JOINT FLEET MAINTENANCE MANUAL

More documents

Recommendations

Info

COMFLTFORCOMINST 4790.3 REV A CH-4 NAVSEA S9086-CQ-STM-010 - NSTM Chapter 081 R4 (Waterborne Underwater Hull Cleaning of Navy Ships) NAVSEA S9086-C4-STM-000 - NSTM Chapter 094 (Trials) NAVSEA S9086-C6-STM-000 - NSTM Chapter 096 (Weights and Stability) NAVSEA S9086-DA-STM-000 - NSTM Chapter 100 (Hull Structures) NAVSEA S9086-GX-STM-010 - NSTM Chapter 220, V1 (Boiler Water/Feedwater Chemistry) NAVSEA S9086-GX-STM-020 - NSTM Chapter 220, V2 (Water Treatment) NAVSEA S9086-GY-STM-010 - NSTM Chapter 221 (Boilers) NAVSEA S9086-G1-STM-010 - NSTM Chapter 223, V1 (Submarine Storage Batteries - Lead Acid Batteries) NAVSEA S9086-G9-STM-000 - NSTM Chapter 231 (Propulsion and SSTG Steam Turbines) NAVSEA S9086-HB-STM-010 - NSTM Chapter 233 (Diesel Engines) NAVSEA S9086-HC-STM-000 - NSTM Chapter 234 (Marine Gas Turbines) NAVSEA S9086-HK-STM-010 - NSTM Chapter 241 (Propulsion Reduction Gears, Couplings, Clutches and Associated Components) NAVSEA S9086-HN-STM-010 - NSTM Chapter 244 (Propulsion Bearings and Seals) NAVSEA S9086-H7-STM-010 - NSTM Chapter 262 (Lubricating Oil) NAVSEA S9086-QN-STM-010 - NSTM Chapter 475 (Magnetic Silencing) NAVSEA S9086-RJ-STM-010 - NSTM Chapter 504 (Pressure, Temperature and other Mechanical and Electromechanical Measuring Instruments) NAVSEA S9086-RK-STM-010 - NSTM Chapter 505 (Piping Systems) NAVSEA S9086-RQ-STM-010 - NSTM Chapter 510 (Heating, Ventilation, and Air Conditioning Systems for Surface Ships) NAVSEA S9086-SP-STM-010 - NSTM Chapter 542 (Gasoline and JP-5 Fuel Systems) NAVSEA S9086-SX-STM-010 - NSTM Chapter 550 (Industrial Gases; Generating, Handling, and Storage) NAVSEA S9086-SY-STM-010 - NSTM Chapter 551 (Compressed Air Plants and Systems) NAVSEA S9086-TK-STM-010 - NSTM Chapter 571 (Underway Replenishment) NAVSEA S9086-TL-STM-000 - NSTM Chapter 572 (Shipboard Stores and Provision Handling) NAVSEA S9086-TM-STM-000 - NSTM Chapter 573 (Booms) NAVSEA S9086-TV-STM-010 - NSTM Chapter 581 (Anchoring) NAVSEA S9086-TX-STM-010 - NSTM Chapter 583 (Boats and Small Craft) NAVSEA S9086-T3-STM-010 - NSTM Chapter 588 (Aircraft Elevators) NAVSEA S9086-T4-STM-010 - NSTM Chapter 589 (Cranes) NAVSEA S9086-T8-STM-010 - NSTM Chapter 593 (Pollution Control) NAVSEA S9086-UU-STM-010 - NSTM Chapter 613 (Wire and Fiber Rope and Rigging) NAVSEA S9086-VD-STM-010 - NSTM Chapter 631 V1 (Preservation of Ships In-Service - General) NAVSEA S9086-VD-STM-020 - NSTM Chapter 631 V2 (Preservation of Ships In-Service - Surface Preparation and Painting) NAVSEA S9086-VD-STM-030 - NSTM Chapter 631 V3 (Preservation of Ships In-Service - Surface Ship/Submarine Applications) NAVSEA S9086-VF-STM-010 - NSTM Chapter 633 (Cathodic Protection) NAVSEA S9086-VG-STM-010 - NSTM Chapter 634 (Deck Coverings) NAVSEA S9086-VH-STM-010 - NSTM Chapter 635 (Thermal, Fire and Acoustic Insulation) NAVSEA S9086-XG-STM-010 - NSTM Chapter 700 (Shipboard Ammunition Handling and Stowage) NAVSEA S9086-ZN-STM-000 - NSTM Chapter 772 (Cargo and Weapons Elevators) NAVSEA S9086-7G-STM-000 - NSTM Chapter 997 (Drydocking of Naval Vessels) NAVSEA S9086-7G-STM-010 - NSTM Chapter 997 (Docking Instructions and Routine Work in Dry Dock) NAVSEA 0348-LP-159-1000 - Freeze Sealing Manual (Nuclear) NAVSEA 0387-LP-046-8000 - System Hydrostatic Test Requirements I-FWD-B-8
I-FWD-B-9 COMFLTFORCOMINST 4790.3 REV A CH-6 NAVSEA 0389-LP-031-7000 - Procedures for Maintenance and Repair of Naval Reactor Plants (Nuclear) NAVSEA 0900-LP-001-7000 - Fabrication and Inspection of Brazed Piping Systems NAVSEA 0900-LP-016-6081 - Quality Assurance Standards for Submarine Antenna and Mast Materials NAVSEA 0900-LP-016-6090 - Handbook for Submarine Antenna Systems NAVSEA 0900-LP-016-7008 - Submarine Antenna Technical Documentation NAVSEA 0900-LP-095-4010 - Ship Test and Evaluation Planning Guide NAVSEA 0901-LP-120-0001 - NSTM Chapter 9120 (Hull Fittings, Lashing Gear, and Access Closures) NAVSEA 0902-LP-018-2010 - General Overhaul Specifications for Deep Diving SSBN/SSN Submarines (DDGOS) NAVSEA 0905-LP-485-6010 - Manual for the Control of Testing and Ships Conditions NAVSEA 0924-LP-062-0010 - Submarine Safety (SUBSAFE) Requirements Manual NAVSEA 0948-LP-045-7010 - Material Control Standard NAVSEA 0967-LP-412-3050 - Sonar Dome Handbook, Volume 5 NAVSEA 0989-028-5000 - Manual for Control of Testing and Plant Conditions (Nuclear) NAVSEA 0989-LP-026-1000 - A4W/A1G Reactor Plant Manual NAVSEA 0989-LP-030-7000 - Lifting Standard NAVSEA 0989-LP-031-4000 - Reactor Instrumentation and Control Equipment Maintenance NAVSEA 0989-LP-037-2000 - Commissioned Submarine General Reactor Plant Overhaul and Repair Specifications NAVSEA 0989-LP-040-6000 - Air Flask Inspection and Maintenance Requirements (Nuclear) NAVSEA 0989-LP-043-0000 - Commissioned Surface Ship General Reactor Plant Overhaul and Repair Specification NAVSEA 0989-LP-058-0000 - AS/AD Tender Nuclear Support Facilities Preventive Maintenance Index NAVSEA 0989-LP-058-1000 - Destroyer Tender and Submarine Tender Nuclear Support Facilities Overhaul and Repair Specification NAVSEA 0989-LP-062-4000 - Naval Nuclear Quality Control Manual for Shipyards NAVSEA 0989-LP-064-3000 - Cleanliness Requirements for Nuclear Propulsion Plant Maintenance by Forces Afloat NAVSEA 250-1500-1 - Welding Standard NAVSEA 389-0153 - Radiological Controls NAVSEA 389-0288 - Radiological Controls NAVSEA 392-0755 - Seal Welding Manual (Nuclear) NAVSEA S0300-B2-MAN-010 - Supervisor of Shipbuilding, Conversion and Repair Operations Manual NAVSEA S0600-AA-PRO-230 - Underwater Ship Husbandry Manual, Chapter 23: Submarine Predeployment Noise Inspections NAVSEA S0600-AA-PRO-280 - Underwater Ship Husbandry Manual, Chapter 28: Pollution Prevention NAVSEA S5475-AL-PRO-010 - Principles and Procedures for Magnetic Treatment of Ships NAVSEA S6470-AA-SAF-010 - Gas Free Engineering Manual NAVSEA S8800-00-GIP-000 - Handbook for Fleet Maintenance Activity Technical Library Personnel NAVSEA S9008-AA-PRO-010 - Lifeboat, Inflatable, MK6, MK7, and MK8 Inspection, Test and Repair Procedures NAVSEA S9040-AA-GTP-010 - Shipboard Systems Certification Requirements for Surface Ship Industrial Periods (Non-Nuclear) NAVSEA S9073-A2-HBK-010 - Resilient Mount Handbook NAVSEA S9073-A4-SNC-010 - USS LOS ANGELES (SSN 688) Class Acoustic Stealth Manual NAVSEA S9073-AF-SNC-010(C) - Ship Noise Control NAVSEA S9073-AW-SNC-010 - Ship Acoustical Surveys for Submarines
Page 1 and 2: LISTING OF APPENDICES. A Master Loc
Page 3 and 4: I-FWD-3 COMFLTFORCOMINST 4790.3 REV
Page 9 and 10: APPENDIX A MASTER LOCATOR GUIDE FOR
Page 11 and 12: CHAPTER 4 TYPE COMMANDER MAINTENANC
Page 13 and 14: 2.3 Assessment Results 2.4 Responsi
Page 15 and 16: 17.5 Safety Procedures 17.6 Catapul
Page 17 and 18: CHAPTER 6 MATERIAL CONTROL 6.1 Purp
Page 19 and 20: CHAPTER 8 DEPARTURE FROM SPECIFICAT
Page 21 and 22: CHAPTER 10 MOTOR GASOLINE HANDLING
Page 23 and 24: CHAPTER 27 SCHEDULED PRESERVATION U
Page 25 and 26: CHAPTER 2 CONTRACTS AND CONTRACT AD
Page 27 and 28: APPENDIX B MASTER LIST OF REFERENCE
Page 29 and 30: I-FWD-B-3 COMFLTFORCOMINST 4790.3 R
Page 31 and 32: FAR 203 FAR Part 1.3 - Agency Acqui
Page 33: I-FWD-B-7 COMFLTFORCOMINST 4790.3 R
Page 37 and 38: NAVSEA SI 009-04 - Quality Manageme
Page 39 and 40: NAVSEAINST 5730.1 - Legislative and
Page 41 and 42: I-FWD-B-15 COMFLTFORCOMINST 4790.3
Page 43 and 44: APPENDIX C RESPONSIBILITIES Fleet C
Page 45 and 46: Type Commander (TYCOM) Section Area
Page 47 and 48: I-FWD-C-5 COMFLTFORCOMINST 4790.3 R
Page 49 and 50: VI-9.2.2 Metrology and Calibration
Page 51 and 52: Immediate Superior in Command (ISIC
Page 53 and 54: V-I-1.4.1 Organizational Responsibi
Page 55 and 56: VI-7.2.2 Board of Inspection and Su
Page 57 and 58: I-FWD-C-15 COMFLTFORCOMINST 4790.3
Page 59 and 60: Regional Maintenance Center Command
Page 61 and 62: Ship's Commanding Officer Section A
Page 65 and 66: VI-8.2.3 Miniature/Micro-miniature
Page 71 and 72: Controlled Material Petty Officer S
Page 73 and 74: JOINT FLEET MAINTENANCE MANUAL VOLU
Page 75 and 76: iii COMFLTFORCOMINST 4790.3 REV A C
Page 77 and 78: JOINT FLEET MAINTENANCE MANUAL VOLU
Page 79 and 80: vii COMFLTFORCOMINST 4790.3 REV A C
Page 81 and 82: ix COMFLTFORCOMINST 4790.3 REV A CH
Page 83 and 84: FOREWORD JOINT FLEET MAINTENANCE MA
Page 85 and 86:
xiii COMFLTFORCOMINST 4790.3 REV A
Page 87 and 88:
xv COMFLTFORCOMINST 4790.3 REV A CH
Page 89 and 90:
xvii COMFLTFORCOMINST 4790.3 REV A
Page 91 and 92:
REFERENCES. VOLUME I CHAPTER 1 INTR
Page 93 and 94:
APPENDIX A1 SUMMARY OF TYPICAL NEW
Page 95 and 96:
APPENDIX A2 SUMMARY OF TYPICAL NEW
Page 97 and 98:
Event APPENDIX A3 SUMMARY OF TYPICA
Page 99 and 100:
I-1B-1 COMFLTFORCOMINST 4790.3 REV
Page 101 and 102:
Page 103 and 104:
Page 105 and 106:
-82 Months Begin Construction -6 Mo
Page 107 and 108:
APPENDIX C LIST OF ACRONYMS 2M Mini
Page 109 and 110:
MACHALT Machinery Alteration MBT Ma
Page 111 and 112:
TERM DEFINITION APPENDIX D GLOSSARY
Page 113 and 114:
COMFLTFORCOMINST 4790.3 REV A CH-2
Page 115 and 116:
REFERENCES. VOLUME I CHAPTER 2 POLI
Page 117 and 118:
Page 119 and 120:
Page 121 and 122:
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
MSG RCMD IN-SERVICE MSG INFO SHIP P
Page 143 and 144:
APPENDIX A2 I-2A-3 COMFLTFORCOMINST
Page 145 and 146:
Page 147 and 148:
Page 149 and 150:
APPENDIX A7 SAMPLE CNO TO SHIP PROG
Page 151 and 152:
APPENDIX A9 SAMPLE SHIP PROGRAM MAN
Page 153 and 154:
MSG PCU READY FOR FAST CRUISE & ALP
Page 155 and 156:
APPENDIX B2 I-2B-3 COMFLTFORCOMINST
Page 157 and 158:
Page 159 and 160:
Page 161 and 162:
APPENDIX B8 SAMPLE NAVSEA TO TYCOM
Page 163 and 164:
APPENDIX C COMFLTFORCOMINST 4790.3
Page 165 and 166:
APPENDIX C2 SAMPLE NAVSEA TO TYCOM
Page 167 and 168:
APPENDIX D Message Scenario and Sam
Page 169 and 170:
Page 171 and 172:
APPENDIX D3 COMFLTFORCOMINST 4790.3
Page 173 and 174:
APPENDIX E COMFLTFORCOMINST 4790.3
Page 175 and 176:
APPENDIX F COMFLTFORCOMINST 4790.3
Page 177 and 178:
APPENDIX G COMFLTFORCOMINST 4790.3
Page 179 and 180:
Concurrence PCO NRRO APPENDIX H Pre
Page 181 and 182:
APPENDIX H2 SAMPLE SUPERVISING AUTH
Page 183 and 184:
APPENDIX I COMFLTFORCOMINST 4790.3
Page 185 and 186:
APPENDIX J COMFLTFORCOMINST 4790.3
Page 187 and 188:
APPENDIX K COMFLTFORCOMINST 4790.3
Page 189 and 190:
APPENDIX L COMFLTFORCOMINST 4790.3
Page 191 and 192:
APPENDIX M COMFLTFORCOMINST 4790.3
Page 193 and 194:
APPENDIX N COMFLTFORCOMINST 4790.3
Page 195 and 196:
APPENDIX O COMFLTFORCOMINST 4790.3
Page 197 and 198:
APPENDIX P SAMPLE TYCOM MESSAGE TO
Page 199 and 200:
APPENDIX Q COMFLTFORCOMINST 4790.3
Page 201 and 202:
APPENDIX R COMFLTFORCOMINST 4790.3
Page 203 and 204:
APPENDIX S COMFLTFORCOMINST 4790.3
Page 205 and 206:
APPENDIX T COMFLTFORCOMINST 4790.3
Page 207 and 208:
APPENDIX U COMFLTFORCOMINST 4790.3
Page 209 and 210:
APPENDIX V COMFLTFORCOMINST 4790.3
Page 211 and 212:
APPENDIX W COMFLTFORCOMINST 4790.3
Page 213 and 214:
APPENDIX X COMFLTFORCOMINST 4790.3
Page 215 and 216:
APPENDIX Y COMFLTFORCOMINST 4790.3
Page 217 and 218:
APPENDIX Z COMFLTFORCOMINST 4790.3
Page 219 and 220:
The TYCOM/ISIC is responsible for t
Page 221 and 222:
APPENDIX AB COMFLTFORCOMINST 4790.3
Page 223 and 224:
Page 225 and 226:
APPENDIX AC COMFLTFORCOMINST 4790.3
Page 227 and 228:
APPENDIX AD GENERIC BASE LINE OF FL
Page 229 and 230:
• Navigation • Combat Systems C
Page 231 and 232:
Page 233 and 234:
APPENDIX AE COMFLTFORCOMINST 4790.3
Page 235 and 236:
APPENDIX AF COMFLTFORCOMINST 4790.3
Page 237 and 238:
APPENDIX AG COMFLTFORCOMINST 4790.3
Page 239 and 240:
REFERENCES. VOLUME I CHAPTER 3 PRE
Page 241 and 242:
3.3.2 Periodic Monitoring/Inspectio
Page 243 and 244:
COMFLTFORCOMINST 4790.3 REV A 3.3.5
Page 245 and 246:
3.3.9 National Policy on the Contro
Page 247 and 248:
3.3.14 Light-Off Assessment (Non-Nu
Page 249 and 250:
Page 251 and 252:
COMFLTFORCOMINST 4790.3 REV A a. Sh
Page 253 and 254:
COMFLTFORCOMINST 4790.3 REV A f. Sh
Page 255 and 256:
APPENDIX A AREAS TO BE EVALUATED DU
Page 257 and 258:
COMFLTFORCOMINST 4790.3 REV A d. Fu
Page 259 and 260:
APPENDIX B AREAS TO BE EVALUATED DU
Page 261 and 262:
Page 263 and 264:
PRE-RSE SCHEDULE OF EXAMINATION COM
Page 265 and 266:
Encl (3) I-3C-5 Name Rate/NEC Repor
Page 267 and 268:
Encl (3) I-3C-7 Name Rate/NEC Repor
Page 269 and 270:
EOOW EWS ERS RO EO RT AEA CH/CD ELT
Page 271 and 272:
INTERVIEWER - A___________ SUBJECT
Page 273 and 274:
INTERVIEWER - C -________________ S
Page 275 and 276:
SAMPLE INTERVIEW SCHEDULE INTERVIEW
Page 277 and 278:
SAMPLE STATUS OF PROPULSION PLANT S
Page 279 and 280:
Departmental SAMPLE STATUS OF PROPU
Page 281 and 282:
APPENDIX D IN-SERVICE COMPARTMENT S
Page 283 and 284:
APPENDIX E SAMPLE PRE-COMMISSIONING
Page 285 and 286:
COMFLTFORCOMINST 4790.3 REV A SAMPL
Page 287 and 288:
Page 289 and 290:
Page 291 and 292:
Page 293 and 294:
Page 295 and 296:
Page 297 and 298:
Page 299 and 300:
Page 301 and 302:
REFERENCES. VOLUME I CHAPTER 4 TRIA
Page 303 and 304:
I-4-3 COMFLTFORCOMINST 4790.3 REV A
Page 305 and 306:
Page 307 and 308:
Page 309 and 310:
Page 311 and 312:
APPENDIX A SPECIFIC DOCK TRIAL TEST
Page 313 and 314:
I-4A-3 COMFLTFORCOMINST 4790.3 REV
Page 315 and 316:
Page 317 and 318:
Page 319 and 320:
APPENDIX B MINIMUM FAST CRUISE REQU
Page 321 and 322:
Page 323 and 324:
APPENDIX C I-4C-1 COMFLTFORCOMINST
Page 325 and 326:
g. Environmental Protection Collect
Page 327 and 328:
APPENDIX D LISTING OF TESTS TO BE P
Page 329 and 330:
I-4D-3 COMFLTFORCOMINST 4790.3 REV
Page 331 and 332:
1. Radio Communication: APPENDIX E
Page 333 and 334:
APPENDIX F LISTING OF TESTS TO BE P
Page 335 and 336:
I-4F-3 COMFLTFORCOMINST 4790.3 REV
Page 337 and 338:
Page 339 and 340:
Page 341 and 342:
APPENDIX G SUBMARINE SEA TRIAL SITU
Page 343 and 344:
REFERENCES. VOLUME I CHAPTER 5 POST
Page 345 and 346:
(4) CSCT. (5) Silencing Deficiencie
Page 347 and 348:
COMFLTFORCOMINST 4790.3 REV A 5.5 G
Page 349 and 350:
I-5A-1 USS_________________________
Page 351 and 352:
APPENDIX B COMFLTFORCOMINST 4790.3
Page 353 and 354:
Key Used In The Following Columns D
Page 355 and 356:
Page 357 and 358:
REFERENCES. VOLUME I CHAPTER 6 POST
Page 359 and 360:
6.4.2 Assignment of Escort Ship (Su
Page 361 and 362:
NOTE: BUILDER TRIALS CORRECT DEFICI
Page 363 and 364:
APPENDIX B COMFLTFORCOMINST 4790.3
Page 365 and 366:
Time Event COMFLTFORCOMINST 4790.3
Page 367 and 368:
Page 369 and 370:
APPENDIX D COMFLTFORCOMINST 4790.3
Page 371 and 372:
show all

JOINT FLEET MAINTENANCE MANUAL

Create successful ePaper yourself

Delete template?

Save as template?