1935 Cadillac - GM Heritage Center

More documents

Recommendations

Info

87 ELECTRICAL SYSTEM Batteries in cars on display or in storage can be charged without removing the battery from the car by using any good portable charger. The charger should be connected to the storage battery or the negative terminal on the charger can be connected to the "Bat" terminal on the current regulator. If the car is to remain in storage for any considerable time, however, it is advisable to remove the battery and turn it over to the battery department for care and attention. The battery must be kept fully charged or nearly so and the proper level of the liquid must be maintained if the battery is to perform satisfactorily. Ordinarily with the car in use the generator will keep the battery charged but there is only one way to make sure and that is to test the battery at regular intervals. If the specific gravity is 1.250 or above, the battery may be safely assumed to be in satisfactory condition. If the reading is below 1.225 the battery should in every case be removed and charged. 6. Removing Storage Battery The storage batteries are mounted differently from previous models and require a different procedure for removal and installation. In all but the Series 10 and 20 Cadillac cars, the battery must be taken out from underneath the car. The battery is located under the front seat at the right-hand side of the car on Cadillac 10 and 20 Series cars and at the left-hand side on Series 50 LaSalle cars. On Series 30, 40 and 60 Cadillac cars, the battery is located under the right front fender next to the frame. See Fig. 1. Cadillac 10 and 20 Series batteries may be removed by loosening the two support bolts from the under side of the car, and lifting the battery out from above. The LaSalle 350 battery is held in a box supported by two metal straps hooked over two long carriage bolts running lengthwise of the car. The bolt holes in the left-hand side of the support bars are elongated, permitting the left-hand bolt to be moved far enough aside to clear the strap hooks. To remove the LaSalle battery, loosen the bolts, lift the battery enough to clear the left-hand bolt, then move the bolt toward the frame side bar and drop the battery and box together. The battery can be unhooked and dropped with greater ease from the driving compartment. To remove the battery from Cadillac 30, 40 and 60 Series cars, first remove the dust cover by removing the nuts from the outer side of the box. Next remove the two cap screws holding the battery box straps to the frame; then lift the battery enough to unhook it from the frame, move it toward the outside of the car enough to clear the frame, and lower the battery. Because Fig. 17. Construction of battery lift which may be made up in any service station. The platform should be of sufficient size to accommodate the V-16 battery, about 7½ in. by 15 in., with sides just high enough to prevent the battery from slipping off of the necessity of working from beneath the car, two men are required to remove and install the battery on these cars. A lift may be made at slight expense which makes it possible for one man to remove and install the battery on Series 30, 40 and 60 cars. The lift, shown in Fig. 17, consists of a jack with a platform for the battery mounted on an underslung base plate equipped with casters. The platform should be of sufficient size to hold the V-16 battery, about 7½ in. x 15 in., with sides just high enough to prevent the battery from slipping off. The base plate should be of approximately the same size as the platform to keep the lift from becoming top heavy, and should be underslung to provide maximum clearance. The standard Cadillac jack with a short crank may be used for the lift. Fig. 18. The battery on the lift may be rolled in or out with the front wheels cramped
oo »—» & rt (v W p TO O SO a SO o w or en i 0 3 OP s 3 o > r CO 3 SO TO SO REAR LAMP 3CPS.C.NQ63 aCPSC..NQS7 BULBS BATTERY
Page 1 and 2:
, -•.•»c;5v ^¾¾¾' 37CWD AND
Page 3 and 4:
CONTENTS Front Wheel Suspension 3 R
Page 5 and 6:
4 Cadillac 355-D, 370-D and 452-D I
Page 7 and 8:
6 Cadillac 355-D, 370-D and 452-D R
Page 9 and 10:
8 Cadillac 355-D, 370-D and 452-D o
Page 11 and 12:
10 Cadillac 355-D, 370-D and 452-D
Page 13 and 14:
Page 15 and 16:
Page 17 and 18:
Page 19 and 20:
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
REAR LAMP 3CP.S.C..N063 I5CPSC.N087
Page 27 and 28:
Page 29 and 30:
Page 31 and 32:
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
Page 39 and 40:
1. Extreme Pressure Lubricants for
Page 41 and 42:
LUBRICATION Lubrication Schedule Ca
Page 43 and 44:
CADILLAC V-8 SRIES 10 AND 20 ENGINE
Page 45 and 46:
F E A T U R E S O F C O N S T R U C
Page 47 and 48:
F E A T U R E S O F C O N S T R U C
Page 49:
CADILLAC V-8 5-PASSENGER TOWN c.F'n
Page 52 and 53:
Jt.- v4 *•} CADILLAC OPERATOR'S M
Page 54 and 55:
CHAPTER I—Cadillac Service Table
Page 56 and 57:
The car owner's first and most freq
Page 58 and 59:
Agreement provides, for a period of
Page 60 and 61:
someone not familiar with Cadillac
Page 62 and 63:
the oil is consumed many times as r
Page 64 and 65:
portion of gasoline and air getting
Page 66 and 67:
in control. Blind curves, hills, ro
Page 68 and 69:
losses. Any solution lost mechanica
Page 70 and 71:
Use of Starter If the engine does n
Page 72 and 73:
ward either side to throw the light
Page 74 and 75:
Spare Wheel Carrier Three tvpes of
Page 76 and 77:
Cooling System The radiator filler
Page 78 and 79:
otates the discs slightly every tim
Page 80 and 81:
from the left headlamp should have
Page 82 and 83:
CHAPTER VII SPECIFICATIONS AND LICE
Page 84:
L Lamp bulbs 49 License data 56 Lig
Page 87 and 88:
IMPORTANT Beginning with' the "D" s
Page 89 and 90:
4 CONTENTS Front Wheel Suspension S
Page 91 and 92:
6 CONTENTS Lubrication Page Service
Page 93 and 94:
8 FRONT WHEEL SUSPENSION SYSTEM Fro
Page 95 and 96:
10 FRONT WHEEL SUSPENSION SYSTEM an
Page 97 and 98:
12 FRONT WHEEL SUSPENSION SYSTEM nu
Page 99 and 100:
14 FRONT WHEEL SUSPENSION SYSTEM C/
Page 101 and 102:
16 FRONT WHEEL SUSPENSION SYSTEM Tr
Page 103 and 104:
18 FRONT WHEEL SUSPENSION SYSTEM F
Page 105 and 106:
20 CAMBER Camber is the outward til
Page 107 and 108:
22 FRONT WHEEL SUSPENSION SYSTEM Di
Page 109 and 110:
24 FRONT WHEEL SUSPENSION SYSTEM Di
Page 111 and 112:
26 REAR AXLE | Universal Joint flan
Page 113 and 114:
28 REAR AXLE •• Bearing Retaine
Page 115 and 116:
30 REAR AXLE Pitch Line Pitch Line
Page 117 and 118:
32 REAR AXLE of the pinion gear tee
Page 119 and 120:
34 BODY Body Types and Style Number
Page 121 and 122:
1935 LA SALLE BODY DE1ENSIONS cd p.
Page 123 and 124: 36 BODY car through the remote cont
Page 125 and 126: 38 BODY oughly and then cleaning it
Page 127 and 128: 40 BODY ment, and cylinder can be e
Page 129 and 130: 42 BODY Fig. 8 Body showing Front E
Page 131 and 132: 44 BODY Lock Board Remove damaged v
Page 133 and 134: 46 BODY Spring Bronze Bushings. rig
Page 135 and 136: 48 BRAKES General Description The C
Page 137: When relining brakes, back off cam
Page 140 and 141: 53 BRAKES Adjust nut to eliminate b
Page 142 and 143: 55 BRAKES drum may prevent proper a
Page 144 and 145: 57 BRAKES Filler and Breather Plug
Page 146 and 147: 59 brake backing plate is to be rem
Page 148 and 149: 61 1 BRAKES Diagnosis Chart Effect
Page 150 and 151: 63 CLUTCH General Description Both
Page 152 and 153: 65 CLUTCH Spacers should be install
Page 154 and 155: 67 CLUTCH Service Information 1. Ca
Page 156 and 157: 69 CLUTCH Specifications Subject an
Page 158 and 159: 71 COOLING SYSTEM General Descripti
Page 160 and 161: 73 COOLING SYSTEM Service Informati
Page 162 and 163: 75 COOLING SYSTEM Second-type therm
Page 164 and 165: 77 COOLING SYSTEM Fig. 18 Remove th
Page 166 and 167: 79 COOLING SYSTEM Specifications Su
Page 168 and 169: 81 ELECTRICAL SYSTEM General Descri
Page 170 and 171: 83 of the contact arm for the No. ]
Page 172 and 173: 85 ELECTRICAL SYSTEM generator curr
Page 176 and 177: 89 ELECTRICAL SYSTEM This lift may
Page 178 and 179: 91 ELECTRICAL SYSTEM Projector and
Page 180 and 181: 93 ELECTRICAL SYSTEM To test for a
Page 182 and 183: ELECTRICAL SYSTEM Specifications Su
Page 184 and 185: 97 ENGINE General Description The c
Page 186 and 187: 99 ENGINE The vacuum pump used on a
Page 188 and 189: 101 ENGINE 5. Worn Limits for Cylin
Page 190 and 191: 103 ENGINE through the connecting r
Page 192 and 193: 105 practicable. Burning the carbon
Page 194 and 195: ENGINE 107 been cut in the frame si
Page 196 and 197: 109 ENGINE Spring Idler Sprocket Ra
Page 198 and 199: ENGINE Plate 43. Oiling System—Ca
Page 200 and 201: ENGINE 113
Page 202 and 203: 115 ENGINE Specifications Subject a
Page 204 and 205: 117 ENGINE Specifications Valve Mec
Page 206 and 207: 119 EXHAUST SYSTEM General Descript
Page 208 and 209: 121 FENDERS—FRAME Fig. 3. LaSalle
Page 210 and 211: 123 FRAME Fie 2 The X-member of the
Page 212 and 213: 125 GASOLINE SYSTEM General Descrip
Page 214 and 215: 127 GASOLINE SYSTEM period than is
Page 216 and 217: 129 GASOLINE SYSTEM during the warm
Page 218 and 219: 131 GASOLINE SYSTEM This filler has
Page 220 and 221: 133 GASOLINE SYSTEM right-hand thro
Page 222 and 223: 135 GASOLINE SYSTEM point, addition
Page 224 and 225:
137 HOOD These hood rest brackets m
Page 226 and 227:
139 LIGHTING SYSTEM Fig. 4. Multibe
Page 228 and 229:
141 LIGHTING SYSTEM likewise have t
Page 230 and 231:
143 LUBRICATION Service Information
Page 232 and 233:
145 LUBRICATION—SPRINGS AND SHOCK
Page 234 and 235:
147 SPRINGS AND SHOCK ABSORBERS mus
Page 236 and 237:
149 SPRINGS AND SHOCK ABSORBERS the
Page 238 and 239:
151 SPRINGS AND SHOCK ABSORBERS Spe
Page 240 and 241:
153 STEERING GEAR General Descripti
Page 242 and 243:
155 Plate 53) is at the top the sam
Page 244:
157 Two types of Synchro-mesh trans
Page 247 and 248:
160 TRANSMISSION Synchronising Yoke
Page 249 and 250:
162 TRANSMISSION Second-speei Adjus
Page 251 and 252:
TRANSMISSION Remove these nuts to d
Page 253 and 254:
166 TRANSMISSION ilHillii Main Shaf
Page 255:
168 TRANSMISSION 9. Remove snap rin
Page 258 and 259:
172 WHEELS, RIMS AND TIRES Fig. 7.
Page 260 and 261:
174 WHEELS, RIMS AND TIRES The whee
Page 262 and 263:
176 WHEELS, RIMS AND TIRES Fig. 16
Page 264 and 265:
UPHOLSTERY CHART NO. 2 Series 35-50
Page 266:
Stylo V-16 Cadillac, Series 60 (BOD
Page 269 and 270:
COPYRIGHTED, 1936, FISHER BODY CORP
Page 271 and 272:
Fisher Body Service Manual, 1936 Pa
Page 273 and 274:
Fisher Body Service Manual, 1935 CO
Page 275 and 276:
Fisher Body Service Manual, 1935 Th
Page 277 and 278:
Fisher Body Service Manual, 1935 To
Page 279 and 280:
Fisher Body Service Manual, 1935
Page 281 and 282:
Fisher Body Service Manual, 1935 FL
Page 283 and 284:
Fisher Body Service Manual, 1935 Il
Page 285 and 286:
Page 287 and 288:
Page 289 and 290:
Fisher Body Service Manual, 1935 DO
Page 291 and 292:
Fisher Body Service Manual, 1935 GL
Page 293 and 294:
Fisher Body Service Manual, 1935 3.
Page 295 and 296:
Fisher Body Service Manual, 1935 th
Page 297 and 298:
Page 299 and 300:
Fisher Body Service Manual, 1935 RE
Page 301 and 302:
Page 303 and 304:
_ Fisher Body Service Manual, 1935
Page 305 and 306:
Page 307 and 308:
Illustration No. 114 CONDITION: Too
Page 309 and 310:
Fisher Body Service Manual, 1935 FR
Page 311 and 312:
Fisher Body Service Manual, 1935 In
Page 313 and 314:
Page 315 and 316:
Fisher Body Service Manual, 1935 CO
Page 317 and 318:
Fisher Body Service Manual, 1935 F.
Page 319 and 320:
Page 321 and 322:
Fisher Body Service Manual, 1935 If
Page 323 and 324:
Fisher Body Service Manual, 1936 19
Page 325 and 326:
Fisher Body Service Manual, 1936 AL
Page 327 and 328:
Fisher Body Service Manual, 1936 OU
Page 329 and 330:
Page 331 and 332:
Fisher Body Service Manual, 1936 19
Page 333 and 334:
Page 335 and 336:
Fisher Body Service Manual, 1936 SE
Page 337 and 338:
Fisher Body Service Manual, 1936 HO
Page 339 and 340:
Fisher Body Service Manual, 1936 LU
Page 341 and 342:
Fisher Body Service Manual, 1936 LI
Page 343 and 344:
Fisher Body Service Manual, 1936 Wi
Page 345 and 346:
Fisher Body Service Manual INDEX
show all

1935 Cadillac - GM Heritage Center

Create successful ePaper yourself

Delete template?

Save as template?