Surgil ESIA Report - Volume III - EKN

OAJ “O’ZLITINEFTGAZ”
ПТЭО «Комплексное обустройство
месторождения Сургиль с извлечением ценных
компонентов»
The pump sends fuel oil fuel oil through a filter at the burner boilers pressure.
Waste water discharged by gravity for the installation of waste water.
Thus, the fuel system Akchalak MCC should utilize the most combustible waste
processing units of the complex, contributes to a significant reduction in environmental
pollution.
11).
To ensure trouble-free operation mode AGHK project provides flare system (Figure
For the collector of wet jet separator installation ethylene connected devices,
operating at temperatures above 0 ° C (absorber and desorber, quench tower, and
depropanizer debutanizer, compressors and echo PRU).
For the collector dry jet separator installation ethylene connected devices, operating
at a temperature lower than 0 ° C (demetanizatory deetanizatory and install gas separation
and the installation of ethylene, ethylene fractionation column, compressor PRU).
By installing sewer jet separator of polyethylene connected devices installed
polyethylene (separators, reactors, absorbers, adsorbers).
By installing sewer jet separator butene-1 connected devices installed butene-1
(reactor, distillation column, a column of butene-1, the capacity of the spent catalyst).
All four flare separator summed fuel gas for purging. All four flare separator
connected to the flare line to it is connected and storage products and fuel system is
complex. According to the flare line discharges enter the trunk flare (flare pressure) by
torchlight water seal (150 mm), which prevents the flow of air into the system of flare line.
When the water seal is broken, evaporation, pass the molecular sieve and burned in the flare
tip. To obtain the smokeless combustion of flare headroom injected steam.
Provides periodic flare stack as necessary burning discharge and dispersion of
combustion gases in the atmosphere.
Torch carries the greatest load at full power outage or a complete cessation of the
cooling water. Also at starting complex for the torch will be supplied substandard product.
The torch burns as required periodic discharges, whose composition can vary within wide
limits.
Water from the jet drive is directed to the wastewater treatment plant.
Книга 2. Часть 2. Проект ЗВОС по строительству ГХК
37