DELOREAN WORKSHOP MANUAL - Free

U
1
n
PRE DELIVERY INSPECTION
After each operation has been completed tick corresponding box | i^* 1
VEHICLE INTERIOR
1 Check operation of instruments, '•
controls, interior/exterior lights.
horns, seal adjustment, window
operation, electric door locks.
2. Check wipers and washers. ad|iist as I
required
3 Check seat belts lor condition and
correcl operation ol mechanism and
buckles
4 Check solt and hard trim for damage
and attachment
VEHICLE EXTERIOR
5 Check and adjust tyre pressures
including spare
6 Check wheel nut torque
7 Check alignment and adjusi if
required, doors, hook and engine
compartment lid and louvre
8 Check operation of hood and engine
compartment lock
9 Check and adjust headlamps
UNDER HOOD
10 Check brake fluid
11 Check clutch fluid
12. Check windshield washer fluid
13 Check tool kit lor completeness
14 Check luggage compartment light
15 Check carpet lor fit and fastening
ENGINE COMPARTMENT
16 Check/Top up Engine oil
Cooling mixture and protection
Auto transmission fluid
17 Check cooling system lor leaks
18 Check fuel system (or leaks.
19 Check engine compartment light
ON HOIST
20 Check tyres lor damage /specification
21 Check brake hoses/pipes lor leaks,
damage and dialing
22 Check gaiteis of dnveshalts lor
damage/leaks
23 Check steering/suspension linkages,
ball joints and gaiters/boots for
damage, and security
24 Check and top manual transmission
j oil and final drive oil (automatic)
25 Check exhaust lor leaks/damage
26 Check coolant and Kiel pipes for
leaks/damage and chafing
ROAD OR ROLLER TEST
27 Chock operation and font lion ol
engine drive performance
28 Operation ol handbrake, loot hrake,
clutch, ant. transmission, kick down
and shifting steering, speedometer,
heater am! air conditioning
29 General check for squeaks and rattles
ON HOIST AFTER ROAD OR
ROLLER TEST
Check and correct
30 Cooling system for leaks
31 Engine oil leaks
32 Transmission for leaks
33 Fuel system lor leak
34 Riake system for leaks
35 Tront I oe In
36 Hear 1 oe In
3? ('lean exterior and interior
Work carried on! hy
Vehicle approved lor delivery
Service Manager
DEALER CERTIFICATE
PDI DATE MILES RO No
We hereby c ortily that this motor vehicle conforms to all applicable
emission standards ol the U S Environmental Protection Agency This
certificate is being made upon the basis of
(1) our knowledge that the vehicle is covered by an EPA certificate of
conformity based on written notification furnished by the
manufacturer
(21 a visible inspection of emission control devices of portions thereof
which are visible without removal or adjustment of any component or
vstem of the vehicle Based on such inspection, there are no
larent deficiencies in the installation of such devices by the
jfaclurer I emission control devices is limited to all devices
tiled on a vehicle for the sole or primary purpose of controlling
i le emissions and which were not in general use prior to 1968). and
performancy of all emission related preparation required by the
iifar.lurer prior to the sale of the vehicle as set forth in the
nit pre delivery service instructions provided by the manufacturer
iu It: fails an EPA approved emission test prior to the expiration
nonths or 4 000 miles (whichever occurs first) from the date or
at lite lime of delivery of the vehicle to the ultimate purchaser
ompany cars and demonstrators), and the vehicle has been
mil iied and used in accordance with the written instructions for proper
marnlenance and use then the vehicle manufacturer shall remedy the non
conformity under the DMC emission performance warranty given to you
fhe dealer certification shall not be construed as either a representative
or a warranty, express or complied by the dealer that the emission control
system or any part thereof it without defect or that the system will
properly perform The emission performance warranty referred lo above is
solely that of the manufacturer
OWNERS ACCEPTANCE CERTIFICATE
I have inspected the above vehicle and accept it without any visible
damage and complete with owner s manual
owner s III
llUllllKMl,
e schedule/record
wairanly Statement/lilt Of mation j
SI(,NAM)ll[/()Alf
vehicle/emission'battery |
tyres
sound system
o
(D
D
CD
—i
O
0)
r+
0)