Handbook for Methane Control in Mining - AMMSA

More documents

Recommendations

Info

Delivering on the Nation’s Promise:Safety and health at work for all peoplethrough research and preventionFor information about occupational safety and health topics contact NIOSH at:1–800–35–NIOSH (1–800–356–4674)Fax: 513–533–8573E-ma il: pubstaft@ cdc.govwww.cdc.gov/nioshSAFER • HEALTHIER • PEOPLE TMDHHS (NIOSH) Publication No. 2006–127
Handbook for Methane Control in Mining • IC 9486
Page 1 and 2:
TMIC 9486Information Circular/2006H
Page 3 and 4:
ORDERING INFORMATIONCopies of Natio
Page 5 and 6:
ILLUSTRATIONS—ContinuedPage4-6. U
Page 8:
HANDBOOK FOR METHANE CONTROL IN MIN
Page 11 and 12:
4Below 5%, called the lower explosi
Page 13 and 14:
6reduced pressure, except at very l
Page 15 and 16:
8Static electricity. Protection aga
Page 17 and 18:
10Figure 1-4.—Estimated methane c
Page 19 and 20:
12LAYERING OF METHANE AT THE MINE R
Page 21 and 22:
14good eyesight. 24methane level.Ot
Page 23 and 24:
16a material balance indicated that
Page 25 and 26:
18As an example, assume that themet
Page 27 and 28:
20Figure 1-10.—Relative frequency
Page 29 and 30:
22Davies AW, Isaac AK, Cook PM [200
Page 31 and 32:
24Margerson SNA, Robinson H, Wilkin
Page 33 and 34:
CHAPTER 2.—SAMPLING FOR METHANE I
Page 35 and 36:
29USING PORTABLE METHANE DETECTORST
Page 37 and 38:
Out-of-range gas concentrations in
Page 39 and 40:
Figure 2-3.—Recorder chart from a
Page 41 and 42:
35Industrial Scientific Corp. [2004
Page 43 and 44:
38peaks, not the overallmethane lev
Page 45 and 46:
40hung on J-hook assemblies, which
Page 47 and 48:
42Methane dilution effectiveness.Th
Page 49 and 50:
44found that effective scrubber ope
Page 51 and 52:
46When the scrubber exhaust is not
Page 53 and 54:
48Methane monitors are usually moun
Page 55 and 56:
50to use radial bits instead of con
Page 57 and 58:
52Mott ML, Chuhta EJ [1991]. Face v
Page 59 and 60:
54Service, Centers for Disease Cont
Page 61 and 62:
56Methane accumulationsaround thesh
Page 63 and 64:
58corner and by 43% at supportNo. 4
Page 65 and 66:
60When using water sprays to reduce
Page 67 and 68:
62Cecala AB, Zimmer JA, Thimons ED
Page 69 and 70:
64DESIGNING BLEEDER SYSTEMSAs part
Page 71 and 72:
66Caved area characteristics. The c
Page 73 and 74:
68then move this gas into the activ
Page 75 and 76:
70perform tests to determine whethe
Page 77 and 78:
72A major purpose of the bleeder sy
Page 79 and 80:
74• Inlets to the pillared area n
Page 81 and 82:
76REFERENCESCFR. Code of federal re
Page 83 and 84:
78Methane is released into each min
Page 85 and 86:
80Figure 6-1.—Gas content of coal
Page 87 and 88:
82Figure 6-3.—Simplified illustra
Page 89 and 90:
842. In-mine inclined or vertical b
Page 91 and 92:
861. Packed cavity method and its v
Page 93 and 94:
88Table 6-3.—Methane capture rati
Page 95 and 96:
90Early experiences with this metho
Page 97 and 98:
9211. At the surface installation (
Page 99 and 100:
94• Estimated cost for moderately
Page 101 and 102:
96Thakur PC [1981]. Methane control
Page 103 and 104:
98Anomalous, unanticipated methane
Page 105 and 106:
100Vertical methane drainage boreho
Page 107 and 108:
102Figure 7-2 shows a mine entry ap
Page 109 and 110:
104obvious solution to this problem
Page 111 and 112:
106Figure 7-8.—Hypothetical gas c
Page 113 and 114:
108Lama and Bodziony [1998] compile
Page 115 and 116:
110In-mine methane drainage systems
Page 117 and 118:
112Iannacchione AT, Ulery JP, Hyman
Page 119 and 120:
114More sophisticated reservoir eng
Page 121 and 122:
116coal lithotype on gas content is
Page 123 and 124:
118FORECASTING REMAINING GAS-IN-PLA
Page 125 and 126:
120⎛ y⎞⎜⎛⎞ ⎛ ⎞= ⎜
Page 127 and 128:
122emissions. The geometry and size
Page 129 and 130:
124Reservoir models require a subst
Page 131 and 132:
126King GR, Ertekin T [1989a]. A su
Page 133 and 134:
128an area of 314 ft 2 would requir
Page 135 and 136:
130In the case of the abovementione
Page 137 and 138:
132FILLING SHAFTS AT CLOSED MINESFi
Page 139 and 140: 134Hinderfeld G [1995]. Ventilation
Page 141 and 142: 136To calculate the effectiveinert,
Page 143 and 144: 138exhaust. The remaining diesel ex
Page 145 and 146: 140required only 4 min. As a result
Page 147 and 148: 142Figure 11-1.—Desorption test a
Page 149 and 150: 144enclosed in a tunnel-like struct
Page 151 and 152: 146Kolada RJ [1985]. Investigation
Page 153 and 154: 148air in a 6-ft by 9-ft by 6.5-ft
Page 155 and 156: 150represents flammable mixtures. F
Page 157 and 158: 152• In Eastern Europe, petroleum
Page 159 and 160: 154Category II applies to domal sal
Page 161 and 162: 1562. Monitoring for gas and taking
Page 163 and 164: 158These mines typically have large
Page 165 and 166: 160Dave Graham is the safety and he
Page 167 and 168: 162Figure 13-2.—Examples of metha
Page 169 and 170: 164REFERENCESAndrews JN [1987]. Nob
Page 171 and 172: 166APPENDIX A.—ONTARIO OCCUPATION
Page 174 and 175: 169CHAPTER 14.—PREVENTING METHANE
Page 176 and 177: Ways to confirm the presence of gas
Page 178 and 179: 173The tunnel face is usually venti
Page 180 and 181: 175Figure 14-5.—TBM ventilation s
Page 182 and 183: face. While one of these elements a
Page 184 and 185: 179ELIMINATING IGNITION SOURCESElec
Page 186 and 187: 181INDEXAAbnormally gassy faces....
Page 188 and 189: 183NNatural ventilation, coal silos
show all

Handbook for Methane Control in Mining - AMMSA

Create successful ePaper yourself

Delete template?

Save as template?