1935 Cadillac - GM Heritage Center

More documents

Recommendations

Info

Introduction This Shop Manual is a book of reference on the adjustment and repair of Cadillac and La Salle motor cars. It is intended for the use of service men who are already familiar with automobile construction and repairing in general. At the beginning of each group is a brief description accompanied by service information in the form of notes. Following this is a specification table giving clearances, dimensions and other facts important to service men. One class of information in the specification tables consists of limits for the clearance between parts subject to wear. The "New limits" are those to be observed when installing new parts. 'The "Worn limits" are those beyond which it is inadvisable to continue to use the worn parts if quietness of operation and maximum performance are to be expected. The remaining information is in picture form. The illustrated pages are laid out to show as far as possible in picture form the repair operations, together with the differences and similarities of the various car units. Unless otherwise specified all illustrations apply to both the Cadillac and the LaSalle. Identification Numbers Each Cadillac and La Salle car when shipped carries an engine number which is also a car serial number. This is the number to be used in filling out license and insurance applications and in general reference to the car. On Cadillac 355-D cars, this engine number is stamped on a boss on the crankcase near the water inlet on the right-hand side. The Cadillac 370-D and 452-D have the engine number stamped on the upper surface of the generator drive chain housing on the right hand side of the engine. The La Salle engine number is stamped on the top edge of the cylinder block opposite the No. 1 cylinder on the left hand side of the engine. The various units such as the engine, transmission, etc., also carry unit assembly numbers. These are located as described in the specification tables. It is important when ordering parts to give, not only the engine number of the car, but also the unit assembly number of the unit to which the part belongs. The style numbers stamped on the body name plate under the hood on the right side of the shroud are useful in identifying the series numbers and wheelbases of 355-D cars which in some cases may be so similar in general appearance as to cause confusion. The style numbers for the various series numbers and wheelbases of 3 5 5-D cars are arranged as follows: Series No. Wheel Base Style Numbers 10 128' 34-701 to 34-750 20 136' 34-651 to 34-700 30 146' Fleetwood The Series 30 cars, of course, are all Fleetwood body styles, identified by the name plate on the lower right front corner of the body. Our Service Department invites correspondence with Service Managers and Shop Foremen on all matters discussed in the Shop Manual. CADILLAC MOTOR CAR COMPANY Detroit, Michigan
4 CONTENTS Front Wheel Suspension System Page General Description 7 Service Information— Front Wheel Alignment (Note 5)... 12, 13, 15, 17, 20, 21 Removal and Installation of Intermediate Steering Arm (Note 3) 9, 10 Removal and Installation of. Steering Knuckle Support (Note 4) 10, 11, 12 Straightening Bent Parts (Note 1) 7 Stop Screw Adjustment (Note 2) 7,9 Front Wheel Alignment Diagnosis Chart.21, 22, 23, 24, 25 Specifications 25 Plate 1. Front Wheel Suspension System 8 Plate 2. Alignment of Front Wheels and Suspension Parts (Part 1) 14 Plate 3. Alignment of Front Wheel Suspension and Steering System Parts (Part 2) 16 Plate 4. Alignment of Front Wheel Suspension and Steering System Parts (Part 3) 18 Plate 5. Alignment of Front Wheel Suspension and Steering System Parts (Part 4) 19 Rear Axle General Description 27 Service Information— Differential Carrier Installation on Cadillac 452-D Cars (Note 1) 27 Removal and Installation of Axle Shaft on La Salle Cars (Note 2) 27, 28 Removal and Installation of Universal Joints (Note 3).28 Replacement and Adjustment of Rear Axle Ring Gear and Drive Pinion (Note 4) 28, 29, 31, 32, 33 Specifications 33 Plate 6. Rear Axle Details and Alignment 26 Plate 7. Details of Rear Axle Gear Adjustment 30 Body General Description 35, 36 Service Information— Care of Top Coverings (Note 2) 37 Cleaning Car Upholstery (Note 5) 37, 38 Cleaning Chromium-Plated Parts (Note 6) 38 Cleaning Door Drain Holes (Note 27) 47 Cleaning Khaki Top Materials (Note 3) 37 Correcting Sticking Front Doors on Fleetwood Bodies (Note 19) 47 Correcting Sticking Lock Bolts (Note 18) 46, 47 Door Garnish Moulding Fastenings on All-Weather Phaeton and Convertible Coupes (Note 7) 38 Installing Colored Tops (Note 4) 37 Installing Rubber Bumpers for Doors (Note 20) 47 Insulating Against Heat in La Salle Front and Rear Compartments (Note 1) 37 Position of Door Handles (Note 12) 41, 43 Removing Door Finishing Pane) (Note 11) 41 Removing Ventilator Control Handle (Note 10) 41 Replacing Door Ventilators (Note 14) 43 Replacing Rear Quarter Window Ventilator (Note 15) 43 Replacing Ventilator Assembly (Note 13) 43 Replacing Ventilator Glass (Note 9) 40, 41 Replacing Window Glass (Note 16) 45 Replacing Windshield Glass (Note 17) 45, 46 Servicing Locks (Note 8) 38, 39, 40 Body Types and Style Numbers 34 Plate 8." Body and Front Door Details—Cadillac. Typical of La Salle 42 Plate 9. Rear Door and Rear Quarter Window Details-— Cadillac. Typical of La Salle 44 Plate 10. Door Details 46 Brakes Page General Description 48, 49 Service Information— Bleeding the LaSalle Brake System (Note 5) 55, 58 Brake Assister Service (Note 1). . 49 Correcting Squeaking Brakes on Cadillac Cars (Note 9) 59 Installation of Brake Lining to Avoid Squeaking Brakes (Note 3) 55 LaSalle Brake Adjustment (Note 4) 55 Lubricating Brake Dust Shield on LaSalle Cars (Note 8) 59 Regrinding Brake Drums (Note 2) 49, 55 Removal and Disassembly of LaSalle Brake Unit in Wheel (Note 7) 58, 59 Replacement of LaSalle Brake Shoe Assemblies (Note 6) 58 LaSalle Brake Diagnosis Chart 60, 61 Specifications 62 Plate 11. (Fig. 2) Brake Connections and Adjustments —Cadillac 50 Plate 12. Brake Details and Adjustments—Cadillac... . 51 Plate 13. (Fig. 7) Diagrams Showing Operation of Vacuum Brake Assister—Cadillac 52 > Plate 14. Brake Assister Adjustments—Cadillac 53 Plate 15. (Fig. 13) Brake Connections and Adjustments—LaSalle 54 Plate 16. Master Cylinder and Brake Connections— LaSalle 56 Plate 17. Brake Cvlinders and Wheel Assembly— LaSalle " 57 Clutch General Description 63 Service Information— Cadillac Clutch Balance (Note 1) ..67 Clutch Control Adjustments (Note 3) 68 Lubrication of LaSalle Clutch Release Bearing (Note 5) 68 Removal of Locking Pins When Installing LaSalle Clutch (Note 4) 68 Removal of Transmission (Note 6) .68 Servicing the LaSalle Clutch (Note 2) 67, 68 Specifications. .: 69 Plate 18. Clutch Details—Cadillac 64 Plate 19. Driven Disc Details—Cadillac 65 Plate 20. Clutch Details—LaSalle 66 Cooling System General Description 71 Service Information— Adding Liquid to Cooling System (Note 3) 73 Disassembling LaSalle Water Pump (Note 6) 75 Flushing Cooling System (Note 1) 73 Installing Retainer in Water Outlet Connection (Note 7) 75 Removal and Installation of Cadillac Radiator Casing (Typical of LaSalle) (Note 10) 76, 77, 78 Removing Radiator Core (Note 9) 75, 76 Servicing Cadillac Radiator Thermostat (Note 4). . 73, 75 Stopping Water Leaks Around LaSalle Cylinder Head Screws (Note 8) 75 Tightening Water Pump Packing (Note 5) 75 Using Soluble Oil in Cooling System (Note 2) 73 Specifications 79, 80 Plate 21. Water Pump Details and Drive Adjustments Cadillac 70 Plate 22. Cooling System Details Cadillac. Radiator Mounting Typical of LaSalle 72 Plate 23. Cooling System Details—LaSalle 74 Plate 24. Removal of Radiator Casing—Part 1 76 Plate 25. Removal of Radiator Casing—Part 2 77 Plate 26. Installation of Radiator Casing 78
Page 1 and 2:
, -•.•»c;5v ^¾¾¾' 37CWD AND
Page 3 and 4:
CONTENTS Front Wheel Suspension 3 R
Page 5 and 6:
4 Cadillac 355-D, 370-D and 452-D I
Page 7 and 8:
6 Cadillac 355-D, 370-D and 452-D R
Page 9 and 10:
8 Cadillac 355-D, 370-D and 452-D o
Page 11 and 12:
10 Cadillac 355-D, 370-D and 452-D
Page 13 and 14:
Page 15 and 16:
Page 17 and 18:
Page 19 and 20:
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
REAR LAMP 3CP.S.C..N063 I5CPSC.N087
Page 27 and 28:
Page 29 and 30:
Page 31 and 32:
Page 33 and 34:
Page 35 and 36:
Page 37 and 38: 36 Cadillac 355-D, 370-D and 452-D
Page 39 and 40: 1. Extreme Pressure Lubricants for
Page 41 and 42: LUBRICATION Lubrication Schedule Ca
Page 43 and 44: CADILLAC V-8 SRIES 10 AND 20 ENGINE
Page 45 and 46: F E A T U R E S O F C O N S T R U C
Page 47 and 48: F E A T U R E S O F C O N S T R U C
Page 49: CADILLAC V-8 5-PASSENGER TOWN c.F'n
Page 52 and 53: Jt.- v4 *•} CADILLAC OPERATOR'S M
Page 54 and 55: CHAPTER I—Cadillac Service Table
Page 56 and 57: The car owner's first and most freq
Page 58 and 59: Agreement provides, for a period of
Page 60 and 61: someone not familiar with Cadillac
Page 62 and 63: the oil is consumed many times as r
Page 64 and 65: portion of gasoline and air getting
Page 66 and 67: in control. Blind curves, hills, ro
Page 68 and 69: losses. Any solution lost mechanica
Page 70 and 71: Use of Starter If the engine does n
Page 72 and 73: ward either side to throw the light
Page 74 and 75: Spare Wheel Carrier Three tvpes of
Page 76 and 77: Cooling System The radiator filler
Page 78 and 79: otates the discs slightly every tim
Page 80 and 81: from the left headlamp should have
Page 82 and 83: CHAPTER VII SPECIFICATIONS AND LICE
Page 84: L Lamp bulbs 49 License data 56 Lig
Page 87: IMPORTANT Beginning with' the "D" s
Page 91 and 92: 6 CONTENTS Lubrication Page Service
Page 93 and 94: 8 FRONT WHEEL SUSPENSION SYSTEM Fro
Page 95 and 96: 10 FRONT WHEEL SUSPENSION SYSTEM an
Page 97 and 98: 12 FRONT WHEEL SUSPENSION SYSTEM nu
Page 99 and 100: 14 FRONT WHEEL SUSPENSION SYSTEM C/
Page 101 and 102: 16 FRONT WHEEL SUSPENSION SYSTEM Tr
Page 103 and 104: 18 FRONT WHEEL SUSPENSION SYSTEM F
Page 105 and 106: 20 CAMBER Camber is the outward til
Page 107 and 108: 22 FRONT WHEEL SUSPENSION SYSTEM Di
Page 109 and 110: 24 FRONT WHEEL SUSPENSION SYSTEM Di
Page 111 and 112: 26 REAR AXLE | Universal Joint flan
Page 113 and 114: 28 REAR AXLE •• Bearing Retaine
Page 115 and 116: 30 REAR AXLE Pitch Line Pitch Line
Page 117 and 118: 32 REAR AXLE of the pinion gear tee
Page 119 and 120: 34 BODY Body Types and Style Number
Page 121 and 122: 1935 LA SALLE BODY DE1ENSIONS cd p.
Page 123 and 124: 36 BODY car through the remote cont
Page 125 and 126: 38 BODY oughly and then cleaning it
Page 127 and 128: 40 BODY ment, and cylinder can be e
Page 129 and 130: 42 BODY Fig. 8 Body showing Front E
Page 131 and 132: 44 BODY Lock Board Remove damaged v
Page 133 and 134: 46 BODY Spring Bronze Bushings. rig
Page 135 and 136: 48 BRAKES General Description The C
Page 137: When relining brakes, back off cam
Page 140 and 141:
53 BRAKES Adjust nut to eliminate b
Page 142 and 143:
55 BRAKES drum may prevent proper a
Page 144 and 145:
57 BRAKES Filler and Breather Plug
Page 146 and 147:
59 brake backing plate is to be rem
Page 148 and 149:
61 1 BRAKES Diagnosis Chart Effect
Page 150 and 151:
63 CLUTCH General Description Both
Page 152 and 153:
65 CLUTCH Spacers should be install
Page 154 and 155:
67 CLUTCH Service Information 1. Ca
Page 156 and 157:
69 CLUTCH Specifications Subject an
Page 158 and 159:
71 COOLING SYSTEM General Descripti
Page 160 and 161:
73 COOLING SYSTEM Service Informati
Page 162 and 163:
75 COOLING SYSTEM Second-type therm
Page 164 and 165:
77 COOLING SYSTEM Fig. 18 Remove th
Page 166 and 167:
79 COOLING SYSTEM Specifications Su
Page 168 and 169:
81 ELECTRICAL SYSTEM General Descri
Page 170 and 171:
83 of the contact arm for the No. ]
Page 172 and 173:
85 ELECTRICAL SYSTEM generator curr
Page 174 and 175:
87 ELECTRICAL SYSTEM Batteries in c
Page 176 and 177:
89 ELECTRICAL SYSTEM This lift may
Page 178 and 179:
91 ELECTRICAL SYSTEM Projector and
Page 180 and 181:
93 ELECTRICAL SYSTEM To test for a
Page 182 and 183:
ELECTRICAL SYSTEM Specifications Su
Page 184 and 185:
97 ENGINE General Description The c
Page 186 and 187:
99 ENGINE The vacuum pump used on a
Page 188 and 189:
101 ENGINE 5. Worn Limits for Cylin
Page 190 and 191:
103 ENGINE through the connecting r
Page 192 and 193:
105 practicable. Burning the carbon
Page 194 and 195:
ENGINE 107 been cut in the frame si
Page 196 and 197:
109 ENGINE Spring Idler Sprocket Ra
Page 198 and 199:
ENGINE Plate 43. Oiling System—Ca
Page 200 and 201:
ENGINE 113
Page 202 and 203:
115 ENGINE Specifications Subject a
Page 204 and 205:
117 ENGINE Specifications Valve Mec
Page 206 and 207:
119 EXHAUST SYSTEM General Descript
Page 208 and 209:
121 FENDERS—FRAME Fig. 3. LaSalle
Page 210 and 211:
123 FRAME Fie 2 The X-member of the
Page 212 and 213:
125 GASOLINE SYSTEM General Descrip
Page 214 and 215:
127 GASOLINE SYSTEM period than is
Page 216 and 217:
129 GASOLINE SYSTEM during the warm
Page 218 and 219:
131 GASOLINE SYSTEM This filler has
Page 220 and 221:
133 GASOLINE SYSTEM right-hand thro
Page 222 and 223:
135 GASOLINE SYSTEM point, addition
Page 224 and 225:
137 HOOD These hood rest brackets m
Page 226 and 227:
139 LIGHTING SYSTEM Fig. 4. Multibe
Page 228 and 229:
141 LIGHTING SYSTEM likewise have t
Page 230 and 231:
143 LUBRICATION Service Information
Page 232 and 233:
145 LUBRICATION—SPRINGS AND SHOCK
Page 234 and 235:
147 SPRINGS AND SHOCK ABSORBERS mus
Page 236 and 237:
149 SPRINGS AND SHOCK ABSORBERS the
Page 238 and 239:
151 SPRINGS AND SHOCK ABSORBERS Spe
Page 240 and 241:
153 STEERING GEAR General Descripti
Page 242 and 243:
155 Plate 53) is at the top the sam
Page 244:
157 Two types of Synchro-mesh trans
Page 247 and 248:
160 TRANSMISSION Synchronising Yoke
Page 249 and 250:
162 TRANSMISSION Second-speei Adjus
Page 251 and 252:
TRANSMISSION Remove these nuts to d
Page 253 and 254:
166 TRANSMISSION ilHillii Main Shaf
Page 255:
168 TRANSMISSION 9. Remove snap rin
Page 258 and 259:
172 WHEELS, RIMS AND TIRES Fig. 7.
Page 260 and 261:
174 WHEELS, RIMS AND TIRES The whee
Page 262 and 263:
176 WHEELS, RIMS AND TIRES Fig. 16
Page 264 and 265:
UPHOLSTERY CHART NO. 2 Series 35-50
Page 266:
Stylo V-16 Cadillac, Series 60 (BOD
Page 269 and 270:
COPYRIGHTED, 1936, FISHER BODY CORP
Page 271 and 272:
Fisher Body Service Manual, 1936 Pa
Page 273 and 274:
Fisher Body Service Manual, 1935 CO
Page 275 and 276:
Fisher Body Service Manual, 1935 Th
Page 277 and 278:
Fisher Body Service Manual, 1935 To
Page 279 and 280:
Fisher Body Service Manual, 1935
Page 281 and 282:
Fisher Body Service Manual, 1935 FL
Page 283 and 284:
Fisher Body Service Manual, 1935 Il
Page 285 and 286:
Page 287 and 288:
Page 289 and 290:
Fisher Body Service Manual, 1935 DO
Page 291 and 292:
Fisher Body Service Manual, 1935 GL
Page 293 and 294:
Fisher Body Service Manual, 1935 3.
Page 295 and 296:
Fisher Body Service Manual, 1935 th
Page 297 and 298:
Page 299 and 300:
Fisher Body Service Manual, 1935 RE
Page 301 and 302:
Page 303 and 304:
_ Fisher Body Service Manual, 1935
Page 305 and 306:
Page 307 and 308:
Illustration No. 114 CONDITION: Too
Page 309 and 310:
Fisher Body Service Manual, 1935 FR
Page 311 and 312:
Fisher Body Service Manual, 1935 In
Page 313 and 314:
Page 315 and 316:
Fisher Body Service Manual, 1935 CO
Page 317 and 318:
Fisher Body Service Manual, 1935 F.
Page 319 and 320:
Page 321 and 322:
Fisher Body Service Manual, 1935 If
Page 323 and 324:
Fisher Body Service Manual, 1936 19
Page 325 and 326:
Fisher Body Service Manual, 1936 AL
Page 327 and 328:
Fisher Body Service Manual, 1936 OU
Page 329 and 330:
Page 331 and 332:
Fisher Body Service Manual, 1936 19
Page 333 and 334:
Page 335 and 336:
Fisher Body Service Manual, 1936 SE
Page 337 and 338:
Fisher Body Service Manual, 1936 HO
Page 339 and 340:
Fisher Body Service Manual, 1936 LU
Page 341 and 342:
Fisher Body Service Manual, 1936 LI
Page 343 and 344:
Fisher Body Service Manual, 1936 Wi
Page 345 and 346:
Fisher Body Service Manual INDEX
show all

1935 Cadillac - GM Heritage Center

Create successful ePaper yourself

Delete template?

Save as template?