This section is available on request - MAN Diesel & Turbo

More documents

Recommendations

Info

MAN B&W Diesel A/S 18.08 External Systems The detailed design of the external systems will normally be carried out by the individual shipyard/ contractor, and <strong>is</strong>, therefore, not subject to the type approval of the engine. The external systems described here include the sealing oil system, the ventilation system, and the gas supply and compressor system. Sealing oil system The sealing oil system supplies oil, via a piping system with protecting hoses, to the gas injection valves, thereby providing a sealing between the gas and the control oil, and lubrication of the moving parts. The sealing oil pump has a separate drive and <strong>is</strong> started before commencing gas operation of the engine. It uses the 200 bar servo oil, or one bar fuel oil, and pressur<strong>is</strong>es it additionally to the oper- �� Fig. 18.08.01: Gas system branching Page 3 of 3 ating pressure, which <strong>is</strong> 25-50 bar higher than the gas pressure. The consumption <strong>is</strong> small, corresponding to a sealing oil consumption of approx. 0.1 g/bhph. After use, the sealing oil <strong>is</strong> burned in the engine. Ventilation system The purpose of the ventilation system <strong>is</strong> to ensure that the outer pipe of the double-wall gas pipe system <strong>is</strong> ventilated with air, and it acts as a separation between the engine room and the highpressure gas system, see Fig 18.08.01. Ventilation <strong>is</strong> achieved by means of an electrically driven mechanical fan or extractor fan. If an electrically driven fan <strong>is</strong> chosen, the motor must be placed outside the ventilation duct. The capacity must ensure approx. 10 - 30 air changes per hour. More ventilation gives quicker detection of any gas leakage. �� 178 53 65-7.0 ME-GI engines 198 50 60-7.0
MAN B&W D<strong>is</strong>patch Pattern, Testing, Spares and Tools MAN Diesel 19
Page 1 and 2:
MAN B&W S65ME-C8-GI-TII Project Gui
Page 3:
MAN B&W Engine Design .............
Page 6 and 7:
MAN B&W Contents Chapter Section 5
Page 8 and 9:
MAN B&W Contents Chapter Section 13
Page 11 and 12:
MAN B&W Index Subject Section Subje
Page 13 and 14:
Page 15 and 16:
Page 17:
Page 21 and 22:
MAN B&W 1.00 ME�GI Dual Fuel Engi
Page 23 and 24:
MAN B&W 1.01 ME Advantages The adva
Page 25 and 26:
MAN B&W 1.02 Engine Type Designatio
Page 27 and 28:
MAN B&W 1.04 Engine Power Range and
Page 29 and 30:
MAN B&W Performance Curves
Page 31 and 32:
MAN B&W 1.06 Cylinder Liner The cyl
Page 33 and 34:
MAN B&W 1.06 Auxiliary Blower The e
Page 35 and 36:
MAN B&W 1.06 This</
Page 37 and 38:
MAN B&W 1.06 The double�wall pipi
Page 39:
MAN B&W Engine Layout and Load Diag
Page 42 and 43:
MAN B&W 2.01 placed on the light ru
Page 44 and 45:
MAN B&W 2.02 Constant ship speed li
Page 46 and 47:
MAN B&W 2.04 Engine Layout and Load
Page 48 and 49:
MAN B&W 2.04 Line 4: Represents the
Page 50 and 51:
MAN B&W 2.04 110 100 90 80 70 60 50
Page 52 and 53:
MAN B&W 2.04 Example 2: Special run
Page 54 and 55:
MAN B&W 2.04 Example 4: Special run
Page 57 and 58:
MAN B&W 2.05 Diagram for actual pro
Page 59 and 60:
MAN B&W 2.07 SFOC for High Efficien
Page 61 and 62:
MAN B&W 2.08 Examples of Graphic Ca
Page 63 and 64:
MAN B&W 2.09 SFOC for S65ME-C8/-GI
Page 65 and 66:
MAN B&W 2.10 Diagram b Reduction of
Page 67:
MAN B&W 2.12 Emiss
Page 71 and 72:
MAN B&W 3.01 Turbocharger Selection
Page 73 and 74:
MAN B&W 3.02 Turbocharger MAN B&W S
Page 75:
MAN B&W 3.03 Air Orifice Air Proces
Page 79 and 80:
MAN B&W 4.01 Electricity Production
Page 81 and 82:
MAN B&W 4.01 Designation of PTO For
Page 83 and 84:
MAN B&W 4.01 The power from the cra
Page 85 and 86:
MAN B&W 4.02 � � � � � Th
Page 87 and 88:
MAN B&W 4.03 Pos. 1 Special face on
Page 89 and 90:
MAN B&W 4.03 DMG/CFE Generators Opt
Page 91 and 92:
MAN B&W 4.03 In such a case, the pr
Page 93 and 94:
MAN B&W 4.04 combinator mode. <stro
Page 95 and 96:
MAN B&W Waste Heat Recovery Systems
Page 97 and 98:
MAN Diesel 4.06 L16/24 GenSet Data
Page 99 and 100:
Page 101 and 102:
Page 103 and 104:
MAN Diesel 4.08 L23/30H GenSet Data
Page 105 and 106:
Page 107 and 108:
Page 109:
MAN Diesel 4.10 L28/32H GenSet Data
Page 113 and 114:
MAN B&W 5.01 Space Requirements and
Page 115 and 116:
MAN B&W 5.02 Cyl. No. 5 6 7 8 A 1,1
Page 117 and 118:
MAN B&W 5.03 Crane beam for turboch
Page 119 and 120:
MAN B&W 5.04 Engine room crane The
Page 121 and 122:
MAN B&W 5.04 MAN B&W Double�Jib C
Page 123 and 124:
MAN B&W 5.06 Engine and Gallery Out
Page 125 and 126:
MAN B&W 5.06 3,560 2,358 400 400 50
Page 127 and 128:
MAN B&W 5.08 Mass of Water and Oil
Page 129 and 130:
MAN B&W 5.09 6,244 (AD) 6,171 (X, F
Page 131 and 132:
MAN B&W 5.10 Counterflanges MAN B&W
Page 133 and 134:
MAN B&W 5.10 Counterflanges, Connec
Page 135 and 136:
MAN B&W 5.10 MHI Type MET Fig. 5.10
Page 137 and 138:
TCA MAN B&W 5.10 ABB Type TPL TPL T
Page 139 and 140:
MAN B&W 5.11 Engine Seating and Hol
Page 141 and 142:
MAN B&W 5.12 Engine Seating Profile
Page 143 and 144:
MAN B&W 5.13 Engine Top Bracing The
Page 145 and 146:
MAN B&W 5.14 Mechanical Top Bracing
Page 147 and 148:
MAN B&W 5.16 Components for Engine
Page 149 and 150:
MAN B&W 5.16 EICU (Engine Interface
Page 151 and 152:
MAN B&W 5.17 Shaftline Earthing Dev
Page 153 and 154:
MAN B&W 5.17 When a generator <stro
Page 155 and 156:
MAN B&W 5.18 Data Sheet for Propell
Page 157 and 158:
MAN B&W 5.18 Servo oil system for V
Page 159 and 160:
MAN B&W 5.18 Alphatronic 2000 Propu
Page 161:
MAN B&W 5.18 Renk KAZ Clutch for au
Page 165 and 166:
MAN B&W 6.01 Calculation of L<stron
Page 167 and 168:
MAN B&W 6.03 List
Page 169 and 170:
MAN B&W 6.03 List
Page 171 and 172:
MAN B&W 6.04 Auxiliary Machinery Ca
Page 173 and 174:
MAN B&W 6.04 Calculation of L<stron
Page 175 and 176:
MAN B&W 6.04 Freshwater Generator I
Page 177 and 178:
MAN B&W 6.04 Calculation of Freshwa
Page 179 and 180:
MAN B&W 6.04 ∆m M% = 14 x ln (P M
Page 181 and 182:
MAN B&W 6.04 Calculation of Exhaust
Page 183:
MAN B&W MAN Diesel Fuel 7
Page 186 and 187:
MAN B&W 7.00 The new modified parts
Page 188 and 189:
MAN B&W 7.00 As can be seen in Fig.
Page 190 and 191:
MAN B&W 7.01 Fuel Oil System No val
Page 192 and 193:
MAN B&W 7.02 Fuel Oils Marine diese
Page 194 and 195:
MAN B&W 7.04 Fuel Oil Pipe Insulati
Page 196 and 197:
MAN B&W 7.04 Fuel Oil Pipe Heat Tra
Page 198 and 199:
MAN B&W 7.05 Fuel Oil Heater The he
Page 200 and 201:
MAN B&W 7.06 Water In Fuel Emulsifi
Page 202 and 203:
MAN B&W Reliquefaction Technology W
Page 204 and 205:
MAN B&W LNG Carriers LNG carriers,
Page 206 and 207:
MAN B&W This</stron
Page 208 and 209:
MAN B&W 7.09 % of full engine load
Page 210 and 211:
MAN B&W 7.09 Safety aspects The com
Page 212 and 213:
MAN B&W 7.09 3,650 Motor Motor Inte
Page 215:
MAN B&W MAN Diesel Lubricating Oil
Page 218 and 219:
MAN B&W 8.02 Hydraulic Power Supply
Page 220 and 221:
MAN B&W 8.03 Lubricating Oil Pipes
Page 222 and 223:
MAN B&W 8.04 Lubricating Oil Centri
Page 224 and 225:
MAN B&W 8.05 Lubricating oil full f
Page 226 and 227:
MAN B&W 8.06 Lubricating Oil Tank
Page 228 and 229:
MAN B&W 8.07 Crankcase Venting and
Page 230 and 231:
MAN B&W 8.09 Separate System for Hy
Page 232 and 233:
MAN B&W 8.09 ��
Page 235:
MAN B&W MAN Diesel Cylinder Lubrica
Page 238 and 239:
MAN B&W 9.02 MAN B&W Alpha Cylinder
Page 240 and 241:
MAN B&W 9.02 Cylinder Oil Pipe Heat
Page 242 and 243:
MAN B&W 9.02 Flow sensor AC Page 5
Page 245:
MAN B&W MAN Diesel Pis</str
Page 249:
MAN B&W MAN Diesel Central Cooling
Page 252 and 253:
MAN B&W 11.02 Central Cooling Water
Page 254 and 255:
MAN B&W 11.03 Jacket water system D
Page 257 and 258:
MAN B&W 12.01 Seawater Systems The
Page 259 and 260:
MAN B&W 12.03 Seawater Cooling Pipe
Page 261 and 262:
MAN B&W 12.05 Jacket Cooling Water
Page 263 and 264:
MAN B&W 12.07 Components for Jacket
Page 265:
MAN B&W 12.08 Temperature at Start
Page 269 and 270:
MAN B&W 13.01 Starting and Control
Page 271 and 272:
MAN B&W 13.03 Starting and Control
Page 273:
MAN B&W 13.04 Electric Motor for Tu
Page 277 and 278:
MAN B&W 14.01 Scavenge Air System S
Page 279 and 280:
MAN B&W 14.02 Control of the Auxili
Page 281 and 282:
MAN B&W 14.04 Electric Motor for Au
Page 283 and 284:
MAN B&W 14.05 Auto Pump Overboard S
Page 285 and 286:
MAN B&W 14.07 Fire Extingui
Page 287:
MAN B&W MAN Diesel Exhaust Gas 15
Page 290 and 291:
MAN B&W 15.02 Exhaust Gas Pipes Exh
Page 292 and 293:
MAN B&W 15.02 Cleaning Systems Wate
Page 294 and 295:
MAN B&W 15.04 Components of the Exh
Page 296 and 297:
MAN B&W 15.05 Calculation of Exhaus
Page 298 and 299:
MAN B&W 15.05 Pressure losses and c
Page 300 and 301:
MAN B&W 15.06 F2 MAN B&W S65ME-C8/-
Page 303:
MAN B&W MAN Diesel Engine Control S
Page 306 and 307:
MAN B&W 16.01 2) Low NO x em<strong
Page 308 and 309:
MAN B&W 16.01 ME�GI operational p
Page 310 and 311:
MAN B&W 16.01 Mechanical�hydrauli
Page 312 and 313: MAN B&W 16.01 Engine Control System
Page 314 and 315: MAN B&W 16.01 Pneumatic Manoeuvring
Page 316 and 317: MAN B&W 16.02 Dual Fuel Control Sys
Page 318 and 319: MAN B&W 16.02 Safe condition/ purge
Page 321: MAN B&W MAN Diesel Vibration Aspect
Page 324 and 325: MAN B&W 17.02 2nd Order Moments on
Page 326 and 327: MAN B&W 17.02 1st Order Moments on
Page 328 and 329: MAN B&W 17.03 Moment compensator Af
Page 330 and 331: MAN B&W 17.05 Guide Force Moments T
Page 332 and 333: MAN B&W 17.05 As the deflection sha
Page 334 and 335: MAN B&W 17.06 Critical Running When
Page 337: MAN B&W Monitoring Systems and Inst
Page 340 and 341: MAN B&W 18.02 PMI System, Type PT/S
Page 342 and 343: MAN B&W 18.03 CoCoS Systems The Com
Page 344 and 345: MAN B&W 18.04 Alarm - Slow Down and
Page 346 and 347: MAN B&W 18.04 Alarms for UMS - Clas
Page 348 and 349: MAN B&W 18.04 Alarms for UMS - Clas
Page 350 and 351: MAN B&W 18.04 Shut down for AMS and
Page 352 and 353: MAN B&W 18.05 Local instruments Rem
Page 354 and 355: MAN B&W 18.06 Other Alarm Functions
Page 356 and 357: MAN B&W 18.06 Bearing Wear Monitori
Page 358 and 359: MAN B&W 18.06 Control Devices Senso
Page 360 and 361: MAN B&W Diesel A/S 18.08 Safety Asp
Page 365 and 366: MAN B&W 19.01 Disp
Page 367 and 368: MAN B&W 19.02 Specification for pai
Page 369 and 370: MAN B&W Dispatch P
Page 371 and 372: MAN B&W 19.06 List
Page 373 and 374: MAN B&W 19.07 Exhaust valve, <stron
Page 375 and 376: MAN B&W 19.08 Table B: Page 2 of 2
Page 377 and 378: MAN B&W 19.10 List
Page 379: MAN B&W MAN Diesel Project Suppport
Page 382 and 383: MAN B&W 20.02 Computeris</s
Page 384 and 385: MAN B&W 20.03 Copenhagen Standard E
Page 386 and 387: MAN B&W 20.04 Main Section 939 Engi
Page 388 and 389: MAN B&W 20.04 Engine production and
Page 391 and 392: MAN B&W Appendix A Symbols for Pipi
Page 393: MAN B&W Appendix A No. Symbol Symbo
show all

This section is available on request - MAN Diesel & Turbo

Create successful ePaper yourself

Delete template?

Save as template?