BC-3500 Series - Rowe International

More documents

Recommendations

Info

Section 4: Troubleshooting P803 1 2 3 12 VDC 8 VDC 4 R801 1.2 KΩ C814 .33 µF @ 50V 5 6 7 8 9 POWER GROUND COMMON 10 11 TRANSPORT GROUND 12 13 OUT OF SERVICE LAMP D801 + C810 2200 µF @ 16V 12 VDC P804 D812 1 2 3 4 5 6 7 5 VDC SWITCHED 30 VDC VR802 REG. FIXED +5V + C807 1000 µF @ 10V + C808 22 µF @ 10V R802 470 Ω D802 5 VDC P807 1 2 3 4 5 6 7 120 VAC SWITCHED 120 VAC HOT + C809 2200 uF @ 16V D809 P805 1 2 3 4 5 6 7 30 VDC 8 9 40 VDC SWITCHED D808 10 11 120 VAC NEUTRAL R803 5.6 KΩ 1/2 W 12 13 14 POWER CONTROL RELAY 15 16 17 D803 18 EARTH GROUND K801 40 VDC R834 82 Ohm 1 W P807 1 2 3 To R813 R812 12 KΩ LEFT TEST S803 P801 R810 1 KΩ + C802 4.7 µF S802 CENTER TEST S801 1 2 3 4 5 6 7 LEFT TEST SWITCH CENTER TEST SWITCH RIGHT TEST SWITCH BUCKET CURRENT SENSE - BUCKET CURRENT SENSE + RIGHT TEST Figure 4-2. Schematic Diagram - Power Supply 25238801 4-75
BC-3500 Bill and Coin Changer Power Supply Circuit Board Assembly - 65069203 (Rev. A) C801 Capacitor - Electrolytic 50 VDC 4.7 µF 70023806 C802 Capacitor - Electrolytic 50 VDC 4.7 µF 70023806 C803 Capacitor - Electrolytic 35 VDC 6800 µF 70023601 C804 Capacitor - Electrolytic 63 VDC 2200 µF 70023610 C807 Capacitor - Electrolytic 10 VDC 1000 µF 70028117 C808 Capacitor - Tantalum 16 VDC 2200 µF 70025104 C809 Capacitor - Electrolytic 16 VDC 2200 µF 70028311 C810 Capacitor - Electrolytic 16 VDC 2200 µF 70028311 C811 Capacitor - Electrolytic 50 VDC 1000 µF 70028309 C812 Capacitor - Electrolytic 50 VDC 220 µF 70028305 C813 Capacitor - Tantalum 20 VDC 2.2 µF 70025107 C814 Capacitor - Mylar 100 VDC .33 µF 70021555 C815 Capacitor - Electrolytic 63 VDC 2200 µF 70023610 C816 Capacitor - Electrolytic 50 VDC 4700 µF 70023604 D801 Diode - Light Emitting (Red) 90° 70035201 D802 Diode - Light Emitting (Red) 90° 70035201 D803 Diode - Light Emitting (Red) 90° 70035201 D804 Diode - Light Emitting (Red) 90° 70035201 D806 Diode - Silicon MR752 70035010 D807 Diode Bridge 21822506 D808 Diode - Silicon 1N4004 70035005 D809 Diode - Silicon 1N4004 70035005 D812 Diode - Silicon 1N4004 70035005 D813 Diode - Silicon MR820 70035017 D814 Diode - Silicon MR820 70035017 D815 Diode - Silicon MR820 70035017 D816 Diode - Silicon 1N4004 70035005 D817 Diode - Silicon 1N4004 70035005 D818 Diode - Silicon 1N4004 70035005 D819 Diode - Silicon MR752 70035010 K801 Relay - Power 35066802 L801 Inductor 200 µH 21513502 L803 Inductor 200 µH 21513502 L804 Inductor 200 µH 21513502 P801 Header - Polarized 7 Circuit 70075007 P802 Header - Polarized 6 Circuit 70075006 P803 Header - Polarized 13 Circuit 70075013 P804 Header - Polarized 7 Circuit 70075007 P805 Header - Polarized 18 Circuit 70075018 P806 Header - Polarized 7 Circuit 70075007 P807 Header - Polarized 3 Circuit 70075003 4-76 25238801
Page 1 and 2:
R BC-3500 Bill & Coin Changer with
Page 3 and 4:
WARNING: This equipment generates,
Page 5 and 6:
SECTION 1 — SYSTEM DESCRIPTION Ta
Page 7 and 8:
SECTION 4 — TROUBLESHOOTING Table
Page 9 and 10:
Figure 1-1. BC-3500 Major Component
Page 11 and 12:
BC-3500 Bill and Coin Changer The c
Page 13 and 14:
BC-3500 Bill and Coin Changer • I
Page 15 and 16:
BC-3500 Bill and Coin Changer Coin
Page 17 and 18:
BC-3500 Bill and Coin Changer Tempo
Page 19 and 20:
BC-3500 Bill and Coin Changer STATU
Page 21 and 22:
BC-3500 Bill and Coin Changer This
Page 23 and 24:
BC-3500 Bill and Coin Changer CONNE
Page 25 and 26:
BC-3500 Bill and Coin Changer There
Page 27 and 28:
BC-3500 Bill and Coin Changer Figur
Page 29 and 30:
BC-3500 Bill and Coin Changer 13. P
Page 31 and 32:
BC-3500 Bill and Coin Changer IF AN
Page 33 and 34:
BC-3500 Bill and Coin Changer Use t
Page 35 and 36:
BC-3500 Bill and Coin Changer 16. P
Page 37 and 38:
BC-3500 Bill and Coin Changer 1. In
Page 39 and 40:
BC-3500 Bill and Coin Changer Token
Page 41 and 42:
BC-3500 Bill and Coin Changer 3. Us
Page 43 and 44:
BC-3500 Bill and Coin Changer 4. If
Page 45 and 46:
BC-3500 Bill and Coin Changer 7. Th
Page 47 and 48:
BC-3500 Bill and Coin Changer CLEAN
Page 49 and 50:
BC-3500 Bill and Coin Changer CHANG
Page 51 and 52:
BC-3500 Bill and Coin Changer Coin
Page 53 and 54:
BC-3500 Bill and Coin Changer BILL
Page 55 and 56:
BC-3500 Bill and Coin Changer Adjus
Page 57 and 58:
BC-3500 Bill and Coin Changer Adjus
Page 59 and 60:
BC-3500 Bill and Coin Changer Bill
Page 61 and 62:
BC-3500 Bill and Coin Changer 2. Ad
Page 63 and 64:
BC-3500 Bill and Coin Changer Timin
Page 65 and 66:
BC-3500 Bill and Coin Changer Seque
Page 67 and 68:
BC-3500 Bill and Coin Changer Index
Page 69 and 70:
BC-3500 Bill and Coin Changer VALID
Page 71 and 72:
BC-3500 Bill and Coin Changer REJEC
Page 73 and 74:
Page 75 and 76:
Page 77 and 78:
Page 79 and 80:
BC-3500 Bill and Coin Changer BILL
Page 81 and 82:
Page 83 and 84:
BC-3500 Bill and Coin Changer Trans
Page 85 and 86:
BC-3500 Bill and Coin Changer Machi
Page 87 and 88: BC-3500 Bill and Coin Changer CK TE
Page 89 and 90: BC-3500 Bill and Coin Changer Chang
Page 91 and 92: BC-3500 Bill and Coin Changer Chart
Page 93 and 94: BC-3500 Bill and Coin Changer 4. If
Page 95 and 96: BC-3500 Bill and Coin Changer CK CO
Page 97 and 98: BC-3500 Bill and Coin Changer L DET
Page 99 and 100: BC-3500 Bill and Coin Changer R DET
Page 101 and 102: BC-3500 Bill and Coin Changer CANNO
Page 103 and 104: BC-3500 Bill and Coin Changer EXTRA
Page 105 and 106: BC-3500 Bill and Coin Changer Chart
Page 107 and 108: BC-3500 Bill and Coin Changer C HOP
Page 109 and 110: BC-3500 Bill and Coin Changer HOPPE
Page 111 and 112: BC-3500 Bill and Coin Changer CK ST
Page 113 and 114: BC-3500 Bill and Coin Changer BUCKE
Page 119 and 120: BC-3500 Bill and Coin Changer One o
Page 121 and 122: BC-3500 Bill and Coin Changer Bill
Page 127 and 128: BC-3500 Bill and Coin Changer DETAI
Page 129 and 130: BC-3500 Bill and Coin Changer Sheet
Page 131 and 132: 1 2 3 4 5 6 7 8 9 BC-3500 Bill and
Page 133 and 134: BC-3500 Bill and Coin Changer 4-70
Page 135 and 136: BC-3500 Bill and Coin Changer Y 36
Page 137: BC-3500 Bill and Coin Changer P802
Page 141 and 142: BC-3500 Bill and Coin Changer 45072
Page 143 and 144: BC-3500 Bill and Coin Changer Inter
Page 145 and 146: BC-3500 Bill and Coin Changer 4-82
Page 147 and 148: BC-3500 Bill and Coin Changer Magne
Page 149 and 150: BC-3500 Bill and Coin Changer AD [
Page 151 and 152: BC-3500 Bill and Coin Changer 30 VD
Page 153 and 154: BC-3500 Bill and Coin Changer 12 VD
Page 155 and 156: BC-3500 Bill and Coin Changer R110
Page 157 and 158: BC-3500 Bill and Coin Changer Compu
Page 165 and 166: BC-3500 Bill and Coin Changer DIREC
Page 167 and 168: BC-3500 Bill and Coin Changer BL +
Page 169 and 170: BC-3500 Bill and Coin Changer 35134
Page 171 and 172: BC-3500 Bill and Coin Changer Inter
Page 173 and 174: BC-3500 Bill and Coin Changer FUNCT
Page 175 and 176: BC-3500 Bill and Coin Changer This
Page 177 and 178: DIGIT 1 = MODEL IDENTIFICATION 5 =
Page 179 and 180: Figure 6-1. Bill and Changer Assemb
Page 181 and 182: Table 6-1. Replacement Cabinet Part
Page 183 and 184: Figure 6-2. Top Cabinet Assembly Sh
Page 185 and 186: Figure 6-2. Top Cabinet Assembly Sh
Page 187 and 188: Figure 6-3. Front Door Assembly 6-1
Page 189 and 190:
Figure 6-4. Base Cabinet Assembly 1
Page 191 and 192:
Figure 6-5. BA-50 Bill Acceptor Ass
Page 193 and 194:
Figure 6-5. BA-50 Bill Acceptor Ass
Page 195 and 196:
Figure 6-6. Power Control Center As
Page 197 and 198:
Figure 6-7. Control Computer Assemb
Page 199 and 200:
C B E Figure 6-8. Coin Dispenser As
Page 201 and 202:
Figure 6-9. Change Bucket Assembly
Page 203 and 204:
R Figure 6-10. Hi-Capacity Hopper A
Page 205 and 206:
Figure 6-11A. Coin Acceptor Bracket
Page 207 and 208:
Figure 6-11B. Coin Acceptor Bracket
Page 209 and 210:
Figure 6-12. Dual Bill Stacker Asse
Page 211 and 212:
Figure 6-12. Dual Bill Stacker Asse
Page 213 and 214:
Figure 6-13. Coin Inlet and Chute A
Page 215:
ACCESSORY KITS 35080605 Nylon Press
show all

BC-3500 Series - Rowe International

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?