View Document Here - Hanford Site

More documents

Recommendations

Info

Literature Search Results WHC-SD-W100-TI-003 Rev. 0 DESCRIPTION OF APPENDICES (cont.) 1. This WHC Letter Report (CEP-WOG-001) contains a thorough literature search and review of solidification technologies. This review was done in support of the Waste Receiving and Processing (WRAP) Facility, Module 2A, Waste Form Qualification efforts. It included a review of all known solidification technologies. This report (generated by solidification expert Earl McDanial, Oak Ridge National Laboratory) is a review specifically of grouting technology (cement-based solidification) used throughout the world. This report was done to support the selection of a grout technology in WRAP 2A. F. Thermosetting Polymer Test Results Contained under four reports: Test Status Report (1) - WHC Trip Thermosetting Polymer Test Report Thermosetting Polymer Test Report Thermosetting Polymer Test Report G. Overview of Solidification Technologies Report to Stock Equipment Company (2) - Stock Equipment Company (3) - Stock Equipment Company (4) - Stock Equipment Company This is an internal WHC memo report that was prepared as a review of all avaiiable solidification technologies, important processing considerations,_and general advantages and disadvantages of various technologies. The report is not specific to WRAP 2A and is intended to provide--general--trackground needed to begin evaluating the various waste forms. viii
WHC-SD-W100-TI-003 Rev. 0 LIST OF TERMS ANS American Nuclear Society ASTM American Society for Testing and Materials BDAT Best Demonstrated Achievable Technology CDR Conceptual Design Report CH contact handled CH-MLLW contact handled mixed low-level waste DOE U.S. Department of Energy EPA U.S. Environmental Protection Agency LETF Liquid Effluent Treatment Facilities LLW low-level waste MLLW mixed low-level waste NRC U.S. Nuclear Regulatory Commission RCRA ---_tespur^&_C=ser-vaLior. -and-Ttecevery Act RH remote handled RMW radioactive mixed waste TCLP Toxicity Characteristic Leaching Procedure UE&C United Engineers and Constructors, Inc. WFQ Waste Form Qualification WHC Westinghouse <strong>Hanford</strong> Company WRAP Waste Receiving and Processing ix
Page 1 and 2: R 2.1 199^ ^.EN GINEERING DATA TRAN
Page 3 and 4: Date Received% • I INFORMATION RE
Page 5 and 6: . SUPPORTING DOCUMENT 1. Total Page
Page 7 and 8: WHC-SD-W100-TI-003 Rev. 0 EXECUTIVE
Page 9 and 10: WHC-SD-W100-TI-003 Rev. 0 been achi
Page 11 and 12: __ _ _ MHC-SIL-yJ3,00-TI-D03 Rev. 0
Page 13: F`= WHC-SD-W100-TI-003 Rev. 0 DESCR
Page 17 and 18: WHC-SD-W100-TI-003 Rev. 0 WASTE REC
Page 19 and 20: WHC-SD-W100-TI-003 Rev. 0 1.2.1 Fee
Page 21 and 22: ^s. WHC-SD-W100-TI-003 Rev. 0 conta
Page 23 and 24: __-'°'2 WHC-SD-W100-TI-003 Rev. 0
Page 25 and 26: 2.1 REGULATORY FRAMEWORK WHC-SD-W10
Page 27 and 28: ^..." ;_:.. :.^ .^.y^ WHC-SD-W100-T
Page 29 and 30: WHC-SD-W100-TI-003 Rev. 0 which the
Page 31 and 32: kIHC-Sû-Wi"v"u-Ti-u03 Rev. V ,--,,
Page 33 and 34: WHC-SD-W100-TI-003 Rev. 0 Type 1 wa
Page 35 and 36: 3.3 TESTING APPROACH WHC-SD-W100-TI
Page 37 and 38: ^.: fi WNC-SD-W100-TI-003 Rev. 0 Fi
Page 39 and 40: 4.1 SCREENING TEST RESULTS WHC-SD-W
Page 41 and 42: ,^. ----- -- WHC-SD-W100-TI-003 Rev
Page 43 and 44: WHC-SD-W100-TI-003 Rev. 0 4.1.3 The
Page 45 and 46: p Sam le Compressive Radiation stre
Page 47 and 48: WHC-SD-W100-TI-003 Rev. 0 Table 4-3
Page 49 and 50: ..., TESTING RESULTS .^.CSSD-W-1OO-
Page 51 and 52: A I w ^^',; ^^ ;J ?1Fasf^.}: "q -?
Page 53 and 54: ;..;: .^:. WHC-SD-W100-TI-003 Rev.
Page 55 and 56: --- ....ti s..` WHC-SD-WI00-TI-003
Page 57 and 58: 1.0 INTRODUCTION WHC-SD-W100-TI-003
Page 59 and 60: WHC-SD-W100-TI-003 Rev. 0 Waste For
Page 61 and 62: ^-: -- ^ Component Waste Type 1 LET
Page 63 and 64: .^x. --1vHC-SD iii00- T i-003 Rev.
Page 65 and 66:
WHC-SD-W: JV-TI-VVJ ^cv. v APPENDIX
Page 67 and 68:
,..^ c:-- z ,.E ^=t ^^ln^l WHC-SD-W
Page 69 and 70:
Scope WHC-SD-W100-TI-003 Rev. 0 Sup
Page 71 and 72:
00 V F-' Activity and Miltstone Cha
Page 73 and 74:
WHC-SD-W100-TI-003 Rev. 0 Laborator
Page 75 and 76:
WHC-SD-WIOO-TI-003 Rev. 0 APPENDIX
Page 77 and 78:
16490 Chiaccothe Itoad Chagrin Fall
Page 79 and 80:
ca-. tY•^_E Q . - - StoGkE4uip+!n
Page 81 and 82:
^.. WHC-SD-W100-TI-003 Rev. 0 . , I
Page 83 and 84:
Waste Type: WHC-SD-W100-TI-003 Rev.
Page 85 and 86:
Stock E quipment Company A Unit of
Page 87 and 88:
G' ,.,. d,_ s WHC-0-W100-TI-003 Rev
Page 89 and 90:
Cx U: r°... .• , .ti Waste Type:
Page 91 and 92:
-. LeachantSolution: Specimen Diame
Page 93 and 94:
c^1, WHC-SD-W100-TI-003 Rev. 0 THER
Page 95 and 96:
..... lry" - Stock E a uipment Comp
Page 97 and 98:
;=. .:^;. WHC-SD-W100-TI-003 Rev< 0
Page 99 and 100:
(.7 ..^^ -„n f^. [Y^. Waste Type:
Page 101 and 102:
Date: _ Leachability Time Point Lea
Page 103 and 104:
23 Ninety ( 90) Day Immersion Test
Page 105 and 106:
ty ,.. ='`F r...,, b Ly.. Specimen
Page 107 and 108:
25 BIODEGRADATION TEST PROCEDURE St
Page 109 and 110:
Date: WHC-SD-W100-TI-003 Rev. 0 BIO
Page 111 and 112:
^_... ..^^ C:i1 Date: WHC-SD-W100-T
Page 113 and 114:
Date: WHC-SD-W100-TI-003 Rev. 0 --
Page 115 and 116:
f-^ -- WHC-SD-W100-TI-003 Rev. 0 2.
Page 117 and 118:
^-..., 3•0 ASSAY FOR MEI'ALS 3.1
Page 119 and 120:
t..f f....,.. P....^ .-- ^ : .^ ^-.
Page 121 and 122:
^c. v 3 0 w.3 cn a v t[ACeRUtIIY IO
Page 123 and 124:
WHC-SD-W100-TI-003 Rev. 0 APPENDIX
Page 125 and 126:
WHC-SD-W100-TI-003 Rev. 0 STOCK EQU
Page 127 and 128:
19 SCOPE AND APPLICATION WHC-SD-W10
Page 129 and 130:
L:^3 ll Q. 4 AA :'ILTEP.S WHC-0-W10
Page 131 and 132:
4_T tJrD o,...Ys j ^,.,. WHC-SD-W10
Page 133 and 134:
WHC-SD-W100-TI-003 Rev. 0 -, Proced
Page 135 and 136:
WHC-SD-W100-TI-003 Rev. 0 Procedure
Page 137 and 138:
(FM WHC-SD-W100-TI-003 Rev. 0 Proce
Page 139 and 140:
C... 6 Wet Waste Sample Contains no
Page 141 and 142:
^..., . ,.y^ h:.r WHC-SD-WI00-Ti-00
Page 143 and 144:
:. WHC-SD-W100-TI-003 Rev. 0 TA3i.E
Page 145 and 146:
^' . WHC-SD-W100-T1-003 Rev. 0 TABL
Page 147 and 148:
^- ^-> ^ C^Jl I I^t ^.: l WHC-St]-W
Page 149 and 150:
c. 03 00 r=3 ^t C^' II 6.0 II Calib
Page 151 and 152:
LY; ^ C=l . ^.^ .^,..,, €:^. MHC-
Page 153 and 154:
R: C=1 rIj s^ ^ ^.. WHC-SD-YlI00-TI
Page 155 and 156:
.,,_..1 ---^ - - i-•_E ?*^^ Mater
Page 157 and 158:
WHC-SD-W100-TI-003 Rev. 0 Dow Chemi
Page 159 and 160:
^ ±.£:a [7.p -;^ --- --------- WH
Page 161 and 162:
WHC-S®-hi1.00-T'.-00?, Rev. Dow Ch
Page 163 and 164:
t;7_7 ,...:: ----------- WHC-SD-W10
Page 165 and 166:
WHC-SD-W100-TI-003 Rev. 0 Daw M.. u
Page 167 and 168:
^ ^..rYfl VF •UIYb 1 1 AGA GllS.
Page 169 and 170:
Page 171 and 172:
CHARACTERIZATION DATA Part A: Overv
Page 173 and 174:
Grit Specie or MaterialOverall Cont
Page 175 and 176:
WHC-SD-W100-TI-003 Rev. 0 The incin
Page 177 and 178:
WHC-SD-W100-TI-003 Rev. 0 183-H BAS
Page 179 and 180:
WHC-SD-W100-TI-003 Rev. 0 June - Se
Page 181 and 182:
WHC-SD-W100-TI-003 Rev. 0 BASINS 3
Page 183 and 184:
WHC-SD-W100-TI-003 Rev. 0 BASINS 3
Page 185 and 186:
^- WHC-SD-W100-TI-003 Rev. 0 BASIN
Page 187 and 188:
WHC-SD-W100-TI-003 Rev. 0 ---------
Page 189 and 190:
J. L. Westcott Page 3 June 1, 1992
Page 191 and 192:
u...^^, WHC-SD-W100-TI-003 Rev. 0 I
Page 193 and 194:
•N`^C-Sf1-"d100-71-003 Rev. 0 ,S'
Page 195 and 196:
CONTAINER /NFORMATlO N: `d"-C-Sn-'w
Page 197 and 198:
ONTANVER BVFORMA SI7 E: AMOUN=i 8 G
Page 199 and 200:
LOT WRAP 2A.4 SHEET 7.XLS RECOMMEND
Page 201 and 202:
LOT WRAP 2A.5 SHEET 8.XLS RECOMMEND
Page 203 and 204:
.:•n-,,, LOT WRAP 2A.6 SHEET 9.XL
Page 205 and 206:
LOT WRAP 2A.7 SHEET 10.XLS RECOMMEN
Page 207 and 208:
PHYSICAL DESCR/PTTON: V-r-S?-W100-T
Page 209 and 210:
,.: Westinoause Harlford COMM WHC-S
Page 211 and 212:
O I tA SHEETII.XLS ;, LOT WRAP2A.2
Page 213 and 214:
CONTAINER /NFORMAT/ON: DOSE: SIZE:
Page 215 and 216:
PU33-11-1992 09:48 FROM EDS/qRI$ir
Page 217 and 218:
LOT WRAP 2A 10 Slf-EET 14.)C,S RECO
Page 219 and 220:
qN i: 105N-89-1097 105N-89-1098 105
Page 221 and 222:
SIZE: DOSE: 5 GAL 1 1@15 Mr 30 GAL
Page 223 and 224:
WHC-SD-W100-TI-003 Rev. 0 Westtngho
Page 225 and 226:
LOT WRAP A2.14 SHEET 18.XLS RECOMME
Page 227 and 228:
---- - LOT WRAP ZA.13 SHEET 17.XLS
Page 229 and 230:
n .-.^..-n..^^- .. ... .dJ. ^ ShIEE
Page 231 and 232:
--^ WHC-SD-W100-TI-003 Rev. 0 APPEN
Page 233 and 234:
WHC-SD-W100-TI-003 Rev. 0 Westingho
Page 235 and 236:
Table 1 Candidate Waste Forms Absor
Page 237 and 238:
--- -Aauaspt and Pe-liroset WHC-SD-
Page 239 and 240:
- '^ - qev. r' Literature Search WR
Page 241 and 242:
Dow Polymer WHC-SD-W100-TI-003 Rev.
Page 243 and 244:
L im e Literature Search WRAP 2A Pa
Page 245 and 246:
The report compares the 7eachabilit
Page 247 and 248:
J. L. Westcott Page 2 May 29, 1992
Page 249 and 250:
Package #1: Package #2: WHC-SD-W100
Page 251 and 252:
WHC-SD-W100-TI-003 Rev. 0 SURVEY OF
Page 253 and 254:
f ..;' WHC-SD-W100-TI-003 Rev. 0 A
Page 255 and 256:
Page 257 and 258:
WHC-SD-W100-TI-003 Rev. 0 commercia
Page 259 and 260:
WHC-SD-W100-TI-003 Revo 0 Bibliogra
Page 261 and 262:
WHC-SD-W100-TI-003 Rev. 0 A. P. Tos
Page 263 and 264:
OAK R1DGE NATIONAL LABORATORY OPERA
Page 265 and 266:
Page 267 and 268:
WHC-SD-W100-TI-003 Rev. 0 commercia
Page 269 and 270:
WHC-SD-W100-TI-003 Revo 0 A report
Page 271 and 272:
WHC-SD-W100-TI-003 Rev. 0 impermeab
Page 273 and 274:
WHC-SD-W100-TI-003 Rev. 0 reprocess
Page 275 and 276:
WHC-SD-W100-TI-003 Rev. 0 STR?.THGI
Page 277 and 278:
Contained under four reports: WHC-S
Page 279 and 280:
^.yo F-SD-W"00-7-003 Rev. 0 THERMOS
Page 281 and 282:
WHC-SD-W100-TI-003 Rev. 0 The techn
Page 283 and 284:
loomi^^lC& 111111111111F .^^.\ West
Page 285 and 286:
û9^c ?fi. ...^ .._-, WHC-SD-W100-T
Page 287 and 288:
Stock Equipment Company WHC-SD-WI00
Page 289 and 290:
^ i w STOCK EOUIPMENT COMPANY 14-OC
Page 291 and 292:
\. . 1 .: lh,lf^ LEACH / IMMERSIONI
Page 293 and 294:
^;- v.4'? Sampls ID L781 Elsment CO
Page 295 and 296:
4.a
Page 297 and 298:
Sanp)a ID L781 Elamant STRONTIUM Ma
Page 299 and 300:
.^ "-; SampI81D L3B2 Z e"- ^.;;. Sa
Page 301 and 302:
Sample 10 L3B1 Elsmant CESIUM Matri
Page 303 and 304:
Sample ID W B1 Elemant STRONIIUM Ma
Page 305 and 306:
Westinghouse Hanford Company 2355 S
Page 307 and 308:
--- - ftCR-e4Uip1P1eFf Company WHC-
Page 309 and 310:
WHC-SD-W100-TI-003 Rev. 0 Russ Czel
Page 311 and 312:
Stock Equipment Company 3:0 -SCFIED
Page 313 and 314:
THERMAL CYCLING SAMPLES BEFORE THE
Page 315 and 316:
BIODEGRADATION SAMPLES BEFORE THE S
Page 317 and 318:
C/ 0D OC M1 0, ^yII i..) d tl ^ a I
Page 319 and 320:
T 1 A w ^ • $ ^py yf ; pp V ^ py
Page 321 and 322:
T 1 A ^ !^^ + ^ i •^^w^:rwwwwrpR^
Page 323 and 324:
'i A v lf^. j^^ u e e - - I I I a i
Page 325 and 326:
0 > d C.) O O F- 0 0 3 G NI U 3 ^ c
Page 327 and 328:
en a-. p g aQ i ^ rr it - l r rF e^
Page 329 and 330:
' iO`F*'P\^ Westinghouse Hanford Co
Page 331 and 332:
Stock Equipment Company 1.0 SUMMARY
Page 333 and 334:
Stock Equipment Company WHC-SD-W100
Page 335 and 336:
2a0 SCHEDULE Activitv - Prepare Wor
Page 337 and 338:
T 1 o+ THERMAL CYCLWG SAMPLES BEFOR
Page 339 and 340:
T 1 OI 80 70 U 60 VJ w 50 w 0 40 30
Page 341 and 342:
^ °' cn l .:. U CD w a: w r' i ^ I
Page 343 and 344:
SAMPLE ID Li-117 L1-118 L1-19 L3-17
Page 345 and 346:
T °,w ^ - : C s 0 n a ^^ s ^ i ^-
Page 347 and 348:
71 I V y,,} ^ • 5il i ^ ^^ ^ ^ ^
Page 349 and 350:
0 a^ on O O M F- 1OCD 3 1 G N^ U il
Page 351 and 352:
O > W C f.) O O 1-- ^ O HI 6./ 3 ^
Page 353 and 354:
0 > ar oe M 0 c C3, I O c V 3 Î d
Page 355 and 356:
TI V 40 IN s i s : s ^l l i " p p l
Page 357 and 358:
Page 359 and 360:
WHC-SD-W100-TI-003 Rev. 0 _QVrDvrru
Page 361 and 362:
^-_- .,:... WHC-SD-W100-TI-003 Rev.
Page 363 and 364:
Ceramics and glass WHC-SD-W200-TI-0
Page 365 and 366:
,. ., Extruder/melter WHC-SD-W100-T
show all

View Document Here - Hanford Site

Create successful ePaper yourself

Delete template?

Save as template?