Specification Part 3 - Road & Bridge Works - Urban Administration ...

More documents

Recommendations

Info

400. SUB-BASES, BASES (NON-BITUMINIOUS)
CONTENT Clause No 401 GRANULAR SUB-BASE Description 402 LIME TREATED SOIL FOR IMPROVE SUB-GRADE/SUB-BASE 403 SUMMARY OF GRANULAR SUB BASE. 404 WATER BOUND MACADAM SUB -BASE/BASE5 405 CRUSHED CEMENT CONCRETE SUB-BASE/BASE. 406 WET MIX MACADAM SUB 4 BASE/BASES 407 SHOULDERS, ISLANDS AND MEDIANS 408 CEMENT CONCRETE KERB AND KERB WITH CHANNEL 409 FOOTPATHS AND SEPARATORS 410 CRUSHER-RUN MACADAM BASE
Page 1 and 2:
GOVERNMENT OF MADHYA PRADESH, URBAN
Page 3 and 4:
SECTION 100
Page 5 and 6:
101 INTRODUCTION These specificatio
Page 7 and 8:
13.2 74 *11.2 *63 9.50 53 *8.00 *45
Page 9 and 10:
107 CONTRACT DRAWINGS 107.1 The Con
Page 11 and 12: 110.3 No clearance or alterations t
Page 13 and 14: Any vehicle with open load-carrying
Page 15 and 16: warning lights of similar type shal
Page 17 and 18: Location of the scales shall be as
Page 19 and 20: c) Sequence of construction and det
Page 21 and 22: ecording shall be done in the prese
Page 23 and 24: IRC : 47-1972 IRC : 48-1972 Tentati
Page 25 and 26: Number Designation IS:1216-1978 IS:
Page 27 and 28: Number Designation IS:12269-1987 IS
Page 29 and 30: Number Designation BS:7542 CRR I &
Page 31 and 32: CONTENT Clause No Description 201 S
Page 33 and 34: (v) All products of clearing and gr
Page 35 and 36: 202.6. Measurements for Payment The
Page 37 and 38: CONTENT Clause No Description 301 E
Page 39 and 40: 301.3 Construction Operations 301.3
Page 41 and 42: 301.6 Preparation of Cut Formation
Page 43 and 44: (13) At a time, not more than 10 ch
Page 45 and 46: All overburden soil and weathered r
Page 47 and 48: If it is determined beforehand that
Page 49 and 50: 11. Excavation in marshes shall beg
Page 51 and 52: Table 300-2 Compaction Requirements
Page 53 and 54: maintained at such a crossfall (not
Page 55 and 56: (c) Only the materials satisfying t
Page 57 and 58: 4 Where the available embankment ma
Page 59 and 60: of drainage. 309.2 Surface Drains S
Page 61: Damage to the fabric resulting from
Page 65 and 66: TABLE 400-1. GRADING FOR CLOSE -GRA
Page 67 and 68: (iii) Compaction: Density shall be
Page 69 and 70: 402.3.6. Addition of lime: Lime may
Page 71 and 72: TABLE 400 -6. PHYSICAL REQUIREMENTS
Page 73 and 74: The consolidated details of quantit
Page 75 and 76: (4) Rolling shall be discontinued w
Page 77 and 78: (ii) Furnishing all materials to be
Page 79 and 80: (4) Optimum moisture for mixing sha
Page 81 and 82: 406.8 Measurements for Payment Wet
Page 83 and 84: iv) For kerb in running meters v) F
Page 85 and 86: 409.3.4 Precast cement concrete blo
Page 87 and 88: The surface finish of construction
Page 89 and 90: CONTENT Clause No Description 501 G
Page 91 and 92: (k) Use of Premix seal coat:- It is
Page 93 and 94: Number 0 and 1 are of very low cons
Page 95 and 96: area beyond it, shall be laid by ha
Page 97 and 98: 501.8. Preparation of Surface 501.8
Page 99 and 100: Normally, the maximum layer thickne
Page 101 and 102: 5. 6. Bituminous penetration macada
Page 103 and 104: Control of temperature of binder in
Page 105 and 106: 501.8.7.5 Tack coat: This is to be
Page 107 and 108: 6. Emergency Response 6.1. The Cont
Page 109 and 110: carpet to ensure a proper bond betw
Page 111 and 112: 504.2.2. Coarse aggregates: (i)The
Page 113 and 114:
504.8. Rate The cont react unit rat
Page 115 and 116:
505.7. Measurement for Payment Pene
Page 117 and 118:
The contract unit rate for built-up
Page 119 and 120:
507.3. Mixture Design 507.3.1. Requ
Page 121 and 122:
507.4. Construction Operations 507.
Page 123 and 124:
1. IS: 2386 Part 1 2. IS: 2386 Part
Page 125 and 126:
508.8. Measurement for Payment The
Page 127 and 128:
Notes: 1. The combined aggregate gr
Page 129 and 130:
ase, followed by a cover of stone c
Page 131 and 132:
The equipment and general procedure
Page 133 and 134:
Aggregates (a) Nominal Stone size 1
Page 135 and 136:
(A) Premix Carpet (a) Coarse aggreg
Page 137 and 138:
511.2.6. Surface finish and quality
Page 139 and 140:
(i)The stone chips shall consist of
Page 141 and 142:
S. No. Nominal size of aggregate De
Page 143 and 144:
* In cold climatic regions (tempera
Page 145 and 146:
(vi)During cooking and mixing, care
Page 147 and 148:
(i)It is usual to use ordinary Port
Page 149 and 150:
(iii)The Contractor shall monitor t
Page 151 and 152:
519.2.1.3. Aggregate grading and bi
Page 153 and 154:
evaporation of water and/or solvent
Page 155 and 156:
519.3.1.3 Aggregate grading and bin
Page 157 and 158:
519.3.6. Measurement for payment: R
Page 159 and 160:
Loss in Weight, %., Maximum Increas
Page 161 and 162:
522.2. Materials 522.2.1. Binder: B
Page 164 and 165:
600 Concrete Pavements
Page 166 and 167:
601. DRY LEAN CEMENT CONCRETE SUB-B
Page 168 and 169:
601.4. Subgrade The subgrade shall
Page 170 and 171:
601.5.7. Curing: As soon as the lea
Page 172 and 173:
602.2. Materials 602.2.1. Source of
Page 174 and 175:
602.3.2. Cement content: The cement
Page 176 and 177:
602.6.2.2. Contraction joints: Cont
Page 178 and 179:
602.6.6. Tie bars 602.6.6.1. Tie ba
Page 180 and 181:
602.9.3.2. Batching plant and equip
Page 182 and 183:
602.9.5.2. The concrete shall be di
Page 184 and 185:
mechanical sprayer shall incorporat
Page 186 and 187:
after concrete has set to expose do
Page 188 and 189:
joints is completed including the c
Page 190 and 191:
603.2.3.4. The coarse and fine aggr
Page 192:
603.9. Tolerances for Surface Regul
Page 195 and 196:
701 GEOSYNTHETICS IN ROAD AND BRIDG
Page 197 and 198:
Table 700-2 Geotextile Requirements
Page 199 and 200:
strong acid/bases, flames including
Page 201 and 202:
702.4 Measurement for Payment The g
Page 203 and 204:
dimensional stability relative to e
Page 205 and 206:
706 GEOSYNTHETICS FOR HIGHWAY PAVEM
Page 207 and 208:
707.2.3 Tack coat: The tack coat us
Page 209 and 210:
708.3.2 Construction and installati
Page 211 and 212:
CONTENT Clause No Description 801 T
Page 213 and 214:
801.3.1. General requirements: The
Page 215 and 216:
lack free adhesive activated by hea
Page 217 and 218:
(iii) (iv) (v) (vi) (vii) (viii) (i
Page 219 and 220:
802.1.1. Overhead signs may be used
Page 221 and 222:
802.7.6. Before erecting support st
Page 223 and 224:
(c) Skid resistance : not less than
Page 225 and 226:
(b) The marking shall not lift from
Page 227 and 228:
The work covers supplying and fixin
Page 229 and 230:
809.3.1. The location of crash barr
Page 231:
810.7.3. No measurement for payment
Page 234 and 235:
901. GENERAL 901.1. All materials t
Page 236 and 237:
902.3. Surface Levels The levels of
Page 238 and 239:
eplacement of a bituminous layer is
Page 240 and 241:
per 5 tones 3. Water Bound Macadam
Page 243 and 244:
CONTENT Clause No Description 1001
Page 245 and 246:
ecommended threshold values as per
Page 247 and 248:
S 415 IS:17B6 High Yield 415 200 St
Page 249 and 250:
and testing of concrete. The contra
Page 251 and 252:
prevented. The use of correctly for
Page 254 and 255:
Page 256 and 257:
1105. TEST PILES 1105.1. Test piles
Page 258 and 259:
The concrete shall be properly grad
Page 260 and 261:
During driving the top of pile shal
Page 262 and 263:
concrete in the installed pile and
Page 264:
the head to the butt of the shoe or
Page 267 and 268:
1201. DESCRIPTION This work consist
Page 269 and 270:
1205. WELL CURB 1205.1. The well cu
Page 271 and 272:
Separate high pressure connection f
Page 273 and 274:
Care shall be taken to keep all par
Page 275 and 276:
The well shall be uniformly seated
Page 277 and 278:
d) The Contract unit rates for sand
Page 279 and 280:
CONTENT Clause No 1301 DESCRIPTION
Page 281 and 282:
Such soaked bricks shall be stacked
Page 283 and 284:
The surfaces can be finished by "jo
Page 285 and 286:
In case of plaster finish, the mini
Page 287 and 288:
Page 289 and 290:
e fluid mixed thoroughly and then p
Page 291 and 292:
1405.3.5. Quoin stone : Quoin stone
Page 293 and 294:
1405.9. Wee Holes Weep holes shall
Page 295 and 296:
Page 297 and 298:
1504.6. Shuttering for walls, slopi
Page 299 and 300:
When formwork is dismantled, its in
Page 301 and 302:
Page 303 and 304:
(i) In case of beam and slab constr
Page 305 and 306:
(iii)The fabrication, furnishing an
Page 307 and 308:
Page 309 and 310:
TABLE 1700-3. FOR BRIDGES OTHER THA
Page 311 and 312:
(iii)The initial trial mixes shall
Page 313 and 314:
Unless specified otherwise, equipme
Page 315 and 316:
All under water concreting shall be
Page 317 and 318:
disappears. The second application
Page 319 and 320:
(iv) After the passage of the above
Page 321 and 322:
Page 323 and 324:
1802.2.3. In severe environment, ca
Page 325 and 326:
strength of steel to concrete. Grou
Page 327 and 328:
) If the calculated elongation has
Page 329 and 330:
1809.5. Protection of Ends The expo
Page 331 and 332:
1900 Structural Steel
Page 333 and 334:
1901. DESCRIPTION This work shall i
Page 335 and 336:
All work shall be in accordance wit
Page 337 and 338:
1904.3.2. Block drilling : Where th
Page 339 and 340:
Taper washers with correct angle of
Page 341 and 342:
Welding shall not be done when the
Page 343 and 344:
column. This dimension shall be mea
Page 345 and 346:
IS:7969 dealing with handling of ma
Page 347 and 348:
(i) (ii) (iii) iv) Visual Inspectio
Page 349 and 350:
(ii) Chemical Resistant Paints The
Page 351 and 352:
Two coats of aluminum paint conform
Page 353:
Weight of structural secti ons shal
Page 356 and 357:
2001. DESCRIPTION This work shall c
Page 358 and 359:
Tolerances on height of any compone
Page 360 and 361:
A bottom plate with concave surface
Page 362 and 363:
3.1 Max change in Hardness IRHD +15
Page 364 and 365:
The size and composition of accepta
Page 366 and 367:
1. Acceptance testing by an indepen
Page 368 and 369:
ii) Template of 6 mm M.S. plate and
Page 370 and 371:
ix) Pot bearings including all pans
Page 372 and 373:
ii) Overall height : -0 to +3 mm ii
Page 374 and 375:
2008. TESTS AND STANDARDS OF ACCEPT
Page 376 and 377:
Page 378 and 379:
Formwork and concrete shall conform
Page 380 and 381:
Page 382 and 383:
The surface on which elastomeric be
Page 384 and 385:
Page 386 and 387:
The surface finish of the deck slab
Page 388 and 389:
2400 Surface and Sub-surface Geotec
Page 390 and 391:
2401. GENERAL 2401.1. The objective
Page 392 and 393:
2403.5. Logging of bore-holes by ra
Page 394 and 395:
For preliminary and detailed sub-su
Page 396 and 397:
2408.4. Rock Samples 2408.4.1. Dist
Page 398 and 399:
1. (a) During construction or immed
Page 400 and 401:
2500 River Training Work and Protec
Page 402 and 403:
2501 DESCRIPTION River training and
Page 404 and 405:
Wherever possible, crates shall be
Page 406 and 407:
2505. RUBBLE STONE/CEMENT CONCRETE
Page 408 and 409:
2600 Expansion Joints
Page 410 and 411:
2601. DESCRIPTION This work shall c
Page 412 and 413:
2603.4. Performance Requirement wit
Page 414 and 415:
2606. ELASTOMERIC SLAB SEAL EXPANSI
Page 416 and 417:
iii) While removing the spacer bar
Page 418 and 419:
ix) All excess sealant shall be rem
Page 420 and 421:
TABLE 2600-1. STRIP SEAL ELEMENT SP
Page 422 and 423:
iii) In view of the importance of t
Page 424 and 425:
2700 Wearing Coat and Appurtenances
Page 426 and 427:
2701. DESCRIPTION This work shall i
Page 428 and 429:
deck structure. In case of viaducts
Page 430 and 431:
2800 Repair of Structures
Page 432 and 433:
2801. DESCRIPTION Repair of structu
Page 434 and 435:
ecommendations. When mined, all adh
Page 436 and 437:
Bond Strength : 12 MPa Tensile Stre
Page 438 and 439:
Grouting shall normally be performe
Page 440 and 441:
2807.11. Sufficient clearance shall
Page 442 and 443:
The behaviour of the girder shall b
Page 444 and 445:
Page 446 and 447:
suffer any undue structural strain,
Page 448 and 449:
3000 Maintenance of Road
Page 450 and 451:
3001. GENERAL The Specifications sh
Page 452 and 453:
3004.1.5. Measurements for payment:
show all

Specification Part 3 - Road & Bridge Works - Urban Administration ...

Create successful ePaper yourself

Delete template?

Save as template?