1935 Cadillac - GM Heritage Center

More documents

Recommendations

Info

69 CLUTCH Specifications Subject and Remarks LaSalle Cadillac 350 355-D 370-D 452-D Clearance between— Driving plates and driving pins New limits .001-.0025" Worn limit, not over .008" .001-.0025" .008" .001-.0025" .008" Hub and splines on clutch connection shaft New limits .0005-.002" .0005-.002" .0005-002" .0005-.002" .005" .005" .005" .005" Release bearing sleeve and extension on transmission bearing cap .001-.004" .001-.004" .001-.004" Worn limit, not over .006" .006" .006" H-H' x-w H-Vs" Disc facings— Area—total in square inches 94.25 150.8 205..6 247.6 Diameter inside W 6½" 5¾" 6½" 9¾" 9½" 10" 11" Number used 2 4 4 4 .130- 136" .120- 130" .120-.130" .135-145" Woven Woven Woven Woven Driven disc with facings— Number used 1 2 2 2 Thickness— .350" .295" .285" .335" .275" .220" .210" .260" Driving plates, number of 1 3 3 3 Pedal (clutch) free play ! .. .. 1K-1H" Pressure springs— Color Free length—minimum Compression pressure, compressed to 1 ^ in Release bearing— Thickness, new limit Worn limit, not under 9 12 12 12 Tan 127-1¾ lbs. ,¾" 9 if 6 Spring, retracting for clutch pedal— Tension in pounds- Stretched to 16¾ in. between loops Stretched to 10¾ in. between loops 9H" 25 6¼" 5½" 5½" 28 32 32 Plate Plate Plate Plate
70 COOLING SYSTEM Turn down and refill with water pump grease every 1,000 miles. Lubricate with water pomp grease every 1,000 miles. Bushings locking Pin ^Locking Ring >• Packings Fig. 1 Sectional View of Cadillac 355-D Water Pump Fig. 2 Sectional View of Water Pump- Cadillac 370-D and 452-D Support Locking Key 1/32 iri. loosen clamp screws before adjusting drive chain. Cadillac 370-D Water- Pump Drive. Typical of 452-D Fibre disc couplings should have at least 1/32 in. total play or clearance endwise between discs and driving' Ranges. Water pump should be lined up to give equal clearance ai all points between fibre discs and driving flange. Fig. 4 Water Pump Mounting— Cadi/lac 355-D Id locking pin out while turning pump gland nut. Plate 21. Water Pump Details and Drive Adjustments—Cadillac
Page 1 and 2:
, -•.•»c;5v ^¾¾¾' 37CWD AND
Page 3 and 4:
CONTENTS Front Wheel Suspension 3 R
Page 5 and 6:
4 Cadillac 355-D, 370-D and 452-D I
Page 7 and 8:
6 Cadillac 355-D, 370-D and 452-D R
Page 9 and 10:
8 Cadillac 355-D, 370-D and 452-D o
Page 11 and 12:
10 Cadillac 355-D, 370-D and 452-D
Page 13 and 14:
Page 15 and 16:
Page 17 and 18:
Page 19 and 20:
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
REAR LAMP 3CP.S.C..N063 I5CPSC.N087
Page 27 and 28:
Page 29 and 30:
Page 31 and 32:
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
Page 39 and 40:
1. Extreme Pressure Lubricants for
Page 41 and 42:
LUBRICATION Lubrication Schedule Ca
Page 43 and 44:
CADILLAC V-8 SRIES 10 AND 20 ENGINE
Page 45 and 46:
F E A T U R E S O F C O N S T R U C
Page 47 and 48:
F E A T U R E S O F C O N S T R U C
Page 49:
CADILLAC V-8 5-PASSENGER TOWN c.F'n
Page 52 and 53:
Jt.- v4 *•} CADILLAC OPERATOR'S M
Page 54 and 55:
CHAPTER I—Cadillac Service Table
Page 56 and 57:
The car owner's first and most freq
Page 58 and 59:
Agreement provides, for a period of
Page 60 and 61:
someone not familiar with Cadillac
Page 62 and 63:
the oil is consumed many times as r
Page 64 and 65:
portion of gasoline and air getting
Page 66 and 67:
in control. Blind curves, hills, ro
Page 68 and 69:
losses. Any solution lost mechanica
Page 70 and 71:
Use of Starter If the engine does n
Page 72 and 73:
ward either side to throw the light
Page 74 and 75:
Spare Wheel Carrier Three tvpes of
Page 76 and 77:
Cooling System The radiator filler
Page 78 and 79:
otates the discs slightly every tim
Page 80 and 81:
from the left headlamp should have
Page 82 and 83:
CHAPTER VII SPECIFICATIONS AND LICE
Page 84:
L Lamp bulbs 49 License data 56 Lig
Page 87 and 88:
IMPORTANT Beginning with' the "D" s
Page 89 and 90:
4 CONTENTS Front Wheel Suspension S
Page 91 and 92:
6 CONTENTS Lubrication Page Service
Page 93 and 94:
8 FRONT WHEEL SUSPENSION SYSTEM Fro
Page 95 and 96:
10 FRONT WHEEL SUSPENSION SYSTEM an
Page 97 and 98:
12 FRONT WHEEL SUSPENSION SYSTEM nu
Page 99 and 100:
14 FRONT WHEEL SUSPENSION SYSTEM C/
Page 101 and 102:
16 FRONT WHEEL SUSPENSION SYSTEM Tr
Page 103 and 104:
18 FRONT WHEEL SUSPENSION SYSTEM F
Page 105 and 106: 20 CAMBER Camber is the outward til
Page 107 and 108: 22 FRONT WHEEL SUSPENSION SYSTEM Di
Page 109 and 110: 24 FRONT WHEEL SUSPENSION SYSTEM Di
Page 111 and 112: 26 REAR AXLE | Universal Joint flan
Page 113 and 114: 28 REAR AXLE •• Bearing Retaine
Page 115 and 116: 30 REAR AXLE Pitch Line Pitch Line
Page 117 and 118: 32 REAR AXLE of the pinion gear tee
Page 119 and 120: 34 BODY Body Types and Style Number
Page 121 and 122: 1935 LA SALLE BODY DE1ENSIONS cd p.
Page 123 and 124: 36 BODY car through the remote cont
Page 125 and 126: 38 BODY oughly and then cleaning it
Page 127 and 128: 40 BODY ment, and cylinder can be e
Page 129 and 130: 42 BODY Fig. 8 Body showing Front E
Page 131 and 132: 44 BODY Lock Board Remove damaged v
Page 133 and 134: 46 BODY Spring Bronze Bushings. rig
Page 135 and 136: 48 BRAKES General Description The C
Page 137: When relining brakes, back off cam
Page 140 and 141: 53 BRAKES Adjust nut to eliminate b
Page 142 and 143: 55 BRAKES drum may prevent proper a
Page 144 and 145: 57 BRAKES Filler and Breather Plug
Page 146 and 147: 59 brake backing plate is to be rem
Page 148 and 149: 61 1 BRAKES Diagnosis Chart Effect
Page 150 and 151: 63 CLUTCH General Description Both
Page 152 and 153: 65 CLUTCH Spacers should be install
Page 154 and 155: 67 CLUTCH Service Information 1. Ca
Page 158 and 159: 71 COOLING SYSTEM General Descripti
Page 160 and 161: 73 COOLING SYSTEM Service Informati
Page 162 and 163: 75 COOLING SYSTEM Second-type therm
Page 164 and 165: 77 COOLING SYSTEM Fig. 18 Remove th
Page 166 and 167: 79 COOLING SYSTEM Specifications Su
Page 168 and 169: 81 ELECTRICAL SYSTEM General Descri
Page 170 and 171: 83 of the contact arm for the No. ]
Page 172 and 173: 85 ELECTRICAL SYSTEM generator curr
Page 174 and 175: 87 ELECTRICAL SYSTEM Batteries in c
Page 176 and 177: 89 ELECTRICAL SYSTEM This lift may
Page 178 and 179: 91 ELECTRICAL SYSTEM Projector and
Page 180 and 181: 93 ELECTRICAL SYSTEM To test for a
Page 182 and 183: ELECTRICAL SYSTEM Specifications Su
Page 184 and 185: 97 ENGINE General Description The c
Page 186 and 187: 99 ENGINE The vacuum pump used on a
Page 188 and 189: 101 ENGINE 5. Worn Limits for Cylin
Page 190 and 191: 103 ENGINE through the connecting r
Page 192 and 193: 105 practicable. Burning the carbon
Page 194 and 195: ENGINE 107 been cut in the frame si
Page 196 and 197: 109 ENGINE Spring Idler Sprocket Ra
Page 198 and 199: ENGINE Plate 43. Oiling System—Ca
Page 200 and 201: ENGINE 113
Page 202 and 203: 115 ENGINE Specifications Subject a
Page 204 and 205: 117 ENGINE Specifications Valve Mec
Page 206 and 207:
119 EXHAUST SYSTEM General Descript
Page 208 and 209:
121 FENDERS—FRAME Fig. 3. LaSalle
Page 210 and 211:
123 FRAME Fie 2 The X-member of the
Page 212 and 213:
125 GASOLINE SYSTEM General Descrip
Page 214 and 215:
127 GASOLINE SYSTEM period than is
Page 216 and 217:
129 GASOLINE SYSTEM during the warm
Page 218 and 219:
131 GASOLINE SYSTEM This filler has
Page 220 and 221:
133 GASOLINE SYSTEM right-hand thro
Page 222 and 223:
135 GASOLINE SYSTEM point, addition
Page 224 and 225:
137 HOOD These hood rest brackets m
Page 226 and 227:
139 LIGHTING SYSTEM Fig. 4. Multibe
Page 228 and 229:
141 LIGHTING SYSTEM likewise have t
Page 230 and 231:
143 LUBRICATION Service Information
Page 232 and 233:
145 LUBRICATION—SPRINGS AND SHOCK
Page 234 and 235:
147 SPRINGS AND SHOCK ABSORBERS mus
Page 236 and 237:
149 SPRINGS AND SHOCK ABSORBERS the
Page 238 and 239:
151 SPRINGS AND SHOCK ABSORBERS Spe
Page 240 and 241:
153 STEERING GEAR General Descripti
Page 242 and 243:
155 Plate 53) is at the top the sam
Page 244:
157 Two types of Synchro-mesh trans
Page 247 and 248:
160 TRANSMISSION Synchronising Yoke
Page 249 and 250:
162 TRANSMISSION Second-speei Adjus
Page 251 and 252:
TRANSMISSION Remove these nuts to d
Page 253 and 254:
166 TRANSMISSION ilHillii Main Shaf
Page 255:
168 TRANSMISSION 9. Remove snap rin
Page 258 and 259:
172 WHEELS, RIMS AND TIRES Fig. 7.
Page 260 and 261:
174 WHEELS, RIMS AND TIRES The whee
Page 262 and 263:
176 WHEELS, RIMS AND TIRES Fig. 16
Page 264 and 265:
UPHOLSTERY CHART NO. 2 Series 35-50
Page 266:
Stylo V-16 Cadillac, Series 60 (BOD
Page 269 and 270:
COPYRIGHTED, 1936, FISHER BODY CORP
Page 271 and 272:
Fisher Body Service Manual, 1936 Pa
Page 273 and 274:
Fisher Body Service Manual, 1935 CO
Page 275 and 276:
Fisher Body Service Manual, 1935 Th
Page 277 and 278:
Fisher Body Service Manual, 1935 To
Page 279 and 280:
Fisher Body Service Manual, 1935
Page 281 and 282:
Fisher Body Service Manual, 1935 FL
Page 283 and 284:
Fisher Body Service Manual, 1935 Il
Page 285 and 286:
Page 287 and 288:
Page 289 and 290:
Fisher Body Service Manual, 1935 DO
Page 291 and 292:
Fisher Body Service Manual, 1935 GL
Page 293 and 294:
Fisher Body Service Manual, 1935 3.
Page 295 and 296:
Fisher Body Service Manual, 1935 th
Page 297 and 298:
Page 299 and 300:
Fisher Body Service Manual, 1935 RE
Page 301 and 302:
Page 303 and 304:
_ Fisher Body Service Manual, 1935
Page 305 and 306:
Page 307 and 308:
Illustration No. 114 CONDITION: Too
Page 309 and 310:
Fisher Body Service Manual, 1935 FR
Page 311 and 312:
Fisher Body Service Manual, 1935 In
Page 313 and 314:
Page 315 and 316:
Fisher Body Service Manual, 1935 CO
Page 317 and 318:
Fisher Body Service Manual, 1935 F.
Page 319 and 320:
Page 321 and 322:
Fisher Body Service Manual, 1935 If
Page 323 and 324:
Fisher Body Service Manual, 1936 19
Page 325 and 326:
Fisher Body Service Manual, 1936 AL
Page 327 and 328:
Fisher Body Service Manual, 1936 OU
Page 329 and 330:
Page 331 and 332:
Fisher Body Service Manual, 1936 19
Page 333 and 334:
Page 335 and 336:
Fisher Body Service Manual, 1936 SE
Page 337 and 338:
Fisher Body Service Manual, 1936 HO
Page 339 and 340:
Fisher Body Service Manual, 1936 LU
Page 341 and 342:
Fisher Body Service Manual, 1936 LI
Page 343 and 344:
Fisher Body Service Manual, 1936 Wi
Page 345 and 346:
Fisher Body Service Manual INDEX
show all

1935 Cadillac - GM Heritage Center

Create successful ePaper yourself

Delete template?

Save as template?