NAVFAC P-300 Management of Transportation Equipment

More documents

Recommendations

Info

Item Service Item Description A B C 58 X X X Crowd Assembly. Check for proper operation. Adjustment should be made according to the manufacturer's instructions. 59 X X X Boom and Hoist Drum Assemblies. Check drum bearings, bushings, shafting, grease seals, and lagging. 60 X X X Swing Mechanism. Inspect gears, circle, roller path, fins, roller shafts, and bearing seals for wear. Rollers should rotate freely. Swing locks and linkage must operate properly. 61 X X Center Pin, House Carrier, and Hold-Down Rollers. Inspect for wear. Adjust to manufacturer's specifications. 62 X X Travel Mechanism. Inspect and adjust clutches. Inspect travel lock, shafts, and linkage for excessive wear. 63 X X X Gears and Pinions. Check open gears and pinions for proper lubrication. 64 X X X Hammer Links. Check for bending and elongated mounting bolt holes. 65 X X X Jaws, Liners, and Concaves. Check for wear and secure mounting. 66 X X Toggle Assembly. Check plates, seats, wedges, and ways for wear, cracks, and breaks. Check tension spring for adjustment. 67 X X X Eccentric Shaft or Sleeve. Check for wear and leaks. 68 X X X Conveyors and Drives. Check condition of belts and splices, alignment, scrapers and cleaners, tail pulley, chains and buckets, sprockets, and safety guards. L-7
Item Service Item Description A B C 69 X X X Screen and Drives. Check for wear, mounting, alignment, and operation. Check that rivets, bolts, and braces are in place and secure. 70 X X X Bins, Hoppers, and Chutes. Check braces and fastenings. Inspect operation of gates and controls. 71 X X X Mixer Drum. Check cleanliness of drum and mixing flight, chutes, bearings, and trunion rollers for wear. 72 X X X Parts and Components. Check miscellaneous parts and components, as required. L-8
Page 1 and 2:
Naval Facilities Engineering Comman
Page 3 and 4:
21A(1) 22A(1) 23(1) 24(1) 39(2) 41A
Page 5 and 6:
ABSTRACT This publication provides
Page 7 and 8:
CHAPTER 2. ADMINISTRATION CONTENTS
Page 9 and 10:
CONTENTS PAGE NO. 2.14.16 REMOVAL O
Page 11 and 12:
CONTENTS PAGE NO. 3.8.13 ACCIDENT R
Page 13 and 14:
CHAPTER 4. MAINTENANCE CONTENTS PAG
Page 15 and 16:
CHAPTER 5. EQUIPMENT SUPPORT FOR TH
Page 17 and 18:
H-14 H-15 H-16 H-17 H-18 H-19 H-20
Page 19 and 20:
augmented in depth and detail for N
Page 21 and 22:
COMSECONDNCB and COMTHIRDNCB perfor
Page 23 and 24:
1.7.5 Shore Activities a. Review an
Page 25 and 26:
Commands/Major Claimants Holding CE
Page 27 and 28:
duties. Persons who report to a reg
Page 29 and 30:
1.13.5 Transportation Between Resid
Page 31 and 32:
2.1 Assignment CHAPTER 2. ADMINISTR
Page 33 and 34:
Commanding Officers can restrict th
Page 35 and 36:
vehicles and equipment inventory ob
Page 37 and 38:
2.1.9 Assignment to Commissaries, E
Page 39 and 40:
General Policy of Vehicle Assignmen
Page 41 and 42:
2.2.3 COMNAVFACENGCOM IO Review/App
Page 43 and 44:
2.4.3 Transfers of Equipment by NCF
Page 45 and 46:
2.5 Foreign Purchases. The Federal
Page 47 and 48:
d. Direct Materials (1) Cost to rep
Page 49 and 50:
2.8.2 Transportation Equipment P-1
Page 51 and 52:
P1 LINE/LINE ITEM REFERENCE NUMBER
Page 53 and 54:
2.8.4 DBOF Requirements Procedures.
Page 55 and 56:
control. COMNAVFACENGCOM is also th
Page 57 and 58:
c. Funding. The criteria for expens
Page 59 and 60:
(6) Name and telephone number (comm
Page 61:
LEASED VEHICLE REPORT FROM: (Activi
Page 64 and 65:
2.9.10.2 Authority. Activity Comman
Page 66 and 67:
equipment. Vehicles leased from the
Page 68 and 69:
Classification of CESE by Assignmen
Page 70 and 71:
2.10.3 Nonappropriated Fund Vehicle
Page 72 and 73:
follows: (1) Disposal Process. A si
Page 74 and 75:
o. Block 15 - Reimbursement Require
Page 76 and 77:
2.13 Warranties and Deficiencies 2.
Page 78 and 79:
2.13.8 Assistance with CESE Deficie
Page 80 and 81:
e. Camouflage Painting of CESE (NCF
Page 82 and 83:
(2) Location of Markings. (a) Side
Page 84 and 85:
(4) Marking Colors. Painted and ela
Page 86 and 87:
2.14.8 Warning Stripes for Vehicles
Page 88 and 89:
cross on a 4-inch square white fiel
Page 90 and 91:
h. Tie Down Markings. It is recomme
Page 92 and 93:
(4) Provides equipment with operato
Page 94 and 95:
(c) Keys. The Dispatcher controls t
Page 96 and 97:
vehicles involved. Applicants for l
Page 98 and 99:
d. Seabee Automated Mobile Manageme
Page 100 and 101:
(3) Implement revised dispatching p
Page 102 and 103:
CHAPTER 3. OPERATIONS This chapter
Page 104 and 105:
a. Application of the various types
Page 106 and 107:
(3) Public Law 100-180 amended 10 U
Page 108 and 109:
tickets. In considering the type of
Page 110 and 111:
3.3.4 Transportation for Morale, We
Page 112 and 113:
the use of the siren or red light i
Page 114 and 115:
activity assignments, annual utiliz
Page 116 and 117:
h. Column 8 - Ending Inventory. Ent
Page 118 and 119:
3.7 Guidelines for Achieving Motor
Page 120 and 121:
3.9. (See Appendix H Figures H-18 a
Page 122 and 123:
. Vehicles over 10,000 pounds GVW;
Page 124 and 125:
applicants knowledge and operationa
Page 126 and 127:
demonstrate competence in driving t
Page 128 and 129:
(1) Has a manufacturer's gross vehi
Page 130 and 131:
Construction Equipment Requiring Li
Page 132 and 133:
3.9.5 Use and Limitations of Licens
Page 134 and 135:
States Civil Service Commission Cer
Page 136 and 137:
d. Notation on Failures. A short li
Page 138 and 139:
(1) Date Revoked, NAVFAC 11260/3. A
Page 140 and 141:
3.15.2 Equipment Not Replaced by th
Page 142 and 143:
3.20.1 Exceptions. Fire extinguishe
Page 144 and 145:
(1) The sides and the end must be e
Page 146:
(3) Origin and destination of the m
Page 149 and 150:
3.25.5 Work Requests. Requests for
Page 151 and 152:
permit. This on-the-scene level of
Page 153 and 154:
CHAPTER 4. MAINTENANCE SECTION 1. S
Page 155 and 156:
where specialized skills, tooling,
Page 157 and 158:
4-1.7 Maintenance Coordination a. C
Page 159:
the direct labor necessary to maint
Page 163 and 164:
4-1.8.5 Inventory Objective (IO) Co
Page 165 and 166:
4-1.8.8 Direct Labor Productivity.
Page 167 and 168:
g. Copies of any applicable quality
Page 169 and 170:
a. Average inventory levels; b. Mil
Page 171:
23.3
Page 175:
c. Vehicles/equipment in process by
Page 178 and 179:
(8) Assume responsibility for stagi
Page 180 and 181:
(2) Furnish basic information for m
Page 182 and 183:
eturned. (3) A copy shall be retain
Page 184 and 185:
Sample Vehicle Safety Inspection St
Page 186 and 187:
(1) Date of inspection (2) Name and
Page 188 and 189:
(5) On air brake systems, inspect a
Page 190 and 191:
4-1.10.7 Tire Maintenance. Tire and
Page 192 and 193:
4-1.11.2 Operator's Daily Inspectio
Page 194 and 195:
load test. A permanent tram point b
Page 196 and 197:
Device; (2) ANSI A92.2-1979, Vehicl
Page 198 and 199:
protective coatings and adequate ma
Page 200 and 201:
support areas to production bays, c
Page 202 and 203:
epair work that pertains to inspect
Page 204 and 205:
NOTE: Amphibious Construction Batta
Page 206 and 207:
PREVENTIVE MAINTENANCE INSPECTION S
Page 208 and 209:
frequent intervals, shall be the de
Page 210 and 211:
, f. Equipment Downtime. Blocks 27
Page 212 and 213:
42.5 Maintenance Program Evaluation
Page 214 and 215:
(3) CESE Maintenance Cost Check. Th
Page 216 and 217:
The following is a complete list of
Page 218 and 219:
should designate one person, normal
Page 220 and 221:
. Justification. Justification for
Page 222 and 223:
G Major detachments with an interme
Page 224 and 225:
FIGURE 5-1 Allowance Change Request
Page 226 and 227:
NOTE: Manufacturers identify vehicl
Page 228 and 229:
NAVSUP Form 1250-1 5.6.2 Completion
Page 230 and 231:
determined, Block 21 and the first
Page 232 and 233:
When the part is issued, line throu
Page 234 and 235:
Date Dept. No. Req. No. UND Nomencl
Page 236 and 237:
APPENDIX A. DEFINITIONS AND TERMS N
Page 238 and 239:
Incidental Driver. A person, other
Page 240 and 241:
and wreckers. The term includes veh
Page 242 and 243:
CFE CONTRACTOR FURNISHED EQUIPMENT
Page 244 and 245:
JAG JUDGE ADVOCATE GENERAL JCCO JOI
Page 246 and 247:
RFI READY FOR ISSUE RIC REPAIRABLE
Page 248 and 249:
APPENDIX C PREPARATION INSTRUCTIONS
Page 250 and 251:
(10) Excess/Remarks. Completed by C
Page 252 and 253:
APPENDIX D. ATTACHMENT MANAGEMENT F
Page 254 and 255:
First Segment List of Attachment Id
Page 256 and 257:
Equipment Attachment Registration R
Page 258 and 259:
. Transfer to Another Activity. Unl
Page 260 and 261:
(1) The Bulk type is open and used
Page 262 and 263:
. Surveillance. In all instances wh
Page 264 and 265:
17. Technical Manuals. Technical ma
Page 266 and 267:
National Stock Number/Navy Item Con
Page 268 and 269:
3. Claimants requiring specialized
Page 270 and 271:
APPENDIX F. REPLACEMENT AND REPAIR
Page 272 and 273:
NAVFAC Life Expectancy Equip. Alpha
Page 274 and 275:
Page 276 and 277:
Page 278 and 279:
8252 Y CRANE CARRIER TORPEDO HANDLI
Page 280 and 281:
Table G-1 of this Appendix, select
Page 282 and 283:
COLUMN (1) EQUIP. CODE. List NAVFAC
Page 284 and 285:
NAVFAC Equip. Code Alpha Code Man-h
Page 286 and 287:
Page 288 and 289:
Page 290 and 291:
Page 292 and 293:
Page 294 and 295:
APPENDIX H (FORMS)
Page 296 and 297:
ACTIVITY NAME NAVSTA ADAK CLAIMANT
Page 298 and 299:
CRANE REQUIREMENTS DATA SHEET (Cont
Page 300 and 301:
CRANE REQUIREMENTS DATA SHEET (Samp
Page 302 and 303:
ACCESSORIES: TRUCK TRACTOR DATA SHE
Page 304 and 305:
TRUCK TRACTOR DATA SHEET (USER REQU
Page 306 and 307:
ECONOMIC ANALYSIS Cost Factors (Con
Page 308 and 309:
Report of Excess Personal Property
Page 310 and 311:
Quality Deficiency Report (SF-3681
Page 312 and 313:
Quality Deficiency Report (Sample)
Page 314 and 315:
Motor Equipment Utilization Record
Page 316 and 317:
Dispatcher’s Log: (NAVFAC Form 11
Page 319 and 320:
Alpha Code Description Figure H-15
Page 321 and 322:
Construction Equipment Operator’s
Page 323:
Application for Construction Equipm
Page 326:
Operator’s Inspection Guide and T
Page 329 and 330:
Maintenance Inspection/Service Reco
Page 331 and 332:
DoD PROPERTY RECORD (DD 1342) H-37
Page 333 and 334:
Figure H-26 (cont’d) 16 Manufactu
Page 335 and 336:
(2) Cylinders make, model, Mfr. par
Page 337 and 338: 54. Remarks. Block Entry A. Transac
Page 341 and 342: STEP 1 Equipment Repair Order Flow
Page 343 and 344: NOTE: If repair parts required are
Page 345 and 346: APPENDIX I. TRANSPORTATION EQUIPMEN
Page 347 and 348: TRANSACTION CODES Transaction Codes
Page 349 and 350: Code Title Definition STATUS CODES
Page 351 and 352: (1) Primer (wash) pretreatment TABL
Page 353 and 354: TABLE J-1. Paint National Stock Num
Page 355 and 356: 1 Wash with liquid detergent, NSN 7
Page 357 and 358: R = REFERENCE DISTANCE B = BAND WID
Page 359 and 360: Vehicle and Equipment Colors and Ma
Page 361 and 362: 3. Corrosion Control a. Corrosion C
Page 363 and 364: DOT Placard for Flammables Figure J
Page 365 and 366: Locations of Markings Figure J-6 J-
Page 367 and 368: Locations of Markings Figure J-6 (c
Page 377 and 378: APPENDIX K. NAVAL CONSTRUCTION FORC
Page 379 and 380: Item Service Item Description A B C
Page 387: Item Service Item Description A B C
Page 391 and 392: d. CF4 - High-Speed Four-Stroke-Cyc
Page 393 and 394: COMMERCIAL HD ENGINE OILS Military
Page 395 and 396: GEAR LUBRICANTS Military Military S
Page 397 and 398: police cars, etc.) or under severe
Page 399 and 400: 6. Miscellaneous Lubricants PTL Lub
Page 401 and 402: Section 2. APPROVED FUELS FOR USE B
Page 403 and 404: Military Symbol Quantity NSN DFA (U
Page 405 and 406: d. If cost effective, use an antifr
Page 407 and 408: . MIL-C-16173. Extended under cover
Page 409 and 410: h. MIL-G-10924. For the lubrication
Page 411 and 412: APPENDIX N. LIVE STORAGE FOR CIVIL
Page 413 and 414: FIGURE N-2. Live Storage Service Sh
Page 415 and 416: (c) Batteries are fully charged and
Page 417 and 418: (5) Any Direct Turnover (DTO) parts
Page 419 and 420: Department of Transportation, 400 S
Page 421 and 422: Occupational Safety and Health Act
Page 423 and 424: PARAGRAPH TOPIC PAGE 2.3 BUDGETING
Page 425 and 426: PARAGRAPH TOPIC PAGE 2.1.2.a(4) EXE
Page 427 and 428: PARAGRAPH TOPIC PAGE 5.1 LOGISTIC S
Page 429 and 430: PARAGRAPH TOPIC PAGE 3.19 PAYMENT O
Page 431 and 432: PARAGRAPH TOPIC PAGE 4-1.9.4 SUPPLY
show all

NAVFAC P-300 Management of Transportation Equipment

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?