Recycling Treated Municipal Wastewater for Industrial Water Use

More documents

Recommendations

Info

Cost Curves as Basis for Tertiary 3 - Reverse Osmosis Costs* Capital Costs Design Capital Cost (mgd) ($) 0.0001 $51,894 0.007 $51,894 0.022 $69,241 0.037 $86,588 0.091 $156,079 0.18 $222,829 0.27 $315,937 0.36 $357,087 0.68 $663,375 1 $912,423 1.2 $1,080,532 2 $2,018,579 3.5 $3,404,129 7 $6,745,258 17 $15,456,118 22 $19,862,964 76 $57,558,238 210 $129,659,099 430 $265,356,059 520 $318,914,577 1,500.00 $902,107,327 Cost, $ $70,000,000 $60,000,000 $50,000,000 $40,000,000 $30,000,000 $20,000,000 $10,000,000 $0 y = -2643.6x 2 + 957682x + 42226 R 2 = 1 0 10 20 30 40 Flow, mgd 50 60 70 80 Curve fit equations CCI Index Multiplier 1.16 Avg Flow Range 0-30 mgd Design Flow Range 0-60mgd Design/Avg Flow Ratio 2 *Source: Environmental Protection Agency (EPA), 2003. Technologies and Costs Document for the Final Long Term 2 Enhanced Surface Water Treatment Rule and Final Stage 2 Disinfectants and Disinfection Byproducts Rule. December. EPA 815-R-05-013. Membranes.xls,Summ-RO-Nanofiltration Page 1 of 2 5/3/2007 2:36 PM
Cost Curves as Basis for Tertiary 3 - Reverse Osmosis Costs* O&M Costs Average Flow O&M Cost (mgd) ($) 0.00005 $6,909 0.0015 $6,909 0.0054 $7,937 0.0095 $9,025 0.025 $13,703 0.054 $29,539 0.084 $37,904 0.11 $43,223 0.23 $70,725 0.35 $112,309 0.41 $126,572 0.77 $205,817 1.4 $343,298 3 $710,894 7.8 $1,780,761 11 $2,429,844 38 $7,914,024 120 $23,845,168 270 $52,975,344 350 $68,097,181 750 $143,706,367 Cost, $ $9,000,000 $8,000,000 $7,000,000 $6,000,000 $5,000,000 $4,000,000 $3,000,000 $2,000,000 $1,000,000 $0 y = -511.65x 2 + 227183x + 18714 R 2 = 1 0 5 10 15 20 Flow, mgd 25 30 35 40 *Source: Environmental Protection Agency (EPA), 2003. Technologies and Costs Document for the Final Long Term 2 Enhanced Surface Water Treatment Rule and Final Stage 2 Disinfectants and Disinfection Byproducts Rule. December. EPA 815-R-05-013. Membranes.xls,Summ-RO-Nanofiltration Page 2 of 2 5/3/2007 2:36 PM
Page 2 and 3:
Acknowledgements This study was con
Page 4 and 5:
Contents Recycling Treated Municipa
Page 6 and 7:
Contents Recycling Treated Municipa
Page 8 and 9:
Executive Summary Vision Executive
Page 10 and 11:
Section 1: Introduction 1.1 Project
Page 12 and 13:
Table 1.2. Water Use in Minnesota,
Page 14 and 15:
Section 1: Introduction Recycling T
Page 16 and 17:
1.5 Summary Section 1: Introduction
Page 18 and 19:
Section 2: Recycled Wastewater Dema
Page 20 and 21:
Page 23 and 24:
Page 26 and 27:
Figure 2.9. Ground Water Contaminat
Page 28:
Page 31:
Page 35 and 36:
Page 38 and 39:
Table 2.8. Ethanol Plant Capacity a
Page 40 and 41:
Page 42 and 43:
2.7 References Section 2: Recycled
Page 44 and 45:
Section 3: Recycled Wastewater Syst
Page 46 and 47:
Water Quality Overview The total co
Page 48 and 49:
Industrial Water Quality Concerns S
Page 50 and 51:
Emerging Contaminants of Concern Se
Page 52 and 53:
Page 54 and 55:
Page 56 and 57:
3.4 Storage and Transmission Overvi
Page 58 and 59:
Page 60 and 61:
Cost by Standard Industry Categorie
Page 62 and 63:
Costs and Planning Considerations S
Page 64 and 65:
Section 4: Implementation Considera
Page 66 and 67:
Economic Incentives and Risk Assess
Page 68 and 69:
Section 5: Summary and Potential Ne
Page 70 and 71:
Long-Term Vision Section 5: Summary
Page 72:
Exhibit A: California Water Recycli
Page 75 and 76:
Metropolitan Council Recycling Trea
Page 77 and 78:
Contents Section 1 - Introduction C
Page 79 and 80:
Craddock Consulting Engineers In As
Page 81 and 82:
Section 1 Introduction Craddock Con
Page 83 and 84:
Page 85 and 86:
Page 87 and 88:
Craddock Consulting Engineers 2-1 I
Page 89 and 90:
Section 2 Implementation Considerat
Page 91 and 92:
Page 93 and 94:
Page 95 and 96:
Table 2.4. Examples of State Water
Page 97 and 98:
Page 99 and 100:
Page 101 and 102:
Page 103 and 104:
Page 105 and 106:
Page 107 and 108:
Page 109:
Page 112 and 113:
Page 114 and 115:
Page 116 and 117:
Page 118 and 119:
Craddock Consulting Engineers 3-1 I
Page 120 and 121:
Section 3 Inventory of Major WWTPs
Page 122 and 123:
Page 124 and 125:
Figure 3.6. Industrial Reuse Custom
Page 126 and 127:
Page 128 and 129:
Figure 3.7b. Ground Water Availabil
Page 130 and 131:
Page 132 and 133:
") Figure 3.8c. Cedar River Watersh
Page 134 and 135:
Page 136 and 137:
Page 138 and 139:
Page 140 and 141:
") ") ") ") Figure 3.10c. Lower Mis
Page 142 and 143:
Page 144 and 145:
Page 146 and 147:
Page 148 and 149:
Page 150 and 151:
Page 152 and 153:
Figure 3.12c. Mississippi River - H
Page 154 and 155:
Page 156 and 157:
Page 158 and 159:
Figure 3.14b. Rainy River Watershed
Page 160 and 161:
Page 162 and 163:
Page 164 and 165:
Page 166 and 167:
") Figure 3.16c. St. Croix River Wa
Page 168 and 169:
Page 170 and 171:
Page 172 and 173:
Page 174 and 175:
Figure 3.18 Metro Area Industrial R
Page 176 and 177:
Page 178 and 179:
G G Flying Cloud Dr !! G! G Figure
Page 180 and 181:
Page 182 and 183:
Figure 3.22. Rogers WWTP - Industri
Page 184 and 185:
Page 186 and 187:
G G G! Dodd Rd GG Figure 3.24. Rose
Page 188 and 189:
Page 190 and 191:
G Figure 3.26. Hastings WWTP - Indu
Page 192 and 193:
State Hwy 36 ! Figure 3.28. St. Cro
Page 194 and 195:
Page 196 and 197:
Page 198 and 199:
Page 200 and 201:
Water Use Code Categories Minnesota
Page 202 and 203:
Minnesota Water Use for All Categor
Page 204 and 205:
Air Conditioning 0.2% Waterworks 15
Page 206 and 207:
Minnesota Water Use, 2000-2004 - St
Page 208 and 209:
Minnesota Water Use in 2004 (withou
Page 210 and 211:
Minnesota Water Use in 2000 (withou
Page 212 and 213:
UseCode by Year Minnesota Power Gen
Page 214 and 215:
Water Use (MGD) Water Use (MGD) 350
Page 216 and 217:
Minnesota Industrial Processing Fac
Page 218 and 219:
Minnesota Industrial Processing Fac
Page 220 and 221:
Water Use (MGD) Water Use (MGD) 120
Page 222 and 223:
Water Use (MGD) Water Use (MGD) 13.
Page 224 and 225:
Page 226 and 227:
Overview There are no federal regul
Page 228 and 229:
Appendix B Status of Water Reuse Re
Page 230 and 231:
Page 232 and 233:
Table 4. Examples of State Water Re
Page 234 and 235:
Page 236 and 237:
Page 238 and 239:
Setback Distances Appendix B Status
Page 240 and 241:
Page 242 and 243:
Page 244 and 245:
Page 246 and 247:
Page 248 and 249:
WATER USE (MGD) WATER USE (MGD) 3.5
Page 250 and 251:
Table 3.9a. Industrial Water Use in
Page 252 and 253:
Table 3.10a. Industrial Water Use i
Page 254 and 255:
Table 3.10d. Industries in the Lowe
Page 256 and 257:
WATER USE (MGD) WATER USE (MGD) 8 7
Page 258 and 259:
Table 3.11d. Industries in the Minn
Page 260 and 261:
Table 3.11d. Industries in the Minn
Page 262 and 263:
WATER USE (MGD) WATER USE (MGD) 12
Page 264 and 265:
Table 3.12c. Industries in the Miss
Page 266 and 267:
Page 268 and 269:
Page 270 and 271:
Page 272 and 273:
Page 274 and 275:
Page 276 and 277:
Page 278 and 279:
Page 280 and 281:
Page 282 and 283:
Table 3.17c. Industries in the West
Page 284 and 285:
MN Permit No Facility Minnesota Mun
Page 286 and 287:
MN Permit No Facility Minnesota Mun
Page 288 and 289:
Page 290:
Minnesota DNR Waters 2005 Ground-wa
Page 294 and 295:
Page 296 and 297:
Permit No. Organization NAICS Code
Page 298 and 299:
Page 300 and 301:
Page 302 and 303:
Page 304 and 305:
Page 306 and 307:
Page 308 and 309:
Page 310 and 311:
Page 312 and 313:
TM2: Sampling Plan and Results Recy
Page 314 and 315:
Page 316 and 317:
Page 318 and 319:
Page 320 and 321:
Page 322 and 323:
Page 324 and 325:
Page 326 and 327:
Recommended Limits for Various Indu
Page 328:
Exhibit B Blue Lake WWTP Sampling R
Page 331 and 332:
MCES Blue Lake Plant Final Effluent
Page 333 and 334:
Date Day of Wk MCES Blue Lake Plant
Page 335 and 336:
Page 337 and 338:
Page 340 and 341:
MCES Empire Plant Final Effluent Sa
Page 342 and 343:
Date Day of Wk 10/24/06 Tuesday 10/
Page 344 and 345:
Page 346 and 347:
Page 348 and 349:
Exhibit D Metropolitan (Metro) WWTP
Page 350 and 351:
MCES Metropolitan Plant Final Efflu
Page 352 and 353:
Date Day of Wk 4/19/07 Thursday 4/2
Page 354 and 355:
Page 356 and 357:
Page 358 and 359:
MCES Seneca Plant Final Effluent Sa
Page 360 and 361:
Date Day of Wk 10/8/06 Sunday 10/9/
Page 362 and 363:
Page 364 and 365:
Page 366 and 367:
Page 368 and 369:
Section 5 - Costs Table of Contents
Page 370 and 371:
TM3: Recycled Wastewater System Com
Page 372 and 373:
Page 374 and 375:
WWTP 1 - 2 - 3 - 4 - 5 - 1 Treatmen
Page 376 and 377:
Page 378 and 379:
Page 380 and 381:
Page 382:
o Synthetic medium o Two-stage Surf
Page 385 and 386:
Page 387 and 388:
Page 389 and 390:
Page 391 and 392:
Page 393 and 394:
Page 395 and 396:
Page 397 and 398:
Page 399 and 400:
Page 401 and 402:
Page 403 and 404:
Table 13 WATER REUSE SYSTEM COST OF
Page 405 and 406:
Page 407 and 408:
Page 409 and 410:
Cost of Service, $/1000 gallon 1.00
Page 411 and 412:
Page 413 and 414:
Page 415 and 416:
Page 417 and 418:
Page 419 and 420:
Cost of Service, $/1000 gallons 8.0
Page 421 and 422:
Page 423 and 424:
Appendix A Water Reuse Regulatory E
Page 425 and 426:
Table A-1. 2000 California Water Re
Page 427 and 428:
California Department of Health Ser
Page 429 and 430:
Other Media Type Filters Fuzzy Filt
Page 431 and 432:
Appendix B TECHNICAL MEMORANDUM Rec
Page 433 and 434:
Appendix B Reclaimed Water Transmis
Page 435 and 436:
Exhibit 1 Transmission Main Cost To
Page 437 and 438:
Pipe Installation Data (DR 18 PVC P
Page 439 and 440:
Equipment Costs (with O&P) Item Des
Page 441 and 442:
Water Reuse Pipe Line Construction
Page 443 and 444:
Construction Unit Costs Item (2006
Page 445 and 446:
Crew Costs (with O&P) St. Paul Pres
Page 447 and 448:
Capital PROJECT Cost Curves for Rec
Page 449 and 450:
Diam (in) Annual Average Day Flow A
Page 451 and 452:
Diam (in) Annual Average Day Flow A
Page 453 and 454:
Pipe Capital Project Cost, $ Millio
Page 455 and 456:
Pipe Capital Project Cost, $/1000 g
Page 457 and 458:
Capital PROJECT Cost Curves for Rec
Page 459 and 460: Capital PROJECT Cost Curves for Rec
Page 461 and 462: Annual Pipe Average Annual Velocity
Page 463 and 464: Pipe Capital Project Cost, $ Millio
Page 465 and 466: Exhibit 3 Water Reuse System O&M Co
Page 467 and 468: Diam (in) Annual Average Day Flow (
Page 475 and 476: Pumping Cost, $/1000 gallons 0.095
Page 477 and 478: Water Reuse System Estimated Cost o
Page 479 and 480: WATER REUSE SYSTEM COST OF SERVICE
Page 489 and 490: Appendix D-1 Water Reuse System Cos
Page 491 and 492: Water Reuse System Estimates of Pro
Page 493 and 494: Cost of Service, $/1000 gallon 2.00
Page 495 and 496: Cost Curves as Basis for Tertiary 1
Page 509: Cost of Service, $/1000 gallon 5.00
Page 533 and 534: Secondary Treatment Assumptions Sus
Page 541 and 542: Craddock Consulting Engineers 1 In
Page 543 and 544: TM4: WWTP Effluent Quality Recyclin
Page 545 and 546: !( !( !( !( !( !( !( !( !( !( !( !(
Page 549 and 550: Frequency of Occurrence, % Frequenc
Page 551 and 552: No. of Plants Total Permitting Desi
Page 555 and 556: !( !( !( !( !( !( !( !( !( !( !( !(
Page 559 and 560: Frequency of Occurrence, % Frequenc
Page 561 and 562:
No. of Plants Total Permitting Desi
Page 563 and 564:
TM4: WWTP Effluent Quality Recyclin
Page 565 and 566:
!( !( !( !( !( !( !( !( !( !( !( !(
Page 567 and 568:
TM4: WWTP Effluent Quality Recyclin
Page 569 and 570:
Craddock Consulting Engineers 1 In
Page 571 and 572:
1.0 Introduction This technical mem
Page 573 and 574:
Exhibit A Regulatory Stakeholder Me
Page 575 and 576:
MCES Recycling Treated Wastewater f
Page 577 and 578:
Page 579 and 580:
Municipal Wastewater Reuse Regulato
Page 581 and 582:
Page 583 and 584:
Exhibit B Industry Stakeholder Meet
Page 585 and 586:
Recycling Treated Wastewater For In
Page 587 and 588:
Institutional Issues Topic Discussi
Page 589 and 590:
Institutional Issues Topic Discussi
Page 591 and 592:
Page 593 and 594:
Page 595 and 596:
Page 597 and 598:
Page 599 and 600:
Exhibit C Broader Base Stakeholder
Page 601 and 602:
Page 603 and 604:
Page 605 and 606:
Page 607 and 608:
Page 609 and 610:
Page 611 and 612:
show all

Recycling Treated Municipal Wastewater for Industrial Water Use

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?