Kawasaki Z1000 - ZR1000 2003-04 Service Manual - Small Engine ...

Not For Resale
www.SmallEngineDiscount.com
16-54 ELECTRICAL SYSTEM
Lighting System
This models adopt the daylight system and have a headlight
relay in the junction box. In these models, the headlight
does not go on when the ignition switch and the engine
stop switch are first turned on. The headlight comes on after
the starter button is released and stays on until the ignition
switch is turned off. The headlight will go out momentarily
whenever the starter button is pressed and come back on
when the button is released.
Headlight Beam Horizontal Adjustment
• Turn the horizontal adjuster [A] on the headlight with the
screwdriver [B] in or out until the beam points straight
ahead.
Headlight Beam Vertical Adjustment
• Turn the vertical adjusters [A] on the headlight with the
screwdriver [B] in or out to adjust the headlight vertically.
NOTE
○On high beam, the brightest points should be slightly
below horizontal with the motorcycle on its wheels and
the rider seated. Adjust the headlight(s) to the proper
angle according to local regulations.
○For US model, the proper angle is 0.4 degrees below
horizontal. This is 50 mm (2 in.) drop at 7.6 m (25
ft) measured from the center of the headlights with the
motorcycle on its wheels and the rider seated.
50 mm (2 in.) [A]
Center of Brightest Spot [B]
7.6 m (25 ft) [C]
Height of Headlight Center [D]
Low Beam [E]
High Beam [F]