naval dockyard, mumbai - Irfc-nausena.nic.in

More documents

Recommendations

Info

(f) DG Exhaust pipe, Dia 65 mm, MatM.S. ASTM 12 meter 106 Gr.B. or Eqv., TP 1.7 kg/cm2 E20028 Renewal of 02 in nos submersible pump (with 02 Nos starter) makes Modi, Capacity 20 TPH. E20029 EOT to be repaired and proved. 01 Nos E20030 Port gear box has specific defects like: 01 nos Gear box making abnormal noise while clutching. Seals observed to be leaking. Undertake necessary repairs / renewal of parts. Make – KPCL Marine reverse gear box. Model – MGP 305 10/21(List of mandatory and anticipatory spares to be quoted as part of defect list, cost of both spares to be included for calculation of L1). List of mandatory and anticipatory spares for renewal is as follows: MANDATORY SPARES (a) Plate clutch, Part Nos 503.0.02.08.00 24 Nos (b) Plate driven steel, Part Nos 503.0.09.00 22 Nos (c) Set of Gaskets consists of following (i)Ring piston 7” Clutch, Part Nos 503.0.02.04.00 (ii)Ring piston 2” Clutch, Part Nos 503.0.02.05.00 (iii)Hose connecting, Part Nos 511.0.06.07.00 (iv) Hose for suction, Part Nos 511.0.06.08.00 (v) Seal oil propel flange, Part Nos 504.0.10.02.00 (vi) Seal oil input flange, Part Nos 511.0.05.02.00 (vii) Ring piston Part Nos 503.0.02.03.00 01 Nos DYT/INCOD/1213/106(a)/PLYCM/MADHURREFIT/420 44/127
(viii) Seal oil Part Nos 509.0.10.12.00 (ix) Element filter Part Nos 503.0.01.37.00 ANTICIPATORY SPARES (i) Shaft forward clutch, Part Nos 509.0.03.05.00 (ii) Input flange, Part Nos 509.0.01.69.00 (iii) Bearing Roller, Part Nos 509.0.06.03.00 (iv) Bearing Roller, Part Nos 509.0.06.04.00 (v) Bearing Ball, Part Nos 509.0.06.06.00 01 Nos 01 Nos 02 Nos 02 Nos 01 Nos MODE OF QUOTATION ELECTRICAL L30001 One in no. 40KV/ 415V, 3 phase,50 Hz alternator to be overhauled and tested onboard on full load. Make – Kirloskar Electric Co. Model/ Type – CM 200L (a) Check insulation value of winding and improve insulation. (b) Renew coupling keys and bearings. 01 nos. 02 nos. (c) Check condition of AVR (01 nos) and replace brushes. L30002 Overhaul and repair main switchboard and following to be tested onboard. (a) Service breaker (100Amp, Make Simens Co.) (b) Hand Change Over switch (100 Amps, Make Kaycee Co.) (c) Rotary switch renew (32 Amps, Make Kycee Co.) (d) Rotary switch renew (16/10 Amps, Make Kycee Co.) 08 nos. 01 nos. 01 nos. 05 nos. 05 nos. DYT/INCOD/1213/106(a)/PLYCM/MADHURREFIT/420 45/127
Page 1 and 2: Tele: 0222275 2066 Fax: 022
Page 3 and 4: 12. Earnest Money Deposit. The bidd
Page 5 and 6: 18. (a) The Commercial bid is to be
Page 7 and 8: ARTICLE 11 QUALITY AND INSPECTIO
Page 9 and 10: DYT/INCOD/1213/106(a)/PLYCM/MAD
Page 11 and 12: p q Similar jobs in marine field
Page 15 and 16: fender securing brackets Supply Sup
Page 17 and 18: store corroded/broken. To be renewe
Page 19 and 20: enewed. Size - 3ft 6 in x 3 ft (a)0
Page 21 and 22: structure on 01 deck broken / peris
Page 23 and 24: To be replaced with four double bun
Page 25 and 26: painted with craft name. 08 in nos
Page 27 and 28: Surface preparation by hydro blasti
Page 29 and 30: (a) M/s Sigma paint scheme (i) To b
Page 31 and 32: (iv) Intershield 300(bronze) - 150
Page 33 and 34: H10069 General Surfaces in Dry Co
Page 35 and 36: (ii) Pilot Primer, Gery to achieve
Page 37 and 38: (ii) Withdraw shaft and check truen
Page 39 and 40: E20014 Overhauling (3000 Hourly r
Page 41 and 42: (g). Fuel filling system MS pipes/
Page 43: (q) Both M/E F/W cooler drain valve
Page 47 and 48: overhauled and tested onboard, (e)
Page 49 and 50: (b) control panel defective to be o
Page 51 and 52: (e) (f) Total VAT @______% (if appl
Page 53 and 54: epair of ships or boats or vessels
Page 55 and 56: machine, measuring instruments, Oxy
Page 57 and 58: NAVAL DOCKYARD MUMBAI DOC CODE Q C
Page 59 and 60: suitable for DP Test approved equiv
Page 61 and 62: 25 Fairleads,Ventilation trunking e
Page 63 and 64: followed 37 Provision of material t
Page 67 and 68: NAVAL DOCKYARD, MUMBAI TITLE : QUAL
Page 69 and 70: i) Check for meters serviceability,
Page 71 and 72: efurbishment, new installation and
Page 73 and 74: 11 Repair, Overhauling, refurbishme
Page 75 and 76: of Wall mounted fan 16 Overhauling,
Page 77 and 78: commissioning / testing of Oily wat
Page 79 and 80: 25 Carbon brushes, brush holder, Ro
Page 81 and 82: SCOPE OF WORK P R W H vi) Check for
Page 83 and 84: DEPT: QC(E) C. No 74 SHIP: FC MADHU
Page 85 and 86: E20006 Defect Description If clea
Page 91 and 92: pump post Overhauling. Make FloRi
Page 95 and 96:
DEPT: QC(E) C. No 74 SHIP: FC MADHU
Page 97 and 98:
DEPT: QC(E) C. No 74 SHIP: FC MADHU
Page 99 and 100:
kg/cm2 Qty 02 (f) Both M/E S/W suct
Page 101 and 102:
65 mm, Mat Steel, TP 3.0 kg/cm2
Page 103 and 104:
new flanges. Hot bending is not per
Page 105 and 106:
Activity Description Remove the cou
Page 107 and 108:
ARTICLE 14 INDEMNITY & INSURANCE
Page 109 and 110:
ARTICLE 2 EFFECTIVE DATE AND OPE
Page 111 and 112:
5.2 “END USER” CERTIFICATE. Con
Page 113 and 114:
Certificate (applicable in the case
Page 115 and 116:
ARTICLE 14 INDEMNITY & INSURANCE
Page 117 and 118:
procuring the Contracts or forbeari
Page 119 and 120:
(c) Control generation and disposal
Page 121 and 122:
ANNEX 2 to Encl - III to RFP SCOP
Page 123 and 124:
DESIGNATION / RANK DEPT/ORGANISATIO
Page 125 and 126:
‘T’ BID COMPLIANCE MATRIX (TO B
Page 127:
Enclosure VII of RFP EMD Bank Guara
show all

naval dockyard, mumbai - Irfc-nausena.nic.in

Create successful ePaper yourself

Delete template?

Save as template?