Pipelaying Tender-VOL I - WorleyParsons.com

More documents

Recommendations

Info

8 Excavator / Back Hoe (Ex 280/ 300/ 200) 12 8 49 Tyre Mounted Crane (30 T & 12T) 3 2 1Check with Dump Sitemanagement10 Pipe Layer/Side Boom 40 & 60 Ton 12 6 611 Horizontal Auger Boring M/c. for 24" & 36" NB casing pipe 3 2 112Pay Welder (Automatic/Semi Auto) welding crew including WeldingM/c.3 2 113 Welding Machines 30 15 1514 Pipe Bending M/c. (Size 18") with Pneumatic Mandrel 2 215 Bevel Cutting M/c.18" (Pneumatic/Hydraulic) 6 3 316 Pipe Clamp Internal 18" (Pneumatic) 4 2 217 Pipe Clamp External 18" (Hydraulic ) 9 3 618 Induction heating equipment / Localised LPG heating 3 2 119 Holiday Detector (Spy Make) 6 3 3MH2145-C000-PS-RFQ-0020Page 226 of 334
20 Air Compressor (300-650 CFM) 2 221 Air Compressor (1050-1500 CFM) 2 0 222 Sand/Grit Blasting Cleaning M/c. [Hopper] + Painting 5 3 223 X-Ray Machine Internal Crawler 3 2 124 X-Ray Machine External 3 2 125 Gamma Source AS REQD26 Dark Room Facility with viewer 2 227 UT Machine (Min.) 3 2 128 Dewatering Pump of capacity 60-80 cu.m/hr 6 3 329Hydro testing set for pre test & post test (Water Filling 50 & 500 to1000 cu.m/h & hydro testing pump-motorized (200 bar), dozzingpump , dead weight tester, Pressure gauge & with testing control unit)2 230 Test Headers sets ( Pre-test, post test,Pigging header) 3 2 1 Each one setMH2145-C000-PS-RFQ-0020Page 227 of 334
Page 1 and 2:
Hindustan Petroleum Corporation Ltd
Page 3 and 4:
CHAPTER 1REQUEST FOR QUOTATION (RFQ
Page 5 and 6:
Local ConditionsIt will be imperati
Page 7:
The tender details including EMD, B
Page 10 and 11:
his bid shall not be considered for
Page 12 and 13:
5) This prime member shall be solel
Page 14 and 15:
Note:1. All the information require
Page 16 and 17:
EMD submitted by the bidder for sub
Page 18 and 19:
however, bids in hard copies shall
Page 20 and 21:
7.0 A firm which is not a PSU or an
Page 22 and 23:
We are unable to bid for the reason
Page 24 and 25:
CUT-OUT SLIPDO NOT OPEN- THIS IS A
Page 26 and 27:
CUT-OUT SLIPDO NOT OPEN- THIS IS A
Page 28 and 29:
QUOTATION AGAINST TENDERENQUIRY (En
Page 30 and 31:
INDEXSR. NO.ARTICLE DESCRIPTION1.0
Page 32 and 33:
modify the Bid Document. The amendm
Page 34 and 35:
sealed and pasted with the enclosed
Page 36 and 37:
l. Declaration with the bid qualifi
Page 38 and 39:
Fax:91-22-67818080 in the presence
Page 40 and 41:
for Part-II. In case such bidder is
Page 42 and 43:
In case if the bidder quotes the ra
Page 44 and 45:
xv)xvi)xvii)Non Submission of decla
Page 46 and 47:
(c)When it is not possible to ascer
Page 48 and 49:
14.7.2 To offset Central Sales Tax
Page 50 and 51:
Where based on workability assessme
Page 52 and 53:
tender terms not in deviation sheet
Page 54 and 55:
INDEXSr. No. Article Description1.
Page 56 and 57:
GENERAL TERMS & CONDITIONS OF CONTR
Page 58 and 59:
2. 8 The "Drawings" shall include m
Page 60 and 61:
3.6 The quantities indicated in the
Page 62 and 63:
wherever required in the tender pap
Page 64 and 65:
For working on Sundays/Holidays, th
Page 66 and 67:
5.b COMMENCEMENT OF WORKThe contrac
Page 68 and 69:
Contractor or the BG (if LD is full
Page 70 and 71:
manufacture or fabrication or on th
Page 72 and 73:
a. defects, if any, to be rectified
Page 74 and 75:
payment of wages, salaries or other
Page 76 and 77:
6.e.INSURANCE AND LABOURContractor
Page 78 and 79:
iv. The contractor shall ensure tha
Page 80 and 81:
7. PAYMENT OF CONTRACTOR'S BILLS7.
Page 82 and 83:
shall be final and binding on the C
Page 84 and 85:
7.e.4.Manufacturer's certificate sh
Page 86 and 87:
accordance with the contract, the C
Page 88 and 89:
12.0 TERMINATION OF CONTRACT12.1 Th
Page 90 and 91:
Contractor to complete the job with
Page 92 and 93:
shall be entitled at any time to in
Page 94 and 95:
INDEX1. DEFINITION2. REFERENCE FOR
Page 96 and 97:
and scope of work (technical), GPC
Page 98 and 99:
In order to facilitate over-all exe
Page 100 and 101:
Dimensions :For every order and eve
Page 102 and 103:
26. CHANGESThe Owner has the option
Page 104 and 105:
34. TECHNICAL INFORMATIONDrawings,
Page 106 and 107:
Chapter: 4SPECIAL CONDITIONSOFCONTR
Page 108 and 109:
44.0 DRAWINGS AND DOCUMENTS45.0 HOU
Page 110 and 111:
viii) General Terms & Conditions of
Page 112 and 113:
duties levied by statutory authorit
Page 114 and 115:
stipulations including obtaining re
Page 116 and 117:
4.1.3 Unless otherwise stated the t
Page 118 and 119:
4.2.6 No Interest charges for delay
Page 120 and 121:
9.0 PROVIDENT FUND, LABOUR, LABOUR
Page 122 and 123:
not carried out work according to g
Page 124 and 125:
16.a7 The Arbitrator may give a com
Page 126 and 127:
19.0 Mobilization Advance19.1 Contr
Page 128 and 129:
persons/persons or bodies/companies
Page 130 and 131:
CONTRACTOR shall take all precautio
Page 132 and 133:
Employer/Consultant shall not provi
Page 134 and 135:
and return to the Contractor the st
Page 136 and 137:
the work as per standards and all c
Page 138 and 139:
42.0 COORDINATION WITH OTHER AGENCI
Page 140 and 141:
pipelines, cables etc., during cons
Page 142 and 143:
Engineer-in-charge during execution
Page 144 and 145:
56.2 All the tests either on the fi
Page 146 and 147:
The information to possible extent
Page 148 and 149:
in part or in full.e) Functional Sc
Page 150 and 151:
OWNER.66.4.4 Progress reports shall
Page 152 and 153:
Order, or material of sub-standard
Page 154 and 155:
75.11 Co-ordination with appropriat
Page 156 and 157:
81.2 Contractor shall develop and s
Page 158 and 159:
y them / Vendors shall be provided
Page 160 and 161:
Contractor to note that it is their
Page 162 and 163:
3.0 APPENDICES TO SCCMH2145-C000-PS
Page 164 and 165:
SCOPE OF WORK & SUPPLY(APPENDIX-I t
Page 166 and 167:
MATHURARKPL Project OfficeHPCL Depo
Page 168 and 169:
12. Compensatory Afforestation as p
Page 170 and 171:
TIME SCHEDULESr No Description Comp
Page 172 and 173:
MEASUREMENT OF WORK(APPENDIX-III to
Page 174 and 175:
The contractor shall submit the bil
Page 176 and 177: 5.0 ELECTRICAL WORKS5.1 Cables5.1.1
Page 178 and 179: TERMS OF PAYMENT(APPENDIX-IV to SCC
Page 180 and 181: B) 5% on completion of all works in
Page 182 and 183: 6.2.2 85% against completion of fou
Page 184 and 185: GENERAL NOTEBefore start of work, t
Page 186 and 187: 3.1.4 The bidder shall submit, alon
Page 188 and 189: methodologies which he is going to
Page 190 and 191: Bidder’s Quality PlanPO/ Contact
Page 192 and 193: 23Check for excessive temperature r
Page 194 and 195: LT MOTORSSlNo. ACTIVITY CONTRACTOR
Page 196 and 197: MLDB, LP AND PDBsSlNo. ACTIVITY CON
Page 198 and 199: PRELIMINARY CHECKS1 Check that cabl
Page 200 and 201: 1.0 INTRODUCTION2.0 SCOPEThis docum
Page 202 and 203: 4.4 TESTINGPrior to shop prefabrica
Page 204 and 205: 6.0 ATTACHMENT (WAIVER/DEVIATION PE
Page 206 and 207: TO BE COMPLETED BY CUSTOMER ‘TECH
Page 208 and 209: APPENDIX -VI TO SCCHSE MANAGEMENT P
Page 210 and 211: INDEX1. CONDITIONS FOR ISSUE OF MAT
Page 212 and 213: NOTE :1)Landed Rate shall be arrive
Page 214 and 215: own cost to Owner's stores. In case
Page 216 and 217: MINIMUM NO. OF SKILLED MANPOWER (AT
Page 218 and 219: NOTE :-(1) The details of estimated
Page 220 and 221: MINIMUM EQUIPMENT DEPLOYMENT PART W
Page 222 and 223: 22 Sand/Grit Blasting Cleaning M/c.
Page 224 and 225: 45 GPS /GIS M/c for taking the co-o
Page 228 and 229: 31 Dead Weight Tester(Ravika 0-400k
Page 230 and 231: (2) Meeting the requirement of depl
Page 232 and 233: EXPERIENCE CRITERIA FOR KEY PERSONN
Page 234 and 235: 1011LEAD WELDING /NDTENGINEERWAREHO
Page 236 and 237: 1. The Labour rates are "all inclus
Page 238 and 239: EQUIPMENT HIRING/RECOVERY RATES(APP
Page 240 and 241: 31. Pipe Trailers (FB / Semi Low Be
Page 242 and 243: INSTRUMENTS1. ELECTRONICS TRANSMITT
Page 244 and 245: 16. SOLENOID VALVESA. AVCON CONTROL
Page 246 and 247: 1. CENTRIFUGAL PUMPS VERTICAL - GEN
Page 248 and 249: G. UNIQUE INDUSTRIAL PACKINGSH. VIR
Page 250 and 251: K. TORMENE GAS TECHNOLOGY SPA, ITAL
Page 252 and 253: 21. VALVE GLOBE FORGEDA. ASSOCIATED
Page 254 and 255: 2. CABLES-CONTROL - PVCA. CCIB. FIN
Page 256 and 257: E. BHARTIA CUTLER HAMMER.F. CONTROL
Page 258 and 259: 33. PERMANENT REFERENCE ELECTRODESA
Page 260 and 261: B. H & R JOHNSONC. BELL CERAMICSD.
Page 262 and 263: HINDUSTAN PETROLEUM CORPORATION LIM
Page 264 and 265: SR.No.A1234567BParticularsF13707 /C
Page 266 and 267: 1 RJ/15/568 (P5322) - 24/12/2012234
Page 268 and 269: 3NCR/GAS-O&M/DM(O&M)-152/2012/216 -
Page 270 and 271: 2 34091/05/12-IA/728 - 3/5/2012G12H
Page 272 and 273: 18192021222324252627282930313233342
Page 274 and 275: CHAPTER-5BRIEF SUMMARY OFAGREED TER
Page 276 and 277:
(ix) Confirm acceptance of Liquidat
Page 278 and 279:
1. Annexure-A Bid Security FormCHAP
Page 280 and 281:
ANNEXURE-ABID SECURITY FORMBANK GUA
Page 282 and 283:
COMPOSITE BANK GUARANTEE FOR SECURI
Page 284 and 285:
writing.8. We, ....................
Page 286 and 287:
ANNEXURE--DDECLARATION (NOT BANNED)
Page 288 and 289:
ANNEXURE-FQUALIFICATION FORMAT - FO
Page 290 and 291:
ANNEXURE-GIntegrity Pact[KK1]MH2145
Page 292 and 293:
form part of this contract / supply
Page 294 and 295:
INTEGRITY PACTBetweenHindustan Petr
Page 296 and 297:
caused by him and has installed a s
Page 298 and 299:
Section 9 — Pact DurationThis Pac
Page 300 and 301:
MH2145-C000-PS-RFQ-0020Page 300 of
Page 302 and 303:
MH2145-C000-PS-RFQ-0020Page 302 of
Page 304 and 305:
Note:1. The message should be in Co
Page 306 and 307:
3 . We ............................
Page 308 and 309:
ANNEXURE-JBANK GUARANTEE FOR MOBILI
Page 310 and 311:
10. "The Bank" has power to issue t
Page 312 and 313:
servants and/or agents whatsoever t
Page 314 and 315:
UNDERTAKING (CORPORATE/ NON-CORPORA
Page 316 and 317:
ANNEXURE-NUNDERTAKING OF ADEQUATE C
Page 318 and 319:
2 This Guarantee/Undertaking shall
Page 320 and 321:
Annexure-PNAME OF SUPPLY : ……
Page 322 and 323:
ANNEXURE - Q.1Business Rules for fi
Page 324 and 325:
v. After the completion of English
Page 326 and 327:
Annexure - Q.IIN.B.Terms & Conditio
Page 328 and 329:
Annexure- Q.IIIProcess Compliance F
Page 330 and 331:
Annexure Q.VCONTACT INFORMATION....
Page 332 and 333:
Annexure -SCERTIFICATE OF NON-INVOL
Page 334 and 335:
CHAPTER NO.8PRICE BID FORMATMH2145-
Page 336 and 337:
PRICE SCHEDULE (INDIAN BIDDERS)Sche
Page 338 and 339:
Page 340 and 341:
Page 342 and 343:
Item No. Item Description Unit Quan
Page 344 and 345:
PRICE SCHEDULE (FOREIGN BIDDERS)Sch
Page 346 and 347:
Page 348 and 349:
Page 350 and 351:
Page 352 and 353:
Page 354 and 355:
Page 356 and 357:
m No. Short description Item Descri
Page 358 and 359:
Page 360 and 361:
Page 362 and 363:
Page 364 and 365:
Item No. Item Description Unit Quan
Page 366 and 367:
UN PRICE SCHEDULE (INDIAN BIDDERS)S
Page 368 and 369:
Page 370 and 371:
Page 372 and 373:
Item No.PRICE SCHEDULE (FOREIGN BID
Page 374 and 375:
Page 376 and 377:
Page 378 and 379:
Page 380 and 381:
UN PRICE SCHEDULE (FOREIGN BIDDERS)
show all

Pipelaying Tender-VOL I - WorleyParsons.com

Create successful ePaper yourself

Delete template?

Save as template?