTEGRITY PACTBetweenHindustan Petr
Page 296 and 297:
caused by him and has installed a s
Page 298 and 299:
Section 9 — Pact DurationThis Pac
Page 300 and 301:
MH2145-C000-PS-RFQ-0020Page 300 of
Page 302 and 303:
MH2145-C000-PS-RFQ-0020Page 302 of
Page 304 and 305:
Note:1. The message should be in Co
Page 306 and 307:
3 . We ............................
Page 308 and 309:
ANNEXURE-JBANK GUARANTEE FOR MOBILI
Page 310 and 311:
10. "The Bank" has power to issue t
Page 312 and 313:
servants and/or agents whatsoever t
Page 314 and 315:
UNDERTAKING (CORPORATE/ NON-CORPORA
Page 316 and 317:
ANNEXURE-NUNDERTAKING OF ADEQUATE C
Page 318 and 319:
2 This Guarantee/Undertaking shall
Page 320 and 321:
Annexure-PNAME OF SUPPLY : ……
Page 322 and 323:
ANNEXURE - Q.1Business Rules for fi
Page 324 and 325:
v. After the completion of English
Page 326 and 327:
Annexure - Q.IIN.B.Terms & Conditio
Page 328 and 329:
Annexure- Q.IIIProcess Compliance F
Page 330 and 331:
Annexure Q.VCONTACT INFORMATION....
Page 332 and 333:
Annexure -SCERTIFICATE OF NON-INVOL
Page 334 and 335:
CHAPTER NO.8PRICE BID FORMATMH2145-
Page 336 and 337:
PRICE SCHEDULE (INDIAN BIDDERS)Sche
Page 338 and 339:
Page 340 and 341:
Page 342 and 343:
Item No. Item Description Unit Quan
Page 344 and 345:
PRICE SCHEDULE (FOREIGN BIDDERS)Sch
Page 346 and 347:
Page 348 and 349:
Page 350 and 351:
Page 352 and 353:
Page 354 and 355:
Page 356 and 357:
m No. Short description Item Descri
Page 358 and 359:
Page 360 and 361:
Page 362 and 363:
Page 364 and 365:
Item No. Item Description Unit Quan
Page 366 and 367:
UN PRICE SCHEDULE (INDIAN BIDDERS)S
Page 368 and 369:
Page 370 and 371:
Page 372 and 373:
Item No.PRICE SCHEDULE (FOREIGN BID
Page 374 and 375:
Page 376 and 377:
Page 378 and 379:
Page 380 and 381:
UN PRICE SCHEDULE (FOREIGN BIDDERS)
show all

Pipelaying Tender-VOL I - WorleyParsons.com

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?