5-speed manual gearbox 0A4.pdf

Carry out procedure as follows:
Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤
5-speed manual gearbox 0A4 - Edition 04.2010
– Remove complete air filter housing if bracket -A- to secure
gear selector cable and gate selector cable are not accessible
⇒ Rep. Gr. 23 ; Repairing diesel direct injection system or ⇒
Rep. Gr. 24 ; Repairing injection system .
– Pull locking mechanisms on gate selector cable and gear selector
cable end-pieces forward to stop -direction of arrow 1-
and then turn to left to lock -direction of arrow 2-.
Secure selector shaft as follows:
– Press selector shaft down in -direction of arrow 1-.
– While pressing down selector shaft, turn angled rod -A- in
-direction of arrow 2- upwards and at the same time press it in
until it engages in selector shaft.
– Remove gaiter with selector knob and cover ⇒ page 61 .
– If noise insulation is present, remove it.
Secure selector lever as follows:
– Select neutral using gear lever.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by Volkswagen AG. Volkswagen AG does not guarantee or accept any liability with respect to the correctness of information
in this document. Copyright by Volkswagen AG.
– Guide locking pin -T10027 A- through hole -A- into hole -B-.
2. Repairing selector mechanism 81