JOINT FLEET MAINTENANCE MANUAL

More documents

Recommendations

Info

COMFLTFORCOMINST 4790.3 REV A CH-6 NAVSEA STD DWG 804-1213717 - Vehicle Tiedown Deck Fittings NAVSEA STD DWG 804-5184163 - Trunk Safety Nets NAVSEA STD DWG 805-1639000 - Deck Screw Reversible Eyebolts NAVSEA STD DWG 805-1645271 - Portable Davits NAVSEA STD DWG 805-1916300 - Aircraft Securing and Engine Run-up Fittings NAVSEA STD DWG 805-2276338 - Cleats NAVSEA STD DWG 805-921806 - Installation of Planking on Deck Plating NAVSEAINST 3151.1 - Diving and Manned Hyperbaric Systems Certification Program NAVSEAINST 3960.4 - Implementation of Total Ship Test Program for Ship Production NAVSEAINST 3960.5 - Policy on Ship Testing NAVSEAINST 4130.9 - Configuration Control Procedures For Preparation of Ordnance Alterations (ORDALTS) to Expendable and Non-Expendable Items NAVSEAINST 4160.3 - Technical Manual Management Program (TMMP) NAVSEAINST 4200.17 - Contracting Officer's Representative NAVSEAINST 4280.2 - Master Agreement for Repair and Alteration of Vessels, Master Ship Repair Agreement (MSRA) and Agreement for Boat Repair (ABR) NAVSEAINST 4355.7A - Nondestructive Test (NDT) Examiner Qualification and Requalification NAVSEAINST 4441.2 - Changes to Coordinated Shipboard Allowance List (COSAL); Procedures for NAVSEAINST 4700.6A - Guarantee Engineer and Industrial Availability Quality Assessment NAVSEAINST 4700.8A - Policy for Performance of Depot Level Ship Availabilities NAVSEAINST 4700.17 - Preparation and Review of Trouble Reports NAVSEAINST 4710.13 - Government Man-day Rates for Use in Private Sector Ship Overhaul and Repair, Planning, Programming and Budgeting NAVSEAINST 4710.6 - Submarine Advanced Equipment Repair Program (AERP); Assignment of Responsibilities for and Administration of NAVSEAINST 4710.7 - Standard Cost Estimating Form for Private Sector Overhaul and Repair Availabilities NAVSEAINST 4710.8A - Cost and Performance Reporting for CNO Scheduled Ship Maintenance Availabilities NAVSEAINST 4710.9 - Requirements for Turnover of Planning Products and Specification Package NAVSEAINST 4720.11 - Shipboard Installation and Modifications Performed by Alteration Installation Teams NAVSEAINST 4720.14 - Temporary Alterations to Active Fleet Submarines; Control of NAVSEAINST 4720.15 - Machinery Alterations on HM&E Equipment and Systems NAVSEAINST 4720.23 - Deep Submergence Systems Temporary Modifications NAVSEAINST 4730.2 - Shipyard Inspection and Required Conditions of Propulsion Plant Systems (Non-Nuclear) for Nuclear Powered Surface Ships NAVSEAINST 4734.1 - NAVSEA Test, Measurement, and Diagnostic Equipment (TMDE) and Calibration Programs NAVSEAINST 4790.8 - Ship's Maintenance and Material Management (3-M) Manual NAVSEAINST 4790.14 - Ship Departure and Alteration Completion Reports NAVSEAINST 4790.16 - SSBN Extended Operating Cycle (EOC) Program; Policy, Procedures and Responsibilities for NAVSEAINST 4790.17 - Fleet Test and Repair of Shipboard Electronic Equipment NAVSEAINST 4790.19 - Submarine Engineered Operating Cycle (SEOC) Program NAVSEAINST 5370.1 - Standards of Conduct and Statements of Affiliations and Financial Interests NAVSEAINST 5400.95 - Waterfront Engineering and Technical Authority Policy NAVSEAINST C5511.32 - Safeguarding of Naval Nuclear Propulsion Information I-FWD-B-12
NAVSEAINST 5730.1 - Legislative and Congressional Matters I-FWD-B-13 COMFLTFORCOMINST 4790.3 REV A CH-3 NAVSEAINST 7500.1 - Audits of NAVSEA by External Audit Organizations NAVSEAINST 7670.1 - Navy Industrial Fund (NIF) Financial Management Systems and Procedures Manual NAVSEAINST 9070.1 - Standard Specification for Ship Repair and Alteration Committee NAVSEAINST C9073.2 - Acoustical Survey of Submarines NAVSEAINST C9094.2 - Submarine Valve Operation Requirements for Builders and Post-Overhaul Sea Trial Test Dives NAVSEAINST C9096.2 - Weight and Stability Requirements for Active Submarines NAVSEAINST 9210.31 - Government Procurement Quality Source Inspection Actions for Shipyard Procedure of Material Under NAVSEA 08 Cognizance NAVSEAINST C9210.4 - Changes, Repairs and Maintenance to Nuclear Powered Ships NAVSEAINST 9210.14 - Changes to Submarine Tenders and Destroyer Tenders with Nuclear Support Facilities, Requirements Concerning NAVSEAINST 9210.23 - Requirements for Naval Nuclear Work at Naval Activities and Private Shipyards - Certification of Work Accomplishment and Data Retention of Associated Records and Retention of Design Records NAVSEAINST 9210.30 - Procedures for Administration of Nuclear Reactor Plant Preventive Maintenance and Tender Nuclear Support Facilities Preventive Maintenance on Ships NAVSEAINST 9210.31 - Government Procurement Quality Source Inspection Actions for Shipyard Procedure of Material Under NAVSEA 08 Cognizance NAVSEAINST C9210.34 - All Nuclear Projects - Material Identification and Control Requirements for Naval Nuclear Reactor Plant Piping Systems NAVSEAINST 9210.36 - Steam Plant Cleanliness Control NAVSEAINST 9210.39 - Submarine Nuclear Propulsion Plant Operator Welders: Procedures for Maintenance of Qualification NAVSEAINST 9210.41 - All Naval Nuclear Propulsion Plants - Use of Standard Lubricants and Penetrating Fluid; Requirements for NAVSEAINST 9210.45 - Reactor Plant Welding and Nondestructive Testing Personnel NAVSEAINST 9304.1C - Shipboard Electrical Cable and Cableway Inspection and Reporting Procedures NAVSEAINST 9593.1 - Certification Program for Sewage Marine Sanitation Devices in U.S. Navy Surface Ships and Craft NAVSO P-1000 - Navy Comptroller Manual NAVSO P-3006 - Financial Management of Resources Operations and Maintenance, (Shore Activities) NAVSO P-3635 - Federal Acquisition Regulation, Section 13, Chapter 312 NAVSO P-3013-2 - Financial Management of Resources Operating Forces Procedures NAVSUP 484 - Supply Afloat Fleet and Field Packaging Procedures NAVSUP 5009 (DLAM 4215.1) - Management of Defense-Owned Industrial Plant Equipment NAVSUP Publication 485 - Afloat Supply Procedures NAVSUP P2003 - Navy Stock List of Forms and Publications NAVSUPPUB 437 - Material - Required Delivery Date Processing NAVSUP S6161-Q5-CAT-010 - Ship Food Service Equipment Catalog NMCARS 5201 - Federal Acquisition Regulations System NMCARS 5219.2 - Special Contracting Policy NMCARS 5219.7 - The Small Business Subcontracting Program NMCARS 5233 - Protests, Disputes and Appeals NMCARS 5233.9000 - Documentation of Significant Contract Events
Page 1 and 2: LISTING OF APPENDICES. A Master Loc
Page 3 and 4: I-FWD-3 COMFLTFORCOMINST 4790.3 REV
Page 9 and 10: APPENDIX A MASTER LOCATOR GUIDE FOR
Page 11 and 12: CHAPTER 4 TYPE COMMANDER MAINTENANC
Page 13 and 14: 2.3 Assessment Results 2.4 Responsi
Page 15 and 16: 17.5 Safety Procedures 17.6 Catapul
Page 17 and 18: CHAPTER 6 MATERIAL CONTROL 6.1 Purp
Page 19 and 20: CHAPTER 8 DEPARTURE FROM SPECIFICAT
Page 21 and 22: CHAPTER 10 MOTOR GASOLINE HANDLING
Page 23 and 24: CHAPTER 27 SCHEDULED PRESERVATION U
Page 25 and 26: CHAPTER 2 CONTRACTS AND CONTRACT AD
Page 27 and 28: APPENDIX B MASTER LIST OF REFERENCE
Page 29 and 30: I-FWD-B-3 COMFLTFORCOMINST 4790.3 R
Page 31 and 32: FAR 203 FAR Part 1.3 - Agency Acqui
Page 37: NAVSEA SI 009-04 - Quality Manageme
Page 41 and 42: I-FWD-B-15 COMFLTFORCOMINST 4790.3
Page 43 and 44: APPENDIX C RESPONSIBILITIES Fleet C
Page 45 and 46: Type Commander (TYCOM) Section Area
Page 47 and 48: I-FWD-C-5 COMFLTFORCOMINST 4790.3 R
Page 49 and 50: VI-9.2.2 Metrology and Calibration
Page 51 and 52: Immediate Superior in Command (ISIC
Page 53 and 54: V-I-1.4.1 Organizational Responsibi
Page 55 and 56: VI-7.2.2 Board of Inspection and Su
Page 57 and 58: I-FWD-C-15 COMFLTFORCOMINST 4790.3
Page 59 and 60: Regional Maintenance Center Command
Page 61 and 62: Ship's Commanding Officer Section A
Page 65 and 66: VI-8.2.3 Miniature/Micro-miniature
Page 71 and 72: Controlled Material Petty Officer S
Page 73 and 74: JOINT FLEET MAINTENANCE MANUAL VOLU
Page 75 and 76: iii COMFLTFORCOMINST 4790.3 REV A C
Page 77 and 78: JOINT FLEET MAINTENANCE MANUAL VOLU
Page 79 and 80: vii COMFLTFORCOMINST 4790.3 REV A C
Page 81 and 82: ix COMFLTFORCOMINST 4790.3 REV A CH
Page 83 and 84: FOREWORD JOINT FLEET MAINTENANCE MA
Page 85 and 86: xiii COMFLTFORCOMINST 4790.3 REV A
Page 87 and 88: xv COMFLTFORCOMINST 4790.3 REV A CH
Page 89 and 90:
xvii COMFLTFORCOMINST 4790.3 REV A
Page 91 and 92:
REFERENCES. VOLUME I CHAPTER 1 INTR
Page 93 and 94:
APPENDIX A1 SUMMARY OF TYPICAL NEW
Page 95 and 96:
APPENDIX A2 SUMMARY OF TYPICAL NEW
Page 97 and 98:
Event APPENDIX A3 SUMMARY OF TYPICA
Page 99 and 100:
I-1B-1 COMFLTFORCOMINST 4790.3 REV
Page 101 and 102:
Page 103 and 104:
Page 105 and 106:
-82 Months Begin Construction -6 Mo
Page 107 and 108:
APPENDIX C LIST OF ACRONYMS 2M Mini
Page 109 and 110:
MACHALT Machinery Alteration MBT Ma
Page 111 and 112:
TERM DEFINITION APPENDIX D GLOSSARY
Page 113 and 114:
COMFLTFORCOMINST 4790.3 REV A CH-2
Page 115 and 116:
REFERENCES. VOLUME I CHAPTER 2 POLI
Page 117 and 118:
Page 119 and 120:
Page 121 and 122:
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
MSG RCMD IN-SERVICE MSG INFO SHIP P
Page 143 and 144:
APPENDIX A2 I-2A-3 COMFLTFORCOMINST
Page 145 and 146:
Page 147 and 148:
Page 149 and 150:
APPENDIX A7 SAMPLE CNO TO SHIP PROG
Page 151 and 152:
APPENDIX A9 SAMPLE SHIP PROGRAM MAN
Page 153 and 154:
MSG PCU READY FOR FAST CRUISE & ALP
Page 155 and 156:
APPENDIX B2 I-2B-3 COMFLTFORCOMINST
Page 157 and 158:
Page 159 and 160:
Page 161 and 162:
APPENDIX B8 SAMPLE NAVSEA TO TYCOM
Page 163 and 164:
APPENDIX C COMFLTFORCOMINST 4790.3
Page 165 and 166:
APPENDIX C2 SAMPLE NAVSEA TO TYCOM
Page 167 and 168:
APPENDIX D Message Scenario and Sam
Page 169 and 170:
Page 171 and 172:
APPENDIX D3 COMFLTFORCOMINST 4790.3
Page 173 and 174:
APPENDIX E COMFLTFORCOMINST 4790.3
Page 175 and 176:
APPENDIX F COMFLTFORCOMINST 4790.3
Page 177 and 178:
APPENDIX G COMFLTFORCOMINST 4790.3
Page 179 and 180:
Concurrence PCO NRRO APPENDIX H Pre
Page 181 and 182:
APPENDIX H2 SAMPLE SUPERVISING AUTH
Page 183 and 184:
APPENDIX I COMFLTFORCOMINST 4790.3
Page 185 and 186:
APPENDIX J COMFLTFORCOMINST 4790.3
Page 187 and 188:
APPENDIX K COMFLTFORCOMINST 4790.3
Page 189 and 190:
APPENDIX L COMFLTFORCOMINST 4790.3
Page 191 and 192:
APPENDIX M COMFLTFORCOMINST 4790.3
Page 193 and 194:
APPENDIX N COMFLTFORCOMINST 4790.3
Page 195 and 196:
APPENDIX O COMFLTFORCOMINST 4790.3
Page 197 and 198:
APPENDIX P SAMPLE TYCOM MESSAGE TO
Page 199 and 200:
APPENDIX Q COMFLTFORCOMINST 4790.3
Page 201 and 202:
APPENDIX R COMFLTFORCOMINST 4790.3
Page 203 and 204:
APPENDIX S COMFLTFORCOMINST 4790.3
Page 205 and 206:
APPENDIX T COMFLTFORCOMINST 4790.3
Page 207 and 208:
APPENDIX U COMFLTFORCOMINST 4790.3
Page 209 and 210:
APPENDIX V COMFLTFORCOMINST 4790.3
Page 211 and 212:
APPENDIX W COMFLTFORCOMINST 4790.3
Page 213 and 214:
APPENDIX X COMFLTFORCOMINST 4790.3
Page 215 and 216:
APPENDIX Y COMFLTFORCOMINST 4790.3
Page 217 and 218:
APPENDIX Z COMFLTFORCOMINST 4790.3
Page 219 and 220:
The TYCOM/ISIC is responsible for t
Page 221 and 222:
APPENDIX AB COMFLTFORCOMINST 4790.3
Page 223 and 224:
Page 225 and 226:
APPENDIX AC COMFLTFORCOMINST 4790.3
Page 227 and 228:
APPENDIX AD GENERIC BASE LINE OF FL
Page 229 and 230:
• Navigation • Combat Systems C
Page 231 and 232:
Page 233 and 234:
APPENDIX AE COMFLTFORCOMINST 4790.3
Page 235 and 236:
APPENDIX AF COMFLTFORCOMINST 4790.3
Page 237 and 238:
APPENDIX AG COMFLTFORCOMINST 4790.3
Page 239 and 240:
REFERENCES. VOLUME I CHAPTER 3 PRE
Page 241 and 242:
3.3.2 Periodic Monitoring/Inspectio
Page 243 and 244:
COMFLTFORCOMINST 4790.3 REV A 3.3.5
Page 245 and 246:
3.3.9 National Policy on the Contro
Page 247 and 248:
3.3.14 Light-Off Assessment (Non-Nu
Page 249 and 250:
Page 251 and 252:
COMFLTFORCOMINST 4790.3 REV A a. Sh
Page 253 and 254:
COMFLTFORCOMINST 4790.3 REV A f. Sh
Page 255 and 256:
APPENDIX A AREAS TO BE EVALUATED DU
Page 257 and 258:
COMFLTFORCOMINST 4790.3 REV A d. Fu
Page 259 and 260:
APPENDIX B AREAS TO BE EVALUATED DU
Page 261 and 262:
Page 263 and 264:
PRE-RSE SCHEDULE OF EXAMINATION COM
Page 265 and 266:
Encl (3) I-3C-5 Name Rate/NEC Repor
Page 267 and 268:
Encl (3) I-3C-7 Name Rate/NEC Repor
Page 269 and 270:
EOOW EWS ERS RO EO RT AEA CH/CD ELT
Page 271 and 272:
INTERVIEWER - A___________ SUBJECT
Page 273 and 274:
INTERVIEWER - C -________________ S
Page 275 and 276:
SAMPLE INTERVIEW SCHEDULE INTERVIEW
Page 277 and 278:
SAMPLE STATUS OF PROPULSION PLANT S
Page 279 and 280:
Departmental SAMPLE STATUS OF PROPU
Page 281 and 282:
APPENDIX D IN-SERVICE COMPARTMENT S
Page 283 and 284:
APPENDIX E SAMPLE PRE-COMMISSIONING
Page 285 and 286:
COMFLTFORCOMINST 4790.3 REV A SAMPL
Page 287 and 288:
Page 289 and 290:
Page 291 and 292:
Page 293 and 294:
Page 295 and 296:
Page 297 and 298:
Page 299 and 300:
Page 301 and 302:
REFERENCES. VOLUME I CHAPTER 4 TRIA
Page 303 and 304:
I-4-3 COMFLTFORCOMINST 4790.3 REV A
Page 305 and 306:
Page 307 and 308:
Page 309 and 310:
Page 311 and 312:
APPENDIX A SPECIFIC DOCK TRIAL TEST
Page 313 and 314:
I-4A-3 COMFLTFORCOMINST 4790.3 REV
Page 315 and 316:
Page 317 and 318:
Page 319 and 320:
APPENDIX B MINIMUM FAST CRUISE REQU
Page 321 and 322:
Page 323 and 324:
APPENDIX C I-4C-1 COMFLTFORCOMINST
Page 325 and 326:
g. Environmental Protection Collect
Page 327 and 328:
APPENDIX D LISTING OF TESTS TO BE P
Page 329 and 330:
I-4D-3 COMFLTFORCOMINST 4790.3 REV
Page 331 and 332:
1. Radio Communication: APPENDIX E
Page 333 and 334:
APPENDIX F LISTING OF TESTS TO BE P
Page 335 and 336:
I-4F-3 COMFLTFORCOMINST 4790.3 REV
Page 337 and 338:
Page 339 and 340:
Page 341 and 342:
APPENDIX G SUBMARINE SEA TRIAL SITU
Page 343 and 344:
REFERENCES. VOLUME I CHAPTER 5 POST
Page 345 and 346:
(4) CSCT. (5) Silencing Deficiencie
Page 347 and 348:
COMFLTFORCOMINST 4790.3 REV A 5.5 G
Page 349 and 350:
I-5A-1 USS_________________________
Page 351 and 352:
APPENDIX B COMFLTFORCOMINST 4790.3
Page 353 and 354:
Key Used In The Following Columns D
Page 355 and 356:
Page 357 and 358:
REFERENCES. VOLUME I CHAPTER 6 POST
Page 359 and 360:
6.4.2 Assignment of Escort Ship (Su
Page 361 and 362:
NOTE: BUILDER TRIALS CORRECT DEFICI
Page 363 and 364:
APPENDIX B COMFLTFORCOMINST 4790.3
Page 365 and 366:
Time Event COMFLTFORCOMINST 4790.3
Page 367 and 368:
Page 369 and 370:
APPENDIX D COMFLTFORCOMINST 4790.3
Page 371 and 372:
show all

JOINT FLEET MAINTENANCE MANUAL

Create successful ePaper yourself

Delete template?

Save as template?