BC-3500 Series - Rowe International

More documents

Recommendations

Info

Section 4: Troubleshooting DETCTRS ON LONG Symptom: While replenishing, more than one detector was blocked too long. Corrective Action: During the last replenish cycle, the system detected a coin pulse from the dispenser that was much longer than normal. Most likely, an incorrect change load has been deposited into one of the change buckets. 1. A detector LED could have burned out during the replenish cycle. If the LEDs are lit, reset the bill changer and see if it goes back into SHUTDOWN. If so, refer to new status message that will appear. 2. If the bill changer stays in service, then check the photo detectors (per Section 3) and wiring. 3. If all three LEDs are not lit, check the +5 VDC LED on the power supply. If the +5 VDC LED is OFF, check the power supply. If the +5 VDC LED is ON, check the harness. 4. Also, check the upper coin chute for anything that would hold a coin up and block the detectors. 5. If everything looks OK, replace the CCC. 6. To restore the bill changer to service, press the FUNCTION button after correcting the problem. For a more complete troubleshooting sequence, refer to Troubleshooting Chart 040 at the end of this DETECTOR troubleshooting. 25238801 4-37
<strong>BC</strong>-<strong>3500</strong> Bill and Coin Changer CANNOT PAYOUT VALUE Symptom: Unable to pay out inserted combination. Corrective Action: Check to make sure the coin mechanism is wired correctly. Reset by pressing the FUNCTION button. ERROR ?? Symptom: Unknown error code xxx. Corrective Action: The changer detected an unknown error. 1. Press the FUNCTION button to reset the bill changer. 2. Run a few test vends. 3. If the error returns, replace the CCC. 4. If OK, put the changer back in service and watch for recurrence of the error. 4-38 25238801
Page 1 and 2:
R BC-3500 Bill & Coin Changer with
Page 3 and 4:
WARNING: This equipment generates,
Page 5 and 6:
SECTION 1 — SYSTEM DESCRIPTION Ta
Page 7 and 8:
SECTION 4 — TROUBLESHOOTING Table
Page 9 and 10:
Figure 1-1. BC-3500 Major Component
Page 11 and 12:
BC-3500 Bill and Coin Changer The c
Page 13 and 14:
BC-3500 Bill and Coin Changer • I
Page 15 and 16:
BC-3500 Bill and Coin Changer Coin
Page 17 and 18:
BC-3500 Bill and Coin Changer Tempo
Page 19 and 20:
BC-3500 Bill and Coin Changer STATU
Page 21 and 22:
BC-3500 Bill and Coin Changer This
Page 23 and 24:
BC-3500 Bill and Coin Changer CONNE
Page 25 and 26:
BC-3500 Bill and Coin Changer There
Page 27 and 28:
BC-3500 Bill and Coin Changer Figur
Page 29 and 30:
BC-3500 Bill and Coin Changer 13. P
Page 31 and 32:
BC-3500 Bill and Coin Changer IF AN
Page 33 and 34:
BC-3500 Bill and Coin Changer Use t
Page 35 and 36:
BC-3500 Bill and Coin Changer 16. P
Page 37 and 38:
BC-3500 Bill and Coin Changer 1. In
Page 39 and 40:
BC-3500 Bill and Coin Changer Token
Page 41 and 42:
BC-3500 Bill and Coin Changer 3. Us
Page 43 and 44:
BC-3500 Bill and Coin Changer 4. If
Page 45 and 46:
BC-3500 Bill and Coin Changer 7. Th
Page 47 and 48:
BC-3500 Bill and Coin Changer CLEAN
Page 49 and 50: BC-3500 Bill and Coin Changer CHANG
Page 51 and 52: BC-3500 Bill and Coin Changer Coin
Page 53 and 54: BC-3500 Bill and Coin Changer BILL
Page 55 and 56: BC-3500 Bill and Coin Changer Adjus
Page 57 and 58: BC-3500 Bill and Coin Changer Adjus
Page 59 and 60: BC-3500 Bill and Coin Changer Bill
Page 61 and 62: BC-3500 Bill and Coin Changer 2. Ad
Page 63 and 64: BC-3500 Bill and Coin Changer Timin
Page 65 and 66: BC-3500 Bill and Coin Changer Seque
Page 67 and 68: BC-3500 Bill and Coin Changer Index
Page 69 and 70: BC-3500 Bill and Coin Changer VALID
Page 71 and 72: BC-3500 Bill and Coin Changer REJEC
Page 79 and 80: BC-3500 Bill and Coin Changer BILL
Page 83 and 84: BC-3500 Bill and Coin Changer Trans
Page 85 and 86: BC-3500 Bill and Coin Changer Machi
Page 87 and 88: BC-3500 Bill and Coin Changer CK TE
Page 89 and 90: BC-3500 Bill and Coin Changer Chang
Page 91 and 92: BC-3500 Bill and Coin Changer Chart
Page 93 and 94: BC-3500 Bill and Coin Changer 4. If
Page 95 and 96: BC-3500 Bill and Coin Changer CK CO
Page 97 and 98: BC-3500 Bill and Coin Changer L DET
Page 99: BC-3500 Bill and Coin Changer R DET
Page 103 and 104: BC-3500 Bill and Coin Changer EXTRA
Page 105 and 106: BC-3500 Bill and Coin Changer Chart
Page 107 and 108: BC-3500 Bill and Coin Changer C HOP
Page 109 and 110: BC-3500 Bill and Coin Changer HOPPE
Page 111 and 112: BC-3500 Bill and Coin Changer CK ST
Page 113 and 114: BC-3500 Bill and Coin Changer BUCKE
Page 119 and 120: BC-3500 Bill and Coin Changer One o
Page 127 and 128: BC-3500 Bill and Coin Changer DETAI
Page 129 and 130: BC-3500 Bill and Coin Changer Sheet
Page 131 and 132: 1 2 3 4 5 6 7 8 9 BC-3500 Bill and
Page 133 and 134: BC-3500 Bill and Coin Changer 4-70
Page 135 and 136: BC-3500 Bill and Coin Changer Y 36
Page 137 and 138: BC-3500 Bill and Coin Changer P802
Page 139 and 140: BC-3500 Bill and Coin Changer Power
Page 141 and 142: BC-3500 Bill and Coin Changer 45072
Page 143 and 144: BC-3500 Bill and Coin Changer Inter
Page 145 and 146: BC-3500 Bill and Coin Changer 4-82
Page 147 and 148: BC-3500 Bill and Coin Changer Magne
Page 149 and 150: BC-3500 Bill and Coin Changer AD [
Page 151 and 152:
BC-3500 Bill and Coin Changer 30 VD
Page 153 and 154:
BC-3500 Bill and Coin Changer 12 VD
Page 155 and 156:
BC-3500 Bill and Coin Changer R110
Page 157 and 158:
BC-3500 Bill and Coin Changer Compu
Page 159 and 160:
Page 161 and 162:
Page 163 and 164:
Page 165 and 166:
BC-3500 Bill and Coin Changer DIREC
Page 167 and 168:
BC-3500 Bill and Coin Changer BL +
Page 169 and 170:
BC-3500 Bill and Coin Changer 35134
Page 171 and 172:
BC-3500 Bill and Coin Changer Inter
Page 173 and 174:
BC-3500 Bill and Coin Changer FUNCT
Page 175 and 176:
BC-3500 Bill and Coin Changer This
Page 177 and 178:
DIGIT 1 = MODEL IDENTIFICATION 5 =
Page 179 and 180:
Figure 6-1. Bill and Changer Assemb
Page 181 and 182:
Table 6-1. Replacement Cabinet Part
Page 183 and 184:
Figure 6-2. Top Cabinet Assembly Sh
Page 185 and 186:
Figure 6-2. Top Cabinet Assembly Sh
Page 187 and 188:
Figure 6-3. Front Door Assembly 6-1
Page 189 and 190:
Figure 6-4. Base Cabinet Assembly 1
Page 191 and 192:
Figure 6-5. BA-50 Bill Acceptor Ass
Page 193 and 194:
Figure 6-5. BA-50 Bill Acceptor Ass
Page 195 and 196:
Figure 6-6. Power Control Center As
Page 197 and 198:
Figure 6-7. Control Computer Assemb
Page 199 and 200:
C B E Figure 6-8. Coin Dispenser As
Page 201 and 202:
Figure 6-9. Change Bucket Assembly
Page 203 and 204:
R Figure 6-10. Hi-Capacity Hopper A
Page 205 and 206:
Figure 6-11A. Coin Acceptor Bracket
Page 207 and 208:
Figure 6-11B. Coin Acceptor Bracket
Page 209 and 210:
Figure 6-12. Dual Bill Stacker Asse
Page 211 and 212:
Figure 6-12. Dual Bill Stacker Asse
Page 213 and 214:
Figure 6-13. Coin Inlet and Chute A
Page 215:
ACCESSORY KITS 35080605 Nylon Press
show all

BC-3500 Series - Rowe International

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?