Bentley Volkswagen.Golf.Jetta.R32.Official.Factory.Repair.Manual.1999-2005

Recommendations

Info

Manual A/C Página 23 de 34 87-17 Fig. 3 Central flap cable, installing and adjusting Prerequisites: Central flap lever correctly adjusted Page 80-21 , Fig. 1. Heating and A/C controls are installed. Connecting duct removed Page 80-10 . Adjusting - Turn air distribution rotary control knob to left onto stop. - Attach center wire of cable -2- to the central flap lever -1- . - Push central flap lever to stop - arrow A- and attach outer cable - 2- with clip -3-. - Turn air distribution rotary control knob to left and right onto stops. When turning the rotary control knob, both end stops must be reached. http://ebahn.bentleypublishers.com/vw/servlet/Display?action=Next&type=repair&id=... 13/2/<strong>2005</strong>
Manual A/C Página 24 de 34 87-18 Heating and A/C components in engine compartment, servicing CAUTION! Before beginning repairs: Switch off all electrical consumers. Switch off ignition. Remove ignition key from ignition switch. Notes: System components marked with an asterisk * can only be serviced or replaced after discharging refrigerant system. Use Kent Moore ACR4 or equivalent. Before carrying out any work on the A/C refrigerant system, refer to A/C refrigerant system http://ebahn.bentleypublishers.com/vw/servlet/Display?action=Next&type=repair&id=... 13/2/<strong>2005</strong>
Page 2 and 3:
Bentley Publishers - eBahn® - Sele
Page 4 and 5:
Technical data Página 1 de 3 00-1
Page 6 and 7:
Page 8 and 9:
Engine, removing and installing Pá
Page 10 and 11:
Page 12 and 13:
Page 14 and 15:
Page 16 and 17:
Page 18 and 19:
Page 20 and 21:
Page 22 and 23:
Page 24 and 25:
Page 26 and 27:
Page 28 and 29:
Page 30 and 31:
Engine, disassembling and assemblin
Page 32 and 33:
Page 34 and 35:
Page 36 and 37:
Page 38 and 39:
Page 40 and 41:
Page 42 and 43:
Page 44 and 45:
Page 46 and 47:
Page 48 and 49:
Page 50 and 51:
Page 52 and 53:
Page 54 and 55:
Page 56 and 57:
Page 58 and 59:
Page 60 and 61:
Sealing flanges and dual-mass flywh
Page 62 and 63:
Page 64 and 65:
Page 66 and 67:
Page 68 and 69:
Page 70 and 71:
Page 72 and 73:
Page 74 and 75:
Crankshaft, removing and installing
Page 76 and 77:
Page 78 and 79:
Page 80 and 81:
Page 82 and 83:
Page 84 and 85:
Piston and connecting rod, disassem
Page 86 and 87:
Page 88 and 89:
Page 90 and 91:
Page 92 and 93:
Page 94 and 95:
Page 96 and 97:
Cylinder head, servicing Página 1
Page 98 and 99:
Page 100 and 101:
Page 102 and 103:
Page 104 and 105:
Page 106 and 107:
Page 108 and 109:
Page 110 and 111:
Page 112 and 113:
Page 114 and 115:
Page 116 and 117:
Page 118 and 119:
Page 120 and 121:
Page 122 and 123:
Page 124 and 125:
Page 126 and 127:
Page 128 and 129:
Page 130 and 131:
Page 132 and 133:
Page 134 and 135:
Page 136 and 137:
Page 138 and 139:
Page 140 and 141:
Page 142 and 143:
Page 144 and 145:
Page 146 and 147:
Page 148 and 149:
Page 150 and 151:
Page 152 and 153:
Page 154 and 155:
Valve gear, servicing Página 1 de
Page 156 and 157:
Page 158 and 159:
Page 160 and 161:
Page 162 and 163:
Page 164 and 165:
Page 166 and 167:
Page 168 and 169:
Page 170 and 171:
Page 172 and 173:
Page 174 and 175:
Page 176 and 177:
Page 178 and 179:
Page 180 and 181:
Page 182 and 183:
Page 184 and 185:
Page 186 and 187:
Page 188 and 189:
Page 190 and 191:
Page 192 and 193:
Page 194 and 195:
Page 196 and 197:
Page 198 and 199:
Page 200 and 201:
Page 202 and 203:
Page 204 and 205:
Lubrication system components, serv
Page 206 and 207:
Page 208 and 209:
Page 210 and 211:
Page 212 and 213:
Page 214 and 215:
Page 216 and 217:
Page 218 and 219:
Page 220 and 221:
Page 222 and 223:
Page 224 and 225:
Page 226 and 227:
Page 228 and 229:
Cooling system components, servicin
Page 230 and 231:
Page 232 and 233:
Page 234 and 235:
Page 236 and 237:
Page 238 and 239:
Page 240 and 241:
Page 242 and 243:
Page 244 and 245:
Page 246 and 247:
Page 248 and 249:
Page 250 and 251:
Page 252 and 253:
Page 254 and 255:
Page 256 and 257:
Page 258 and 259:
Page 260 and 261:
Page 262 and 263:
Page 264 and 265:
Page 266 and 267:
Page 268 and 269:
Page 270 and 271:
Components of fuel supply system, s
Page 272 and 273:
Page 274 and 275:
Page 276 and 277:
Page 278 and 279:
Page 280 and 281:
Page 282 and 283:
Page 284 and 285:
Page 286 and 287:
Page 288 and 289:
Page 290 and 291:
Page 292 and 293:
Page 294 and 295:
Page 296 and 297:
Page 298 and 299:
Page 300 and 301:
Page 302 and 303:
Page 304 and 305:
Page 306 and 307:
Page 308 and 309:
Page 310 and 311:
Page 312 and 313:
Evaporative Emissions (EVAP) system
Page 314 and 315:
Page 316 and 317:
Page 318 and 319:
Page 320 and 321:
Page 322 and 323:
Page 324 and 325:
Page 326 and 327:
Page 328 and 329:
Page 330 and 331:
Page 332 and 333:
Page 334 and 335:
Page 336 and 337:
Page 338 and 339:
Page 340 and 341:
Page 342 and 343:
Electronic Power Control (EPC) Pág
Page 344 and 345:
Page 346 and 347:
Page 348 and 349:
Page 350 and 351:
Page 352 and 353:
Page 354 and 355:
Exhaust system components, servicin
Page 356 and 357:
Page 358 and 359:
Page 360 and 361:
Page 362 and 363:
Page 364 and 365:
Page 366 and 367:
Page 368 and 369:
Page 370 and 371:
Page 372 and 373:
Page 374 and 375:
Page 376 and 377:
Page 378 and 379:
Page 380 and 381:
Secondary air system Página 2 de 3
Page 382 and 383:
Page 384 and 385:
Page 386 and 387:
Page 388 and 389:
Secondary air system Página 10 de
Page 390 and 391:
Page 392 and 393:
Page 394 and 395:
Page 396 and 397:
Page 398 and 399:
Page 400 and 401:
Page 402 and 403:
Page 404 and 405:
Page 406 and 407:
Page 408 and 409:
Page 410 and 411:
Page 412 and 413:
Page 414 and 415:
2.8 Liter VR6 4V Fuel Injection & I
Page 416 and 417:
2.8 Liter VR6 4V Fuel Injection & I
Page 418 and 419:
On Board Diagnostic (OBD) Página 2
Page 420 and 421:
Page 422 and 423:
Page 424 and 425:
Page 426 and 427:
Page 428 and 429:
Page 430 and 431:
Page 432 and 433:
Page 434 and 435:
Page 436 and 437:
Page 438 and 439:
Page 440 and 441:
DTC memory Página 2 de 7 01-24 Wor
Page 442 and 443:
DTC memory Página 4 de 7 01-26 - P
Page 444 and 445:
DTC memory Página 6 de 7 01-28 Wor
Page 446 and 447:
DTC table: SAE P0 codes Página 1 d
Page 448 and 449:
Page 450 and 451:
Page 452 and 453:
Page 454 and 455:
Page 456 and 457:
DTC table: SAE P0 codes Página 11
Page 458 and 459:
Page 460 and 461:
Page 462 and 463:
Page 464 and 465:
Page 466 and 467:
Page 468 and 469:
Page 470 and 471:
Page 472 and 473:
Page 474 and 475:
Page 476 and 477:
Page 478 and 479:
Page 480 and 481:
Page 482 and 483:
Page 484 and 485:
Page 486 and 487:
Page 488 and 489:
Page 490 and 491:
Page 492 and 493:
Page 494 and 495:
Page 496 and 497:
Page 498 and 499:
Page 500 and 501:
Page 502 and 503:
Page 504 and 505:
Page 506 and 507:
Page 508 and 509:
Page 510 and 511:
Page 512 and 513:
Page 514 and 515:
Page 516 and 517:
Page 518 and 519:
Output Diagnosis Test Mode (DTM) P
Page 520 and 521:
Page 522 and 523:
Page 524 and 525:
Page 526 and 527:
Page 528 and 529:
Page 530 and 531:
Page 532 and 533:
Page 534 and 535:
Page 536 and 537:
Page 538 and 539:
Page 540 and 541:
Page 542 and 543:
Page 544 and 545:
Page 546 and 547:
Page 548 and 549:
Page 550 and 551:
Page 552 and 553:
Page 554 and 555:
Page 556 and 557:
Page 558 and 559:
Page 560 and 561:
Page 562 and 563:
Page 564 and 565:
Readiness code Página 2 de 37 01-1
Page 566 and 567:
Page 568 and 569:
Page 570 and 571:
Page 572 and 573:
Readiness code Página 10 de 37 01-
Page 574 and 575:
Page 576 and 577:
Page 578 and 579:
Page 580 and 581:
Page 582 and 583:
Page 584 and 585:
Page 586 and 587:
Page 588 and 589:
Page 590 and 591:
Page 592 and 593:
Page 594 and 595:
Page 596 and 597:
Page 598 and 599:
Page 600 and 601:
Page 602 and 603:
Page 604 and 605:
Page 606 and 607:
Page 608 and 609:
Page 610 and 611:
Page 612 and 613:
Page 614 and 615:
Page 616 and 617:
Page 618 and 619:
Page 620 and 621:
Page 622 and 623:
Page 624 and 625:
Page 626 and 627:
Page 628 and 629:
Page 630 and 631:
Page 632 and 633:
Page 634 and 635:
Page 636 and 637:
Page 638 and 639:
Measured value (data) blocks Págin
Page 640 and 641:
Page 642 and 643:
Page 644 and 645:
Page 646 and 647:
Page 648 and 649:
Page 650 and 651:
Page 652 and 653:
Page 654 and 655:
Page 656 and 657:
Page 658 and 659:
Page 660 and 661:
Page 662 and 663:
Page 664 and 665:
Page 666 and 667:
Page 668 and 669:
Page 670 and 671:
Page 672 and 673:
Page 674 and 675:
Page 676 and 677:
Page 678 and 679:
Page 680 and 681:
Page 682 and 683:
Page 684 and 685:
Page 686 and 687:
Page 688 and 689:
Page 690 and 691:
Page 692 and 693:
Page 694 and 695:
Page 696 and 697:
Page 698 and 699:
Page 700 and 701:
Page 702 and 703:
Page 704 and 705:
Page 706 and 707:
Page 708 and 709:
Page 710 and 711:
Page 712 and 713:
Page 714 and 715:
Page 716 and 717:
Page 718 and 719:
Page 720 and 721:
Page 722 and 723:
Page 724 and 725:
Fuel injection system, servicing P
Page 726 and 727:
Page 728 and 729:
Page 730 and 731:
Page 732 and 733:
Page 734 and 735:
Page 736 and 737:
Page 738 and 739:
Page 740 and 741:
Page 742 and 743:
Page 744 and 745:
Page 746 and 747:
Page 748 and 749:
Page 750 and 751:
Page 752 and 753:
Page 754 and 755:
Page 756 and 757:
Page 758 and 759:
Page 760 and 761:
Page 762 and 763:
Page 764 and 765:
Page 766 and 767:
Page 768 and 769:
Page 770 and 771:
Page 772 and 773:
Page 774 and 775:
Page 776 and 777:
Page 778 and 779:
Page 780 and 781:
Page 782 and 783:
Components, checking Página 2 de 8
Page 784 and 785:
Page 786 and 787:
Page 788 and 789:
Page 790 and 791:
Components, checking Página 10 de
Page 792 and 793:
Page 794 and 795:
Page 796 and 797:
Page 798 and 799:
Page 800 and 801:
Page 802 and 803:
Page 804 and 805:
Page 806 and 807:
Page 808 and 809:
Page 810 and 811:
Page 812 and 813:
Page 814 and 815:
Page 816 and 817:
Page 818 and 819:
Page 820 and 821:
Page 822 and 823:
Page 824 and 825:
Page 826 and 827:
Page 828 and 829:
Page 830 and 831:
Page 832 and 833:
Page 834 and 835:
Page 836 and 837:
Page 838 and 839:
Page 840 and 841:
Page 842 and 843:
Page 844 and 845:
Page 846 and 847:
Page 848 and 849:
Page 850 and 851:
Page 852 and 853:
Page 854 and 855:
Page 856 and 857:
Page 858 and 859:
Page 860 and 861:
Page 862 and 863:
Page 864 and 865:
Page 866 and 867:
Page 868 and 869:
Functions, checking Página 1 de 37
Page 870 and 871:
Page 872 and 873:
Page 874 and 875:
Page 876 and 877:
Page 878 and 879:
Page 880 and 881:
Page 882 and 883:
Page 884 and 885:
Page 886 and 887:
Page 888 and 889:
Page 890 and 891:
Page 892 and 893:
Page 894 and 895:
Page 896 and 897:
Page 898 and 899:
Page 900 and 901:
Page 902 and 903:
Page 904 and 905:
Page 906 and 907:
Motronic Engine Control Module (ECM
Page 908 and 909:
Page 910 and 911:
Page 912 and 913:
Page 914 and 915:
Page 916 and 917:
Page 918 and 919:
Page 920 and 921:
Page 922 and 923:
Page 924 and 925:
Page 926 and 927:
Page 928 and 929:
Page 930 and 931:
Page 932 and 933:
Additional signals, checking Págin
Page 934 and 935:
Page 936 and 937:
Page 938 and 939:
Page 940 and 941:
Page 942 and 943:
Page 944 and 945:
Page 946 and 947:
Page 948 and 949:
Page 950 and 951:
Page 952 and 953:
Page 954 and 955:
Page 956 and 957:
Page 958 and 959:
Page 960 and 961:
Page 962 and 963:
Page 964 and 965:
Page 966 and 967:
Page 968 and 969:
Page 970 and 971:
Page 972 and 973:
Ignition system, servicing Página
Page 974 and 975:
Page 976 and 977:
Page 978 and 979:
Page 980 and 981:
Page 982 and 983:
Page 984 and 985:
Page 986 and 987:
Page 988 and 989:
Page 990 and 991:
Page 992 and 993:
Page 994 and 995:
Page 996 and 997:
Page 998 and 999:
Page 1000 and 1001:
Page 1002 and 1003:
Page 1004 and 1005:
Page 1006 and 1007:
Page 1008 and 1009:
Page 1010 and 1011:
Page 1012 and 1013:
Page 1014 and 1015:
Page 1016 and 1017:
Page 1018 and 1019:
Page 1020 and 1021:
Page 1022 and 1023:
5 & 6 Spd. Manual Transmission 02M
Page 1024 and 1025:
Transmission identification Página
Page 1026 and 1027:
Page 1028 and 1029:
Page 1030 and 1031:
Transmission layout Página 2 de 2
Page 1032 and 1033:
General repair instructions Página
Page 1034 and 1035:
General repair instructions Página
Page 1036 and 1037:
Clutch mechanism, repairing Página
Page 1038 and 1039:
Page 1040 and 1041:
Page 1042 and 1043:
Page 1044 and 1045:
Page 1046 and 1047:
Page 1048 and 1049:
Page 1050 and 1051:
Page 1052 and 1053:
Page 1054 and 1055:
Page 1056 and 1057:
Page 1058 and 1059:
Page 1060 and 1061:
Clutch release mechanism, servicing
Page 1062 and 1063:
Clutch release mechanism, servicing
Page 1064 and 1065:
Clutch, servicing Página 2 de 8 30
Page 1066 and 1067:
Page 1068 and 1069:
Page 1070 and 1071:
Page 1072 and 1073:
Page 1074 and 1075:
Page 1076 and 1077:
Page 1078 and 1079:
Page 1080 and 1081:
Gear selector mechanism, servicing
Page 1082 and 1083:
Page 1084 and 1085:
Page 1086 and 1087:
Page 1088 and 1089:
Page 1090 and 1091:
Page 1092 and 1093:
Page 1094 and 1095:
Page 1096 and 1097:
Page 1098 and 1099:
Page 1100 and 1101:
Page 1102 and 1103:
Page 1104 and 1105:
Page 1106 and 1107:
Page 1108 and 1109:
Page 1110 and 1111:
Transmission, removing and installi
Page 1112 and 1113:
Page 1114 and 1115:
Page 1116 and 1117:
Page 1118 and 1119:
Page 1120 and 1121:
Page 1122 and 1123:
Page 1124 and 1125:
Page 1126 and 1127:
Page 1128 and 1129:
Page 1130 and 1131:
Page 1132 and 1133:
Page 1134 and 1135:
Page 1136 and 1137:
Page 1138 and 1139:
Transmission gear oil, checking Pá
Page 1140 and 1141:
Transmission, disassembling and ass
Page 1142 and 1143:
Page 1144 and 1145:
Page 1146 and 1147:
Page 1148 and 1149:
Page 1150 and 1151:
Page 1152 and 1153:
Page 1154 and 1155:
Page 1156 and 1157:
Page 1158 and 1159:
Page 1160 and 1161:
Page 1162 and 1163:
Page 1164 and 1165:
Transmission housing, servicing Pá
Page 1166 and 1167:
Page 1168 and 1169:
Page 1170 and 1171:
Page 1172 and 1173:
Page 1174 and 1175:
Page 1176 and 1177:
Page 1178 and 1179:
Clutch housing, servicing Página 2
Page 1180 and 1181:
Page 1182 and 1183:
Page 1184 and 1185:
Page 1186 and 1187:
Page 1188 and 1189:
Page 1190 and 1191:
Transmission selector mechanism, di
Page 1192 and 1193:
Page 1194 and 1195:
Page 1196 and 1197:
Selector forks, disassembling and a
Page 1198 and 1199:
Input shaft, disassembling and asse
Page 1200 and 1201:
Page 1202 and 1203:
Page 1204 and 1205:
Page 1206 and 1207:
Page 1208 and 1209:
Page 1210 and 1211:
Page 1212 and 1213:
Page 1214 and 1215:
Input shaft, adjusting Página 2 de
Page 1216 and 1217:
Page 1218 and 1219:
Page 1220 and 1221:
Output shaft, 1st-4th gear, disasse
Page 1222 and 1223:
Page 1224 and 1225:
Page 1226 and 1227:
Page 1228 and 1229:
Page 1230 and 1231:
Page 1232 and 1233:
Page 1234 and 1235:
Page 1236 and 1237:
Page 1238 and 1239:
Page 1240 and 1241:
Page 1242 and 1243:
Page 1244 and 1245:
Page 1246 and 1247:
Page 1248 and 1249:
Page 1250 and 1251:
Page 1252 and 1253:
Output shaft for 1st-4th gears, adj
Page 1254 and 1255:
Page 1256 and 1257:
Page 1258 and 1259:
Page 1260 and 1261:
Output shaft for 5th, 6th and rever
Page 1262 and 1263:
Page 1264 and 1265:
Page 1266 and 1267:
Page 1268 and 1269:
Page 1270 and 1271:
Page 1272 and 1273:
Page 1274 and 1275:
Page 1276 and 1277:
Page 1278 and 1279:
Page 1280 and 1281:
Page 1282 and 1283:
Page 1284 and 1285:
Page 1286 and 1287:
Page 1288 and 1289:
Page 1290 and 1291:
Page 1292 and 1293:
Page 1294 and 1295:
Oil seals for flanged shafts, repla
Page 1296 and 1297:
Page 1298 and 1299:
Page 1300 and 1301:
Differential, disassembling and ass
Page 1302 and 1303:
Page 1304 and 1305:
Page 1306 and 1307:
Page 1308 and 1309:
Page 1310 and 1311:
Page 1312 and 1313:
Page 1314 and 1315:
Page 1316 and 1317:
Page 1318 and 1319:
Page 1320 and 1321:
Adjustment overview Página 1 de 2
Page 1322 and 1323:
Differential, adjusting Página 1 d
Page 1324 and 1325:
Page 1326 and 1327:
Page 1328 and 1329:
Page 1330 and 1331:
Brake System On Board Diagnostic (O
Page 1332 and 1333:
ABS ITT Mark 20 IE On Board Diagnos
Page 1334 and 1335:
Page 1336 and 1337:
Page 1338 and 1339:
Page 1340 and 1341:
Electrical/electronic components an
Page 1342 and 1343:
Page 1344 and 1345:
Page 1346 and 1347:
Page 1348 and 1349:
Page 1350 and 1351:
Page 1352 and 1353:
Page 1354 and 1355:
Page 1356 and 1357:
ABS ITT Mk 20 IE On Board Diagnosti
Page 1358 and 1359:
Page 1360 and 1361:
Page 1362 and 1363:
Page 1364 and 1365:
Page 1366 and 1367:
Page 1368 and 1369:
Page 1370 and 1371:
Page 1372 and 1373:
Page 1374 and 1375:
Page 1376 and 1377:
Page 1378 and 1379:
Page 1380 and 1381:
Page 1382 and 1383:
Page 1384 and 1385:
Page 1386 and 1387:
Page 1388 and 1389:
Page 1390 and 1391:
Page 1392 and 1393:
Page 1394 and 1395:
Page 1396 and 1397:
Page 1398 and 1399:
Page 1400 and 1401:
Page 1402 and 1403:
Page 1404 and 1405:
Page 1406 and 1407:
Page 1408 and 1409:
Page 1410 and 1411:
Page 1412 and 1413:
Page 1414 and 1415:
Page 1416 and 1417:
ABS, ABS/EDL and ABS/EDL/ASR ITT Ma
Page 1418 and 1419:
Page 1420 and 1421:
Page 1422 and 1423:
Page 1424 and 1425:
Page 1426 and 1427:
Page 1428 and 1429:
Page 1430 and 1431:
Page 1432 and 1433:
Page 1434 and 1435:
Page 1436 and 1437:
Page 1438 and 1439:
Page 1440 and 1441:
Page 1442 and 1443:
Page 1444 and 1445:
Page 1446 and 1447:
Page 1448 and 1449:
ABS Mark 60 On Board Diagnostic (OB
Page 1450 and 1451:
Page 1452 and 1453:
Page 1454 and 1455:
Page 1456 and 1457:
Page 1458 and 1459:
Page 1460 and 1461:
Page 1462 and 1463:
Page 1464 and 1465:
Page 1466 and 1467:
Page 1468 and 1469:
Page 1470 and 1471:
Page 1472 and 1473:
Page 1474 and 1475:
Page 1476 and 1477:
Diagnostic Trouble Codes (DTCs) dis
Page 1478 and 1479:
Diagnostic Trouble Codes (DTCs) dis
Page 1480 and 1481:
On Board Diagnostic (OBD), performi
Page 1482 and 1483:
Page 1484 and 1485:
Page 1486 and 1487:
Page 1488 and 1489:
Page 1490 and 1491:
Page 1492 and 1493:
Page 1494 and 1495:
Page 1496 and 1497:
Page 1498 and 1499:
Page 1500 and 1501:
Page 1502 and 1503:
Page 1504 and 1505:
Page 1506 and 1507:
Page 1508 and 1509:
Page 1510 and 1511:
Page 1512 and 1513:
Page 1514 and 1515:
Page 1516 and 1517:
Page 1518 and 1519:
Page 1520 and 1521:
Page 1522 and 1523:
Page 1524 and 1525:
Page 1526 and 1527:
Page 1528 and 1529:
Page 1530 and 1531:
Page 1532 and 1533:
Page 1534 and 1535:
Page 1536 and 1537:
Page 1538 and 1539:
Page 1540 and 1541:
Electrical check of Mark 60 Página
Page 1542 and 1543:
Page 1544 and 1545:
Page 1546 and 1547:
Page 1548 and 1549:
Page 1550 and 1551:
Page 1552 and 1553:
Page 1554 and 1555:
Page 1556 and 1557:
Page 1558 and 1559:
Page 1560 and 1561:
Page 1562 and 1563:
Page 1564 and 1565:
Page 1566 and 1567:
Page 1568 and 1569:
Page 1570 and 1571:
Page 1572 and 1573:
Page 1574 and 1575:
Page 1576 and 1577:
Page 1578 and 1579:
Page 1580 and 1581:
Definitions Página 1 de 6 01-326 D
Page 1582 and 1583:
Definitions Página 3 de 6 01-328 E
Page 1584 and 1585:
Definitions Página 5 de 6 01-330 S
Page 1586 and 1587:
Brake System Página 1 de 3 Select
Page 1588 and 1589:
Brake System Página 3 de 3 Brake s
Page 1590 and 1591:
Page 1592 and 1593:
Page 1594 and 1595:
Page 1596 and 1597:
Technical data, brakes Página 2 de
Page 1598 and 1599:
Page 1600 and 1601:
Page 1602 and 1603:
Anti-lock brake system (ABS) and an
Page 1604 and 1605:
Anti-lock brake system (ABS) and an
Page 1606 and 1607:
Hydraulic unit, brake booster/maste
Page 1608 and 1609:
Page 1610 and 1611:
Page 1612 and 1613:
Page 1614 and 1615:
Page 1616 and 1617:
Page 1618 and 1619:
Page 1620 and 1621:
Page 1622 and 1623:
ABS system components for front axl
Page 1624 and 1625:
Page 1626 and 1627:
Page 1628 and 1629:
Page 1630 and 1631:
Page 1632 and 1633:
Page 1634 and 1635:
Page 1636 and 1637:
Page 1638 and 1639:
Page 1640 and 1641:
Anti-lock brake system (ABS) Mark 6
Page 1642 and 1643:
Page 1644 and 1645:
Page 1646 and 1647:
VAS 5051 Vehicle Diagnostic, Testin
Page 1648 and 1649:
Page 1650 and 1651:
Page 1652 and 1653:
Page 1654 and 1655:
Page 1656 and 1657:
Page 1658 and 1659:
Hydraulic unit, brake booster/brake
Page 1660 and 1661:
Page 1662 and 1663:
Page 1664 and 1665:
Page 1666 and 1667:
Page 1668 and 1669:
Page 1670 and 1671:
Page 1672 and 1673:
Page 1674 and 1675:
Page 1676 and 1677:
DTCs displayed by (ABS) Mark 60 war
Page 1678 and 1679:
Page 1680 and 1681:
Page 1682 and 1683:
ABS system components for front and
Page 1684 and 1685:
Page 1686 and 1687:
Page 1688 and 1689:
Page 1690 and 1691:
Page 1692 and 1693:
Page 1694 and 1695:
Page 1696 and 1697:
Page 1698 and 1699:
Page 1700 and 1701:
Page 1702 and 1703:
Page 1704 and 1705:
Page 1706 and 1707:
Page 1708 and 1709:
Page 1710 and 1711:
Page 1712 and 1713:
Page 1714 and 1715:
Page 1716 and 1717:
Page 1718 and 1719:
ESP system components, removing and
Page 1720 and 1721:
Page 1722 and 1723:
Page 1724 and 1725:
Page 1726 and 1727:
Page 1728 and 1729:
Page 1730 and 1731:
Page 1732 and 1733:
Page 1734 and 1735:
Page 1736 and 1737:
Front brakes Página 2 de 53 46-2 S
Page 1738 and 1739:
Front brakes Página 4 de 53 head s
Page 1740 and 1741:
Front brakes Página 6 de 53 Checki
Page 1742 and 1743:
Front brakes Página 8 de 53 - Remo
Page 1744 and 1745:
Front brakes Página 10 de 53 12 -
Page 1746 and 1747:
Front brakes Página 12 de 53 46-8
Page 1748 and 1749:
Page 1750 and 1751:
Page 1752 and 1753:
Page 1754 and 1755:
Page 1756 and 1757:
Page 1758 and 1759:
Page 1760 and 1761:
Page 1762 and 1763:
Front brakes Página 28 de 53 Wear
Page 1764 and 1765:
Page 1766 and 1767:
Page 1768 and 1769:
Page 1770 and 1771:
Front brakes Página 36 de 53 for w
Page 1772 and 1773:
Front brakes Página 38 de 53 panel
Page 1774 and 1775:
Page 1776 and 1777:
Page 1778 and 1779:
Page 1780 and 1781:
Page 1782 and 1783:
Page 1784 and 1785:
Page 1786 and 1787:
Page 1788 and 1789:
Rear wheel brakes (disc brakes - fr
Page 1790 and 1791:
Page 1792 and 1793:
Page 1794 and 1795:
Page 1796 and 1797:
Page 1798 and 1799:
Page 1800 and 1801:
Page 1802 and 1803:
Page 1804 and 1805:
Page 1806 and 1807:
Page 1808 and 1809:
Rear wheel brakes/disc brakes (all-
Page 1810 and 1811:
Page 1812 and 1813:
Page 1814 and 1815:
Page 1816 and 1817:
Page 1818 and 1819:
Page 1820 and 1821:
Page 1822 and 1823:
Page 1824 and 1825:
Parking brake cables for disc brake
Page 1826 and 1827:
Page 1828 and 1829:
Page 1830 and 1831:
Page 1832 and 1833:
Parking brake lever, assembly overv
Page 1834 and 1835:
Brake pedal - assembly overview Pá
Page 1836 and 1837:
Page 1838 and 1839:
Page 1840 and 1841:
Page 1842 and 1843:
Page 1844 and 1845:
Page 1846 and 1847:
Front brake calipers, servicing Pá
Page 1848 and 1849:
Page 1850 and 1851:
Page 1852 and 1853:
FN 3 front brake calipers, servicin
Page 1854 and 1855:
Page 1856 and 1857:
Page 1858 and 1859:
Page 1860 and 1861:
Page 1862 and 1863:
Page 1864 and 1865:
Page 1866 and 1867:
Page 1868 and 1869:
Rear brake caliper, servicing Pági
Page 1870 and 1871:
Page 1872 and 1873:
Page 1874 and 1875:
Page 1876 and 1877:
Page 1878 and 1879:
Page 1880 and 1881:
Brake pressure regulator, assembly
Page 1882 and 1883:
Brake pressure regulator, assembly
Page 1884 and 1885:
Brake system, bleeding Página 1 de
Page 1886 and 1887:
Page 1888 and 1889:
Page 1890 and 1891:
Page 1892 and 1893:
Page 1894 and 1895:
Brake booster/brake master cylinder
Page 1896 and 1897:
Page 1898 and 1899:
Page 1900 and 1901:
Page 1902 and 1903:
Page 1904 and 1905:
Page 1906 and 1907:
Page 1908 and 1909:
Page 1910 and 1911:
Page 1912 and 1913:
Page 1914 and 1915:
Page 1916 and 1917:
Page 1918 and 1919:
Page 1920 and 1921:
Page 1922 and 1923:
Page 1924 and 1925:
Page 1926 and 1927:
Page 1928 and 1929:
Page 1930 and 1931:
Page 1932 and 1933:
Page 1934 and 1935:
Page 1936 and 1937:
Brake master cylinder, removing and
Page 1938 and 1939:
Brake master cylinder, removing and
Page 1940 and 1941:
Brake booster, removing and install
Page 1942 and 1943:
Definitions Página 1 de 2 47-87 De
Page 1944 and 1945:
Suspension, Wheels, Steering Págin
Page 1946 and 1947:
Suspension, Wheels, Steering Págin
Page 1948 and 1949:
Technical data Página 1 de 1 00 -
Page 1950 and 1951:
Check list for evaluating the suspe
Page 1952 and 1953:
Evaluation of accident vehicles Pá
Page 1954 and 1955:
Page 1956 and 1957:
Page 1958 and 1959:
Page 1960 and 1961:
Page 1962 and 1963:
Page 1964 and 1965:
Front suspension, servicing Página
Page 1966 and 1967:
Page 1968 and 1969:
Page 1970 and 1971:
Page 1972 and 1973:
Page 1974 and 1975:
Page 1976 and 1977:
Page 1978 and 1979:
Page 1980 and 1981:
Page 1982 and 1983:
Page 1984 and 1985:
Page 1986 and 1987:
Page 1988 and 1989:
Page 1990 and 1991:
Page 1992 and 1993:
Page 1994 and 1995:
Page 1996 and 1997:
Page 1998 and 1999:
Page 2000 and 2001:
Page 2002 and 2003:
Page 2004 and 2005:
Page 2006 and 2007:
Page 2008 and 2009:
Page 2010 and 2011:
Page 2012 and 2013:
Page 2014 and 2015:
Page 2016 and 2017:
Front suspension R32, servicing Pá
Page 2018 and 2019:
Page 2020 and 2021:
Page 2022 and 2023:
Page 2024 and 2025:
Page 2026 and 2027:
Page 2028 and 2029:
Page 2030 and 2031:
Page 2032 and 2033:
Page 2034 and 2035:
Page 2036 and 2037:
Page 2038 and 2039:
Page 2040 and 2041:
Page 2042 and 2043:
Page 2044 and 2045:
Page 2046 and 2047:
Page 2048 and 2049:
Page 2050 and 2051:
Page 2052 and 2053:
Page 2054 and 2055:
Page 2056 and 2057:
Page 2058 and 2059:
Front drive axle, servicing Página
Page 2060 and 2061:
Page 2062 and 2063:
Page 2064 and 2065:
Page 2066 and 2067:
Page 2068 and 2069:
Page 2070 and 2071:
Page 2072 and 2073:
Page 2074 and 2075:
Page 2076 and 2077:
Page 2078 and 2079:
Page 2080 and 2081:
Page 2082 and 2083:
Page 2084 and 2085:
Page 2086 and 2087:
Page 2088 and 2089:
Page 2090 and 2091:
Page 2092 and 2093:
Page 2094 and 2095:
Page 2096 and 2097:
Page 2098 and 2099:
Page 2100 and 2101:
Page 2102 and 2103:
Page 2104 and 2105:
Page 2106 and 2107:
Page 2108 and 2109:
Page 2110 and 2111:
Page 2112 and 2113:
Page 2114 and 2115:
Page 2116 and 2117:
Page 2118 and 2119:
Page 2120 and 2121:
Rear axle, servicing Página 1 de 3
Page 2122 and 2123:
Page 2124 and 2125:
Page 2126 and 2127:
Page 2128 and 2129:
Page 2130 and 2131:
Rear axle, servicing Página 11 de
Page 2132 and 2133:
Page 2134 and 2135:
Page 2136 and 2137:
Page 2138 and 2139:
Page 2140 and 2141:
Page 2142 and 2143:
Page 2144 and 2145:
Page 2146 and 2147:
Page 2148 and 2149:
Page 2150 and 2151:
Page 2152 and 2153:
Wheel bearing, servicing Página 1
Page 2154 and 2155:
Page 2156 and 2157:
Page 2158 and 2159:
Page 2160 and 2161:
Page 2162 and 2163:
Page 2164 and 2165:
Rear axle, servicing (all wheel dri
Page 2166 and 2167:
Page 2168 and 2169:
Page 2170 and 2171:
Page 2172 and 2173:
Page 2174 and 2175:
Page 2176 and 2177:
Page 2178 and 2179:
Page 2180 and 2181:
Page 2182 and 2183:
Page 2184 and 2185:
Page 2186 and 2187:
Page 2188 and 2189:
Page 2190 and 2191:
Page 2192 and 2193:
Trailing arm and transverse links (
Page 2194 and 2195:
Page 2196 and 2197:
Page 2198 and 2199:
Page 2200 and 2201:
Page 2202 and 2203:
Page 2204 and 2205:
Page 2206 and 2207:
Page 2208 and 2209:
Page 2210 and 2211:
Page 2212 and 2213:
Page 2214 and 2215:
Page 2216 and 2217:
Page 2218 and 2219:
Page 2220 and 2221:
Page 2222 and 2223:
Page 2224 and 2225:
Page 2226 and 2227:
Page 2228 and 2229:
Page 2230 and 2231:
Page 2232 and 2233:
Page 2234 and 2235:
Page 2236 and 2237:
Subframe with final drive, assembly
Page 2238 and 2239:
Page 2240 and 2241:
Page 2242 and 2243:
Page 2244 and 2245:
Page 2246 and 2247:
Page 2248 and 2249:
Page 2250 and 2251:
Page 2252 and 2253:
Rear drive axle, servicing Página
Page 2254 and 2255:
Page 2256 and 2257:
Page 2258 and 2259:
Page 2260 and 2261:
Page 2262 and 2263:
Page 2264 and 2265:
Evaluation of accident vehicles Pá
Page 2266 and 2267:
Protecting wheel centering seat aga
Page 2268 and 2269:
Wheels, tires Página 2 de 3 Tires
Page 2270 and 2271:
Wheel alignment Página 1 de 14 44
Page 2272 and 2273:
Wheel alignment Página 3 de 14 (al
Page 2274 and 2275:
Wheel alignment Página 5 de 14 The
Page 2276 and 2277:
Wheel alignment Página 7 de 14 1)
Page 2278 and 2279:
Wheel alignment Página 9 de 14 axl
Page 2280 and 2281:
Wheel alignment Página 11 de 14 -
Page 2282 and 2283:
Wheel alignment Página 13 de 14 ba
Page 2284 and 2285:
Wheels, tires Página 1 de 1 44 - 6
Page 2286 and 2287:
Connecting VAS 5051 and selecting f
Page 2288 and 2289:
Connecting VAS 5051 and selecting f
Page 2290 and 2291:
Steering column Página 1 de 20 48
Page 2292 and 2293:
Steering column Página 3 de 20 - R
Page 2294 and 2295:
Steering column Página 5 de 20 - R
Page 2296 and 2297:
Steering column Página 7 de 20 New
Page 2298 and 2299:
Steering column Página 9 de 20 2.
Page 2300 and 2301:
Steering column Página 11 de 20 .
Page 2302 and 2303:
Steering column Página 13 de 20 Re
Page 2304 and 2305:
Steering column Página 15 de 20 1.
Page 2306 and 2307:
Steering column Página 17 de 20 Be
Page 2308 and 2309:
Steering column Página 19 de 20 Re
Page 2310 and 2311:
Power steering, servicing Página 1
Page 2312 and 2313:
Page 2314 and 2315:
Page 2316 and 2317:
Page 2318 and 2319:
Page 2320 and 2321:
Page 2322 and 2323:
Page 2324 and 2325:
Page 2326 and 2327:
Page 2328 and 2329:
Page 2330 and 2331:
Power steering pump, reservoir and
Page 2332 and 2333:
Page 2334 and 2335:
Page 2336 and 2337:
Page 2338 and 2339:
Page 2340 and 2341:
Page 2342 and 2343:
Page 2344 and 2345:
Page 2346 and 2347:
Page 2348 and 2349:
Page 2350 and 2351:
Page 2352 and 2353:
Page 2354 and 2355:
Page 2356 and 2357:
Page 2358 and 2359:
Page 2360 and 2361:
Page 2362 and 2363:
Definitions Página 1 de 2 48 - 7 D
Page 2364 and 2365:
Body Collision Repair Página 1 de
Page 2366 and 2367:
Body Collision Repair Página 3 de
Page 2368 and 2369:
Page 2370 and 2371:
Page 2372 and 2373:
Body foam insulation Página 1 de 2
Page 2374 and 2375:
Reinforced body sheet metal Página
Page 2376 and 2377:
Galvanized body panels Página 1 de
Page 2378 and 2379:
Body panel gaps/mating lines Págin
Page 2380 and 2381:
Page 2382 and 2383:
Page 2384 and 2385:
Body dimensions Página 2 de 23 00-
Page 2386 and 2387:
Page 2388 and 2389:
Page 2390 and 2391:
Page 2392 and 2393:
Body dimensions Página 10 de 23 00
Page 2394 and 2395:
Page 2396 and 2397:
Page 2398 and 2399:
Page 2400 and 2401:
Page 2402 and 2403:
Page 2404 and 2405:
Page 2406 and 2407:
Straightening fixture Página 1 de
Page 2408 and 2409:
Page 2410 and 2411:
Page 2412 and 2413:
Page 2414 and 2415:
Page 2416 and 2417:
Page 2418 and 2419:
Page 2420 and 2421:
Page 2422 and 2423:
Page 2424 and 2425:
50 40 55 50 Engine mount bracket, r
Page 2426 and 2427:
50 52 55 50 Intermediate piece, rep
Page 2428 and 2429:
50 53 55 50 fender connecting plate
Page 2430 and 2431:
50 53 55 50 fender connecting plate
Page 2432 and 2433:
50 72 55 50 long member for upper w
Page 2434 and 2435:
50 74 55 00 Front wheel house, part
Page 2436 and 2437:
50 75 55 50 Front inner fender, rep
Page 2438 and 2439:
50 79 55 00 Front long member, repl
Page 2440 and 2441:
50 79 55 00 Front long member, repl
Page 2442 and 2443:
50 79 55 02 Front long member, part
Page 2444 and 2445:
50 80 55 00 Long member front secti
Page 2446 and 2447:
50 80 55 00 Long member front secti
Page 2448 and 2449:
51 03 55 00 Roof, replacing (Golf)
Page 2450 and 2451:
51 03 55 00 Roof, replacing (Golf)
Page 2452 and 2453:
51 03 55 00 Roof, replacing (Jetta)
Page 2454 and 2455:
51 03 55 00 Roof, replacing (Jetta)
Page 2456 and 2457:
51 03 55 20 Roof, replacing (Jetta
Page 2458 and 2459:
Page 2460 and 2461:
Page 2462 and 2463:
Page 2464 and 2465:
51 07 55 50 Front roof cross member
Page 2466 and 2467:
51 08 55 50 Roof reinforcement, rep
Page 2468 and 2469:
51 09 55 50 Rear roof cross member,
Page 2470 and 2471:
51 09 55 50 Rear cross member, repl
Page 2472 and 2473:
51 09 55 70 Rear roof crossmember,
Page 2474 and 2475:
51 09 55 70 Rear roof crossmember,
Page 2476 and 2477:
51 37 55 00 A-pillar, inner, replac
Page 2478 and 2479:
Page 2480 and 2481:
Page 2482 and 2483:
Page 2484 and 2485:
Page 2486 and 2487:
51 41 55 62 B-pillar, replacing (4
Page 2488 and 2489:
51 41 55 62 B-pillar, replacing (4
Page 2490 and 2491:
51 42 55 50 Inner B-pillar, replaci
Page 2492 and 2493:
Page 2494 and 2495:
Page 2496 and 2497:
Page 2498 and 2499:
Page 2500 and 2501:
51 45 55 00 Outer side member, repl
Page 2502 and 2503:
Page 2504 and 2505:
Page 2506 and 2507:
51 49 55 50 Side member reinforceme
Page 2508 and 2509:
51 49 55 50 Side member reinforceme
Page 2510 and 2511:
51 73 55 50 Floor plate, partial re
Page 2512 and 2513:
51 73 55 50 Floor plate, partial re
Page 2514 and 2515:
53 05 55 50 Rear cross panel, repla
Page 2516 and 2517:
53 05 55 20 Rear cross panel, exter
Page 2518 and 2519:
53 05 55 20 Rear cross panel, exter
Page 2520 and 2521:
53 05 55 23 Rear cross panel, compl
Page 2522 and 2523:
Page 2524 and 2525:
Page 2526 and 2527:
Page 2528 and 2529:
Page 2530 and 2531:
Page 2532 and 2533:
Page 2534 and 2535:
Page 2536 and 2537:
53 10 55 50 Tail light mount, repla
Page 2538 and 2539:
Page 2540 and 2541:
Page 2542 and 2543:
53 05 55 50 Rear center cross panel
Page 2544 and 2545:
53 05 55 50 Rear center cross panel
Page 2546 and 2547:
53 05 55 50 Rear cross panel, repla
Page 2548 and 2549:
53 16 55 00 End cross panel, replac
Page 2550 and 2551:
53 16 55 00 Outer wheel house, repl
Page 2552 and 2553:
53 29 55 70 Reinforcement for C-pil
Page 2554 and 2555:
53 48 55 50 Rear long member, repla
Page 2556 and 2557:
53 47 55 52 Long member, partial re
Page 2558 and 2559:
53 55 55 10 Quarter panel, partial
Page 2560 and 2561:
Page 2562 and 2563:
Page 2564 and 2565:
Page 2566 and 2567:
Page 2568 and 2569:
Page 2570 and 2571:
53 55 55 20 Side panel, partial rep
Page 2572 and 2573:
Page 2574 and 2575:
Page 2576 and 2577:
Page 2578 and 2579:
Page 2580 and 2581:
53 69 55 50 Wheel house connecting
Page 2582 and 2583:
53 36 55 50 Connecting panel, repla
Page 2584 and 2585:
53 69 55 70 Rear wheelhousing, oute
Page 2586 and 2587:
53 69 55 70 Rear wheelhousing, oute
Page 2588 and 2589:
53 80 55 50 Spare wheel well, repla
Page 2590 and 2591:
53 80 55 52 Spare wheel well, parti
Page 2592 and 2593:
Page 2594 and 2595:
Page 2596 and 2597:
Body Exterior Página 2 de 5 Front
Page 2598 and 2599:
Body Exterior Página 4 de 5 Windsh
Page 2600 and 2601:
Body, front Página 1 de 9 50 - 1 B
Page 2602 and 2603:
Body, front Página 3 de 9 carrier.
Page 2604 and 2605:
Body, front Página 5 de 9 Front fe
Page 2606 and 2607:
Body, front Página 7 de 9 Offset b
Page 2608 and 2609:
Body, front Página 9 de 9 2. Bolt
Page 2610 and 2611:
Hood Página 2 de 9 - and remove li
Page 2612 and 2613:
Hood Página 4 de 9 Bowden cable, r
Page 2614 and 2615:
Hood Página 6 de 9 - Release opera
Page 2616 and 2617:
Hood Página 8 de 9 3. Bumper ◦ R
Page 2618 and 2619:
Rear lid (Golf) Página 1 de 12 55
Page 2620 and 2621:
Rear lid (Golf) Página 3 de 12 adj
Page 2622 and 2623:
Rear lid (Golf) Página 5 de 12 - C
Page 2624 and 2625:
Rear lid (Golf) Página 7 de 12 - U
Page 2626 and 2627:
Rear lid (Golf) Página 9 de 12 Ite
Page 2628 and 2629:
Rear lid (Golf) Página 11 de 12 1.
Page 2630 and 2631:
Rear lid (Jetta) Página 1 de 11 55
Page 2632 and 2633:
Rear lid (Jetta) Página 3 de 11 3.
Page 2634 and 2635:
Rear lid (Jetta) Página 5 de 11
Page 2636 and 2637:
Rear lid (Jetta) Página 7 de 11 1.
Page 2638 and 2639:
Rear lid (Jetta) Página 9 de 11
Page 2640 and 2641:
Rear lid (Jetta) Página 11 de 11 -
Page 2642 and 2643:
Rear lid, (Jetta Wagon) Página 2 d
Page 2644 and 2645:
Page 2646 and 2647:
Page 2648 and 2649:
Page 2650 and 2651:
Rear lid, (Jetta Wagon) Página 10
Page 2652 and 2653:
Tank flap unit Página 2 de 4 ◦ I
Page 2654 and 2655:
Tank flap unit Página 4 de 4 - Ins
Page 2656 and 2657:
Front door Página 2 de 28 Front do
Page 2658 and 2659:
Front door Página 4 de 28 ◦ 20 N
Page 2660 and 2661:
Front door Página 6 de 28 - Remove
Page 2662 and 2663:
Front door Página 8 de 28 Tighteni
Page 2664 and 2665:
Front door Página 10 de 28 Batteri
Page 2666 and 2667:
Front door Página 12 de 28 - Now s
Page 2668 and 2669:
Front door Página 14 de 28 - Inser
Page 2670 and 2671:
Front door Página 16 de 28 - Lower
Page 2672 and 2673:
Front door Página 18 de 28 - Uncli
Page 2674 and 2675:
Front door Página 20 de 28 - Tight
Page 2676 and 2677:
Front door Página 22 de 28 - Remov
Page 2678 and 2679:
Front door Página 24 de 28 1. Door
Page 2680 and 2681:
Front door Página 26 de 28 Applica
Page 2682 and 2683:
Front door Página 28 de 28 dimensi
Page 2684 and 2685:
Central locking system Página 2 de
Page 2686 and 2687:
Page 2688 and 2689:
Page 2690 and 2691:
Page 2692 and 2693:
Central locking system Página 10 d
Page 2694 and 2695:
Page 2696 and 2697:
Page 2698 and 2699:
Page 2700 and 2701:
Rear doors Página 1 de 23 58 - 1 R
Page 2702 and 2703:
Rear doors Página 3 de 23 4. Bolt
Page 2704 and 2705:
Rear doors Página 5 de 23 ◦ Inst
Page 2706 and 2707:
Rear doors Página 7 de 23 1. Door
Page 2708 and 2709:
Rear doors Página 9 de 23 Removing
Page 2710 and 2711:
Rear doors Página 11 de 23 - Inser
Page 2712 and 2713:
Rear doors Página 13 de 23 If work
Page 2714 and 2715:
Rear doors Página 15 de 23 - Slide
Page 2716 and 2717:
Rear doors Página 17 de 23 - Remov
Page 2718 and 2719:
Rear doors Página 19 de 23 - Tight
Page 2720 and 2721:
Rear doors Página 21 de 23 Door se
Page 2722 and 2723:
Rear doors Página 23 de 23 http://
Page 2724 and 2725:
Sunroof Página 2 de 4 ignition is
Page 2726 and 2727:
Sunroof Página 4 de 4 rear corner
Page 2728 and 2729:
Sunroof with glass panel (Webasto)
Page 2730 and 2731:
Page 2732 and 2733:
Page 2734 and 2735:
Page 2736 and 2737:
Page 2738 and 2739:
Page 2740 and 2741:
Page 2742 and 2743:
Page 2744 and 2745:
Page 2746 and 2747:
Page 2748 and 2749:
Page 2750 and 2751:
Sunroof with glass panel (Meritor)
Page 2752 and 2753:
Page 2754 and 2755:
Page 2756 and 2757:
Page 2758 and 2759:
Page 2760 and 2761:
Page 2762 and 2763:
Page 2764 and 2765:
Page 2766 and 2767:
Page 2768 and 2769:
Page 2770 and 2771:
Front bumper Página 1 de 12 63 - 1
Page 2772 and 2773:
Front bumper Página 3 de 12 10. Ai
Page 2774 and 2775:
Front bumper Página 5 de 12 1. Bum
Page 2776 and 2777:
Front bumper Página 7 de 12 1. Bum
Page 2778 and 2779:
Front bumper Página 9 de 12 Removi
Page 2780 and 2781:
Front bumper Página 11 de 12 Insta
Page 2782 and 2783:
Rear bumper Página 1 de 14 63 - 2
Page 2784 and 2785:
Rear bumper Página 3 de 14 Removin
Page 2786 and 2787:
Rear bumper Página 5 de 14 3. Scre
Page 2788 and 2789:
Rear bumper Página 7 de 14 ◦ Rem
Page 2790 and 2791:
Rear bumper Página 9 de 14 of remo
Page 2792 and 2793:
Rear bumper Página 11 de 14 Removi
Page 2794 and 2795:
Rear bumper Página 13 de 14 order
Page 2796 and 2797:
Flush-bonded windows Página 1 de 3
Page 2798 and 2799:
Page 2800 and 2801:
Page 2802 and 2803:
Page 2804 and 2805:
Page 2806 and 2807:
Flush-bonded windows Página 11 de
Page 2808 and 2809:
Page 2810 and 2811:
Page 2812 and 2813:
Page 2814 and 2815:
Page 2816 and 2817:
Page 2818 and 2819:
Page 2820 and 2821:
Page 2822 and 2823:
Page 2824 and 2825:
Page 2826 and 2827:
Page 2828 and 2829:
Page 2830 and 2831:
Page 2832 and 2833:
Door windows Página 1 de 38 64 - 2
Page 2834 and 2835:
Door windows Página 3 de 38 instal
Page 2836 and 2837:
Door windows Página 5 de 38 holes.
Page 2838 and 2839:
Door windows Página 7 de 38 If wor
Page 2840 and 2841:
Door windows Página 9 de 38 - Pull
Page 2842 and 2843:
Door windows Página 11 de 38 1. Do
Page 2844 and 2845:
Door windows Página 13 de 38 Carri
Page 2846 and 2847:
Door windows Página 15 de 38 - Pul
Page 2848 and 2849:
Door windows Página 17 de 38 Bolt
Page 2850 and 2851:
Door windows Página 19 de 38 - Rem
Page 2852 and 2853:
Door windows Página 21 de 38 - Pul
Page 2854 and 2855:
Door windows Página 23 de 38 - Wit
Page 2856 and 2857:
Door windows Página 25 de 38 Switc
Page 2858 and 2859:
Door windows Página 27 de 38 rear
Page 2860 and 2861:
Door windows Página 29 de 38 - Rem
Page 2862 and 2863:
Door windows Página 31 de 38 ◦ W
Page 2864 and 2865:
Door windows Página 33 de 38 coupl
Page 2866 and 2867:
Door windows Página 35 de 38 - Ins
Page 2868 and 2869:
Door windows Página 37 de 38 as de
Page 2870 and 2871:
Wheelhousing liner, removing and in
Page 2872 and 2873:
Wheelhousing liner, removing and in
Page 2874 and 2875:
Outside rear view mirror Página 2
Page 2876 and 2877:
Outside rear view mirror Página 4
Page 2878 and 2879:
Roof moldings Página 1 de 2 66 - 3
Page 2880 and 2881:
Roof rail Página 1 de 3 66 - 4 Roo
Page 2882 and 2883:
Roof rail Página 3 de 3 locks in.
Page 2884 and 2885:
Trim Página 2 de 3 6. VW emblem
Page 2886 and 2887:
Protective side moldings Página 1
Page 2888 and 2889:
Rear spoiler with integrated stopli
Page 2890 and 2891:
Page 2892 and 2893:
Page 2894 and 2895:
Page 2896 and 2897:
Special components of Golf "GTI 337
Page 2898 and 2899:
Page 2900 and 2901:
Page 2902 and 2903:
Page 2904 and 2905:
Page 2906 and 2907:
Page 2908 and 2909:
Page 2910 and 2911:
Page 2912 and 2913:
Page 2914 and 2915:
Page 2916 and 2917:
Page 2918 and 2919:
Page 2920 and 2921:
Body Interior Página 2 de 6 Check
Page 2922 and 2923:
Body Interior Página 4 de 6 side c
Page 2924 and 2925:
Body Interior Página 6 de 6 Cover,
Page 2926 and 2927:
Seatbelts Página 2 de 15 Caution!
Page 2928 and 2929:
Seatbelts Página 4 de 15 Repair Ma
Page 2930 and 2931:
Seatbelts Página 6 de 15 1. Automa
Page 2932 and 2933:
Seatbelts Página 8 de 15 - Remove
Page 2934 and 2935:
Seatbelts Página 10 de 15 7. Belt
Page 2936 and 2937:
Seatbelts Página 12 de 15 Rear top
Page 2938 and 2939:
Seatbelts Página 14 de 15 Illustra
Page 2940 and 2941:
Seatbelts, inspecting Página 1 de
Page 2942 and 2943:
Page 2944 and 2945:
Page 2946 and 2947:
Airbag Página 1 de 55 69 - 4 Airba
Page 2948 and 2949:
Airbag Página 3 de 55 ◦ Removing
Page 2950 and 2951:
Airbag Página 5 de 55 Airbag syste
Page 2952 and 2953:
Airbag Página 7 de 55 driver and p
Page 2954 and 2955:
Airbag Página 9 de 55 special airb
Page 2956 and 2957:
Airbag Página 11 de 55 When replac
Page 2958 and 2959:
Airbag Página 13 de 55 4, Driver s
Page 2960 and 2961:
Airbag Página 15 de 55 Repair Manu
Page 2962 and 2963:
Airbag Página 17 de 55 - Disconnec
Page 2964 and 2965:
Airbag Página 19 de 55 1. Steering
Page 2966 and 2967:
Airbag Página 21 de 55 - Insert a
Page 2968 and 2969:
Airbag Página 23 de 55 1. Steering
Page 2970 and 2971:
Airbag Página 25 de 55 - Remove bo
Page 2972 and 2973:
Airbag Página 27 de 55 • Three-s
Page 2974 and 2975:
Airbag Página 29 de 55 - Disconnec
Page 2976 and 2977:
Airbag Página 31 de 55 ◦ 4 Nm 4.
Page 2978 and 2979:
Airbag Página 33 de 55 - Installat
Page 2980 and 2981:
Airbag Página 35 de 55 ◦ Qty. 4,
Page 2982 and 2983:
Airbag Página 37 de 55 Repair Manu
Page 2984 and 2985:
Airbag Página 39 de 55 1. Side cur
Page 2986 and 2987:
Airbag Página 41 de 55 removing an
Page 2988 and 2989:
Airbag Página 43 de 55 Make sure n
Page 2990 and 2991:
Airbag Página 45 de 55 • 04.01.
Page 2992 and 2993:
Airbag Página 47 de 55 . Side curt
Page 2994 and 2995:
Airbag Página 49 de 55 - Molded he
Page 2996 and 2997:
Airbag Página 51 de 55 . Driver an
Page 2998 and 2999:
Airbag Página 53 de 55 Therefore,
Page 3000 and 3001:
Airbag Página 55 de 55 - Press "Go
Page 3002 and 3003:
Crash sensors Página 2 de 7 4. Car
Page 3004 and 3005:
Crash sensors Página 4 de 7 . Cras
Page 3006 and 3007:
Crash sensors Página 6 de 7 Instal
Page 3008 and 3009:
Instrument panel Página 1 de 15 70
Page 3010 and 3011:
Instrument panel Página 3 de 15 -
Page 3012 and 3013:
Page 3014 and 3015:
Page 3016 and 3017:
Page 3018 and 3019:
Page 3020 and 3021:
Page 3022 and 3023:
Instrument panel Página 15 de 15 R
Page 3024 and 3025:
Door trim Página 2 de 13 1. Trim
Page 3026 and 3027:
Door trim Página 4 de 13 reach int
Page 3028 and 3029:
Door trim Página 6 de 13 1. Trim
Page 3030 and 3031:
Door trim Página 8 de 13 - Unclip
Page 3032 and 3033:
Door trim Página 10 de 13 7. locki
Page 3034 and 3035:
Door trim Página 12 de 13 - Remain
Page 3036 and 3037:
Pillar and side trim Página 1 de 7
Page 3038 and 3039:
Page 3040 and 3041:
Page 3042 and 3043:
Page 3044 and 3045:
Page 3046 and 3047:
Pillar and side trim Página 11 de
Page 3048 and 3049:
Page 3050 and 3051:
Page 3052 and 3053:
Page 3054 and 3055:
Page 3056 and 3057:
Page 3058 and 3059:
Page 3060 and 3061:
Page 3062 and 3063:
Page 3064 and 3065:
Page 3066 and 3067:
Page 3068 and 3069:
Page 3070 and 3071:
Page 3072 and 3073:
Page 3074 and 3075:
Page 3076 and 3077:
Page 3078 and 3079:
Page 3080 and 3081:
Page 3082 and 3083:
Page 3084 and 3085:
Page 3086 and 3087:
Page 3088 and 3089:
Page 3090 and 3091:
Page 3092 and 3093:
Page 3094 and 3095:
Page 3096 and 3097:
Page 3098 and 3099:
Page 3100 and 3101:
Page 3102 and 3103:
Page 3104 and 3105:
Page 3106 and 3107:
Luggage compartment trim Página 1
Page 3108 and 3109:
Page 3110 and 3111:
Page 3112 and 3113:
Page 3114 and 3115:
Page 3116 and 3117:
Page 3118 and 3119:
Page 3120 and 3121:
Page 3122 and 3123:
Page 3124 and 3125:
Page 3126 and 3127:
Page 3128 and 3129:
Page 3130 and 3131:
Page 3132 and 3133:
Rear lid trim Página 2 de 13 1. Lo
Page 3134 and 3135:
Rear lid trim Página 4 de 13 - Ins
Page 3136 and 3137:
Rear lid trim Página 6 de 13 Insta
Page 3138 and 3139:
Rear lid trim Página 8 de 13 - Loo
Page 3140 and 3141:
Rear lid trim Página 10 de 13 wago
Page 3142 and 3143:
Rear lid trim Página 12 de 13 - Un
Page 3144 and 3145:
Headliner Página 1 de 14 70 - 6 He
Page 3146 and 3147:
Headliner Página 3 de 14 Caution!
Page 3148 and 3149:
Headliner Página 5 de 14 - Remove
Page 3150 and 3151:
Headliner Página 7 de 14 - Unclip
Page 3152 and 3153:
Headliner Página 9 de 14 (Vehicles
Page 3154 and 3155:
Headliner Página 11 de 14 - Unclip
Page 3156 and 3157:
Headliner Página 13 de 14 lifting
Page 3158 and 3159:
Front seats Página 1 de 27 72 - 1
Page 3160 and 3161:
Front seats Página 3 de 27 - Push
Page 3162 and 3163:
Front seats Página 5 de 27 Repair
Page 3164 and 3165:
Front seats Página 7 de 27 ◦ for
Page 3166 and 3167:
Front seats Página 9 de 27 Front b
Page 3168 and 3169:
Front seats Página 11 de 27 - Remo
Page 3170 and 3171:
Page 3172 and 3173:
Page 3174 and 3175:
Front seats Página 17 de 27 1. Cov
Page 3176 and 3177:
Front seats Página 19 de 27 - Unho
Page 3178 and 3179:
Front seats Página 21 de 27 - Uncl
Page 3180 and 3181:
Page 3182 and 3183:
Page 3184 and 3185:
Page 3186 and 3187:
Rear seats Página 2 de 12 - Guide
Page 3188 and 3189:
Rear seats Página 4 de 12 1. Cover
Page 3190 and 3191:
Rear seats Página 6 de 12 - Remove
Page 3192 and 3193:
Rear seats Página 8 de 12 - Guide
Page 3194 and 3195:
Rear seats Página 10 de 12 Right b
Page 3196 and 3197:
Rear seats Página 12 de 12 Install
Page 3198 and 3199:
Front seat cushion and cover Págin
Page 3200 and 3201:
Page 3202 and 3203:
Page 3204 and 3205:
Page 3206 and 3207:
Page 3208 and 3209:
Page 3210 and 3211:
Page 3212 and 3213:
Seat heating elements Página 2 de
Page 3214 and 3215:
Rear seat upholstery and cover Pág
Page 3216 and 3217:
Page 3218 and 3219:
Page 3220 and 3221:
Body On Board Diagnostic (OBD) Pág
Page 3222 and 3223:
Page 3224 and 3225:
Page 3226 and 3227:
Airbag system, On Board Diagnostic
Page 3228 and 3229:
Page 3230 and 3231:
Page 3232 and 3233:
Page 3234 and 3235:
Page 3236 and 3237:
Page 3238 and 3239:
Page 3240 and 3241:
Page 3242 and 3243:
Page 3244 and 3245:
Page 3246 and 3247:
Page 3248 and 3249:
Page 3250 and 3251:
Page 3252 and 3253:
Page 3254 and 3255:
Page 3256 and 3257:
Page 3258 and 3259:
Page 3260 and 3261:
Page 3262 and 3263:
Page 3264 and 3265:
Page 3266 and 3267:
Page 3268 and 3269:
Page 3270 and 3271:
Page 3272 and 3273:
Page 3274 and 3275:
Page 3276 and 3277:
Page 3278 and 3279:
Page 3280 and 3281:
Page 3282 and 3283:
Page 3284 and 3285:
Page 3286 and 3287:
Page 3288 and 3289:
Page 3290 and 3291:
Page 3292 and 3293:
Page 3294 and 3295:
Page 3296 and 3297:
Page 3298 and 3299:
Page 3300 and 3301:
Page 3302 and 3303:
Page 3304 and 3305:
Page 3306 and 3307:
Page 3308 and 3309:
Page 3310 and 3311:
Convenience system (vehicles with p
Page 3312 and 3313:
Page 3314 and 3315:
Page 3316 and 3317:
Page 3318 and 3319:
Page 3320 and 3321:
Page 3322 and 3323:
Page 3324 and 3325:
Page 3326 and 3327:
Page 3328 and 3329:
Page 3330 and 3331:
Page 3332 and 3333:
Page 3334 and 3335:
Page 3336 and 3337:
Page 3338 and 3339:
Page 3340 and 3341:
Page 3342 and 3343:
Page 3344 and 3345:
Page 3346 and 3347:
Page 3348 and 3349:
Page 3350 and 3351:
Page 3352 and 3353:
Page 3354 and 3355:
Page 3356 and 3357:
Page 3358 and 3359:
Page 3360 and 3361:
Page 3362 and 3363:
Page 3364 and 3365:
Page 3366 and 3367:
Page 3368 and 3369:
Page 3370 and 3371:
Page 3372 and 3373:
Page 3374 and 3375:
Page 3376 and 3377:
Page 3378 and 3379:
Page 3380 and 3381:
Page 3382 and 3383:
Page 3384 and 3385:
Page 3386 and 3387:
Page 3388 and 3389:
Page 3390 and 3391:
Page 3392 and 3393:
Page 3394 and 3395:
Page 3396 and 3397:
Page 3398 and 3399:
Page 3400 and 3401:
Page 3402 and 3403:
Page 3404 and 3405:
Page 3406 and 3407:
Page 3408 and 3409:
Page 3410 and 3411:
Page 3412 and 3413:
Page 3414 and 3415:
Page 3416 and 3417:
Page 3418 and 3419:
Page 3420 and 3421:
Page 3422 and 3423:
Page 3424 and 3425:
Page 3426 and 3427:
Page 3428 and 3429:
Page 3430 and 3431:
Page 3432 and 3433:
Page 3434 and 3435:
Page 3436 and 3437:
Page 3438 and 3439:
Page 3440 and 3441:
Page 3442 and 3443:
Page 3444 and 3445:
Page 3446 and 3447:
Page 3448 and 3449:
Page 3450 and 3451:
Page 3452 and 3453:
Page 3454 and 3455:
Page 3456 and 3457:
Page 3458 and 3459:
Page 3460 and 3461:
Page 3462 and 3463:
Page 3464 and 3465:
Page 3466 and 3467:
Page 3468 and 3469:
Page 3470 and 3471:
Page 3472 and 3473:
Page 3474 and 3475:
Page 3476 and 3477:
Page 3478 and 3479:
Page 3480 and 3481:
Page 3482 and 3483:
Page 3484 and 3485:
Page 3486 and 3487:
Page 3488 and 3489:
Page 3490 and 3491:
Page 3492 and 3493:
Page 3494 and 3495:
Page 3496 and 3497:
Page 3498 and 3499:
Page 3500 and 3501:
Page 3502 and 3503:
Page 3504 and 3505:
Page 3506 and 3507:
Page 3508 and 3509:
Page 3510 and 3511:
Page 3512 and 3513:
Page 3514 and 3515:
Page 3516 and 3517:
Page 3518 and 3519:
Page 3520 and 3521:
Page 3522 and 3523:
Page 3524 and 3525:
Central locking system (vehicles wi
Page 3526 and 3527:
Page 3528 and 3529:
Page 3530 and 3531:
Page 3532 and 3533:
Page 3534 and 3535:
Page 3536 and 3537:
Page 3538 and 3539:
Page 3540 and 3541:
Page 3542 and 3543:
Page 3544 and 3545:
Page 3546 and 3547:
Page 3548 and 3549:
Page 3550 and 3551:
Page 3552 and 3553:
Page 3554 and 3555:
Page 3556 and 3557:
Page 3558 and 3559:
Page 3560 and 3561:
Page 3562 and 3563:
Page 3564 and 3565:
Page 3566 and 3567:
Page 3568 and 3569:
Page 3570 and 3571:
Page 3572 and 3573:
Page 3574 and 3575:
Page 3576 and 3577:
Page 3578 and 3579:
Page 3580 and 3581:
Page 3582 and 3583:
Page 3584 and 3585:
Page 3586 and 3587:
Page 3588 and 3589:
Page 3590 and 3591:
Page 3592 and 3593:
Page 3594 and 3595:
Page 3596 and 3597:
Page 3598 and 3599:
Page 3600 and 3601:
Page 3602 and 3603:
Page 3604 and 3605:
Page 3606 and 3607:
Driver's side seat adjustment, On B
Page 3608 and 3609:
Page 3610 and 3611:
Page 3612 and 3613:
Page 3614 and 3615:
Page 3616 and 3617:
Page 3618 and 3619:
Page 3620 and 3621:
Page 3622 and 3623:
Page 3624 and 3625:
Page 3626 and 3627:
Page 3628 and 3629:
Page 3630 and 3631:
Page 3632 and 3633:
Page 3634 and 3635:
Page 3636 and 3637:
Page 3638 and 3639:
Page 3640 and 3641:
Page 3642 and 3643:
Page 3644 and 3645:
Page 3646 and 3647:
Page 3648 and 3649:
Page 3650 and 3651:
Page 3652 and 3653:
Page 3654 and 3655:
Page 3656 and 3657:
Page 3658 and 3659:
Page 3660 and 3661:
Heating and Air Conditioning Págin
Page 3662 and 3663:
On Board Diagnostic (OBD) through m
Page 3664 and 3665:
Page 3666 and 3667:
Climatronic On Board Diagnostic (OB
Page 3668 and 3669:
Page 3670 and 3671:
Page 3672 and 3673:
Page 3674 and 3675:
Page 3676 and 3677:
Page 3678 and 3679:
Page 3680 and 3681:
Page 3682 and 3683:
Page 3684 and 3685:
Page 3686 and 3687:
Page 3688 and 3689:
Page 3690 and 3691:
Page 3692 and 3693:
Page 3694 and 3695:
Page 3696 and 3697:
Page 3698 and 3699:
Page 3700 and 3701:
Page 3702 and 3703:
Page 3704 and 3705:
Page 3706 and 3707:
Page 3708 and 3709:
Page 3710 and 3711:
Page 3712 and 3713:
Page 3714 and 3715:
Page 3716 and 3717:
Page 3718 and 3719:
Heating and ventilation system, ser
Page 3720 and 3721:
Page 3722 and 3723:
Page 3724 and 3725:
Page 3726 and 3727: Heating and ventilation system, ser
Page 3754 and 3755: Manual A/C Página 1 de 34 87-1 Man
Page 3756 and 3757: Manual A/C Página 3 de 34 87-2 3 -
Page 3758 and 3759: Manual A/C Página 5 de 34 87-3 8 -
Page 3760 and 3761: Manual A/C Página 7 de 34 87-5 18
Page 3762 and 3763: Manual A/C Página 9 de 34 87-6 Ser
Page 3764 and 3765: Manual A/C Página 11 de 34 87-8 Re
Page 3766 and 3767: Manual A/C Página 13 de 34 87-10 -
Page 3768 and 3769: Manual A/C Página 15 de 34 fuel ho
Page 3770 and 3771: Manual A/C Página 17 de 34 87-13 C
Page 3774 and 3775: Manual A/C Página 21 de 34 87-15 F
Page 3778 and 3779: Manual A/C Página 25 de 34 safety
Page 3782 and 3783: Manual A/C Página 29 de 34 system
Page 3784 and 3785: Manual A/C Página 31 de 34 Note: h
Page 3788 and 3789: Climatronic Página 1 de 61 87-25 C
Page 3790 and 3791: Climatronic Página 3 de 61 87-27 N
Page 3792 and 3793: Climatronic Página 5 de 61 87-29 C
Page 3794 and 3795: Climatronic Página 7 de 61 87-31 A
Page 3796 and 3797: Climatronic Página 9 de 61 87-32 4
Page 3798 and 3799: Climatronic Página 11 de 61 17 -.
Page 3800 and 3801: Climatronic Página 13 de 61 87-35
Page 3816 and 3817: Climatronic Página 29 de 61 Page 8
Page 3818 and 3819: Climatronic Página 31 de 61 code C
Page 3820 and 3821: Climatronic Página 33 de 61 Findin
Page 3826 and 3827:
Climatronic Página 39 de 61 87-51
Page 3828 and 3829:
Page 3830 and 3831:
Page 3832 and 3833:
Page 3834 and 3835:
Page 3836 and 3837:
Page 3838 and 3839:
Climatronic Página 51 de 61 measur
Page 3840 and 3841:
Page 3842 and 3843:
Climatronic Página 55 de 61 pressu
Page 3844 and 3845:
Climatronic Página 57 de 61 F). No
Page 3846 and 3847:
Climatronic Página 59 de 61 in mod
Page 3848 and 3849:
Page 3850 and 3851:
A/C refrigerant system Página 2 de
Page 3852 and 3853:
Page 3854 and 3855:
Page 3856 and 3857:
Page 3858 and 3859:
A/C refrigerant system Página 10 d
Page 3860 and 3861:
Page 3862 and 3863:
Page 3864 and 3865:
Page 3866 and 3867:
Page 3868 and 3869:
Page 3870 and 3871:
A/C refrigerant system, servicing P
Page 3872 and 3873:
Page 3874 and 3875:
Page 3876 and 3877:
Page 3878 and 3879:
Page 3880 and 3881:
Page 3882 and 3883:
Page 3884 and 3885:
Page 3886 and 3887:
Page 3888 and 3889:
Page 3890 and 3891:
Page 3892 and 3893:
Page 3894 and 3895:
Page 3896 and 3897:
Page 3898 and 3899:
Page 3900 and 3901:
Page 3902 and 3903:
Page 3904 and 3905:
Page 3906 and 3907:
Page 3908 and 3909:
Page 3910 and 3911:
Page 3912 and 3913:
Page 3914 and 3915:
Page 3916 and 3917:
Page 3918 and 3919:
Page 3920 and 3921:
Page 3922 and 3923:
A/C refrigerant system, troubleshoo
Page 3924 and 3925:
Page 3926 and 3927:
Page 3928 and 3929:
Page 3930 and 3931:
Page 3932 and 3933:
A/C refrigerant system, capacities
Page 3934 and 3935:
A/C refrigerant system, capacities
Page 3936 and 3937:
Compressor bracket, removing and in
Page 3938 and 3939:
Page 3940 and 3941:
Page 3942 and 3943:
Page 3944 and 3945:
Page 3946 and 3947:
Page 3948 and 3949:
Page 3950 and 3951:
Page 3952 and 3953:
Page 3954 and 3955:
Page 3956 and 3957:
Page 3958 and 3959:
Page 3960 and 3961:
Page 3962 and 3963:
Page 3964 and 3965:
Page 3966 and 3967:
Page 3968 and 3969:
Page 3970 and 3971:
Refrigerant R134a - Servicing Pági
Page 3972 and 3973:
General information for A/C system
Page 3974 and 3975:
Page 3976 and 3977:
Page 3978 and 3979:
Page 3980 and 3981:
Page 3982 and 3983:
Page 3984 and 3985:
Page 3986 and 3987:
Page 3988 and 3989:
Page 3990 and 3991:
Page 3992 and 3993:
General information on refrigerant
Page 3994 and 3995:
Page 3996 and 3997:
Page 3998 and 3999:
Page 4000 and 4001:
Page 4002 and 4003:
Page 4004 and 4005:
Page 4006 and 4007:
Page 4008 and 4009:
Page 4010 and 4011:
Page 4012 and 4013:
Laws and regulations Página 1 de 6
Page 4014 and 4015:
Page 4016 and 4017:
Page 4018 and 4019:
Refrigerant circuit Página 1 de 11
Page 4020 and 4021:
Page 4022 and 4023:
Page 4024 and 4025:
Page 4026 and 4027:
Page 4028 and 4029:
Page 4030 and 4031:
Complaints Página 2 de 2 A/C compr
Page 4032 and 4033:
Pressures, checking on vehicles Pá
Page 4034 and 4035:
Page 4036 and 4037:
Page 4038 and 4039:
Page 4040 and 4041:
Page 4042 and 4043:
Page 4044 and 4045:
Page 4046 and 4047:
Page 4048 and 4049:
Page 4050 and 4051:
Page 4052 and 4053:
Page 4054 and 4055:
Page 4056 and 4057:
Page 4058 and 4059:
Page 4060 and 4061:
Page 4062 and 4063:
Page 4064 and 4065:
Page 4066 and 4067:
Components, replacing Página 2 de
Page 4068 and 4069:
Page 4070 and 4071:
Page 4072 and 4073:
Testing equipment and tools Página
Page 4074 and 4075:
Page 4076 and 4077:
Page 4078 and 4079:
Page 4080 and 4081:
Electrical Equipment On Board Diagn
Page 4082 and 4083:
Page 4084 and 4085:
Page 4086 and 4087:
On Board Diagnostic (OBD) from m.y.
Page 4088 and 4089:
Instrument cluster through m.y. 199
Page 4090 and 4091:
Page 4092 and 4093:
Page 4094 and 4095:
Page 4096 and 4097:
Page 4098 and 4099:
Page 4100 and 4101:
Page 4102 and 4103:
Page 4104 and 4105:
Page 4106 and 4107:
Page 4108 and 4109:
Page 4110 and 4111:
Page 4112 and 4113:
Page 4114 and 4115:
Page 4116 and 4117:
Page 4118 and 4119:
Page 4120 and 4121:
Page 4122 and 4123:
Page 4124 and 4125:
Page 4126 and 4127:
Page 4128 and 4129:
Page 4130 and 4131:
Page 4132 and 4133:
Page 4134 and 4135:
Page 4136 and 4137:
Page 4138 and 4139:
Page 4140 and 4141:
Page 4142 and 4143:
Page 4144 and 4145:
Page 4146 and 4147:
Page 4148 and 4149:
Page 4150 and 4151:
Instrument cluster m.y. 2000 throug
Page 4152 and 4153:
Page 4154 and 4155:
Page 4156 and 4157:
Page 4158 and 4159:
Page 4160 and 4161:
Page 4162 and 4163:
Page 4164 and 4165:
Page 4166 and 4167:
Page 4168 and 4169:
Page 4170 and 4171:
Page 4172 and 4173:
Page 4174 and 4175:
Page 4176 and 4177:
Page 4178 and 4179:
Page 4180 and 4181:
Page 4182 and 4183:
Page 4184 and 4185:
Page 4186 and 4187:
Page 4188 and 4189:
Page 4190 and 4191:
Page 4192 and 4193:
Page 4194 and 4195:
Page 4196 and 4197:
Page 4198 and 4199:
Page 4200 and 4201:
Page 4202 and 4203:
Page 4204 and 4205:
Page 4206 and 4207:
Page 4208 and 4209:
Page 4210 and 4211:
Page 4212 and 4213:
Page 4214 and 4215:
Page 4216 and 4217:
Page 4218 and 4219:
Page 4220 and 4221:
Page 4222 and 4223:
Page 4224 and 4225:
Page 4226 and 4227:
Data Bus On Board Diagnostic Interf
Page 4228 and 4229:
Page 4230 and 4231:
Page 4232 and 4233:
Page 4234 and 4235:
Page 4236 and 4237:
Page 4238 and 4239:
Page 4240 and 4241:
Page 4242 and 4243:
Page 4244 and 4245:
Page 4246 and 4247:
Anti-theft immobilizer, On Board Di
Page 4248 and 4249:
Electrical Equipment Página 2 de 6
Page 4250 and 4251:
Page 4252 and 4253:
Page 4254 and 4255:
Battery Página 2 de 7 27-2 A new g
Page 4256 and 4257:
Battery Página 4 de 7 27-4 Warning
Page 4258 and 4259:
Battery Página 6 de 7 27-5 Battery
Page 4260 and 4261:
Battery, checking Página 1 de 28 2
Page 4262 and 4263:
Page 4264 and 4265:
Page 4266 and 4267:
Page 4268 and 4269:
Page 4270 and 4271:
Battery, checking Página 11 de 28
Page 4272 and 4273:
Page 4274 and 4275:
Page 4276 and 4277:
Page 4278 and 4279:
Page 4280 and 4281:
Page 4282 and 4283:
Page 4284 and 4285:
Page 4286 and 4287:
Page 4288 and 4289:
Battery, charging Página 1 de 5 27
Page 4290 and 4291:
Page 4292 and 4293:
Page 4294 and 4295:
Battery, disconnecting and reconnec
Page 4296 and 4297:
Page 4298 and 4299:
Page 4300 and 4301:
Page 4302 and 4303:
Page 4304 and 4305:
Page 4306 and 4307:
Battery, removing and installing P
Page 4308 and 4309:
Page 4310 and 4311:
Page 4312 and 4313:
Page 4314 and 4315:
Page 4316 and 4317:
Starter Página 1 de 9 27-61 Starte
Page 4318 and 4319:
Starter Página 3 de 9 27-63 Specia
Page 4320 and 4321:
Starter Página 5 de 9 27-65 - Remo
Page 4322 and 4323:
Starter Página 7 de 9 27-67 Starte
Page 4324 and 4325:
Starter Página 9 de 9 27-69 - Remo
Page 4326 and 4327:
Generator (GEN) Página 1 de 1 27-7
Page 4328 and 4329:
Generator (GEN) through 04.99 Pági
Page 4330 and 4331:
Generator (GEN) through 04.99 Pági
Page 4332 and 4333:
Generator (GEN) from 05.99 Página
Page 4334 and 4335:
Page 4336 and 4337:
Page 4338 and 4339:
Generator (GEN) - 4-cylinder gasoli
Page 4340 and 4341:
Page 4342 and 4343:
Page 4344 and 4345:
Page 4346 and 4347:
Page 4348 and 4349:
Page 4350 and 4351:
Page 4352 and 4353:
Page 4354 and 4355:
Page 4356 and 4357:
Page 4358 and 4359:
Page 4360 and 4361:
Generator (GEN) - 4-cylinder TDI en
Page 4362 and 4363:
Page 4364 and 4365:
Page 4366 and 4367:
Page 4368 and 4369:
Page 4370 and 4371:
Page 4372 and 4373:
Page 4374 and 4375:
Page 4376 and 4377:
Page 4378 and 4379:
Generator (GEN) - 4-cylinder TDI -
Page 4380 and 4381:
Page 4382 and 4383:
Page 4384 and 4385:
Page 4386 and 4387:
Page 4388 and 4389:
Page 4390 and 4391:
Generator (GEN), tightening torques
Page 4392 and 4393:
Page 4394 and 4395:
Page 4396 and 4397:
Cruise Control System (CCS) through
Page 4398 and 4399:
Page 4400 and 4401:
Page 4402 and 4403:
Page 4404 and 4405:
Page 4406 and 4407:
Page 4408 and 4409:
Page 4410 and 4411:
Instrument cluster Página 1 de 20
Page 4412 and 4413:
Page 4414 and 4415:
Page 4416 and 4417:
Page 4418 and 4419:
Page 4420 and 4421:
Page 4422 and 4423:
Page 4424 and 4425:
Page 4426 and 4427:
Page 4428 and 4429:
Page 4430 and 4431:
Windshield wiper system Página 1 d
Page 4432 and 4433:
Page 4434 and 4435:
Page 4436 and 4437:
Page 4438 and 4439:
Page 4440 and 4441:
Windshield wiper system Página 11
Page 4442 and 4443:
Page 4444 and 4445:
Page 4446 and 4447:
Page 4448 and 4449:
Windshield wiper system, tightening
Page 4450 and 4451:
Washer system Página 2 de 10 Remov
Page 4452 and 4453:
Washer system Página 4 de 10 92-22
Page 4454 and 4455:
Page 4456 and 4457:
Page 4458 and 4459:
Page 4460 and 4461:
Rear window wiper [amp] washer syst
Page 4462 and 4463:
Page 4464 and 4465:
Page 4466 and 4467:
Page 4468 and 4469:
Page 4470 and 4471:
Washer hoses, repairing Página 1 d
Page 4472 and 4473:
Washer hoses, repairing Página 3 d
Page 4474 and 4475:
Headlights - Golf Página 1 de 20 9
Page 4476 and 4477:
Headlights - Golf Página 3 de 20 L
Page 4478 and 4479:
Page 4480 and 4481:
Page 4482 and 4483:
Page 4484 and 4485:
Headlights - Golf Página 11 de 20
Page 4486 and 4487:
Page 4488 and 4489:
Page 4490 and 4491:
Page 4492 and 4493:
Page 4494 and 4495:
Headlights - Jetta Página 1 de 17
Page 4496 and 4497:
Page 4498 and 4499:
Page 4500 and 4501:
Page 4502 and 4503:
Page 4504 and 4505:
Page 4506 and 4507:
Page 4508 and 4509:
Page 4510 and 4511:
Page 4512 and 4513:
Side mounted turn signals Página 2
Page 4514 and 4515:
Rear lights Página 2 de 11 94-37 5
Page 4516 and 4517:
Page 4518 and 4519:
Page 4520 and 4521:
Rear lights Página 8 de 11 94-43 R
Page 4522 and 4523:
Rear lights Página 10 de 11 94-45
Page 4524 and 4525:
Rear lights, tightening torques Pá
Page 4526 and 4527:
High-mount brake light Página 1 de
Page 4528 and 4529:
Page 4530 and 4531:
Page 4532 and 4533:
Steering column switches Página 1
Page 4534 and 4535:
Page 4536 and 4537:
Page 4538 and 4539:
Page 4540 and 4541:
Ignition/starter switch and lock cy
Page 4542 and 4543:
Page 4544 and 4545:
Page 4546 and 4547:
Page 4548 and 4549:
Interior lights and switches Págin
Page 4550 and 4551:
Page 4552 and 4553:
Page 4554 and 4555:
Page 4556 and 4557:
Page 4558 and 4559:
Page 4560 and 4561:
Page 4562 and 4563:
Page 4564 and 4565:
Page 4566 and 4567:
Page 4568 and 4569:
Page 4570 and 4571:
Page 4572 and 4573:
Page 4574 and 4575:
Anti-theft Immobilizer Página 1 de
Page 4576 and 4577:
Page 4578 and 4579:
Page 4580 and 4581:
Page 4582 and 4583:
Fuse holder and relay carriers Pág
Page 4584 and 4585:
Page 4586 and 4587:
Page 4588 and 4589:
Page 4590 and 4591:
Page 4592 and 4593:
Wiring harnesses and connectors, re
Page 4594 and 4595:
Page 4596 and 4597:
Page 4598 and 4599:
Page 4600 and 4601:
Antenna cables, replacing Página 2
Page 4602 and 4603:
Antenna cables, replacing Página 4
Page 4604 and 4605:
Communication Página 2 de 3 Genera
Page 4606 and 4607:
Radio system - Premium IV and Premi
Page 4608 and 4609:
Page 4610 and 4611:
Page 4612 and 4613:
Page 4614 and 4615:
Page 4616 and 4617:
Page 4618 and 4619:
Page 4620 and 4621:
Page 4622 and 4623:
Page 4624 and 4625:
Page 4626 and 4627:
Page 4628 and 4629:
Page 4630 and 4631:
Page 4632 and 4633:
Radio system - Premium VI (includin
Page 4634 and 4635:
Page 4636 and 4637:
Page 4638 and 4639:
Page 4640 and 4641:
Page 4642 and 4643:
Page 4644 and 4645:
Page 4646 and 4647:
Page 4648 and 4649:
Page 4650 and 4651:
Page 4652 and 4653:
Page 4654 and 4655:
Page 4656 and 4657:
Page 4658 and 4659:
Page 4660 and 4661:
Page 4662 and 4663:
Multi-function steering wheel throu
Page 4664 and 4665:
Page 4666 and 4667:
Page 4668 and 4669:
Page 4670 and 4671:
Page 4672 and 4673:
Page 4674 and 4675:
Page 4676 and 4677:
Page 4678 and 4679:
Page 4680 and 4681:
Page 4682 and 4683:
Page 4684 and 4685:
Page 4686 and 4687:
Page 4688 and 4689:
Multi-function steering wheel from
Page 4690 and 4691:
Multi-function steering wheel from
Page 4692 and 4693:
Communication Página 2 de 3 91-2 O
Page 4694 and 4695:
Radio systems Página 1 de 1 91-4 R
Page 4696 and 4697:
Radio, Premium IV' Página 2 de 10
Page 4698 and 4699:
Page 4700 and 4701:
Page 4702 and 4703:
Page 4704 and 4705:
Page 4706 and 4707:
Radio, Premium V and Premium V - Mo
Page 4708 and 4709:
Page 4710 and 4711:
Page 4712 and 4713:
Page 4714 and 4715:
Page 4716 and 4717:
Radio, Premium VI and Premium VI -
Page 4718 and 4719:
Page 4720 and 4721:
Page 4722 and 4723:
Page 4724 and 4725:
Page 4726 and 4727:
Page 4728 and 4729:
Amplifier system - Monsoon Página
Page 4730 and 4731:
Page 4732 and 4733:
Page 4734 and 4735:
Speaker system Página 2 de 4 91-43
Page 4736 and 4737:
Speaker system Página 4 de 4 91-45
Page 4738 and 4739:
Antenna systems Página 2 de 11 91-
Page 4740 and 4741:
Page 4742 and 4743:
Page 4744 and 4745:
Page 4746 and 4747:
Antenna systems Página 10 de 11 91
Page 4748 and 4749:
CD Changer / CD Player Página 1 de
Page 4750 and 4751:
Page 4752 and 4753:
Page 4754 and 4755:
Page 4756 and 4757:
Page 4758 and 4759:
Multi-function steering wheel Pági
Page 4760 and 4761:
Page 4762 and 4763:
Page 4764 and 4765:
Page 4766 and 4767:
Page 4768 and 4769:
Page 4770 and 4771:
Telematics Página 2 de 35 91-77 Du
Page 4772 and 4773:
Telematics Página 4 de 35 91-79 Te
Page 4774 and 4775:
Telematics Página 6 de 35 91-80 4
Page 4776 and 4777:
Page 4778 and 4779:
Telematics Página 10 de 35 91-82 T
Page 4780 and 4781:
Page 4782 and 4783:
Telematics Página 14 de 35 91-86 -
Page 4784 and 4785:
Page 4786 and 4787:
Page 4788 and 4789:
Page 4790 and 4791:
Telematics Página 22 de 35 - Enter
Page 4792 and 4793:
Page 4794 and 4795:
Telematics Página 26 de 35 91-97 C
Page 4796 and 4797:
Telematics Página 28 de 35 91-99 -
Page 4798 and 4799:
Telematics Página 30 de 35 91-101
Page 4800 and 4801:
Page 4802 and 4803:
Page 4804 and 4805:
Mobile telephone and two-way radio
Page 4806 and 4807:
Page 4808 and 4809:
Page 4810 and 4811:
Page 4812 and 4813:
Page 4814 and 4815:
Page 4816 and 4817:
Página 2 de 3 Transportation wiper
Page 4818 and 4819:
Engine overview Página 1 de 1 1 En
Page 4820 and 4821:
Oil change service Página 1 de 1 3
Page 4822 and 4823:
Maintenance service Página 1 de 1
Page 4824 and 4825:
General Página 2 de 23 Installing
Page 4826 and 4827:
General Página 4 de 23 Front valan
Page 4828 and 4829:
General Página 6 de 23 Assembly to
Page 4830 and 4831:
General Página 8 de 23 in. Thereaf
Page 4832 and 4833:
General Página 10 de 23 - Set spri
Page 4834 and 4835:
General Página 12 de 23 Vehicle Di
Page 4836 and 4837:
General Página 14 de 23 The vehicl
Page 4838 and 4839:
General Página 16 de 23 - - 2 - PR
Page 4840 and 4841:
General Página 18 de 23 Stamped in
Page 4842 and 4843:
General Página 20 de 23 Front: Beh
Page 4844 and 4845:
General Página 22 de 23 Driver of
Page 4846 and 4847:
Description of work (part 1 of 2) P
Page 4848 and 4849:
Page 4850 and 4851:
Page 4852 and 4853:
Page 4854 and 4855:
Page 4856 and 4857:
Page 4858 and 4859:
Page 4860 and 4861:
Page 4862 and 4863:
Page 4864 and 4865:
Page 4866 and 4867:
Page 4868 and 4869:
Page 4870 and 4871:
Page 4872 and 4873:
Page 4874 and 4875:
Page 4876 and 4877:
Page 4878 and 4879:
Page 4880 and 4881:
Page 4882 and 4883:
Page 4884 and 4885:
Page 4886 and 4887:
Page 4888 and 4889:
Page 4890 and 4891:
Page 4892 and 4893:
Page 4894 and 4895:
Page 4896 and 4897:
Page 4898 and 4899:
Page 4900 and 4901:
Page 4902 and 4903:
Page 4904 and 4905:
Page 4906 and 4907:
Page 4908 and 4909:
Page 4910 and 4911:
Page 4912 and 4913:
Page 4914 and 4915:
Page 4916 and 4917:
Page 4918 and 4919:
Page 4920 and 4921:
Page 4922 and 4923:
Page 4924 and 4925:
Page 4926 and 4927:
Page 4928 and 4929:
Page 4930 and 4931:
Page 4932 and 4933:
Page 4934 and 4935:
Page 4936 and 4937:
Page 4938 and 4939:
Page 4940 and 4941:
Page 4942 and 4943:
Page 4944 and 4945:
Page 4946 and 4947:
Page 4948 and 4949:
Page 4950 and 4951:
Page 4952 and 4953:
Page 4954:
show all

Bentley Volkswagen.Golf.Jetta.R32.Official.Factory.Repair.Manual.1999-2005

Create successful ePaper yourself

Delete template?

Save as template?