View Document Here - Hanford Site

More documents

Recommendations

Info

DON'T SAY IT TO: Distribution cc E. P. Mertens R. J. Roberts J. L. Scott J. A. Swenson WHC-SD-W100-TI-003 Rev. 0 Write It ^ DATE: May 6, 1991 N3-13 N3-13 N3-12 G6-45 FROM: L. A. Fort SUBJECT: E. W. McDANIEL LETTER REPORT "SURVEY OF GROUTING TECHNOLOGY IN SUPPORT OF WRAP'S SHRED GROUT MODULE" Please find attached a copy of Mr. E. W. McDaniel's initial letter reoort HaCeQ[ar3i '-^-' A 29-r-19 9 i^ on ^^, "sub'ect ^.. J of Suooort of WRAP's Shred Grout Module." "Surve y of Grouting Technolo Qy in This activity is to assess the international and DOE Complex waste immobilization technology development and defense waste management grout techniques applicable to the Waste Receiving and Processing (WRAP) Facility Shred-Grout operation. During the April 9, 1991 Exchange Meeting, Mr. E. W. McDaniel provided a preliminary draft letter report in compliance with the 5/24/91 milestone. The edited version of the earlier preliminary draft report is attached. The preliminary draft report was distributed as Attachment 2 to the April 9, 1991 Exchange Meeting report. Again, copies of the approximately 60 references identified within the draft report (over 15 inches of documents) are available in my office for referral. As stated in the April 9, 1991 Exchange Meeting report, the draft report essentially formulates a"road map" to all the referenced documents. The evaluation does provide the current information on grout formulations, lessons learned at other DOE Sites, and any pertinent information relative to imnobilization technology. The final Cementation/Grout Technology Evaluation report is due by 8/30/91. After the final report has been delivered, I will edit and format the formal report so it can be issued internally. v E-32 RECEIVED MAY 0 6 1991 E.P. MERSELa
OAK R1DGE NATIONAL LABORATORY OPERATED EY MARTIN MARIETTA ENERGY SYSTEMS, INC. FOR THE U.S. DEPARTMENT OF ENERGY Mr. L. A. Fort Westinghouse Hanford Company P.O. Box 1970, R2-37 Richland, Washington 99352 Dear Les: WHC-SD-W100-TI-003 Rev. 0 POST OFFICE BOX 2008 OAK RIDGE. TENNESSEE 37831 April 29. 1991 Milestone Letter Report: Cement Grout Technology Evaluation Report due May 1991 Enclosed is a clean copy of the above milestone titled. "Survey of Grouting Technology in Support of WRAP'S Shred-Grout Module." I hope the fifty or so documents that I brou,ght out to you in support of the above milestone provide you with much useful information. EWM:jml cc: O. K Tallent E-33 Best Regards. C.C1%-f r.c1.^^^^ Earl W. McDaniel, ivlanager Hanford Grout Program Chemical Technology Division
Page 1 and 2:
R 2.1 199^ ^.EN GINEERING DATA TRAN
Page 3 and 4:
Date Received% • I INFORMATION RE
Page 5 and 6:
. SUPPORTING DOCUMENT 1. Total Page
Page 7 and 8:
WHC-SD-W100-TI-003 Rev. 0 EXECUTIVE
Page 9 and 10:
WHC-SD-W100-TI-003 Rev. 0 been achi
Page 11 and 12:
__ _ _ MHC-SIL-yJ3,00-TI-D03 Rev. 0
Page 13 and 14:
F`= WHC-SD-W100-TI-003 Rev. 0 DESCR
Page 15 and 16:
WHC-SD-W100-TI-003 Rev. 0 LIST OF T
Page 17 and 18:
WHC-SD-W100-TI-003 Rev. 0 WASTE REC
Page 19 and 20:
WHC-SD-W100-TI-003 Rev. 0 1.2.1 Fee
Page 21 and 22:
^s. WHC-SD-W100-TI-003 Rev. 0 conta
Page 23 and 24:
__-'°'2 WHC-SD-W100-TI-003 Rev. 0
Page 25 and 26:
2.1 REGULATORY FRAMEWORK WHC-SD-W10
Page 27 and 28:
^..." ;_:.. :.^ .^.y^ WHC-SD-W100-T
Page 29 and 30:
WHC-SD-W100-TI-003 Rev. 0 which the
Page 31 and 32:
kIHC-Sû-Wi"v"u-Ti-u03 Rev. V ,--,,
Page 33 and 34:
WHC-SD-W100-TI-003 Rev. 0 Type 1 wa
Page 35 and 36:
3.3 TESTING APPROACH WHC-SD-W100-TI
Page 37 and 38:
^.: fi WNC-SD-W100-TI-003 Rev. 0 Fi
Page 39 and 40:
4.1 SCREENING TEST RESULTS WHC-SD-W
Page 41 and 42:
,^. ----- -- WHC-SD-W100-TI-003 Rev
Page 43 and 44:
WHC-SD-W100-TI-003 Rev. 0 4.1.3 The
Page 45 and 46:
p Sam le Compressive Radiation stre
Page 47 and 48:
WHC-SD-W100-TI-003 Rev. 0 Table 4-3
Page 49 and 50:
..., TESTING RESULTS .^.CSSD-W-1OO-
Page 51 and 52:
A I w ^^',; ^^ ;J ?1Fasf^.}: "q -?
Page 53 and 54:
;..;: .^:. WHC-SD-W100-TI-003 Rev.
Page 55 and 56:
--- ....ti s..` WHC-SD-WI00-TI-003
Page 57 and 58:
1.0 INTRODUCTION WHC-SD-W100-TI-003
Page 59 and 60:
WHC-SD-W100-TI-003 Rev. 0 Waste For
Page 61 and 62:
^-: -- ^ Component Waste Type 1 LET
Page 63 and 64:
.^x. --1vHC-SD iii00- T i-003 Rev.
Page 65 and 66:
WHC-SD-W: JV-TI-VVJ ^cv. v APPENDIX
Page 67 and 68:
,..^ c:-- z ,.E ^=t ^^ln^l WHC-SD-W
Page 69 and 70:
Scope WHC-SD-W100-TI-003 Rev. 0 Sup
Page 71 and 72:
00 V F-' Activity and Miltstone Cha
Page 73 and 74:
WHC-SD-W100-TI-003 Rev. 0 Laborator
Page 75 and 76:
WHC-SD-WIOO-TI-003 Rev. 0 APPENDIX
Page 77 and 78:
16490 Chiaccothe Itoad Chagrin Fall
Page 79 and 80:
ca-. tY•^_E Q . - - StoGkE4uip+!n
Page 81 and 82:
^.. WHC-SD-W100-TI-003 Rev. 0 . , I
Page 83 and 84:
Waste Type: WHC-SD-W100-TI-003 Rev.
Page 85 and 86:
Stock E quipment Company A Unit of
Page 87 and 88:
G' ,.,. d,_ s WHC-0-W100-TI-003 Rev
Page 89 and 90:
Cx U: r°... .• , .ti Waste Type:
Page 91 and 92:
-. LeachantSolution: Specimen Diame
Page 93 and 94:
c^1, WHC-SD-W100-TI-003 Rev. 0 THER
Page 95 and 96:
..... lry" - Stock E a uipment Comp
Page 97 and 98:
;=. .:^;. WHC-SD-W100-TI-003 Rev< 0
Page 99 and 100:
(.7 ..^^ -„n f^. [Y^. Waste Type:
Page 101 and 102:
Date: _ Leachability Time Point Lea
Page 103 and 104:
23 Ninety ( 90) Day Immersion Test
Page 105 and 106:
ty ,.. ='`F r...,, b Ly.. Specimen
Page 107 and 108:
25 BIODEGRADATION TEST PROCEDURE St
Page 109 and 110:
Date: WHC-SD-W100-TI-003 Rev. 0 BIO
Page 111 and 112:
^_... ..^^ C:i1 Date: WHC-SD-W100-T
Page 113 and 114:
Date: WHC-SD-W100-TI-003 Rev. 0 --
Page 115 and 116:
f-^ -- WHC-SD-W100-TI-003 Rev. 0 2.
Page 117 and 118:
^-..., 3•0 ASSAY FOR MEI'ALS 3.1
Page 119 and 120:
t..f f....,.. P....^ .-- ^ : .^ ^-.
Page 121 and 122:
^c. v 3 0 w.3 cn a v t[ACeRUtIIY IO
Page 123 and 124:
WHC-SD-W100-TI-003 Rev. 0 APPENDIX
Page 125 and 126:
WHC-SD-W100-TI-003 Rev. 0 STOCK EQU
Page 127 and 128:
19 SCOPE AND APPLICATION WHC-SD-W10
Page 129 and 130:
L:^3 ll Q. 4 AA :'ILTEP.S WHC-0-W10
Page 131 and 132:
4_T tJrD o,...Ys j ^,.,. WHC-SD-W10
Page 133 and 134:
WHC-SD-W100-TI-003 Rev. 0 -, Proced
Page 135 and 136:
WHC-SD-W100-TI-003 Rev. 0 Procedure
Page 137 and 138:
(FM WHC-SD-W100-TI-003 Rev. 0 Proce
Page 139 and 140:
C... 6 Wet Waste Sample Contains no
Page 141 and 142:
^..., . ,.y^ h:.r WHC-SD-WI00-Ti-00
Page 143 and 144:
:. WHC-SD-W100-TI-003 Rev. 0 TA3i.E
Page 145 and 146:
^' . WHC-SD-W100-T1-003 Rev. 0 TABL
Page 147 and 148:
^- ^-> ^ C^Jl I I^t ^.: l WHC-St]-W
Page 149 and 150:
c. 03 00 r=3 ^t C^' II 6.0 II Calib
Page 151 and 152:
LY; ^ C=l . ^.^ .^,..,, €:^. MHC-
Page 153 and 154:
R: C=1 rIj s^ ^ ^.. WHC-SD-YlI00-TI
Page 155 and 156:
.,,_..1 ---^ - - i-•_E ?*^^ Mater
Page 157 and 158:
WHC-SD-W100-TI-003 Rev. 0 Dow Chemi
Page 159 and 160:
^ ±.£:a [7.p -;^ --- --------- WH
Page 161 and 162:
WHC-S®-hi1.00-T'.-00?, Rev. Dow Ch
Page 163 and 164:
t;7_7 ,...:: ----------- WHC-SD-W10
Page 165 and 166:
WHC-SD-W100-TI-003 Rev. 0 Daw M.. u
Page 167 and 168:
^ ^..rYfl VF •UIYb 1 1 AGA GllS.
Page 169 and 170:
Page 171 and 172:
CHARACTERIZATION DATA Part A: Overv
Page 173 and 174:
Grit Specie or MaterialOverall Cont
Page 175 and 176:
WHC-SD-W100-TI-003 Rev. 0 The incin
Page 177 and 178:
WHC-SD-W100-TI-003 Rev. 0 183-H BAS
Page 179 and 180:
WHC-SD-W100-TI-003 Rev. 0 June - Se
Page 181 and 182:
WHC-SD-W100-TI-003 Rev. 0 BASINS 3
Page 183 and 184:
WHC-SD-W100-TI-003 Rev. 0 BASINS 3
Page 185 and 186:
^- WHC-SD-W100-TI-003 Rev. 0 BASIN
Page 187 and 188:
WHC-SD-W100-TI-003 Rev. 0 ---------
Page 189 and 190:
J. L. Westcott Page 3 June 1, 1992
Page 191 and 192:
u...^^, WHC-SD-W100-TI-003 Rev. 0 I
Page 193 and 194:
•N`^C-Sf1-"d100-71-003 Rev. 0 ,S'
Page 195 and 196:
CONTAINER /NFORMATlO N: `d"-C-Sn-'w
Page 197 and 198:
ONTANVER BVFORMA SI7 E: AMOUN=i 8 G
Page 199 and 200:
LOT WRAP 2A.4 SHEET 7.XLS RECOMMEND
Page 201 and 202:
LOT WRAP 2A.5 SHEET 8.XLS RECOMMEND
Page 203 and 204:
.:•n-,,, LOT WRAP 2A.6 SHEET 9.XL
Page 205 and 206:
LOT WRAP 2A.7 SHEET 10.XLS RECOMMEN
Page 207 and 208:
PHYSICAL DESCR/PTTON: V-r-S?-W100-T
Page 209 and 210:
,.: Westinoause Harlford COMM WHC-S
Page 211 and 212: O I tA SHEETII.XLS ;, LOT WRAP2A.2
Page 213 and 214: CONTAINER /NFORMAT/ON: DOSE: SIZE:
Page 215 and 216: PU33-11-1992 09:48 FROM EDS/qRI$ir
Page 217 and 218: LOT WRAP 2A 10 Slf-EET 14.)C,S RECO
Page 219 and 220: qN i: 105N-89-1097 105N-89-1098 105
Page 221 and 222: SIZE: DOSE: 5 GAL 1 1@15 Mr 30 GAL
Page 223 and 224: WHC-SD-W100-TI-003 Rev. 0 Westtngho
Page 225 and 226: LOT WRAP A2.14 SHEET 18.XLS RECOMME
Page 227 and 228: ---- - LOT WRAP ZA.13 SHEET 17.XLS
Page 229 and 230: n .-.^..-n..^^- .. ... .dJ. ^ ShIEE
Page 231 and 232: --^ WHC-SD-W100-TI-003 Rev. 0 APPEN
Page 233 and 234: WHC-SD-W100-TI-003 Rev. 0 Westingho
Page 235 and 236: Table 1 Candidate Waste Forms Absor
Page 237 and 238: --- -Aauaspt and Pe-liroset WHC-SD-
Page 239 and 240: - '^ - qev. r' Literature Search WR
Page 241 and 242: Dow Polymer WHC-SD-W100-TI-003 Rev.
Page 243 and 244: L im e Literature Search WRAP 2A Pa
Page 245 and 246: The report compares the 7eachabilit
Page 247 and 248: J. L. Westcott Page 2 May 29, 1992
Page 249 and 250: Package #1: Package #2: WHC-SD-W100
Page 251 and 252: WHC-SD-W100-TI-003 Rev. 0 SURVEY OF
Page 253 and 254: f ..;' WHC-SD-W100-TI-003 Rev. 0 A
Page 257 and 258: WHC-SD-W100-TI-003 Rev. 0 commercia
Page 259 and 260: WHC-SD-W100-TI-003 Revo 0 Bibliogra
Page 261: WHC-SD-W100-TI-003 Rev. 0 A. P. Tos
Page 267 and 268: WHC-SD-W100-TI-003 Rev. 0 commercia
Page 269 and 270: WHC-SD-W100-TI-003 Revo 0 A report
Page 271 and 272: WHC-SD-W100-TI-003 Rev. 0 impermeab
Page 273 and 274: WHC-SD-W100-TI-003 Rev. 0 reprocess
Page 275 and 276: WHC-SD-W100-TI-003 Rev. 0 STR?.THGI
Page 277 and 278: Contained under four reports: WHC-S
Page 279 and 280: ^.yo F-SD-W"00-7-003 Rev. 0 THERMOS
Page 281 and 282: WHC-SD-W100-TI-003 Rev. 0 The techn
Page 283 and 284: loomi^^lC& 111111111111F .^^.\ West
Page 285 and 286: û9^c ?fi. ...^ .._-, WHC-SD-W100-T
Page 287 and 288: Stock Equipment Company WHC-SD-WI00
Page 289 and 290: ^ i w STOCK EOUIPMENT COMPANY 14-OC
Page 291 and 292: \. . 1 .: lh,lf^ LEACH / IMMERSIONI
Page 293 and 294: ^;- v.4'? Sampls ID L781 Elsment CO
Page 295 and 296: 4.a
Page 297 and 298: Sanp)a ID L781 Elamant STRONTIUM Ma
Page 299 and 300: .^ "-; SampI81D L3B2 Z e"- ^.;;. Sa
Page 301 and 302: Sample 10 L3B1 Elsmant CESIUM Matri
Page 303 and 304: Sample ID W B1 Elemant STRONIIUM Ma
Page 305 and 306: Westinghouse Hanford Company 2355 S
Page 307 and 308: --- - ftCR-e4Uip1P1eFf Company WHC-
Page 309 and 310: WHC-SD-W100-TI-003 Rev. 0 Russ Czel
Page 311 and 312: Stock Equipment Company 3:0 -SCFIED
Page 313 and 314:
THERMAL CYCLING SAMPLES BEFORE THE
Page 315 and 316:
BIODEGRADATION SAMPLES BEFORE THE S
Page 317 and 318:
C/ 0D OC M1 0, ^yII i..) d tl ^ a I
Page 319 and 320:
T 1 A w ^ • $ ^py yf ; pp V ^ py
Page 321 and 322:
T 1 A ^ !^^ + ^ i •^^w^:rwwwwrpR^
Page 323 and 324:
'i A v lf^. j^^ u e e - - I I I a i
Page 325 and 326:
0 > d C.) O O F- 0 0 3 G NI U 3 ^ c
Page 327 and 328:
en a-. p g aQ i ^ rr it - l r rF e^
Page 329 and 330:
' iO`F*'P\^ Westinghouse Hanford Co
Page 331 and 332:
Stock Equipment Company 1.0 SUMMARY
Page 333 and 334:
Stock Equipment Company WHC-SD-W100
Page 335 and 336:
2a0 SCHEDULE Activitv - Prepare Wor
Page 337 and 338:
T 1 o+ THERMAL CYCLWG SAMPLES BEFOR
Page 339 and 340:
T 1 OI 80 70 U 60 VJ w 50 w 0 40 30
Page 341 and 342:
^ °' cn l .:. U CD w a: w r' i ^ I
Page 343 and 344:
SAMPLE ID Li-117 L1-118 L1-19 L3-17
Page 345 and 346:
T °,w ^ - : C s 0 n a ^^ s ^ i ^-
Page 347 and 348:
71 I V y,,} ^ • 5il i ^ ^^ ^ ^ ^
Page 349 and 350:
0 a^ on O O M F- 1OCD 3 1 G N^ U il
Page 351 and 352:
O > W C f.) O O 1-- ^ O HI 6./ 3 ^
Page 353 and 354:
0 > ar oe M 0 c C3, I O c V 3 Î d
Page 355 and 356:
TI V 40 IN s i s : s ^l l i " p p l
Page 357 and 358:
Page 359 and 360:
WHC-SD-W100-TI-003 Rev. 0 _QVrDvrru
Page 361 and 362:
^-_- .,:... WHC-SD-W100-TI-003 Rev.
Page 363 and 364:
Ceramics and glass WHC-SD-W200-TI-0
Page 365 and 366:
,. ., Extruder/melter WHC-SD-W100-T
show all

View Document Here - Hanford Site

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?