JOINT FLEET MAINTENANCE MANUAL

More documents

Recommendations

Info

COMFLTFORCOMINST 4790.3 REV A CH-3 REF/D/DOC/COMFLTFORCOMINST 4790.3// AMPN/REF D IS JOINT FLEET MAINTENANCE MANUAL// REF/E/TEL/COMSUBLANT/(DD MM YY)//(CONFIRMING STRL SCHEDULE) AMPN/REF E IS TELCON BETWEEN (ORIGINATOR ACTIVITY)/(PERSON'S NAME) AND (CALLED ACTIVITY)/(PERSON'S NAME) OR (SUPERVISING AUTHORITY)(SUBSIG II)// RMKS/1. IRT REF A AND IAW REF B THROUGH D, THE FOLLOWING ASSIGNMENTS APPLY FOR (STRL UNIT NAME AND HULL NO.) SEA TRIALS OCCURRING PD: (DD-DDMMM) (ALPHA 70% TD) AND (DD-DDMMM) (BRAVO 100% TD). A. DSRV SUPPORT SHIP - USS (MOSUB NAME AND HULL NO.) B. RESCUE PORT - C. RESCUE PORT REPRESENTATIVE - D. RESCUE AIRFIELD - 2. FOR CNO, UNODIR, INTEND TO IMPLEMENT REF C RECOMMENDATIONS TO COMPENSATE FOR LOW (LESS THAN 1.0 FT) TRANSVERSE METACENTRIC HEIGHT (GM) CONDITION WITH DSRV INSTALLED ON MOSUB. 3. FOR COMSUBGRU TWO USS (MOSUB): TO CORRECT CONDITION OF PARA 2, ACCOMPLISH FOLLOWING IF ACTUAL RESCUE OPS WITH DSRV REQUIRED: A. OFF-LOAD TORPEDOES AS REQUIRED BY REF C (REMAINING TORPEDOES MAY BE TUBE LOADED OR STOWED IN LOWER RACKS) B. REDUCE STORES AS REQUIRED BY REF C, APPROXIMATELY: - DRY--(SPECIFY) LBS (LOWER AND MIDDLE LEVEL) - FROZEN--(SPECIFY) LBS - CHILL--(SPECIFY) LBS C. CONVERT AUX 2 TO VARIABLE BALLAST TANK AND PRESS FULL WITH WATER (FRESH WATER IS ACCEPTABLE). RETAIN STORED CONTENTS OF AUX 2 ON BOARD, SECURED LOW IN TORPEDO ROOM. USS (MOSUB NAME) VERIFY ABILITY TO COMPLY WITH SUBPARA C AND REPORT RESULTS TO COMSUBLANT INFO (COMSUBGRU/RON (ISIC)). 4. AS REQUIRED REF A AND IAW REF D SUBSIG II IS APPROVED AS ESCORT FOR (STRL UNIT) SEA TRIALS OCCURRING (DD-DDMMM). THIS CONFIRMS REF E. 5. FOR (COMSUBGRU/RON (ISIC)), PROVIDE GOLD DOLPHIN RIDER ONBOARD SUBSIG II. 6. FOR (STRL UNIT), INCLUDE THE FOLLOWING INFO ADDEES ON FINAL TEST DEPTH DEEP DIVE CHECK REPORT: COMSUBPAC PEARL HARBOR HI, COMSUBDEVRON FIVE SILVERDALE WA, AND DSU SAN DIEGO CA. 7. DIRLAUTH ALCON FOR EVENT SCHEDULES AND SCHEDULE CHANGES.// BT NOTE: ENSURE MESSAGES ARE IN ACCORDANCE WITH NTP-3 FORMAT AND CURRENT PLAD IS UTILIZED. I-2J-2
APPENDIX K COMFLTFORCOMINST 4790.3 REV A CH-3 SAMPLE TYCOM MESSAGE TO PCU CONCERNING USE OF THE FBW SCS IN SUPPORT OF ALPHA SEA TRIALS (SUBMARINES) FROM: COMSUB// TO: PRECOMUNIT // INFO CNO WASHINGTON DC COMNAVSEASYSCOM WASHINGTON DC COMFLT COMSUBGRU COMSUBRON BT UNCLAS // N09094 // MSGID/GENADMIN/COMSUB// SUBJ/(SUBS) PRECOMUNIT AUTHORIZATION TO USE THE FLY-BY-WIRE SHIP CONTROL SYSTEM IN SUPPORT OF ALPHA SEA TRIALS// REF/A/MSG/COMNAVSEASYSCOM/// {G.2.2} REF/B/MSG////{G.2.3} REF/C/LTR/COMSUB/// REF/D/LTR/NAVSEA/// REF /E/LTR NAVSEA SERNO./DATE NARR/REF A IS NAVSEA FLY-BY-WIRE SHIP CONTROL SYSTEM MATERIAL CONDITION READINESS REPORT AND ALPHA SEA TRIALS RECOMMENDATION FOR . REF B IS REPORT OF FAST CRUISE COMPLETION AND READINESS OF FLY-BY-WIRE SHIP CONTROL SYSTEM FOR ALPHA SEA TRIALS. REF C CONCURRED WITH THE SEA TRIALS AGENDA. REF D APPROVED THE SEA TRIALS AGENDA.// RMKS/1. REF A CERTIFIED THE FLY-BY-WIRE SHIP CONTROL SYSTEM MATERIAL CONDITION OF SATISFACTORY FOR ALPHA SEA TRIALS. 2. REF B REPORTED SUCCESSFUL COMPLETION OF FAST CRUISE AND READINESS OF FLY-BY- WIRE SHIP CONTROL SYSTEM FOR ALPHA SEA TRIALS. 3. FLY-BY-WIRE SHIP CONTROL SYSTEM USE IS AUTHORIZED IN SUPPORT OF ALPHA SEA TRIALS IAW THE ALPHA SEA TRIALS AGENDA CONCURRED IN BY REF C AND APPROVED BY REF D. THERE ARE NO FLY-BY-WIRE SHIP CONTROL SYSTEM or SHIP RELATED OPERATING RESTRICTIONS/LIMITS WHICH HAVE NOT BEEN SATISFIED. // 4. THIS CERTIFICATION IS VALID THROUGHOUT TRIALS UNLESS A DEFICIENCY HAS BEEN DISCOVERED. SHIP SPEED IS RESTRICTED TO LESS THAN 20 KNOTS WHEN A FBW SCS FAULT CONDITION RESULTS IN A MAJOR NON-CONFORMANCE AFFECTING CONTROL OF SHIPS PITCH, HEADING, DEPTH OR CONTROL SURFACES. THESE DEFICIENCIES MUST BE REPORTED TO NAVSEA AND THE APPROPRIATE FLEET AND TYPE COMMANDERS. PREVIOUS NAVSEA CERTIFICATION OF THE FBW SCS MATERIAL CONDITION SHALL BE SUSPENDED UNTIL NAVSEA REVIEWS THE REPORT AND CERTIFIES TO THE TYCOM THAT THE FBW SCS MATERIAL CONDITION IS SATISFACTORY FOR SEA TRIALS IN ACCORDANCE WITH THE SEA TRIAL AGENDA APPROVED BY REFERENCE D. THE SHIP'S SPEED IS RESTRICTED TO LESS THAN 20 KNOTS UNTIL SATISFACTORY RESOLUTION OF THE MAJOR NON-CONFORMANCE AND TYCOM APPROVAL TO OPERATE THE FBW SCS TO PREVIOUSLY AUTHORIZED CONDITIONS IS GRANTED, UNLESS SPECIFICALLY ADDRESSED IN THE SEA TRIAL AGENDA. BT NOTE: ENSURE MESSAGES ARE IN ACCORDANCE WITH NTP-3 FORMAT AND CURRENT PLAD IS UTILIZED. I-2K-1
Page 1 and 2:
LISTING OF APPENDICES. A Master Loc
Page 3 and 4:
I-FWD-3 COMFLTFORCOMINST 4790.3 REV
Page 5 and 6:
Page 7 and 8:
Page 9 and 10:
APPENDIX A MASTER LOCATOR GUIDE FOR
Page 11 and 12:
CHAPTER 4 TYPE COMMANDER MAINTENANC
Page 13 and 14:
2.3 Assessment Results 2.4 Responsi
Page 15 and 16:
17.5 Safety Procedures 17.6 Catapul
Page 17 and 18:
CHAPTER 6 MATERIAL CONTROL 6.1 Purp
Page 19 and 20:
CHAPTER 8 DEPARTURE FROM SPECIFICAT
Page 21 and 22:
CHAPTER 10 MOTOR GASOLINE HANDLING
Page 23 and 24:
CHAPTER 27 SCHEDULED PRESERVATION U
Page 25 and 26:
CHAPTER 2 CONTRACTS AND CONTRACT AD
Page 27 and 28:
APPENDIX B MASTER LIST OF REFERENCE
Page 29 and 30:
I-FWD-B-3 COMFLTFORCOMINST 4790.3 R
Page 31 and 32:
FAR 203 FAR Part 1.3 - Agency Acqui
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
NAVSEA SI 009-04 - Quality Manageme
Page 39 and 40:
NAVSEAINST 5730.1 - Legislative and
Page 41 and 42:
I-FWD-B-15 COMFLTFORCOMINST 4790.3
Page 43 and 44:
APPENDIX C RESPONSIBILITIES Fleet C
Page 45 and 46:
Type Commander (TYCOM) Section Area
Page 47 and 48:
I-FWD-C-5 COMFLTFORCOMINST 4790.3 R
Page 49 and 50:
VI-9.2.2 Metrology and Calibration
Page 51 and 52:
Immediate Superior in Command (ISIC
Page 53 and 54:
V-I-1.4.1 Organizational Responsibi
Page 55 and 56:
VI-7.2.2 Board of Inspection and Su
Page 57 and 58:
I-FWD-C-15 COMFLTFORCOMINST 4790.3
Page 59 and 60:
Regional Maintenance Center Command
Page 61 and 62:
Ship's Commanding Officer Section A
Page 63 and 64:
Page 65 and 66:
VI-8.2.3 Miniature/Micro-miniature
Page 67 and 68:
Page 69 and 70:
Page 71 and 72:
Controlled Material Petty Officer S
Page 73 and 74:
JOINT FLEET MAINTENANCE MANUAL VOLU
Page 75 and 76:
iii COMFLTFORCOMINST 4790.3 REV A C
Page 77 and 78:
JOINT FLEET MAINTENANCE MANUAL VOLU
Page 79 and 80:
vii COMFLTFORCOMINST 4790.3 REV A C
Page 81 and 82:
ix COMFLTFORCOMINST 4790.3 REV A CH
Page 83 and 84:
FOREWORD JOINT FLEET MAINTENANCE MA
Page 85 and 86:
xiii COMFLTFORCOMINST 4790.3 REV A
Page 87 and 88:
xv COMFLTFORCOMINST 4790.3 REV A CH
Page 89 and 90:
xvii COMFLTFORCOMINST 4790.3 REV A
Page 91 and 92:
REFERENCES. VOLUME I CHAPTER 1 INTR
Page 93 and 94:
APPENDIX A1 SUMMARY OF TYPICAL NEW
Page 95 and 96:
APPENDIX A2 SUMMARY OF TYPICAL NEW
Page 97 and 98:
Event APPENDIX A3 SUMMARY OF TYPICA
Page 99 and 100:
I-1B-1 COMFLTFORCOMINST 4790.3 REV
Page 101 and 102:
Page 103 and 104:
Page 105 and 106:
-82 Months Begin Construction -6 Mo
Page 107 and 108:
APPENDIX C LIST OF ACRONYMS 2M Mini
Page 109 and 110:
MACHALT Machinery Alteration MBT Ma
Page 111 and 112:
TERM DEFINITION APPENDIX D GLOSSARY
Page 113 and 114:
COMFLTFORCOMINST 4790.3 REV A CH-2
Page 115 and 116:
REFERENCES. VOLUME I CHAPTER 2 POLI
Page 117 and 118:
Page 119 and 120:
Page 121 and 122:
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136: COMFLTFORCOMINST 4790.3 REV A CH-1
Page 141 and 142: MSG RCMD IN-SERVICE MSG INFO SHIP P
Page 143 and 144: APPENDIX A2 I-2A-3 COMFLTFORCOMINST
Page 149 and 150: APPENDIX A7 SAMPLE CNO TO SHIP PROG
Page 151 and 152: APPENDIX A9 SAMPLE SHIP PROGRAM MAN
Page 153 and 154: MSG PCU READY FOR FAST CRUISE & ALP
Page 155 and 156: APPENDIX B2 I-2B-3 COMFLTFORCOMINST
Page 161 and 162: APPENDIX B8 SAMPLE NAVSEA TO TYCOM
Page 163 and 164: APPENDIX C COMFLTFORCOMINST 4790.3
Page 165 and 166: APPENDIX C2 SAMPLE NAVSEA TO TYCOM
Page 167 and 168: APPENDIX D Message Scenario and Sam
Page 171 and 172: APPENDIX D3 COMFLTFORCOMINST 4790.3
Page 173 and 174: APPENDIX E COMFLTFORCOMINST 4790.3
Page 175 and 176: APPENDIX F COMFLTFORCOMINST 4790.3
Page 177 and 178: APPENDIX G COMFLTFORCOMINST 4790.3
Page 179 and 180: Concurrence PCO NRRO APPENDIX H Pre
Page 181 and 182: APPENDIX H2 SAMPLE SUPERVISING AUTH
Page 183 and 184: APPENDIX I COMFLTFORCOMINST 4790.3
Page 185: APPENDIX J COMFLTFORCOMINST 4790.3
Page 189 and 190: APPENDIX L COMFLTFORCOMINST 4790.3
Page 191 and 192: APPENDIX M COMFLTFORCOMINST 4790.3
Page 193 and 194: APPENDIX N COMFLTFORCOMINST 4790.3
Page 195 and 196: APPENDIX O COMFLTFORCOMINST 4790.3
Page 197 and 198: APPENDIX P SAMPLE TYCOM MESSAGE TO
Page 199 and 200: APPENDIX Q COMFLTFORCOMINST 4790.3
Page 201 and 202: APPENDIX R COMFLTFORCOMINST 4790.3
Page 203 and 204: APPENDIX S COMFLTFORCOMINST 4790.3
Page 205 and 206: APPENDIX T COMFLTFORCOMINST 4790.3
Page 207 and 208: APPENDIX U COMFLTFORCOMINST 4790.3
Page 209 and 210: APPENDIX V COMFLTFORCOMINST 4790.3
Page 211 and 212: APPENDIX W COMFLTFORCOMINST 4790.3
Page 213 and 214: APPENDIX X COMFLTFORCOMINST 4790.3
Page 215 and 216: APPENDIX Y COMFLTFORCOMINST 4790.3
Page 217 and 218: APPENDIX Z COMFLTFORCOMINST 4790.3
Page 219 and 220: The TYCOM/ISIC is responsible for t
Page 221 and 222: APPENDIX AB COMFLTFORCOMINST 4790.3
Page 225 and 226: APPENDIX AC COMFLTFORCOMINST 4790.3
Page 227 and 228: APPENDIX AD GENERIC BASE LINE OF FL
Page 229 and 230: • Navigation • Combat Systems C
Page 233 and 234: APPENDIX AE COMFLTFORCOMINST 4790.3
Page 235 and 236: APPENDIX AF COMFLTFORCOMINST 4790.3
Page 237 and 238:
APPENDIX AG COMFLTFORCOMINST 4790.3
Page 239 and 240:
REFERENCES. VOLUME I CHAPTER 3 PRE
Page 241 and 242:
3.3.2 Periodic Monitoring/Inspectio
Page 243 and 244:
COMFLTFORCOMINST 4790.3 REV A 3.3.5
Page 245 and 246:
3.3.9 National Policy on the Contro
Page 247 and 248:
3.3.14 Light-Off Assessment (Non-Nu
Page 249 and 250:
Page 251 and 252:
COMFLTFORCOMINST 4790.3 REV A a. Sh
Page 253 and 254:
COMFLTFORCOMINST 4790.3 REV A f. Sh
Page 255 and 256:
APPENDIX A AREAS TO BE EVALUATED DU
Page 257 and 258:
COMFLTFORCOMINST 4790.3 REV A d. Fu
Page 259 and 260:
APPENDIX B AREAS TO BE EVALUATED DU
Page 261 and 262:
APPENDIX C COMFLTFORCOMINST 4790.3
Page 263 and 264:
PRE-RSE SCHEDULE OF EXAMINATION COM
Page 265 and 266:
Encl (3) I-3C-5 Name Rate/NEC Repor
Page 267 and 268:
Encl (3) I-3C-7 Name Rate/NEC Repor
Page 269 and 270:
EOOW EWS ERS RO EO RT AEA CH/CD ELT
Page 271 and 272:
INTERVIEWER - A___________ SUBJECT
Page 273 and 274:
INTERVIEWER - C -________________ S
Page 275 and 276:
SAMPLE INTERVIEW SCHEDULE INTERVIEW
Page 277 and 278:
SAMPLE STATUS OF PROPULSION PLANT S
Page 279 and 280:
Departmental SAMPLE STATUS OF PROPU
Page 281 and 282:
APPENDIX D IN-SERVICE COMPARTMENT S
Page 283 and 284:
APPENDIX E SAMPLE PRE-COMMISSIONING
Page 285 and 286:
COMFLTFORCOMINST 4790.3 REV A SAMPL
Page 287 and 288:
Page 289 and 290:
Page 291 and 292:
Page 293 and 294:
Page 295 and 296:
Page 297 and 298:
Page 299 and 300:
Page 301 and 302:
REFERENCES. VOLUME I CHAPTER 4 TRIA
Page 303 and 304:
I-4-3 COMFLTFORCOMINST 4790.3 REV A
Page 305 and 306:
Page 307 and 308:
Page 309 and 310:
Page 311 and 312:
APPENDIX A SPECIFIC DOCK TRIAL TEST
Page 313 and 314:
I-4A-3 COMFLTFORCOMINST 4790.3 REV
Page 315 and 316:
Page 317 and 318:
Page 319 and 320:
APPENDIX B MINIMUM FAST CRUISE REQU
Page 321 and 322:
Page 323 and 324:
APPENDIX C I-4C-1 COMFLTFORCOMINST
Page 325 and 326:
g. Environmental Protection Collect
Page 327 and 328:
APPENDIX D LISTING OF TESTS TO BE P
Page 329 and 330:
I-4D-3 COMFLTFORCOMINST 4790.3 REV
Page 331 and 332:
1. Radio Communication: APPENDIX E
Page 333 and 334:
APPENDIX F LISTING OF TESTS TO BE P
Page 335 and 336:
I-4F-3 COMFLTFORCOMINST 4790.3 REV
Page 337 and 338:
Page 339 and 340:
Page 341 and 342:
APPENDIX G SUBMARINE SEA TRIAL SITU
Page 343 and 344:
REFERENCES. VOLUME I CHAPTER 5 POST
Page 345 and 346:
(4) CSCT. (5) Silencing Deficiencie
Page 347 and 348:
COMFLTFORCOMINST 4790.3 REV A 5.5 G
Page 349 and 350:
I-5A-1 USS_________________________
Page 351 and 352:
APPENDIX B COMFLTFORCOMINST 4790.3
Page 353 and 354:
Key Used In The Following Columns D
Page 355 and 356:
Page 357 and 358:
REFERENCES. VOLUME I CHAPTER 6 POST
Page 359 and 360:
6.4.2 Assignment of Escort Ship (Su
Page 361 and 362:
NOTE: BUILDER TRIALS CORRECT DEFICI
Page 363 and 364:
APPENDIX B COMFLTFORCOMINST 4790.3
Page 365 and 366:
Time Event COMFLTFORCOMINST 4790.3
Page 367 and 368:
Page 369 and 370:
APPENDIX D COMFLTFORCOMINST 4790.3
Page 371 and 372:
show all

JOINT FLEET MAINTENANCE MANUAL

Create successful ePaper yourself

Delete template?

Save as template?