molded case circuit breakers - Eaton Canada

More documents

Recommendations

Info

188 Typical Schematic CW P2 TO QA2 KA2 CA2 VPF AV1 SYNCHRONOUS MOTOR CONTROL Brush Type Mark V Solid-State Slipsyn Class 14-200 Low-Voltage Motor Starters PRODUCTION DESCRIPTION Application Slipsyn magnetic starters provide reliable, automatic starting of synchronous motors. Automatic synchronization is provided by the Mark V Solid-State Field Panel which assures application of the field at proper motor speed, and at a favorable angular position of stator and rotor poles. As a result, line disturbance resulting from synchronization is reduced and effective motor pull-in torque is increased. Application of DC power to motor field windings is accomplished without mechanically moving parts, and the device features a ”soft-turn on“ <strong>circuit</strong> when applying DC voltage to the motor field. The solid-state Mark V Slipsyn controller will provide the following protective functions: A. Locked rotor protection B. Incomplete sequence C. Failure to synchronize D. Fuse failure (Mark V) E. Pull out protection F. DC current failure protection The cabinet will contain the following: 1 – Primary starter full voltage or reduced voltage 1 – Ammeter shunt (when required) TO QB2 KB2 CB2 TO QC2 KC2 CC2 TO QA1 KA1 CA1 TO QB1 KB1 CB1 TO QC1 KC1 CC1 TO Q4 CQ4 KQ4 (WB) CB SYNCHRONIZING AND CONTROL CIRCUIT AV2 PSC RLY 1 RLY 3 VR TO D1 115 IN- IN+ ST1 ST2 SQ1 TO 120V CONTROL CIRCUIT SQ2 1 – Auxiliary relay for main line contactor (when required) (MX) 1 – Starting and field discharge resistor (IRES) 1 – Current transformer for AC ammeter through NEMA Size 4; Sizes 5 and larger use three current transformers for overload relays and AC ammeter 1 – Set control <strong>circuit</strong> terminal blocks 3 – Type AN manual reset thermal overload relay and three heater elements (OL) 1 – Step down exciter transformer – 3 phase (TX) 3 – Primary fuses (3 PRI) AC SUPPLY MX * * START 1 1A STOP 2 3 M M2 M3 L3 L2 L1 PRI FUSE 3 AMP FLA L N 3 A MX F CB 115 C B M M M H1 H2 VA CPT X1 X2 M 1L1 1L2 1L3 FLA 11 14 FLT TDO WX K ST1 RLY1K1 ST2 SYTR TDO TO 3 PRI FUSE OL OL OL SQ1 RLY3 OL SQ2 K2 ON DELAY .1-30 SEC (SET 2 SEC LONGER THAN FLT ACCELERATION TIME) ON DELAY .1-30 SEC SY TR SET @ .5 SEC 3 – Secondary fuses (3 SEC) 1 – SCR power supply panel 1 – Synchronous control board (CB) 3 – MOV for surge protection (MOV) 1 – Starting and field discharge resistor (when size permits; otherwise provided for separate mounting) 1 – AC ammeter, panel type (AM) 1 – DC ammeter, panel type (DC AMM) 1 – Exciter field potentiometer (P2) 1 – Field failure relay (FLA) 1 – Incomplete SEQ Timer (FLT) 1 – Start Timer (SYTR) 12 RES STARTING/DISCHARGE D1 R1 RESISTOR 1RES R3 Q4 (-) VR SH DC AMM FLA TO CB (+) QC1 TO CB TO CB TO CB QC1 P T3 T2 T1 TO CB QB1 KB1 CB1 TO CB QA1 KA1 CA1 KC1 CC1 3SEC FUSE MOTOR FIELD F1 F2 1L31 1L32 1L33 1L21 1L22 1L23 AMPS 1X1 1X3 1X21X4 2X12X3 2X22X4 3X1 3X3 3X2 3X4 TX 1H1 1H2 2H1 2H2 3H1 3H2 1L11 3PRI FUSE 1L12 1L13 AMPS 1L1 1L2 1L3 TO AC SUPPLY KC2 CC2 TO CB QB1 KB2 CB2 TO CB QA2 Typical Schematic Full Voltage Starter, Class 14-200 Non-Combination Type * Remote Device KA2 CA2 N March 2001
GENERAL INFORMATION Volts 3-Phase 60 Hz 230 40 MODIFICATIONS March 2001 SYNCHRONOUS MOTOR CONTROL Brush Type Mark V Solid-State Slipsyn Class 14-200 Low-Voltage Motor Starters Maximum HP Size Full-Voltage Starters Non-reversing Classes 14-200, 14-203, 14-204, 14-206 in NEMA 1 Enclosure 1.0 PF 0.8 PF Without Short Circuit Protection➊ 60 125 250 350 500 460 30 60 125 250 500 700 30 50 100 200 300 400 25 50 100 200 400 600 3 4 5 6 7 8 2 3 4 5 6 7 Catalog Number 14-200 S3 S4 S5 S6 S7 S8 S2 S3 S4 S5 S6 S7 List Price $16270 17220 20945 25800 34290 36110 15895 16270 17220 20945 25800 34290 With Non-Fusible Disconnect➊ Catalog Number 14-203 List Price Disconnect Fusible or Fused➋ Catalog Number 14-204 Modification List Price Addition Enclosures a. NEMA 1, with gasketed door ....................................................................................$ 340 b. NEMA 12, dust-tight .................................................................................................... 2740 Space Heater (per enclosure)............................................................................................... 140 Thermostat for space heater (per enclosure) ..................................................................... 100 Voltmeter DC — Panel Type................................................................................................. 480 Voltmeter DC — Switchboard Type..................................................................................... 680 Ammeter DC — Switchboard Type (In lieu of Panel Type) ............................................... 200 IQ1000 II with G.F. Current Transformer .......................................................................... 3650 RTD Module for IQ1000 II .................................................................................................. 2000 IQ Data Plus II ..................................................................................................................... 3000 IQ Data ................................................................................................................................ 1150 Pilot Devices Pushbuttons ............................................................................................................................ 80 Selector Switches.................................................................................................................. 100 Indicator Lights – Full Voltage.............................................................................................. 120 Indicator Lights – Push-to-Test ............................................................................................ 220 Automatic Power Factor/VAR/DC Field Current Regulations➍........................................ 9780 For Vacuum or ADVANTAGE Type Contactors, contact your local Cutler-Hammer Field Sales Office. S3 S4 S5 S6 S7 S8 S2 S3 S4 S5 S6 S7 $17045 18275 22865 28560 38165 41720 16507 17045 18275 22865 28560 38720 S3 S4 S5 S6 S7 S8 S2 S3 S4 S5 S6 S7 List Price $17310 19040 23760 29840 38760 42330 16660 17310 19040 23760 29840 38760 With Molded Case Circuit Breaker Catalog Number 14-206 S3 S4 S5 S6 S7 S8 S2 S3 S4 S5 S6 S7 List Price $17220 18960 24350 30020 46020 47330 16770 17220 18960 24350 30020 46020 DIMENSIONS IN INCHES PRICING INFORMATION 1. Enter order on AMP 2. Discount Symbol: SYNCH 189 Reduced Voltage Adder for Auto-transformer Type – NEMA 1 Enclosure➌ Catalog Number 14-60_ S3 S4 S5 S6 S7 S8 S2 S3 S4 S5 S6 S7 List Price $ 4000 5800 7600 14490 21770 30600 3200 4200 5940 8730 15230 23100 Contact your local Cutler-Hammer Field Sales Office. CUSTOMER REQUIRED INFORMATION 1. Complete motor data: HP, volts, amperes, rpm, phase, power factor, Hz, locked rotor amperes, full load DC amperes, excitation volts, recommended discharge resistor ohms, amperes, and time. 2. Application data (including any unusual service conditions) and 100% synchronous motor data MUST accompany each other. ➊ Interrupting capacity: 10 times motor full load current. ➋ Fuses not included up to and including size 5. Sizes 6, 7, 8 include current limiting fuses with 100KAIC asymmetrical amperes interrupting capacity. A load break disconnect is supplied. ➌ For reduced voltage auto-transformer starter — Add list price from column #1 or #2, or #3 or #4 to column #5 price — This total will be list price for reduced voltage autotransformer — synchronous starter. Also ordering catalog number becomes 14-60_ not 14-20_. ➍ Power Factor Regulation — Note: Cannot provide regulation below 50% of rated voltage and/or 25% of rated current. Regulation cannot be accomplished on light loads, i.e., Iess than 20% load. Not for use with reciprocating compressors. M
Page 1 and 2:
DISTRIBUTION SYSTEM 2 MOLDED CASE C
Page 3 and 4:
MARGIN March 2001 SECONDARY SPOT NE
Page 5 and 6:
PRODUCT DESCRIPTION Molded case cir
Page 7 and 8:
FACTORY ORIGINAL CIRCUIT BREAKERS W
Page 9 and 10:
NEW TECHNOLOGY Digitrip OPTIM is a
Page 11 and 12:
NEW TECHNOLOGY, Continued Digitrip
Page 13 and 14:
Quicklag Plug-in Industrial Circuit
Page 15 and 16:
CHB CIRCUIT BREAKER Originally a Cu
Page 17 and 18:
MOLDED CASE CIRCUIT BREAKER REPLACE
Page 19 and 20:
March 2001 MOLDED CASE CIRCUIT BREA
Page 21 and 22:
C U R R E N T D E S I G N R E P L A
Page 23 and 24:
REPLACEMENT CAPABILITIES, Continued
Page 25 and 26:
Type KB and MARK 75 Type HKB 90-250
Page 27 and 28:
Continuous Ampere Rating at 40°C M
Page 29 and 30:
Special Breakers➍ Trip Units Only
Page 31 and 32:
Continuous Ampere Rating at 40°C 2
Page 33 and 34:
Page 35 and 36:
Terminals➊➋ Two terminals are r
Page 37 and 38:
Page 39 and 40:
Page 41 and 42:
Page 43 and 44:
Page 45 and 46:
Page 47 and 48:
THIS PAGE INTENTIONALLY LEFT BLANK
Page 49 and 50:
Page 51 and 52:
Page 53 and 54:
Page 55 and 56:
Page 57 and 58:
Page 59 and 60:
ACCESSORIES Rear Connected Studs➊
Page 61 and 62:
ACCESSORIES, Continued Extended Lin
Page 63 and 64:
ACCESSORIES, Continued Left Hand Mo
Page 65 and 66:
ACCESSORIES, Continued Alarm Switch
Page 67 and 68:
ACCESSORIES, Continued Motor Operat
Page 69 and 70:
Page 71 and 72:
C U R R E N T D E S I G N O U T O F
Page 73 and 74:
(Includes Terminals on Load Side on
Page 75 and 76:
Type RHK 2-, 3-Poles; 600 Volts AC
Page 77 and 78:
Page 79 and 80:
GENERAL INFORMATION Accessories and
Page 81 and 82:
Page 83 and 84:
SELECTION AND AVAILABILITY GUIDE Ci
Page 85 and 86:
SLIDE PLATE TYPE Vertical Mounting
Page 87 and 88:
TYPE SM SAFETY HANDLE Door Hardware
Page 89 and 90:
AMT VARI-DEPTH Fixed Width Type Typ
Page 91 and 92:
AMT VARI-DEPTH Vari-Width Type Type
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
PRODUCT HISTORY TIMELINE Page Produ
Page 99 and 100:
ORIGINAL CUTLER-HAMMER PANELBOARD B
Page 101 and 102:
Westinghouse Panelboard Type March
Page 103 and 104:
PB/PH/PH-L Originally a Cutler-Hamm
Page 105 and 106:
PRL1 AND PRL2 PANELBOARDS Originall
Page 107 and 108:
PRL4B/PRL4F Originally a Westinghou
Page 109 and 110:
PRODUCT SUPPORT SERVICES Satellite
Page 111 and 112:
PRODUCT HISTORY TIMELINE Originally
Page 113 and 114:
PRODUCT DESCRIPTION Operating Handl
Page 115 and 116:
BUSWAY VS. CABLE AND CONDUIT March
Page 117 and 118:
PRODUCT HISTORY, Continued In 1966,
Page 119 and 120:
Page 121 and 122:
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
IQ ENERGY SENTINEL FOR BUS PLUGS Th
Page 131 and 132:
PRODUCT DESCRIPTION The IQ Metering
Page 133 and 134:
GENERAL INFORMATION Application Ove
Page 135 and 136:
IQ DP-4000/4100 IQ Analyzer Digitri
Page 137 and 138: IQ 2000 March 2001 IQ PRODUCTS Disc
Page 139 and 140: PRODUCT HISTORY March 2001 COMMUNIC
Page 141 and 142: March 2001 COMMUNICATIONS SYSTEMS (
Page 143 and 144: FUNCTION Electronic Device IMPACC S
Page 145 and 146: IMPACC SOFTWARE IMPACC Series III S
Page 147 and 148: 100/110 SERIES 300 SERIES 400 SERIE
Page 149 and 150: PRODUCT DESCRIPTION PRODUCT HISTORY
Page 151 and 152: Size Size 0 1950 1955 1960 1965 197
Page 153 and 154: REPLACEMENT CAPABILITIES Contacts a
Page 155 and 156: REPLACEMENT CAPABILITIES, Continued
Page 157 and 158: Type ST Standard Trip Eutectic Allo
Page 159 and 160: Type ST Standard Trip Eutectic Allo
Page 161 and 162: Type BNC Bimetal For Replacement in
Page 163 and 164: March 2001 CONTACTORS AND STARTERS
Page 165 and 166: March 2001 CONTACTORS AND STARTERS
Page 167 and 168: REPLACEMENT CAPABILITIES, Continued
Page 169 and 170: PRODUCT DESCRIPTION Auto/Manual Res
Page 171 and 172: PRODUCT DESCRIPTION Types A and B E
Page 173 and 174: A202 REPLACEMENT CAPABILITIES, Cont
Page 175 and 176: Literature Number SA-135 SA-175A SA
Page 177 and 178: SUPPORT CHART March 2001 PCB Repair
Page 179 and 180: Model HP Range ➊ Also available w
Page 181 and 182: Originally a Westinghouse Product M
Page 183 and 184: GENERAL INFORMATION Brushless Type
Page 185 and 186: GENERAL INFORMATION Modifications M
Page 187: GENERAL INFORMATION Modifications M
Page 191 and 192: GENERAL INFORMATION March 2001 SYNC
Page 193 and 194: CUSTOMER REQUIRED INFORMATION Ident
Page 195 and 196: PRODUCT DESCRIPTION Originally a We
Page 197 and 198: GENERAL INFORMATION, Continued Typi
Page 199 and 200: GENERAL INFORMATION, Continued SJO
Page 201 and 202: TECHNOLOGY UPGRADES AMPGARD Selecti
Page 205 and 206: TECHNOLOGY UPGRADES, Continued LF S
Page 207 and 208: CUSTOMER REQUIRED INFORMATION Proce
Page 209 and 210: GENERAL INFORMATION Procedure for I
Page 211 and 212: PRODUCT DESCRIPTION Originally a Cu
Page 213 and 214: PRODUCT DESCRIPTION Originally a Cu
Page 217 and 218: INTRODUCTION AND DESCRIPTION Cutler
Page 219 and 220: ADVANTAGE TECHNOLOGY RETROFITS Marc
Page 221 and 222: SERIES C RETROFIT KITS Series C Ret
Page 223 and 224: March 2001 DISTRIBUTION SWITCHBOARD
Page 229 and 230: Clipper Power System Transient Volt
Page 231 and 232: PRODUCT DESCRIPTION Originally A We
Page 233 and 234: FURTHER INFORMATION Literature Numb
Page 235 and 236: SWITCHGEAR (LOW VOLTAGE) DB Assembl
Page 237 and 238: GENERAL INFORMATION DS Switchgear V
Page 239 and 240:
PRODUCT DESCRIPTION March 2001 DS S
Page 241 and 242:
Switchgear Kits and Renewal Parts M
Page 243 and 244:
TECHNOLOGY UPGRADES Application Cut
Page 245 and 246:
CUSTOMER REQUIRED INFORMATION Proce
Page 247 and 248:
March 2001 SWITCHGEAR (TRIP UNIT RE
Page 249 and 250:
March 2001 SWITCHGEAR (TRIP UNIT RE
Page 251 and 252:
➊ 50 Hz rating plugs are availabl
Page 253 and 254:
Past Technology (500/600/700/800) P
Page 255 and 256:
SWITCHGEAR (TRIP UNIT RETROFIT KITS
Page 257 and 258:
CATALOG NUMBER Trip Unit Type 5 Z 6
Page 259 and 260:
Page 261 and 262:
CATALOG NUMBER Trip Unit Type 5 510
Page 263 and 264:
Page 265 and 266:
Page 267 and 268:
Page 269 and 270:
Page 271 and 272:
Page 273 and 274:
Page 275 and 276:
PRODUCT DESCRIPTION Medium Voltage
Page 277 and 278:
SWITCHGEAR (MEDIUM VOLTAGE) DHP Swi
Page 279 and 280:
SWITCHGEAR (MEDIUM VOLTAGE) VCP-W V
Page 281 and 282:
FURTHER INFORMATION Product Literat
Page 283 and 284:
March 2001 SWITCHGEAR (MEDIUM VOLTA
Page 285 and 286:
March 2001 SWITCHGEAR (MEDIUM VOLTA
Page 287 and 288:
PRODUCT DESCRIPTION Medium voltage
Page 289 and 290:
PRODUCT DESCRIPTION CLE and HLE Cur
Page 291 and 292:
Originally a Westinghouse Product M
Page 293 and 294:
INDEX A A10 Contactors and Starters
Page 295 and 296:
INDEX MV, Medium Voltage Switchgear
Page 297 and 298:
INDEX M MA Molded Case Circuit Brea
Page 299 and 300:
INDEX Slide Plate Handle Mechanism
Page 301 and 302:
March 2001 CUTLER-HAMMER SALES OFFI
show all

molded case circuit breakers - Eaton Canada

Create successful ePaper yourself

Delete template?

Save as template?