Hardware and Engineering DF6-340-... Frequency ... - Moeller.com.tr

More documents

Recommendations

Info

01/02 AWB8230-1413GBAppendixTechnical Data<strong>DF6</strong>-<strong>340</strong>-... 11K 15K 18K5 22K 30K 37K 45K 55K 75K 90K 110K 132KProtection class according to EN 60529 IP20Overvoltage category IIIMaximum permissible effective motorpower in kW; data for four pole threephasecurrent asynchronous motors11.0 15.0 18.5 22.0 30.0 37.0 45.0 55.0 75.0 90.0 110 132Maximum permissibleapparent motor power inkVA at400 V 15.2 20.0 25.6 29.7 39.4 48.4 58.5 72.7 93.5 111 135 159480 V 22.0 29.0 37.0 35.7 47.3 58.1 70.1 87.2 112 133 162 191Primary side: Number of phases Three-phasePrimary side: Rated voltage 342 V ~ – 0 % to 528 V ~ + 0 %, 47 to 63 HzSecondary side: Rated voltage Three-phase 380 to 480 V ~Corresponding to the primary side rated voltageIf the primary voltage drops, the secondary voltage also drops.Primary side: Rated current in A 24.0 32.0 41.0 47.0 63.0 77.0 94.0 116 149 176 215 253Secondary side: Rated current in A 22.0 29.0 37.0 43.0 57.0 70.0 85.0 105 135 160 195 253Heat dissipation in W at... % output power70 % 435 575 698 820 1100 1345 1625 1975 2675 3375 3900 4670100 % 600 800 975 1150 1550 1900 2300 2800 3800 4800 5550 6650Secondary side: <strong>Frequency</strong> range0.1 to 400 HzWith motors which are operated at rated frequencies above 50/60 Hz, the maximum possible motor speed should be observed.<strong>Frequency</strong> error limits (at 25 °C g10 °C) • Digital setpoint value: g0.01 % of the maximum frequency• Analog setpoint value: g0.2 % of the maximum frequency<strong>Frequency</strong> resolution • Digital setpoint value: 0.1 Hz• Analog setpoint value: Maximum frequency/1000Voltage/frequency characteristic • Constant torque• Reduced torque• User-programmable V/f characteristicPermissible overcurrent 120 % for 60 s, 150 % for 0.5 s (once every ten minutes)Acceleration/deceleration time 0.01 to 3600 s with linear <strong>and</strong> non-linear characteristic (applies also for second <strong>and</strong> third acceleration/deceleration time)Braking torquewith feedback to the capacitors Reducedbraking torque at frequencies above50 Hz.Approx. 10 %159
Appendix01/02 AWB8230-1413GB<strong>DF6</strong>-<strong>340</strong>-... 11K 15K 18K5 22K 30K 37K 45K 55K 75K 90K 110K 132Kwith external braking resistor 55 % 50 % –with external braking device <strong>and</strong> externalbraking resistor– – 40 to200 %35 to200 %110 to170 %90 to150 %70 to120 %60 to100 %45 to70 %40 to60 %30 to50 %25 to40 %With DC injection braking Braking occurs at frequencies below the minimum frequency (minimum frequency, braking time <strong>and</strong> braking torque are user-definable)Inputs<strong>Frequency</strong> setting Keypad Setting through keys or potentiometerExternalsignals•0 to 10VH, input impedance 10 kO;• –10 V to +10 V H, input impedance 10 kO;• 4 to 20 mA, load impedance 250 O• Potentiometer f 1kO, re<strong>com</strong>mended 4.7 kOClockwise/anticlockwiseoperation (start/stop)Keypad ON key (for Start) <strong>and</strong> OFF key (for Stop); default setting = clockwise operationExternalsignals• Digital input FW for clockwise operation (FWD)• Digital input programmable as REV for anticlockwise operationDigital control inputs programmable as • REV: Start/stop anticlockwise• FF1 to FF4: Fixed frequency selection• JOG: Jog mode• DB: DC braking active• SET: Second parameter set active• 2CH: Second time ramp• FRS: Free run stop (coasting)• EXT: External fault message• USP: Unattended start protection• CS: Heavy starting duty• SFT: Software protection• AT: Select analog input• RST: Reset• STA: Pulse start (3-wire)• STP: Pulse stop (3-wire)• F/R: Direction of rotation (3-wire)• PID: PID control active• PIDC: Reset integral <strong>com</strong>ponent of PID control• UP: Remote access, acceleration• DWN: Remote access, deceleration• UDC: Reset frequency with remote control• OPE: Setpoint value through operator panel• SF1 to SF7: Bitwise frequency selection• OLR: Current limit changeover• NO: No function160
Page 1 and 2:
Hardware a
Page 3 and 4:
• All covers and
Page 5 and 6:
Contents01/02 AWB8230-1413GB4 Opera
Page 7 and 8:
Contents01/02 AWB8230-1413GB- Contr
Page 9 and 10:
601/02 AWB8230-1413GB
Page 11 and 12:
About the DF6 <str
Page 13 and 14:
About the DF6 <str
Page 15 and 16:
About the DF6 <str
Page 17 and 18:
Engineering01/02 A
Page 19 and 20:
Engineering01/02 A
Page 21 and 22:
Engineering01/02 A
Page 23 and 24:
Installation01/02 AWB8230-1413GBMou
Page 25 and 26:
Installation01/02 AWB8230-1413GBWit
Page 27 and 28:
Installation01/02 AWB8230-1413GBFit
Page 29 and 30:
Installation01/02 AWB8230-1413GBEle
Page 31 and 32:
Installation01/02 AWB8230-1413GBCon
Page 33 and 34:
Installation01/02 AWB8230-1413GBThe
Page 35 and 36:
Installation01/02 AWB8230-1413GBPES
Page 37 and 38:
Page 39 and 40:
Installation01/02 AWB8230-1413GBPar
Page 41 and 42:
Page 43 and 44:
Installation01/02 AWB8230-1413GBNo.
Page 45 and 46:
Installation01/02 AWB8230-1413GBhRo
Page 47 and 48:
Installation01/02 AWB8230-1413GBHav
Page 49 and 50:
Operating the DF60
Page 51 and 52:
Operating the DF60
Page 53 and 54:
Operating the DF60
Page 55 and 56:
Operating the DF60
Page 57 and 58:
Programming the ControlSignal Termi
Page 59 and 60:
Page 61 and 62:
Page 63 and 64:
Page 65 and 66:
Page 67 and 68:
Page 69 and 70:
Page 71 and 72:
Page 73 and 74:
Page 75 and 76:
Page 77 and 78:
Page 79 and 80:
Page 81 and 82:
Page 83 and 84:
Page 85 and 86:
Page 87 and 88:
Page 89 and 90:
Page 91 and 92:
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
Page 99 and 100:
Page 101 and 102:
Page 103 and 104:
Page 105 and 106:
10201/02 AWB8230-1413GB
Page 107 and 108:
Setting Parameters01/02 AWB8230-141
Page 109 and 110:
Setting Parameters01/02 AWB8230-141
Page 111 and 112: Setting Parameters01/02 AWB8230-141
Page 113 and 114: ......Setting Parameters01/02 AWB82
Page 155 and 156: Messages01/02 AWB8230-1413GBDisplay
Page 157 and 158: Messages01/02 AWB8230-1413GBOther m
Page 159 and 160: Messages01/02 AWB8230-1413GBDisplay
Page 161: Troubleshooting01/02 AWB8230-1413GB
Page 165 and 166: Appendix01/02 AWB8230-1413GB<strong
Page 167 and 168: Appendix01/02 AWB8230-1413GBCables
Page 169 and 170: Appendix01/02 AWB8230-1413GBRFI fil
Page 171 and 172: Appendix01/02 AWB8230-1413GBPNU Fun
Page 183 and 184: Index01/02 AWB8230-1413GBFlow contr
show all

Hardware and Engineering DF6-340-... Frequency ... - Moeller.com.tr

Create successful ePaper yourself

Delete template?

Save as template?