Kawasaki Z1000 - ZR1000 2003-04 Service Manual - Small Engine ...

More documents

Recommendations

Info

Not For Resale www.SmallEngineDiscount.com 4-6 COOLING SYSTEM Specifications Item Standard Coolant provided when shipping: Type (recommended) Permanent type of antifreeze (soft water and ethylene glycol plus corrosion and rust inhibitor chemicals for aluminum engines and radiators) Color Green Mixed ratio Soft water 50%, coolant 50% Freezing point – 35°C (– 31°F) Total amount 2.9 L (3.1 US qt) (reserve tank full level, including radiator and engine) Radiator cap Relief pressure 93 ∼ 123 kPa (0.95 ∼ 1.25 kgf/cm², 13.5 ∼ 17.8 psi) Thermostat: Valve opening temperature 58 ∼ 62°C (136 ∼ 144°F) Valve full opening lift 8 mm (0.31 in.) or more @75°C (167°F)
Not For Resale www.SmallEngineDiscount.com Special Tool Bearing Driver Set: 57001–1129 COOLING SYSTEM 4-7 Kawasaki Bond (Silicone Sealant): 56019–120 Bearing Driver: 57001–382
Page 1 and 2:
Not For Resale www.SmallEngineDisco
Page 3 and 4:
Page 5 and 6:
© 2002 Kawasaki Heavy Industries,
Page 7 and 8:
Page 9 and 10:
Page 11 and 12:
Page 13 and 14:
Page 15 and 16:
Page 17 and 18:
Page 19 and 20:
General Specifications GENERAL INFO
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
Page 27 and 28:
Page 29 and 30:
Page 31 and 32:
Page 33 and 34:
Torque and Locking Agent PERIODIC M
Page 35 and 36:
Torque and Locking Agent PERIODIC M
Page 37 and 38:
Page 39 and 40:
Page 41 and 42:
Page 43 and 44:
Page 45 and 46:
Page 47 and 48:
Page 49 and 50:
Page 51 and 52:
Periodic Maintenance Procedures •
Page 53 and 54:
Page 55 and 56:
Page 57 and 58:
Periodic Maintenance Procedures PER
Page 59 and 60:
Page 61 and 62:
Page 63 and 64:
Page 65 and 66:
Page 67 and 68:
Page 69 and 70:
Page 71 and 72:
Page 73 and 74:
Page 75 and 76:
Page 77 and 78:
FUEL SYSTEM (DFI) 3-1 Fuel System (
Page 79 and 80:
Page 81 and 82:
Page 83 and 84:
Page 85 and 86:
Page 87 and 88:
Page 89 and 90:
Page 91 and 92:
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
FUEL SYSTEM (DFI) 3-21 Troubleshoot
Page 99 and 100:
Page 101 and 102:
DFI System Troubleshooting Guide FU
Page 103 and 104:
Page 105 and 106:
Page 107 and 108:
Page 109 and 110:
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
Page 117 and 118:
Page 119 and 120:
Inlet Air Pressure Sensor (Service
Page 121 and 122:
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132: Not For Resale www.SmallEngineDisco
Page 133 and 134: For Resale www.SmallEngineDiscount.
Page 143 and 144: Subthrottle Valve Actuator (Service
Page 153 and 154: Fuel Line • Open the fuel tank ca
Page 181: Not For Resale www.SmallEngineDisco
Page 185 and 186: Coolant COOLING SYSTEM 4-9 Pressure
Page 211 and 212: Camshaft, Camshaft Chain ENGINE TOP
Page 225 and 226: Cylinder, Pistons ENGINE TOP END 5-
Page 233 and 234:
Page 235 and 236:
Page 237 and 238:
Clutch Cover CLUTCH 6-7 Clutch Cove
Page 239 and 240:
Page 241 and 242:
Page 243 and 244:
Page 245 and 246:
Page 247 and 248:
Page 249 and 250:
Page 251 and 252:
Page 253 and 254:
Page 255 and 256:
Page 257 and 258:
Page 259 and 260:
Page 261 and 262:
Page 263 and 264:
Page 265 and 266:
Page 267 and 268:
• Install the engine ground cable
Page 269 and 270:
Page 271 and 272:
Page 273 and 274:
Page 275 and 276:
Page 277 and 278:
Page 279 and 280:
Page 281 and 282:
Crankcase Splitting • Apply liqui
Page 283 and 284:
Crankshaft and Connecting Rods •
Page 285 and 286:
Crankshaft and Connecting Rods CRAN
Page 287 and 288:
Page 289 and 290:
Page 291 and 292:
Page 293 and 294:
Page 295 and 296:
Transmission CRANKSHAFT/TRANSMISSIO
Page 297 and 298:
Page 299 and 300:
Page 301 and 302:
Page 303 and 304:
Page 305 and 306:
Page 307 and 308:
Page 309 and 310:
Page 311 and 312:
Page 313 and 314:
Page 315 and 316:
Page 317 and 318:
Page 319 and 320:
Page 321 and 322:
Page 323 and 324:
Page 325 and 326:
Page 327 and 328:
Page 329 and 330:
Page 331 and 332:
Page 333 and 334:
Page 335 and 336:
Page 337 and 338:
Page 339 and 340:
Page 341 and 342:
Page 343 and 344:
Page 345 and 346:
Page 347 and 348:
Page 349 and 350:
Page 351 and 352:
Page 353 and 354:
Page 355 and 356:
Page 357 and 358:
Page 359 and 360:
Page 361 and 362:
Page 363 and 364:
Page 365 and 366:
Page 367 and 368:
Page 369 and 370:
Page 371 and 372:
Page 373 and 374:
Page 375 and 376:
Page 377 and 378:
Page 379 and 380:
Page 381 and 382:
Page 383 and 384:
Page 385 and 386:
Page 387 and 388:
Page 389 and 390:
Page 391 and 392:
Page 393 and 394:
Page 395 and 396:
Page 397 and 398:
Page 399 and 400:
Page 401 and 402:
Page 403 and 404:
Page 405 and 406:
Page 407 and 408:
ELECTRICAL SYSTEM 16-1 Electrical S
Page 409 and 410:
Page 411 and 412:
Page 413 and 414:
Page 415 and 416:
Page 417 and 418:
Page 419 and 420:
Page 421 and 422:
Page 423 and 424:
Page 425 and 426:
Page 427 and 428:
Page 429 and 430:
Page 431 and 432:
Page 433 and 434:
Page 435 and 436:
Page 437 and 438:
Page 439 and 440:
Page 441 and 442:
Page 443 and 444:
Page 445 and 446:
Ignition System ELECTRICAL SYSTEM 1
Page 447 and 448:
Page 449 and 450:
Page 451 and 452:
Page 453 and 454:
Page 455 and 456:
Page 457 and 458:
Page 459 and 460:
Page 461 and 462:
Page 463 and 464:
Page 465 and 466:
Page 467 and 468:
For Resale www.SmallEngineDiscount.
Page 469 and 470:
Page 471 and 472:
Page 473 and 474:
Page 475 and 476:
Page 477 and 478:
Meter, Gauge, Indicator Unit ELECTR
Page 479 and 480:
Page 481 and 482:
Page 483 and 484:
Page 485 and 486:
Page 487 and 488:
Page 489 and 490:
Page 491 and 492:
Page 493 and 494:
Page 495 and 496:
Page 497 and 498:
Page 499 and 500:
Page 501 and 502:
Page 503 and 504:
Page 505 and 506:
Page 507 and 508:
Page 509 and 510:
Page 511 and 512:
Page 513 and 514:
Page 515:
MODEL APPLICATION Year Model Beginn
show all

Kawasaki Z1000 - ZR1000 2003-04 Service Manual - Small Engine ...

Create successful ePaper yourself

Delete template?

Save as template?