Series 16/18/160/180-Model C Maintenance Manual, GFZ-62755EN ...

More documents

Recommendations

Info

7. AC SPINDLE (ANALOG INTERFACE) B–<strong>62755EN</strong>/01(4)If the output voltage is not correct, perform the following calculation,change the value of parameter no. 3730 and tune the gain of D/Aconverter.10VSetting value= measured voltage (Current value of PRM 3730)(5)Execute an S command again and confirm that the output voltage iscorrect.Return the parameters to the previous values.284
B–<strong>62755EN</strong>/017. AC SPINDLE (ANALOG INTERFACE)7.2TABLE OF TESTPOINTS7.2.1 Name Signal RemarksDA2PAPBAnalog speed commandvoltage (SVC)Pulse generator outputA–phasePulse generator outputB–phase0 to +10V, Rated speed at 10V90° advance by PB at CW rotationV p–p =0.36–0.5V90° delay by PA at CW rotationV p–p =0.36–0.5VRA A–phase standard voltage +2. 5VDC 0. 2VRB B–phase standard voltage +2. 5VDC 0. 2VPAP A phase pulse waveform Duty 50% (ON/ OFF ratio)PBP B phase pulse waveform Duty 50% (ON/ OFF ratio)TSA Speed feedback signal 10V at rated max. speed of motor(CW:+,CCW:–)TS2 Low–speed detection signal Adjustment of each model by RV6TS3Speed pulse F/V conversionsignalAt CCW (forwar rotation)6000rpm, –4.65 to –6.15VVCMD Speed command voltage 010V,(CCW:+, CW: – )FWP CCW rotation pulse Pulse width=3.2µs, occurs only at CCW (forwardrotation)RVP CW rotation pulse Pulse width=3.2µs, occurs only at CW (backwardrotation)ER Error voltage –4.2 to +4.8VCLK1 Clock signal 2. 5MHz, duty 50%SLIPSlip pulseVDC DC link voltage signal Voltage 1/100 of DC link voltageDTDCIUIVIWDC form voltage of input ACvoltageU–phase current detectionsignalV–phase current detectionsignalW–phase current detectionsignalVoltage 1/100 of DC form voltage of input ACvoltage22.2 A/V+24V +24V DC voltage About 23V 4%+15V +15V DC voltage +15V4%+5V +5V DC voltage +5V4%–15V –15V DC voltage –15V4%0VSM Speed meter signal At maximum rated max. rotation +10VLM Loadmeter signal At maximum rated max. output +10V285
Page 1:
GE Fanuc AutomationComputer Numeric
Page 4 and 5:
B-62755EN/01PREFACEPREFACEDescripti
Page 6 and 7:
B-62755EN/01PREFACERelated manualsT
Page 10 and 11:
B-62755EN/01 2.7 HOW TO REPLACE TH
Page 12:
B-62755EN/01 7. AC SPINDLE (ANALOG
Page 15 and 16:
B-62755EN/011DISPLAYAND OPERATION O
Page 17 and 18:
B-62755EN/011. DISPLAY AND OPERATIO
Page 19 and 20:
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
Page 27 and 28:
Page 29 and 30:
Page 31 and 32:
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
Page 39 and 40:
Page 41 and 42:
Page 43 and 44:
Page 45 and 46:
Page 47 and 48:
Page 49 and 50:
Page 51 and 52:
Page 53 and 54:
Page 55 and 56:
Page 57 and 58:
Page 59 and 60:
Page 61 and 62:
Page 63 and 64:
Page 65 and 66:
Page 67 and 68:
Page 69 and 70:
Page 71 and 72:
Page 73 and 74:
Page 75 and 76:
Page 77 and 78:
Page 79 and 80:
Page 81 and 82:
Page 83 and 84:
Page 85 and 86:
Page 87 and 88:
Page 89 and 90:
Page 91 and 92:
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
Page 99 and 100:
Page 101 and 102:
Page 103 and 104:
Page 105 and 106:
B-62755EN/012. HARDWARE2.1STRUCTURE
Page 107 and 108:
ÈÈÈÈÈÈÈÈÈÈÈÈÈÈÈÈÈ
Page 109 and 110:
B-62755EN/012. HARDWARE(Main CPU)SE
Page 111 and 112:
B-62755EN/012. HARDWARESCALE1 (JF21
Page 113 and 114:
B-62755EN/012. HARDWARE2) When the
Page 115 and 116:
B-62755EN/012. HARDWARE4) When the
Page 117 and 118:
B-62755EN/012. HARDWARE Terminal la
Page 119 and 120:
B-62755EN/012. HARDWARE3) For 14″
Page 121 and 122:
B-62755EN/012. HARDWARE2.4.2Reader/
Page 123 and 124:
B-62755EN/012. HARDWARE2.4.4I/O LIN
Page 125 and 126:
B-62755EN/012. HARDWARE Cable conne
Page 127 and 128:
B-62755EN/012. HARDWARE Connection
Page 129 and 130:
B-62755EN/012. HARDWARE2.4.6Connect
Page 131 and 132:
B-62755EN/012. HARDWARE Serial spin
Page 133 and 134:
B-62755EN/012. HARDWARE2.4.9Connect
Page 135 and 136:
B-62755EN/012. HARDWARE2.4.11Remote
Page 137 and 138:
B-62755EN/012. HARDWARE2.4.12High-s
Page 139 and 140:
B-62755EN/012. HARDWARE2.4.14Enviro
Page 141 and 142:
B-62755EN/012. HARDWARE GroundThe f
Page 143 and 144:
B-62755EN/012. HARDWARE Noise suppr
Page 145 and 146:
B-62755EN/012. HARDWARE2.5LED DISPL
Page 147 and 148:
B-62755EN/012. HARDWARE FuseFusesPo
Page 149 and 150:
B-62755EN/012. HARDWARE2.5.2Main CP
Page 151 and 152:
B-62755EN/012. HARDWARENo. Name Spe
Page 153 and 154:
B-62755EN/012. HARDWARE2.5.4Option
Page 155 and 156:
B-62755EN/012. HARDWARE Location of
Page 157 and 158:
B-62755EN/012. HARDWARE2.5.5Option
Page 159 and 160:
Page 161 and 162:
Page 163 and 164:
B-62755EN/012. HARDWARE2.5.9I/O Car
Page 165 and 166:
B-62755EN/012. HARDWARE2.5.11Backgr
Page 167 and 168:
B-62755EN/012. HARDWARE2.5.1264-bit
Page 169 and 170:
B-62755EN/012. HARDWARE2.6.3Control
Page 171 and 172:
B-62755EN/012. HARDWARE2.6.4Modules
Page 173 and 174:
B-62755EN/012. HARDWARE2.6.5CRT/MDI
Page 175 and 176:
B-62755EN/012. HARDWARENameSpecific
Page 177 and 178:
Page 179 and 180:
Page 181 and 182:
B-62755EN/012. HARDWARE2.7HOW TO RE
Page 183 and 184:
B-62755EN/012. HARDWARE2.8.1Replaci
Page 185 and 186:
B-62755EN/012. HARDWARE2.8.3Replaci
Page 187 and 188:
B-62755EN/012. HARDWARE(5)(4)Fan mo
Page 189 and 190:
B-62755EN/012. HARDWARETable 1. Fus
Page 191 and 192:
B-62755EN/012. HARDWARECleaning hea
Page 193 and 194:
B-62755EN/012. HARDWARE2.12ADJUSTIN
Page 195 and 196:
B-62755EN/012. HARDWARE2.13REPLACIN
Page 197 and 198:
B-62755EN/013. INPUT AND OUTPUT OF
Page 199 and 200:
Page 201 and 202:
Page 203 and 204:
Page 205 and 206:
Page 207 and 208:
Page 209 and 210:
Page 211 and 212:
Page 213 and 214:
Page 215 and 216:
Page 217 and 218:
Page 219 and 220:
Page 221 and 222:
Page 223 and 224:
Page 225 and 226:
B-62755EN/014.INTERFACE BETWEEN NC
Page 227 and 228:
Page 229 and 230:
Page 231 and 232:
Page 233 and 234:
Page 235 and 236:
Page 237 and 238:
Page 239 and 240:
Page 241 and 242:
Page 243 and 244:
Page 245 and 246:
Page 247 and 248: B-62755EN/014.INTERFACE BETWEEN NC
Page 249 and 250: ÀÀÀÀÀÀÀÀÀÀÀÀB-62755EN/0
Page 261 and 262: B-62755EN/015. DIGITAL SERVO5DIGITA
Page 263 and 264: B-62755EN/015. DIGITAL SERVO(2)MOTO
Page 265 and 266: B-62755EN/015. DIGITAL SERVO8) For
Page 267 and 268: B-62755EN/015. DIGITAL SERVO(8)No.
Page 269 and 270: B-62755EN/015. DIGITAL SERVOAlarm1#
Page 271 and 272: B-62755EN/015. DIGITAL SERVO5.3ADJU
Page 273 and 274: B-62755EN/015. DIGITAL SERVO5.4DOGL
Page 275 and 276: B-62755EN/016ACSPINDLE (SERIAL INTE
Page 277 and 278: B-62755EN/016. AC SPINDLE (SERIAL I
Page 293 and 294: B-62755EN/017. AC SPINDLE (ANALOG I
Page 297: B-62755EN/017. AC SPINDLE (ANALOG I
Page 309 and 310: B-62755EN/018.TROUBLESHOOTING8TROUB
Page 311 and 312: B-62755EN/018.TROUBLESHOOTING8.1COR
Page 313 and 314: B-62755EN/018.TROUBLESHOOTING8.2POW
Page 315 and 316: B-62755EN/018.TROUBLESHOOTINGMain C
Page 317 and 318: B-62755EN/018.TROUBLESHOOTING(c) Co
Page 319 and 320: B-62755EN/018.TROUBLESHOOTINGc. Jog
Page 321 and 322: B-62755EN/018.TROUBLESHOOTING(3)Che
Page 323 and 324: B-62755EN/018.TROUBLESHOOTINGc. Jog
Page 325 and 326: B-62755EN/018.TROUBLESHOOTINGG0019#
Page 327 and 328: B-62755EN/018.TROUBLESHOOTING8.6AUT
Page 329 and 330: B-62755EN/018.TROUBLESHOOTINGG0005#
Page 331 and 332: B-62755EN/018.TROUBLESHOOTINGf. Int
Page 333 and 334: B-62755EN/018.TROUBLESHOOTINGi. NC
Page 335 and 336: B-62755EN/018.TROUBLESHOOTING8.7CYC
Page 337 and 338: B-62755EN/018.TROUBLESHOOTING8.8NOT
Page 339 and 340: B-62755EN/018.TROUBLESHOOTING8.9ALA
Page 341 and 342: B-62755EN/018.TROUBLESHOOTING0102 T
Page 343 and 344: B-62755EN/018.TROUBLESHOOTING(c) Sp
Page 345 and 346: B-62755EN/018.TROUBLESHOOTING< Cabl
Page 347 and 348: B-62755EN/018.TROUBLESHOOTING8.10RE
Page 349 and 350:
B-62755EN/018.TROUBLESHOOTING(1)Che
Page 351 and 352:
B-62755EN/018.TROUBLESHOOTING8.13AL
Page 353 and 354:
Page 355 and 356:
ÇÇÇÇÇÇB-62755EN/018.TROUBLESH
Page 357 and 358:
Page 359 and 360:
B-62755EN/018.TROUBLESHOOTING Overh
Page 361 and 362:
B-62755EN/018.TROUBLESHOOTINGPower
Page 363 and 364:
Page 365 and 366:
B-62755EN/018.TROUBLESHOOTINGMove t
Page 367 and 368:
B-62755EN/018.TROUBLESHOOTING #6(LV
Page 369 and 370:
B-62755EN/018.TROUBLESHOOTING #4(HC
Page 371 and 372:
B-62755EN/018.TROUBLESHOOTING #2(DC
Page 373 and 374:
B-62755EN/018.TROUBLESHOOTING #1(FB
Page 375 and 376:
B-62755EN/018.TROUBLESHOOTING LED d
Page 377 and 378:
B-62755EN/018.TROUBLESHOOTING Curre
Page 379 and 380:
Page 381 and 382:
Page 383 and 384:
B-62755EN/018.TROUBLESHOOTING Optio
Page 385 and 386:
B-62755EN/018.TROUBLESHOOTINGRemedi
Page 387 and 388:
Page 389 and 390:
Page 391 and 392:
Page 393 and 394:
B-62755EN/018.TROUBLESHOOTING Main
Page 395 and 396:
Page 397 and 398:
Page 399 and 400:
Page 401 and 402:
Page 403 and 404:
B-62755EN/019. TROUBLESHOOTING (SER
Page 405 and 406:
Page 407 and 408:
Page 409 and 410:
Page 411 and 412:
Page 413 and 414:
B-62755EN/0110. TROUBLESHOOTING(ANA
Page 415 and 416:
Page 417 and 418:
Page 419 and 420:
Page 421 and 422:
Page 423 and 424:
Page 425 and 426:
B-62755EN/01APPENDIXA. I/O UNIT MOD
Page 427 and 428:
Page 429 and 430:
Page 431 and 432:
B-62755EN/01APPENDIXB. ALARM LISTBA
Page 433 and 434:
B-62755EN/01APPENDIXB. ALARM LISTNu
Page 435 and 436:
Page 437 and 438:
Page 439 and 440:
Page 441 and 442:
Page 443 and 444:
Page 445 and 446:
Page 447 and 448:
Page 449 and 450:
Page 451 and 452:
B-62755EN/01APPENDIXB. ALARM LIST(4
Page 453 and 454:
Page 455 and 456:
B-62755EN/01APPENDIXB. ALARM LIST(8
Page 457 and 458:
Page 459 and 460:
B-62755EN/01APPENDIXB. ALARM LISTB.
Page 461 and 462:
B-62755EN/01APPENDIXB. ALARM LISTMe
Page 463 and 464:
Page 467 and 468:
Page 469 and 470:
B-62755EN/01APPENDIXB. ALARM LISTAl
Page 471 and 472:
B-62755EN/01APPENDIXB. ALARM LISTB.
Page 473 and 474:
B-62755EN/01APPENDIXB. ALARM LIST M
Page 475 and 476:
B-62755EN/01APPENDIXC. LIST OF MAIN
Page 477 and 478:
Page 479 and 480:
Page 481 and 482:
Page 483 and 484:
Page 485 and 486:
Page 487 and 488:
Page 489 and 490:
B-62755EN/01APPENDIXD. BOOT SYSTEMD
Page 491 and 492:
Page 493 and 494:
Page 495 and 496:
Page 497 and 498:
Page 499 and 500:
B-62755EN/01APPENDIXD. BOOT SYSTEM
Page 501 and 502:
B-62755EN/01APPENDIXD. BOOT SYSTEM
Page 503 and 504:
Page 505 and 506:
Page 507 and 508:
Page 509 and 510:
B-62755EN/01ENOTATIONAPPENDIXOF MDI
Page 511 and 512:
B-62755EN/01Numbers16-TC/MC, 160-TC
Page 513 and 514:
B-62755EN/01INDEXMMain CPU board, 1
Page 515 and 516:
Revision RecordFANUC MAINTENANCE
show all

Series 16/18/160/180-Model C Maintenance Manual, GFZ-62755EN ...

Create successful ePaper yourself

Delete template?

Save as template?