Rover 214 & 414 Service and Repair Manual - Rover club

Recommendations

Info

1689 Rover 214 & 414 Updated Version 09/97 Diagram 4: Anti-lock braking system 12•30 Wiring diagrams
1689 Rover 214 & 414 Updated Version 09/97 12 Diagram 5: In-car entertainment and electric sunroof Wiring diagrams 12•31
Page 1 and 2:
Rover 214 & 414 Service and Repair
Page 3 and 4:
REPAIRS AND OVERHAUL Engine and Ass
Page 5 and 6:
Working on your car can be dangerou
Page 7 and 8:
Jump starting will get you out of t
Page 9 and 10:
Puddles on the garage floor or driv
Page 11 and 12:
Engine oil level Before you start 4
Page 13 and 14:
Power steering fluid level Before y
Page 15 and 16:
Electrical system 4 Check all exter
Page 17 and 18:
Chapter 2 Part A Engine in-car repa
Page 19 and 20:
Valves Seat angle: Inlet . . . . .
Page 21 and 22:
The crankshaft runs in five main be
Page 23 and 24:
5.14 Cylinder head cover bolt tight
Page 25 and 26:
8.6 Crankshaft pulley mark aligned
Page 27 and 28:
1 Timing belt upper righthand (oute
Page 29 and 30:
9.39 Ensure timing belt tensioner s
Page 31 and 32:
11.9 Secure partly-removed timing b
Page 33 and 34:
12 Valve clearances - general infor
Page 35 and 36:
tightens each bolt through half a t
Page 37 and 38:
16.12 Oil pump outer rotor outside
Page 39 and 40:
front of the vehicle and support it
Page 41 and 42:
2B•2 Engine removal and general o
Page 43 and 44:
Page 45 and 46:
Page 47 and 48:
Page 49 and 50:
2B•10 Engine removal and general
Page 51 and 52:
Page 53 and 54:
Page 55 and 56:
Page 57 and 58:
Chapter 3 Cooling, heating and vent
Page 59 and 60:
4 Cooling system hoses - renewal 2
Page 61 and 62:
6.7 Testing the thermostat Ensure t
Page 63 and 64:
9.10 Inlet manifold pre-heater temp
Page 65 and 66:
10.5b . . . and disengage duct from
Page 67 and 68:
10.20d Remove fan retaining nut . .
Page 69 and 70:
17 Working from inside the vehicle,
Page 71 and 72:
3•2 Cooling, heating and ventilat
Page 73 and 74:
Page 75 and 76:
Page 77 and 78:
Page 79 and 80:
3•10 Cooling, heating and ventila
Page 81 and 82:
3•12 Cooling, heating and ventila
Page 83 and 84:
Chapter 4 Part A Fuel and exhaust s
Page 85 and 86:
3.4 Slacken clamp to disconnect int
Page 87 and 88:
8.3 Removing cover retaining bolt (
Page 89 and 90:
port with a wad of clean cloth to p
Page 91 and 92:
Page 93 and 94:
18.1b Exhaust system components - w
Page 95 and 96:
Chapter 4 Part B Fuel and exhaust s
Page 97 and 98:
eturn to the tank swirl pot, where
Page 99 and 100:
6.7 Slackening pressure release bol
Page 101 and 102:
15.1 Disconnecting fuel feed and re
Page 103 and 104:
15.26 Absolute pressure sensor fuel
Page 105 and 106:
18 Exhaust manifold - removal and r
Page 107 and 108:
4C•2 Fuel and exhaust systems - m
Page 109 and 110:
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
Chapter 4 Part D Emission control s
Page 117 and 118:
3.8 Disconnecting multiplug from pu
Page 119 and 120:
Chapter 3 Cooling, heating and vent
Page 121 and 122:
4 Cooling system hoses - renewal 2
Page 123 and 124:
6.7 Testing the thermostat Ensure t
Page 125 and 126:
Page 127 and 128:
10.5b . . . and disengage duct from
Page 129 and 130:
10.20d Remove fan retaining nut . .
Page 131 and 132:
17 Working from inside the vehicle,
Page 133 and 134:
5A•2 Ignition system - carburetto
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
5B•2 Ignition system - fuel injec
Page 141 and 142:
Chapter 5 Part C Starting and charg
Page 143 and 144:
4.4 Battery clamp bolt 4 Battery -
Page 145 and 146:
9 Starting system - testing 2 1 If
Page 147 and 148:
11.14 Unscrew nut and disconnect st
Page 149 and 150:
9•2 Braking system Rear brakes No
Page 151 and 152:
9•4 Braking system shut down and
Page 153 and 154:
9•6 Braking system 6.21 Using a o
Page 155 and 156:
9•8 Braking system piston in as f
Page 157 and 158:
9•10 Braking system the caliper p
Page 159 and 160:
9•12 Braking system 1 Brake drum
Page 161 and 162:
9•14 Braking system 18.3 Wheel cy
Page 163 and 164:
9•16 Braking system 15 Inspect al
Page 165 and 166: 9•18 Braking system 1 Servo unit
Page 167 and 168: 10•2 Suspension and steering Whee
Page 169 and 170: 10•4 Suspension and steering opti
Page 171 and 172: 10•6 Suspension and steering 5.4
Page 173 and 174: 10•8 Suspension and steering 9.4
Page 175 and 176: 10•10 Suspension and steering 11.
Page 177 and 178: 10•12 Suspension and steering 8 R
Page 181 and 182: 10•16 Suspension and steering 1 H
Page 187 and 188: Chapter 12 Body electrical systems
Page 189 and 190: 1 General information and precautio
Page 191 and 192: 3.10a Unclip plastic cover . . . Un
Page 193 and 194: 4.22 Driver’s side window switch
Page 195 and 196: 5.20b Rear cluster tail lamp bulb i
Page 197 and 198: 16 Refitting is a reversal of the r
Page 199 and 200: 13.2a Carefully prise out clock mou
Page 201 and 202: 16.7 Disconnect Lucar connection an
Page 203 and 204: 21.5 Removing tailgate washer jet -
Page 205 and 206: 24.3a Use DIN tools to release reta
Page 207 and 208: Key to wiring diagrams (continued)
Page 209 and 210: 1689 Rover 214 & 414 Updated Versio
Page 215: 1689 Rover 214 & 414 Updated Versio
show all

Rover 214 & 414 Service and Repair Manual - Rover club

Create successful ePaper yourself

Delete template?

Save as template?