JOINT FLEET MAINTENANCE MANUAL

More documents

Recommendations

Info

COMFLTFORCOMINST 4790.3 REV A SAMPLE PRE-COMMISSIONING HABITABILITY INSPECTION CHECK LIST FOR NEW CONSTRUCTION SHIPS (Cont'd) Compartment Number: Division:_____________________________ b. Ice scoop, stored handle up, in a covered and freely draining bracket outside ice storage compartment or inside the ice machine on a bracket above the highest level of the ice (NAVMED P-5010, Article 1-36). 9. Manual Dishwashing a. Utensils move from dirty to clean side of wash area without risk of cross contamination by handling or splashing. b. A three compartment sink installed for washing pots, pans and utensils. c. Booster heater installed and functional. d. Temperature gage installed or thermometer used to monitor wash and rinse temperatures. e. Wash water temperature ranges between 95-125°F. f. Final rinse water temperature reaches at least 170°F. g. Long-handled dip baskets available. 10. Dishwashing Machine a. Center and end curtains installed. b. Temperature gages accurate to +/- 3°F. c. Multiple tank conveyor dishwashing machine meets following requirements (NAVMED P-5010, Article 1-9): (1) Wash temperature 150-160°F for 7 seconds. (2) Rinse temperature 160-180°F for 7 seconds. (3) Final rinse temperature 180-195°F with a conveyor speed of 15 feet per minute at 15 - 25 psi or as specified in the machine technical manual. Inspector: Date:____________________________ I-3E-8 YES NO
COMFLTFORCOMINST 4790.3 REV A SAMPLE PRE-COMMISSIONING HABITABILITY INSPECTION CHECK LIST FOR NEW CONSTRUCTION SHIPS (Cont'd) Compartment Number: Division:_____________________________ d. Operating instructions posted on, or conspicuously near, the machine (OPNAVINST 5100.19, Section V. 16). C. LIVING SPACES 1. Bunks and lockers neat and in usable condition and bunk curtains installed (OPNAVINST 4700.29). 2. Plumbing fixtures installed in washrooms, showers and water closets, including shower heads and soap dishes and other necessary items (OPNAVINST 4700.29). 3. Prescribed deck covering installed (OPNAVINST 4700.29). 4. Adequate furniture and equipment installed to provide reasonable comfort, relaxation and entertainment in lounge areas (OPNAVINST 4700.29). 5. Berthing spaces are clean, adequately ventilated and well illuminated (OPNAVINST 9640.1 and NAVMED P-5010, Chapter 2). 6. Drinking fountains are of the jet-angle type with clean bowls, orifices and orifice guards (NAVMED P-5010, Chapter 2). 7. No Category I flammables, combustibles or aerosol containers stored in berthing spaces (NSTM 670). 8. Sinks, urinals and commodes are clean, odor free and operable (NAVMED P-5010, Chapter 2). 9. The temperature of the hot water supplied for personal use of the crew does not exceed 130°F (NSTM 533). 10. Temperatures in berthing and messing spaces do not exceed 80°F (OPNAVINST 9640.1). 11. Temperatures in living, sanitary, messing, medical, control spaces, and normal working stations are not lower than 65°F (OPNAVINST 9640.1). Inspector: Date:______________________ I-3E-9 YES NO
Page 1 and 2:
LISTING OF APPENDICES. A Master Loc
Page 3 and 4:
I-FWD-3 COMFLTFORCOMINST 4790.3 REV
Page 5 and 6:
Page 7 and 8:
Page 9 and 10:
APPENDIX A MASTER LOCATOR GUIDE FOR
Page 11 and 12:
CHAPTER 4 TYPE COMMANDER MAINTENANC
Page 13 and 14:
2.3 Assessment Results 2.4 Responsi
Page 15 and 16:
17.5 Safety Procedures 17.6 Catapul
Page 17 and 18:
CHAPTER 6 MATERIAL CONTROL 6.1 Purp
Page 19 and 20:
CHAPTER 8 DEPARTURE FROM SPECIFICAT
Page 21 and 22:
CHAPTER 10 MOTOR GASOLINE HANDLING
Page 23 and 24:
CHAPTER 27 SCHEDULED PRESERVATION U
Page 25 and 26:
CHAPTER 2 CONTRACTS AND CONTRACT AD
Page 27 and 28:
APPENDIX B MASTER LIST OF REFERENCE
Page 29 and 30:
I-FWD-B-3 COMFLTFORCOMINST 4790.3 R
Page 31 and 32:
FAR 203 FAR Part 1.3 - Agency Acqui
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
NAVSEA SI 009-04 - Quality Manageme
Page 39 and 40:
NAVSEAINST 5730.1 - Legislative and
Page 41 and 42:
I-FWD-B-15 COMFLTFORCOMINST 4790.3
Page 43 and 44:
APPENDIX C RESPONSIBILITIES Fleet C
Page 45 and 46:
Type Commander (TYCOM) Section Area
Page 47 and 48:
I-FWD-C-5 COMFLTFORCOMINST 4790.3 R
Page 49 and 50:
VI-9.2.2 Metrology and Calibration
Page 51 and 52:
Immediate Superior in Command (ISIC
Page 53 and 54:
V-I-1.4.1 Organizational Responsibi
Page 55 and 56:
VI-7.2.2 Board of Inspection and Su
Page 57 and 58:
I-FWD-C-15 COMFLTFORCOMINST 4790.3
Page 59 and 60:
Regional Maintenance Center Command
Page 61 and 62:
Ship's Commanding Officer Section A
Page 63 and 64:
Page 65 and 66:
VI-8.2.3 Miniature/Micro-miniature
Page 67 and 68:
Page 69 and 70:
Page 71 and 72:
Controlled Material Petty Officer S
Page 73 and 74:
JOINT FLEET MAINTENANCE MANUAL VOLU
Page 75 and 76:
iii COMFLTFORCOMINST 4790.3 REV A C
Page 77 and 78:
JOINT FLEET MAINTENANCE MANUAL VOLU
Page 79 and 80:
vii COMFLTFORCOMINST 4790.3 REV A C
Page 81 and 82:
ix COMFLTFORCOMINST 4790.3 REV A CH
Page 83 and 84:
FOREWORD JOINT FLEET MAINTENANCE MA
Page 85 and 86:
xiii COMFLTFORCOMINST 4790.3 REV A
Page 87 and 88:
xv COMFLTFORCOMINST 4790.3 REV A CH
Page 89 and 90:
xvii COMFLTFORCOMINST 4790.3 REV A
Page 91 and 92:
REFERENCES. VOLUME I CHAPTER 1 INTR
Page 93 and 94:
APPENDIX A1 SUMMARY OF TYPICAL NEW
Page 95 and 96:
APPENDIX A2 SUMMARY OF TYPICAL NEW
Page 97 and 98:
Event APPENDIX A3 SUMMARY OF TYPICA
Page 99 and 100:
I-1B-1 COMFLTFORCOMINST 4790.3 REV
Page 101 and 102:
Page 103 and 104:
Page 105 and 106:
-82 Months Begin Construction -6 Mo
Page 107 and 108:
APPENDIX C LIST OF ACRONYMS 2M Mini
Page 109 and 110:
MACHALT Machinery Alteration MBT Ma
Page 111 and 112:
TERM DEFINITION APPENDIX D GLOSSARY
Page 113 and 114:
COMFLTFORCOMINST 4790.3 REV A CH-2
Page 115 and 116:
REFERENCES. VOLUME I CHAPTER 2 POLI
Page 117 and 118:
Page 119 and 120:
Page 121 and 122:
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
MSG RCMD IN-SERVICE MSG INFO SHIP P
Page 143 and 144:
APPENDIX A2 I-2A-3 COMFLTFORCOMINST
Page 145 and 146:
Page 147 and 148:
Page 149 and 150:
APPENDIX A7 SAMPLE CNO TO SHIP PROG
Page 151 and 152:
APPENDIX A9 SAMPLE SHIP PROGRAM MAN
Page 153 and 154:
MSG PCU READY FOR FAST CRUISE & ALP
Page 155 and 156:
APPENDIX B2 I-2B-3 COMFLTFORCOMINST
Page 157 and 158:
Page 159 and 160:
Page 161 and 162:
APPENDIX B8 SAMPLE NAVSEA TO TYCOM
Page 163 and 164:
APPENDIX C COMFLTFORCOMINST 4790.3
Page 165 and 166:
APPENDIX C2 SAMPLE NAVSEA TO TYCOM
Page 167 and 168:
APPENDIX D Message Scenario and Sam
Page 169 and 170:
Page 171 and 172:
APPENDIX D3 COMFLTFORCOMINST 4790.3
Page 173 and 174:
APPENDIX E COMFLTFORCOMINST 4790.3
Page 175 and 176:
APPENDIX F COMFLTFORCOMINST 4790.3
Page 177 and 178:
APPENDIX G COMFLTFORCOMINST 4790.3
Page 179 and 180:
Concurrence PCO NRRO APPENDIX H Pre
Page 181 and 182:
APPENDIX H2 SAMPLE SUPERVISING AUTH
Page 183 and 184:
APPENDIX I COMFLTFORCOMINST 4790.3
Page 185 and 186:
APPENDIX J COMFLTFORCOMINST 4790.3
Page 187 and 188:
APPENDIX K COMFLTFORCOMINST 4790.3
Page 189 and 190:
APPENDIX L COMFLTFORCOMINST 4790.3
Page 191 and 192:
APPENDIX M COMFLTFORCOMINST 4790.3
Page 193 and 194:
APPENDIX N COMFLTFORCOMINST 4790.3
Page 195 and 196:
APPENDIX O COMFLTFORCOMINST 4790.3
Page 197 and 198:
APPENDIX P SAMPLE TYCOM MESSAGE TO
Page 199 and 200:
APPENDIX Q COMFLTFORCOMINST 4790.3
Page 201 and 202:
APPENDIX R COMFLTFORCOMINST 4790.3
Page 203 and 204:
APPENDIX S COMFLTFORCOMINST 4790.3
Page 205 and 206:
APPENDIX T COMFLTFORCOMINST 4790.3
Page 207 and 208:
APPENDIX U COMFLTFORCOMINST 4790.3
Page 209 and 210:
APPENDIX V COMFLTFORCOMINST 4790.3
Page 211 and 212:
APPENDIX W COMFLTFORCOMINST 4790.3
Page 213 and 214:
APPENDIX X COMFLTFORCOMINST 4790.3
Page 215 and 216:
APPENDIX Y COMFLTFORCOMINST 4790.3
Page 217 and 218:
APPENDIX Z COMFLTFORCOMINST 4790.3
Page 219 and 220:
The TYCOM/ISIC is responsible for t
Page 221 and 222:
APPENDIX AB COMFLTFORCOMINST 4790.3
Page 223 and 224:
Page 225 and 226:
APPENDIX AC COMFLTFORCOMINST 4790.3
Page 227 and 228:
APPENDIX AD GENERIC BASE LINE OF FL
Page 229 and 230:
• Navigation • Combat Systems C
Page 231 and 232:
Page 233 and 234:
APPENDIX AE COMFLTFORCOMINST 4790.3
Page 235 and 236:
APPENDIX AF COMFLTFORCOMINST 4790.3
Page 237 and 238:
APPENDIX AG COMFLTFORCOMINST 4790.3
Page 239 and 240: REFERENCES. VOLUME I CHAPTER 3 PRE
Page 241 and 242: 3.3.2 Periodic Monitoring/Inspectio
Page 243 and 244: COMFLTFORCOMINST 4790.3 REV A 3.3.5
Page 245 and 246: 3.3.9 National Policy on the Contro
Page 247 and 248: 3.3.14 Light-Off Assessment (Non-Nu
Page 249 and 250: COMFLTFORCOMINST 4790.3 REV A CH-3
Page 251 and 252: COMFLTFORCOMINST 4790.3 REV A a. Sh
Page 253 and 254: COMFLTFORCOMINST 4790.3 REV A f. Sh
Page 255 and 256: APPENDIX A AREAS TO BE EVALUATED DU
Page 257 and 258: COMFLTFORCOMINST 4790.3 REV A d. Fu
Page 259 and 260: APPENDIX B AREAS TO BE EVALUATED DU
Page 261 and 262: APPENDIX C COMFLTFORCOMINST 4790.3
Page 263 and 264: PRE-RSE SCHEDULE OF EXAMINATION COM
Page 265 and 266: Encl (3) I-3C-5 Name Rate/NEC Repor
Page 267 and 268: Encl (3) I-3C-7 Name Rate/NEC Repor
Page 269 and 270: EOOW EWS ERS RO EO RT AEA CH/CD ELT
Page 271 and 272: INTERVIEWER - A___________ SUBJECT
Page 273 and 274: INTERVIEWER - C -________________ S
Page 275 and 276: SAMPLE INTERVIEW SCHEDULE INTERVIEW
Page 277 and 278: SAMPLE STATUS OF PROPULSION PLANT S
Page 279 and 280: Departmental SAMPLE STATUS OF PROPU
Page 281 and 282: APPENDIX D IN-SERVICE COMPARTMENT S
Page 283 and 284: APPENDIX E SAMPLE PRE-COMMISSIONING
Page 285 and 286: COMFLTFORCOMINST 4790.3 REV A SAMPL
Page 289: COMFLTFORCOMINST 4790.3 REV A SAMPL
Page 301 and 302: REFERENCES. VOLUME I CHAPTER 4 TRIA
Page 303 and 304: I-4-3 COMFLTFORCOMINST 4790.3 REV A
Page 311 and 312: APPENDIX A SPECIFIC DOCK TRIAL TEST
Page 313 and 314: I-4A-3 COMFLTFORCOMINST 4790.3 REV
Page 319 and 320: APPENDIX B MINIMUM FAST CRUISE REQU
Page 321 and 322: I-4B-3 COMFLTFORCOMINST 4790.3 REV
Page 323 and 324: APPENDIX C I-4C-1 COMFLTFORCOMINST
Page 325 and 326: g. Environmental Protection Collect
Page 327 and 328: APPENDIX D LISTING OF TESTS TO BE P
Page 329 and 330: I-4D-3 COMFLTFORCOMINST 4790.3 REV
Page 331 and 332: 1. Radio Communication: APPENDIX E
Page 333 and 334: APPENDIX F LISTING OF TESTS TO BE P
Page 335 and 336: I-4F-3 COMFLTFORCOMINST 4790.3 REV
Page 341 and 342:
APPENDIX G SUBMARINE SEA TRIAL SITU
Page 343 and 344:
REFERENCES. VOLUME I CHAPTER 5 POST
Page 345 and 346:
(4) CSCT. (5) Silencing Deficiencie
Page 347 and 348:
COMFLTFORCOMINST 4790.3 REV A 5.5 G
Page 349 and 350:
I-5A-1 USS_________________________
Page 351 and 352:
APPENDIX B COMFLTFORCOMINST 4790.3
Page 353 and 354:
Key Used In The Following Columns D
Page 355 and 356:
Page 357 and 358:
REFERENCES. VOLUME I CHAPTER 6 POST
Page 359 and 360:
6.4.2 Assignment of Escort Ship (Su
Page 361 and 362:
NOTE: BUILDER TRIALS CORRECT DEFICI
Page 363 and 364:
APPENDIX B COMFLTFORCOMINST 4790.3
Page 365 and 366:
Time Event COMFLTFORCOMINST 4790.3
Page 367 and 368:
Page 369 and 370:
APPENDIX D COMFLTFORCOMINST 4790.3
Page 371 and 372:
show all

JOINT FLEET MAINTENANCE MANUAL

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?