Bentley Volkswagen.Golf.Jetta.R32.Official.Factory.Repair.Manual.1999-2005

Recommendations

Info

Fuel injection system, servicing Página 54 de 58 24-33 Safety precautions CAUTION! When performing repair work, especially due to the confined conditions in the engine well, pay attention to the following: Route all types of lines (e.g. for fuel, hydraulics, Evaporative Emissions (EVAP) system, coolant, refrigerant, brake fluid and vacuum) as well as electrical wiring so that the original positions are restored. Ensure sufficient clearance to all moving or hot components. For safety reasons, fuse No. 28 must be removed from fuse holder before opening fuel system because fuel pump can be activated by door terminal switch in driver's door. http://ebahn.bentleypublishers.com/vw/servlet/Display?action=Goto&type=repair&id=... 12/2/<strong>2005</strong>
Fuel injection system, servicing Página 55 de 58 24-34 To prevent injuries to persons and/or damage to the fuel injection and ignition system, the following must be noted: WARNING! Fuel system is under pressure! Before opening the system place a cloth around the connection. Then release pressure by carefully loosening the connection. Do not touch or disconnect ignition coils when the engine is running or being turned at starter speed. The ignition must be switched off before connecting or disconnecting injection or ignition system wiring or tester cables. Observe following if test and measuring instruments are required during a road test: Test and measuring instruments must be secured to rear seat and operated by a 2nd person from this location. WARNING! If test and measuring instruments are operated from front passenger's seat and the vehicle is involved in an accident, there is a possibility that the person sitting in this seat may receive serious injuries when the airbag is triggered. http://ebahn.bentleypublishers.com/vw/servlet/Display?action=Goto&type=repair&id=... 12/2/<strong>2005</strong>
Page 2 and 3:
Bentley Publishers - eBahn® - Sele
Page 4 and 5:
Technical data Página 1 de 3 00-1
Page 6 and 7:
Page 8 and 9:
Engine, removing and installing Pá
Page 10 and 11:
Page 12 and 13:
Page 14 and 15:
Page 16 and 17:
Page 18 and 19:
Page 20 and 21:
Page 22 and 23:
Page 24 and 25:
Page 26 and 27:
Page 28 and 29:
Page 30 and 31:
Engine, disassembling and assemblin
Page 32 and 33:
Page 34 and 35:
Page 36 and 37:
Page 38 and 39:
Page 40 and 41:
Page 42 and 43:
Page 44 and 45:
Page 46 and 47:
Page 48 and 49:
Page 50 and 51:
Page 52 and 53:
Page 54 and 55:
Page 56 and 57:
Page 58 and 59:
Page 60 and 61:
Sealing flanges and dual-mass flywh
Page 62 and 63:
Page 64 and 65:
Page 66 and 67:
Page 68 and 69:
Page 70 and 71:
Page 72 and 73:
Page 74 and 75:
Crankshaft, removing and installing
Page 76 and 77:
Page 78 and 79:
Page 80 and 81:
Page 82 and 83:
Page 84 and 85:
Piston and connecting rod, disassem
Page 86 and 87:
Page 88 and 89:
Page 90 and 91:
Page 92 and 93:
Page 94 and 95:
Page 96 and 97:
Cylinder head, servicing Página 1
Page 98 and 99:
Page 100 and 101:
Page 102 and 103:
Page 104 and 105:
Page 106 and 107:
Page 108 and 109:
Page 110 and 111:
Page 112 and 113:
Page 114 and 115:
Page 116 and 117:
Page 118 and 119:
Page 120 and 121:
Page 122 and 123:
Page 124 and 125:
Page 126 and 127:
Page 128 and 129:
Page 130 and 131:
Page 132 and 133:
Page 134 and 135:
Page 136 and 137:
Page 138 and 139:
Page 140 and 141:
Page 142 and 143:
Page 144 and 145:
Page 146 and 147:
Page 148 and 149:
Page 150 and 151:
Page 152 and 153:
Page 154 and 155:
Valve gear, servicing Página 1 de
Page 156 and 157:
Page 158 and 159:
Page 160 and 161:
Page 162 and 163:
Page 164 and 165:
Page 166 and 167:
Page 168 and 169:
Page 170 and 171:
Page 172 and 173:
Page 174 and 175:
Page 176 and 177:
Page 178 and 179:
Page 180 and 181:
Page 182 and 183:
Page 184 and 185:
Page 186 and 187:
Page 188 and 189:
Page 190 and 191:
Page 192 and 193:
Page 194 and 195:
Page 196 and 197:
Page 198 and 199:
Page 200 and 201:
Page 202 and 203:
Page 204 and 205:
Lubrication system components, serv
Page 206 and 207:
Page 208 and 209:
Page 210 and 211:
Page 212 and 213:
Page 214 and 215:
Page 216 and 217:
Page 218 and 219:
Page 220 and 221:
Page 222 and 223:
Page 224 and 225:
Page 226 and 227:
Page 228 and 229:
Cooling system components, servicin
Page 230 and 231:
Page 232 and 233:
Page 234 and 235:
Page 236 and 237:
Page 238 and 239:
Page 240 and 241:
Page 242 and 243:
Page 244 and 245:
Page 246 and 247:
Page 248 and 249:
Page 250 and 251:
Page 252 and 253:
Page 254 and 255:
Page 256 and 257:
Page 258 and 259:
Page 260 and 261:
Page 262 and 263:
Page 264 and 265:
Page 266 and 267:
Page 268 and 269:
Page 270 and 271:
Components of fuel supply system, s
Page 272 and 273:
Page 274 and 275:
Page 276 and 277:
Page 278 and 279:
Page 280 and 281:
Page 282 and 283:
Page 284 and 285:
Page 286 and 287:
Page 288 and 289:
Page 290 and 291:
Page 292 and 293:
Page 294 and 295:
Page 296 and 297:
Page 298 and 299:
Page 300 and 301:
Page 302 and 303:
Page 304 and 305:
Page 306 and 307:
Page 308 and 309:
Page 310 and 311:
Page 312 and 313:
Evaporative Emissions (EVAP) system
Page 314 and 315:
Page 316 and 317:
Page 318 and 319:
Page 320 and 321:
Page 322 and 323:
Page 324 and 325:
Page 326 and 327:
Page 328 and 329:
Page 330 and 331:
Page 332 and 333:
Page 334 and 335:
Page 336 and 337:
Page 338 and 339:
Page 340 and 341:
Page 342 and 343:
Electronic Power Control (EPC) Pág
Page 344 and 345:
Page 346 and 347:
Page 348 and 349:
Page 350 and 351:
Page 352 and 353:
Page 354 and 355:
Exhaust system components, servicin
Page 356 and 357:
Page 358 and 359:
Page 360 and 361:
Page 362 and 363:
Page 364 and 365:
Page 366 and 367:
Page 368 and 369:
Page 370 and 371:
Page 372 and 373:
Page 374 and 375:
Page 376 and 377:
Page 378 and 379:
Page 380 and 381:
Secondary air system Página 2 de 3
Page 382 and 383:
Page 384 and 385:
Page 386 and 387:
Page 388 and 389:
Secondary air system Página 10 de
Page 390 and 391:
Page 392 and 393:
Page 394 and 395:
Page 396 and 397:
Page 398 and 399:
Page 400 and 401:
Page 402 and 403:
Page 404 and 405:
Page 406 and 407:
Page 408 and 409:
Page 410 and 411:
Page 412 and 413:
Page 414 and 415:
2.8 Liter VR6 4V Fuel Injection & I
Page 416 and 417:
2.8 Liter VR6 4V Fuel Injection & I
Page 418 and 419:
On Board Diagnostic (OBD) Página 2
Page 420 and 421:
Page 422 and 423:
Page 424 and 425:
Page 426 and 427:
Page 428 and 429:
Page 430 and 431:
Page 432 and 433:
Page 434 and 435:
Page 436 and 437:
Page 438 and 439:
Page 440 and 441:
DTC memory Página 2 de 7 01-24 Wor
Page 442 and 443:
DTC memory Página 4 de 7 01-26 - P
Page 444 and 445:
DTC memory Página 6 de 7 01-28 Wor
Page 446 and 447:
DTC table: SAE P0 codes Página 1 d
Page 448 and 449:
Page 450 and 451:
Page 452 and 453:
Page 454 and 455:
Page 456 and 457:
DTC table: SAE P0 codes Página 11
Page 458 and 459:
Page 460 and 461:
Page 462 and 463:
Page 464 and 465:
Page 466 and 467:
Page 468 and 469:
Page 470 and 471:
Page 472 and 473:
Page 474 and 475:
Page 476 and 477:
Page 478 and 479:
Page 480 and 481:
Page 482 and 483:
Page 484 and 485:
Page 486 and 487:
Page 488 and 489:
Page 490 and 491:
Page 492 and 493:
Page 494 and 495:
Page 496 and 497:
Page 498 and 499:
Page 500 and 501:
Page 502 and 503:
Page 504 and 505:
Page 506 and 507:
Page 508 and 509:
Page 510 and 511:
Page 512 and 513:
Page 514 and 515:
Page 516 and 517:
Page 518 and 519:
Output Diagnosis Test Mode (DTM) P
Page 520 and 521:
Page 522 and 523:
Page 524 and 525:
Page 526 and 527:
Page 528 and 529:
Page 530 and 531:
Page 532 and 533:
Page 534 and 535:
Page 536 and 537:
Page 538 and 539:
Page 540 and 541:
Page 542 and 543:
Page 544 and 545:
Page 546 and 547:
Page 548 and 549:
Page 550 and 551:
Page 552 and 553:
Page 554 and 555:
Page 556 and 557:
Page 558 and 559:
Page 560 and 561:
Page 562 and 563:
Page 564 and 565:
Readiness code Página 2 de 37 01-1
Page 566 and 567:
Page 568 and 569:
Page 570 and 571:
Page 572 and 573:
Readiness code Página 10 de 37 01-
Page 574 and 575:
Page 576 and 577:
Page 578 and 579:
Page 580 and 581:
Page 582 and 583:
Page 584 and 585:
Page 586 and 587:
Page 588 and 589:
Page 590 and 591:
Page 592 and 593:
Page 594 and 595:
Page 596 and 597:
Page 598 and 599:
Page 600 and 601:
Page 602 and 603:
Page 604 and 605:
Page 606 and 607:
Page 608 and 609:
Page 610 and 611:
Page 612 and 613:
Page 614 and 615:
Page 616 and 617:
Page 618 and 619:
Page 620 and 621:
Page 622 and 623:
Page 624 and 625:
Page 626 and 627:
Page 628 and 629:
Page 630 and 631:
Page 632 and 633:
Page 634 and 635:
Page 636 and 637:
Page 638 and 639:
Measured value (data) blocks Págin
Page 640 and 641:
Page 642 and 643:
Page 644 and 645:
Page 646 and 647:
Page 648 and 649:
Page 650 and 651:
Page 652 and 653:
Page 654 and 655:
Page 656 and 657:
Page 658 and 659:
Page 660 and 661:
Page 662 and 663:
Page 664 and 665:
Page 666 and 667:
Page 668 and 669:
Page 670 and 671:
Page 672 and 673:
Page 674 and 675:
Page 676 and 677:
Page 678 and 679:
Page 680 and 681:
Page 682 and 683:
Page 684 and 685:
Page 686 and 687:
Page 688 and 689:
Page 690 and 691:
Page 692 and 693:
Page 694 and 695:
Page 696 and 697:
Page 698 and 699:
Page 700 and 701:
Page 702 and 703:
Page 704 and 705:
Page 706 and 707:
Page 708 and 709:
Page 710 and 711:
Page 712 and 713:
Page 714 and 715:
Page 716 and 717:
Page 718 and 719:
Page 720 and 721:
Page 722 and 723:
Page 724 and 725:
Fuel injection system, servicing P
Page 726 and 727: Fuel injection system, servicing P
Page 782 and 783: Components, checking Página 2 de 8
Page 790 and 791: Components, checking Página 10 de
Page 826 and 827:
Components, checking Página 46 de
Page 828 and 829:
Page 830 and 831:
Page 832 and 833:
Page 834 and 835:
Page 836 and 837:
Page 838 and 839:
Page 840 and 841:
Page 842 and 843:
Page 844 and 845:
Page 846 and 847:
Page 848 and 849:
Page 850 and 851:
Page 852 and 853:
Page 854 and 855:
Page 856 and 857:
Page 858 and 859:
Page 860 and 861:
Page 862 and 863:
Page 864 and 865:
Page 866 and 867:
Page 868 and 869:
Functions, checking Página 1 de 37
Page 870 and 871:
Page 872 and 873:
Page 874 and 875:
Page 876 and 877:
Page 878 and 879:
Page 880 and 881:
Page 882 and 883:
Page 884 and 885:
Page 886 and 887:
Page 888 and 889:
Page 890 and 891:
Page 892 and 893:
Page 894 and 895:
Page 896 and 897:
Page 898 and 899:
Page 900 and 901:
Page 902 and 903:
Page 904 and 905:
Page 906 and 907:
Motronic Engine Control Module (ECM
Page 908 and 909:
Page 910 and 911:
Page 912 and 913:
Page 914 and 915:
Page 916 and 917:
Page 918 and 919:
Page 920 and 921:
Page 922 and 923:
Page 924 and 925:
Page 926 and 927:
Page 928 and 929:
Page 930 and 931:
Page 932 and 933:
Additional signals, checking Págin
Page 934 and 935:
Page 936 and 937:
Page 938 and 939:
Page 940 and 941:
Page 942 and 943:
Page 944 and 945:
Page 946 and 947:
Page 948 and 949:
Page 950 and 951:
Page 952 and 953:
Page 954 and 955:
Page 956 and 957:
Page 958 and 959:
Page 960 and 961:
Page 962 and 963:
Page 964 and 965:
Page 966 and 967:
Page 968 and 969:
Page 970 and 971:
Page 972 and 973:
Ignition system, servicing Página
Page 974 and 975:
Page 976 and 977:
Page 978 and 979:
Page 980 and 981:
Page 982 and 983:
Page 984 and 985:
Page 986 and 987:
Page 988 and 989:
Page 990 and 991:
Page 992 and 993:
Page 994 and 995:
Page 996 and 997:
Page 998 and 999:
Page 1000 and 1001:
Page 1002 and 1003:
Page 1004 and 1005:
Page 1006 and 1007:
Page 1008 and 1009:
Page 1010 and 1011:
Page 1012 and 1013:
Page 1014 and 1015:
Page 1016 and 1017:
Page 1018 and 1019:
Page 1020 and 1021:
Page 1022 and 1023:
5 & 6 Spd. Manual Transmission 02M
Page 1024 and 1025:
Transmission identification Página
Page 1026 and 1027:
Page 1028 and 1029:
Page 1030 and 1031:
Transmission layout Página 2 de 2
Page 1032 and 1033:
General repair instructions Página
Page 1034 and 1035:
General repair instructions Página
Page 1036 and 1037:
Clutch mechanism, repairing Página
Page 1038 and 1039:
Page 1040 and 1041:
Page 1042 and 1043:
Page 1044 and 1045:
Page 1046 and 1047:
Page 1048 and 1049:
Page 1050 and 1051:
Page 1052 and 1053:
Page 1054 and 1055:
Page 1056 and 1057:
Page 1058 and 1059:
Page 1060 and 1061:
Clutch release mechanism, servicing
Page 1062 and 1063:
Clutch release mechanism, servicing
Page 1064 and 1065:
Clutch, servicing Página 2 de 8 30
Page 1066 and 1067:
Page 1068 and 1069:
Page 1070 and 1071:
Page 1072 and 1073:
Page 1074 and 1075:
Page 1076 and 1077:
Page 1078 and 1079:
Page 1080 and 1081:
Gear selector mechanism, servicing
Page 1082 and 1083:
Page 1084 and 1085:
Page 1086 and 1087:
Page 1088 and 1089:
Page 1090 and 1091:
Page 1092 and 1093:
Page 1094 and 1095:
Page 1096 and 1097:
Page 1098 and 1099:
Page 1100 and 1101:
Page 1102 and 1103:
Page 1104 and 1105:
Page 1106 and 1107:
Page 1108 and 1109:
Page 1110 and 1111:
Transmission, removing and installi
Page 1112 and 1113:
Page 1114 and 1115:
Page 1116 and 1117:
Page 1118 and 1119:
Page 1120 and 1121:
Page 1122 and 1123:
Page 1124 and 1125:
Page 1126 and 1127:
Page 1128 and 1129:
Page 1130 and 1131:
Page 1132 and 1133:
Page 1134 and 1135:
Page 1136 and 1137:
Page 1138 and 1139:
Transmission gear oil, checking Pá
Page 1140 and 1141:
Transmission, disassembling and ass
Page 1142 and 1143:
Page 1144 and 1145:
Page 1146 and 1147:
Page 1148 and 1149:
Page 1150 and 1151:
Page 1152 and 1153:
Page 1154 and 1155:
Page 1156 and 1157:
Page 1158 and 1159:
Page 1160 and 1161:
Page 1162 and 1163:
Page 1164 and 1165:
Transmission housing, servicing Pá
Page 1166 and 1167:
Page 1168 and 1169:
Page 1170 and 1171:
Page 1172 and 1173:
Page 1174 and 1175:
Page 1176 and 1177:
Page 1178 and 1179:
Clutch housing, servicing Página 2
Page 1180 and 1181:
Page 1182 and 1183:
Page 1184 and 1185:
Page 1186 and 1187:
Page 1188 and 1189:
Page 1190 and 1191:
Transmission selector mechanism, di
Page 1192 and 1193:
Page 1194 and 1195:
Page 1196 and 1197:
Selector forks, disassembling and a
Page 1198 and 1199:
Input shaft, disassembling and asse
Page 1200 and 1201:
Page 1202 and 1203:
Page 1204 and 1205:
Page 1206 and 1207:
Page 1208 and 1209:
Page 1210 and 1211:
Page 1212 and 1213:
Page 1214 and 1215:
Input shaft, adjusting Página 2 de
Page 1216 and 1217:
Page 1218 and 1219:
Page 1220 and 1221:
Output shaft, 1st-4th gear, disasse
Page 1222 and 1223:
Page 1224 and 1225:
Page 1226 and 1227:
Page 1228 and 1229:
Page 1230 and 1231:
Page 1232 and 1233:
Page 1234 and 1235:
Page 1236 and 1237:
Page 1238 and 1239:
Page 1240 and 1241:
Page 1242 and 1243:
Page 1244 and 1245:
Page 1246 and 1247:
Page 1248 and 1249:
Page 1250 and 1251:
Page 1252 and 1253:
Output shaft for 1st-4th gears, adj
Page 1254 and 1255:
Page 1256 and 1257:
Page 1258 and 1259:
Page 1260 and 1261:
Output shaft for 5th, 6th and rever
Page 1262 and 1263:
Page 1264 and 1265:
Page 1266 and 1267:
Page 1268 and 1269:
Page 1270 and 1271:
Page 1272 and 1273:
Page 1274 and 1275:
Page 1276 and 1277:
Page 1278 and 1279:
Page 1280 and 1281:
Page 1282 and 1283:
Page 1284 and 1285:
Page 1286 and 1287:
Page 1288 and 1289:
Page 1290 and 1291:
Page 1292 and 1293:
Page 1294 and 1295:
Oil seals for flanged shafts, repla
Page 1296 and 1297:
Page 1298 and 1299:
Page 1300 and 1301:
Differential, disassembling and ass
Page 1302 and 1303:
Page 1304 and 1305:
Page 1306 and 1307:
Page 1308 and 1309:
Page 1310 and 1311:
Page 1312 and 1313:
Page 1314 and 1315:
Page 1316 and 1317:
Page 1318 and 1319:
Page 1320 and 1321:
Adjustment overview Página 1 de 2
Page 1322 and 1323:
Differential, adjusting Página 1 d
Page 1324 and 1325:
Page 1326 and 1327:
Page 1328 and 1329:
Page 1330 and 1331:
Brake System On Board Diagnostic (O
Page 1332 and 1333:
ABS ITT Mark 20 IE On Board Diagnos
Page 1334 and 1335:
Page 1336 and 1337:
Page 1338 and 1339:
Page 1340 and 1341:
Electrical/electronic components an
Page 1342 and 1343:
Page 1344 and 1345:
Page 1346 and 1347:
Page 1348 and 1349:
Page 1350 and 1351:
Page 1352 and 1353:
Page 1354 and 1355:
Page 1356 and 1357:
ABS ITT Mk 20 IE On Board Diagnosti
Page 1358 and 1359:
Page 1360 and 1361:
Page 1362 and 1363:
Page 1364 and 1365:
Page 1366 and 1367:
Page 1368 and 1369:
Page 1370 and 1371:
Page 1372 and 1373:
Page 1374 and 1375:
Page 1376 and 1377:
Page 1378 and 1379:
Page 1380 and 1381:
Page 1382 and 1383:
Page 1384 and 1385:
Page 1386 and 1387:
Page 1388 and 1389:
Page 1390 and 1391:
Page 1392 and 1393:
Page 1394 and 1395:
Page 1396 and 1397:
Page 1398 and 1399:
Page 1400 and 1401:
Page 1402 and 1403:
Page 1404 and 1405:
Page 1406 and 1407:
Page 1408 and 1409:
Page 1410 and 1411:
Page 1412 and 1413:
Page 1414 and 1415:
Page 1416 and 1417:
ABS, ABS/EDL and ABS/EDL/ASR ITT Ma
Page 1418 and 1419:
Page 1420 and 1421:
Page 1422 and 1423:
Page 1424 and 1425:
Page 1426 and 1427:
Page 1428 and 1429:
Page 1430 and 1431:
Page 1432 and 1433:
Page 1434 and 1435:
Page 1436 and 1437:
Page 1438 and 1439:
Page 1440 and 1441:
Page 1442 and 1443:
Page 1444 and 1445:
Page 1446 and 1447:
Page 1448 and 1449:
ABS Mark 60 On Board Diagnostic (OB
Page 1450 and 1451:
Page 1452 and 1453:
Page 1454 and 1455:
Page 1456 and 1457:
Page 1458 and 1459:
Page 1460 and 1461:
Page 1462 and 1463:
Page 1464 and 1465:
Page 1466 and 1467:
Page 1468 and 1469:
Page 1470 and 1471:
Page 1472 and 1473:
Page 1474 and 1475:
Page 1476 and 1477:
Diagnostic Trouble Codes (DTCs) dis
Page 1478 and 1479:
Diagnostic Trouble Codes (DTCs) dis
Page 1480 and 1481:
On Board Diagnostic (OBD), performi
Page 1482 and 1483:
Page 1484 and 1485:
Page 1486 and 1487:
Page 1488 and 1489:
Page 1490 and 1491:
Page 1492 and 1493:
Page 1494 and 1495:
Page 1496 and 1497:
Page 1498 and 1499:
Page 1500 and 1501:
Page 1502 and 1503:
Page 1504 and 1505:
Page 1506 and 1507:
Page 1508 and 1509:
Page 1510 and 1511:
Page 1512 and 1513:
Page 1514 and 1515:
Page 1516 and 1517:
Page 1518 and 1519:
Page 1520 and 1521:
Page 1522 and 1523:
Page 1524 and 1525:
Page 1526 and 1527:
Page 1528 and 1529:
Page 1530 and 1531:
Page 1532 and 1533:
Page 1534 and 1535:
Page 1536 and 1537:
Page 1538 and 1539:
Page 1540 and 1541:
Electrical check of Mark 60 Página
Page 1542 and 1543:
Page 1544 and 1545:
Page 1546 and 1547:
Page 1548 and 1549:
Page 1550 and 1551:
Page 1552 and 1553:
Page 1554 and 1555:
Page 1556 and 1557:
Page 1558 and 1559:
Page 1560 and 1561:
Page 1562 and 1563:
Page 1564 and 1565:
Page 1566 and 1567:
Page 1568 and 1569:
Page 1570 and 1571:
Page 1572 and 1573:
Page 1574 and 1575:
Page 1576 and 1577:
Page 1578 and 1579:
Page 1580 and 1581:
Definitions Página 1 de 6 01-326 D
Page 1582 and 1583:
Definitions Página 3 de 6 01-328 E
Page 1584 and 1585:
Definitions Página 5 de 6 01-330 S
Page 1586 and 1587:
Brake System Página 1 de 3 Select
Page 1588 and 1589:
Brake System Página 3 de 3 Brake s
Page 1590 and 1591:
Page 1592 and 1593:
Page 1594 and 1595:
Page 1596 and 1597:
Technical data, brakes Página 2 de
Page 1598 and 1599:
Page 1600 and 1601:
Page 1602 and 1603:
Anti-lock brake system (ABS) and an
Page 1604 and 1605:
Anti-lock brake system (ABS) and an
Page 1606 and 1607:
Hydraulic unit, brake booster/maste
Page 1608 and 1609:
Page 1610 and 1611:
Page 1612 and 1613:
Page 1614 and 1615:
Page 1616 and 1617:
Page 1618 and 1619:
Page 1620 and 1621:
Page 1622 and 1623:
ABS system components for front axl
Page 1624 and 1625:
Page 1626 and 1627:
Page 1628 and 1629:
Page 1630 and 1631:
Page 1632 and 1633:
Page 1634 and 1635:
Page 1636 and 1637:
Page 1638 and 1639:
Page 1640 and 1641:
Anti-lock brake system (ABS) Mark 6
Page 1642 and 1643:
Page 1644 and 1645:
Page 1646 and 1647:
VAS 5051 Vehicle Diagnostic, Testin
Page 1648 and 1649:
Page 1650 and 1651:
Page 1652 and 1653:
Page 1654 and 1655:
Page 1656 and 1657:
Page 1658 and 1659:
Hydraulic unit, brake booster/brake
Page 1660 and 1661:
Page 1662 and 1663:
Page 1664 and 1665:
Page 1666 and 1667:
Page 1668 and 1669:
Page 1670 and 1671:
Page 1672 and 1673:
Page 1674 and 1675:
Page 1676 and 1677:
DTCs displayed by (ABS) Mark 60 war
Page 1678 and 1679:
Page 1680 and 1681:
Page 1682 and 1683:
ABS system components for front and
Page 1684 and 1685:
Page 1686 and 1687:
Page 1688 and 1689:
Page 1690 and 1691:
Page 1692 and 1693:
Page 1694 and 1695:
Page 1696 and 1697:
Page 1698 and 1699:
Page 1700 and 1701:
Page 1702 and 1703:
Page 1704 and 1705:
Page 1706 and 1707:
Page 1708 and 1709:
Page 1710 and 1711:
Page 1712 and 1713:
Page 1714 and 1715:
Page 1716 and 1717:
Page 1718 and 1719:
ESP system components, removing and
Page 1720 and 1721:
Page 1722 and 1723:
Page 1724 and 1725:
Page 1726 and 1727:
Page 1728 and 1729:
Page 1730 and 1731:
Page 1732 and 1733:
Page 1734 and 1735:
Page 1736 and 1737:
Front brakes Página 2 de 53 46-2 S
Page 1738 and 1739:
Front brakes Página 4 de 53 head s
Page 1740 and 1741:
Front brakes Página 6 de 53 Checki
Page 1742 and 1743:
Front brakes Página 8 de 53 - Remo
Page 1744 and 1745:
Front brakes Página 10 de 53 12 -
Page 1746 and 1747:
Front brakes Página 12 de 53 46-8
Page 1748 and 1749:
Page 1750 and 1751:
Page 1752 and 1753:
Page 1754 and 1755:
Page 1756 and 1757:
Page 1758 and 1759:
Page 1760 and 1761:
Page 1762 and 1763:
Front brakes Página 28 de 53 Wear
Page 1764 and 1765:
Page 1766 and 1767:
Page 1768 and 1769:
Page 1770 and 1771:
Front brakes Página 36 de 53 for w
Page 1772 and 1773:
Front brakes Página 38 de 53 panel
Page 1774 and 1775:
Page 1776 and 1777:
Page 1778 and 1779:
Page 1780 and 1781:
Page 1782 and 1783:
Page 1784 and 1785:
Page 1786 and 1787:
Page 1788 and 1789:
Rear wheel brakes (disc brakes - fr
Page 1790 and 1791:
Page 1792 and 1793:
Page 1794 and 1795:
Page 1796 and 1797:
Page 1798 and 1799:
Page 1800 and 1801:
Page 1802 and 1803:
Page 1804 and 1805:
Page 1806 and 1807:
Page 1808 and 1809:
Rear wheel brakes/disc brakes (all-
Page 1810 and 1811:
Page 1812 and 1813:
Page 1814 and 1815:
Page 1816 and 1817:
Page 1818 and 1819:
Page 1820 and 1821:
Page 1822 and 1823:
Page 1824 and 1825:
Parking brake cables for disc brake
Page 1826 and 1827:
Page 1828 and 1829:
Page 1830 and 1831:
Page 1832 and 1833:
Parking brake lever, assembly overv
Page 1834 and 1835:
Brake pedal - assembly overview Pá
Page 1836 and 1837:
Page 1838 and 1839:
Page 1840 and 1841:
Page 1842 and 1843:
Page 1844 and 1845:
Page 1846 and 1847:
Front brake calipers, servicing Pá
Page 1848 and 1849:
Page 1850 and 1851:
Page 1852 and 1853:
FN 3 front brake calipers, servicin
Page 1854 and 1855:
Page 1856 and 1857:
Page 1858 and 1859:
Page 1860 and 1861:
Page 1862 and 1863:
Page 1864 and 1865:
Page 1866 and 1867:
Page 1868 and 1869:
Rear brake caliper, servicing Pági
Page 1870 and 1871:
Page 1872 and 1873:
Page 1874 and 1875:
Page 1876 and 1877:
Page 1878 and 1879:
Page 1880 and 1881:
Brake pressure regulator, assembly
Page 1882 and 1883:
Brake pressure regulator, assembly
Page 1884 and 1885:
Brake system, bleeding Página 1 de
Page 1886 and 1887:
Page 1888 and 1889:
Page 1890 and 1891:
Page 1892 and 1893:
Page 1894 and 1895:
Brake booster/brake master cylinder
Page 1896 and 1897:
Page 1898 and 1899:
Page 1900 and 1901:
Page 1902 and 1903:
Page 1904 and 1905:
Page 1906 and 1907:
Page 1908 and 1909:
Page 1910 and 1911:
Page 1912 and 1913:
Page 1914 and 1915:
Page 1916 and 1917:
Page 1918 and 1919:
Page 1920 and 1921:
Page 1922 and 1923:
Page 1924 and 1925:
Page 1926 and 1927:
Page 1928 and 1929:
Page 1930 and 1931:
Page 1932 and 1933:
Page 1934 and 1935:
Page 1936 and 1937:
Brake master cylinder, removing and
Page 1938 and 1939:
Brake master cylinder, removing and
Page 1940 and 1941:
Brake booster, removing and install
Page 1942 and 1943:
Definitions Página 1 de 2 47-87 De
Page 1944 and 1945:
Suspension, Wheels, Steering Págin
Page 1946 and 1947:
Suspension, Wheels, Steering Págin
Page 1948 and 1949:
Technical data Página 1 de 1 00 -
Page 1950 and 1951:
Check list for evaluating the suspe
Page 1952 and 1953:
Evaluation of accident vehicles Pá
Page 1954 and 1955:
Page 1956 and 1957:
Page 1958 and 1959:
Page 1960 and 1961:
Page 1962 and 1963:
Page 1964 and 1965:
Front suspension, servicing Página
Page 1966 and 1967:
Page 1968 and 1969:
Page 1970 and 1971:
Page 1972 and 1973:
Page 1974 and 1975:
Page 1976 and 1977:
Page 1978 and 1979:
Page 1980 and 1981:
Page 1982 and 1983:
Page 1984 and 1985:
Page 1986 and 1987:
Page 1988 and 1989:
Page 1990 and 1991:
Page 1992 and 1993:
Page 1994 and 1995:
Page 1996 and 1997:
Page 1998 and 1999:
Page 2000 and 2001:
Page 2002 and 2003:
Page 2004 and 2005:
Page 2006 and 2007:
Page 2008 and 2009:
Page 2010 and 2011:
Page 2012 and 2013:
Page 2014 and 2015:
Page 2016 and 2017:
Front suspension R32, servicing Pá
Page 2018 and 2019:
Page 2020 and 2021:
Page 2022 and 2023:
Page 2024 and 2025:
Page 2026 and 2027:
Page 2028 and 2029:
Page 2030 and 2031:
Page 2032 and 2033:
Page 2034 and 2035:
Page 2036 and 2037:
Page 2038 and 2039:
Page 2040 and 2041:
Page 2042 and 2043:
Page 2044 and 2045:
Page 2046 and 2047:
Page 2048 and 2049:
Page 2050 and 2051:
Page 2052 and 2053:
Page 2054 and 2055:
Page 2056 and 2057:
Page 2058 and 2059:
Front drive axle, servicing Página
Page 2060 and 2061:
Page 2062 and 2063:
Page 2064 and 2065:
Page 2066 and 2067:
Page 2068 and 2069:
Page 2070 and 2071:
Page 2072 and 2073:
Page 2074 and 2075:
Page 2076 and 2077:
Page 2078 and 2079:
Page 2080 and 2081:
Page 2082 and 2083:
Page 2084 and 2085:
Page 2086 and 2087:
Page 2088 and 2089:
Page 2090 and 2091:
Page 2092 and 2093:
Page 2094 and 2095:
Page 2096 and 2097:
Page 2098 and 2099:
Page 2100 and 2101:
Page 2102 and 2103:
Page 2104 and 2105:
Page 2106 and 2107:
Page 2108 and 2109:
Page 2110 and 2111:
Page 2112 and 2113:
Page 2114 and 2115:
Page 2116 and 2117:
Page 2118 and 2119:
Page 2120 and 2121:
Rear axle, servicing Página 1 de 3
Page 2122 and 2123:
Page 2124 and 2125:
Page 2126 and 2127:
Page 2128 and 2129:
Page 2130 and 2131:
Rear axle, servicing Página 11 de
Page 2132 and 2133:
Page 2134 and 2135:
Page 2136 and 2137:
Page 2138 and 2139:
Page 2140 and 2141:
Page 2142 and 2143:
Page 2144 and 2145:
Page 2146 and 2147:
Page 2148 and 2149:
Page 2150 and 2151:
Page 2152 and 2153:
Wheel bearing, servicing Página 1
Page 2154 and 2155:
Page 2156 and 2157:
Page 2158 and 2159:
Page 2160 and 2161:
Page 2162 and 2163:
Page 2164 and 2165:
Rear axle, servicing (all wheel dri
Page 2166 and 2167:
Page 2168 and 2169:
Page 2170 and 2171:
Page 2172 and 2173:
Page 2174 and 2175:
Page 2176 and 2177:
Page 2178 and 2179:
Page 2180 and 2181:
Page 2182 and 2183:
Page 2184 and 2185:
Page 2186 and 2187:
Page 2188 and 2189:
Page 2190 and 2191:
Page 2192 and 2193:
Trailing arm and transverse links (
Page 2194 and 2195:
Page 2196 and 2197:
Page 2198 and 2199:
Page 2200 and 2201:
Page 2202 and 2203:
Page 2204 and 2205:
Page 2206 and 2207:
Page 2208 and 2209:
Page 2210 and 2211:
Page 2212 and 2213:
Page 2214 and 2215:
Page 2216 and 2217:
Page 2218 and 2219:
Page 2220 and 2221:
Page 2222 and 2223:
Page 2224 and 2225:
Page 2226 and 2227:
Page 2228 and 2229:
Page 2230 and 2231:
Page 2232 and 2233:
Page 2234 and 2235:
Page 2236 and 2237:
Subframe with final drive, assembly
Page 2238 and 2239:
Page 2240 and 2241:
Page 2242 and 2243:
Page 2244 and 2245:
Page 2246 and 2247:
Page 2248 and 2249:
Page 2250 and 2251:
Page 2252 and 2253:
Rear drive axle, servicing Página
Page 2254 and 2255:
Page 2256 and 2257:
Page 2258 and 2259:
Page 2260 and 2261:
Page 2262 and 2263:
Page 2264 and 2265:
Evaluation of accident vehicles Pá
Page 2266 and 2267:
Protecting wheel centering seat aga
Page 2268 and 2269:
Wheels, tires Página 2 de 3 Tires
Page 2270 and 2271:
Wheel alignment Página 1 de 14 44
Page 2272 and 2273:
Wheel alignment Página 3 de 14 (al
Page 2274 and 2275:
Wheel alignment Página 5 de 14 The
Page 2276 and 2277:
Wheel alignment Página 7 de 14 1)
Page 2278 and 2279:
Wheel alignment Página 9 de 14 axl
Page 2280 and 2281:
Wheel alignment Página 11 de 14 -
Page 2282 and 2283:
Wheel alignment Página 13 de 14 ba
Page 2284 and 2285:
Wheels, tires Página 1 de 1 44 - 6
Page 2286 and 2287:
Connecting VAS 5051 and selecting f
Page 2288 and 2289:
Connecting VAS 5051 and selecting f
Page 2290 and 2291:
Steering column Página 1 de 20 48
Page 2292 and 2293:
Steering column Página 3 de 20 - R
Page 2294 and 2295:
Steering column Página 5 de 20 - R
Page 2296 and 2297:
Steering column Página 7 de 20 New
Page 2298 and 2299:
Steering column Página 9 de 20 2.
Page 2300 and 2301:
Steering column Página 11 de 20 .
Page 2302 and 2303:
Steering column Página 13 de 20 Re
Page 2304 and 2305:
Steering column Página 15 de 20 1.
Page 2306 and 2307:
Steering column Página 17 de 20 Be
Page 2308 and 2309:
Steering column Página 19 de 20 Re
Page 2310 and 2311:
Power steering, servicing Página 1
Page 2312 and 2313:
Page 2314 and 2315:
Page 2316 and 2317:
Page 2318 and 2319:
Page 2320 and 2321:
Page 2322 and 2323:
Page 2324 and 2325:
Page 2326 and 2327:
Page 2328 and 2329:
Page 2330 and 2331:
Power steering pump, reservoir and
Page 2332 and 2333:
Page 2334 and 2335:
Page 2336 and 2337:
Page 2338 and 2339:
Page 2340 and 2341:
Page 2342 and 2343:
Page 2344 and 2345:
Page 2346 and 2347:
Page 2348 and 2349:
Page 2350 and 2351:
Page 2352 and 2353:
Page 2354 and 2355:
Page 2356 and 2357:
Page 2358 and 2359:
Page 2360 and 2361:
Page 2362 and 2363:
Definitions Página 1 de 2 48 - 7 D
Page 2364 and 2365:
Body Collision Repair Página 1 de
Page 2366 and 2367:
Body Collision Repair Página 3 de
Page 2368 and 2369:
Page 2370 and 2371:
Page 2372 and 2373:
Body foam insulation Página 1 de 2
Page 2374 and 2375:
Reinforced body sheet metal Página
Page 2376 and 2377:
Galvanized body panels Página 1 de
Page 2378 and 2379:
Body panel gaps/mating lines Págin
Page 2380 and 2381:
Page 2382 and 2383:
Page 2384 and 2385:
Body dimensions Página 2 de 23 00-
Page 2386 and 2387:
Page 2388 and 2389:
Page 2390 and 2391:
Page 2392 and 2393:
Body dimensions Página 10 de 23 00
Page 2394 and 2395:
Page 2396 and 2397:
Page 2398 and 2399:
Page 2400 and 2401:
Page 2402 and 2403:
Page 2404 and 2405:
Page 2406 and 2407:
Straightening fixture Página 1 de
Page 2408 and 2409:
Page 2410 and 2411:
Page 2412 and 2413:
Page 2414 and 2415:
Page 2416 and 2417:
Page 2418 and 2419:
Page 2420 and 2421:
Page 2422 and 2423:
Page 2424 and 2425:
50 40 55 50 Engine mount bracket, r
Page 2426 and 2427:
50 52 55 50 Intermediate piece, rep
Page 2428 and 2429:
50 53 55 50 fender connecting plate
Page 2430 and 2431:
50 53 55 50 fender connecting plate
Page 2432 and 2433:
50 72 55 50 long member for upper w
Page 2434 and 2435:
50 74 55 00 Front wheel house, part
Page 2436 and 2437:
50 75 55 50 Front inner fender, rep
Page 2438 and 2439:
50 79 55 00 Front long member, repl
Page 2440 and 2441:
50 79 55 00 Front long member, repl
Page 2442 and 2443:
50 79 55 02 Front long member, part
Page 2444 and 2445:
50 80 55 00 Long member front secti
Page 2446 and 2447:
50 80 55 00 Long member front secti
Page 2448 and 2449:
51 03 55 00 Roof, replacing (Golf)
Page 2450 and 2451:
51 03 55 00 Roof, replacing (Golf)
Page 2452 and 2453:
51 03 55 00 Roof, replacing (Jetta)
Page 2454 and 2455:
51 03 55 00 Roof, replacing (Jetta)
Page 2456 and 2457:
51 03 55 20 Roof, replacing (Jetta
Page 2458 and 2459:
Page 2460 and 2461:
Page 2462 and 2463:
Page 2464 and 2465:
51 07 55 50 Front roof cross member
Page 2466 and 2467:
51 08 55 50 Roof reinforcement, rep
Page 2468 and 2469:
51 09 55 50 Rear roof cross member,
Page 2470 and 2471:
51 09 55 50 Rear cross member, repl
Page 2472 and 2473:
51 09 55 70 Rear roof crossmember,
Page 2474 and 2475:
51 09 55 70 Rear roof crossmember,
Page 2476 and 2477:
51 37 55 00 A-pillar, inner, replac
Page 2478 and 2479:
Page 2480 and 2481:
Page 2482 and 2483:
Page 2484 and 2485:
Page 2486 and 2487:
51 41 55 62 B-pillar, replacing (4
Page 2488 and 2489:
51 41 55 62 B-pillar, replacing (4
Page 2490 and 2491:
51 42 55 50 Inner B-pillar, replaci
Page 2492 and 2493:
Page 2494 and 2495:
Page 2496 and 2497:
Page 2498 and 2499:
Page 2500 and 2501:
51 45 55 00 Outer side member, repl
Page 2502 and 2503:
Page 2504 and 2505:
Page 2506 and 2507:
51 49 55 50 Side member reinforceme
Page 2508 and 2509:
51 49 55 50 Side member reinforceme
Page 2510 and 2511:
51 73 55 50 Floor plate, partial re
Page 2512 and 2513:
51 73 55 50 Floor plate, partial re
Page 2514 and 2515:
53 05 55 50 Rear cross panel, repla
Page 2516 and 2517:
53 05 55 20 Rear cross panel, exter
Page 2518 and 2519:
53 05 55 20 Rear cross panel, exter
Page 2520 and 2521:
53 05 55 23 Rear cross panel, compl
Page 2522 and 2523:
Page 2524 and 2525:
Page 2526 and 2527:
Page 2528 and 2529:
Page 2530 and 2531:
Page 2532 and 2533:
Page 2534 and 2535:
Page 2536 and 2537:
53 10 55 50 Tail light mount, repla
Page 2538 and 2539:
Page 2540 and 2541:
Page 2542 and 2543:
53 05 55 50 Rear center cross panel
Page 2544 and 2545:
53 05 55 50 Rear center cross panel
Page 2546 and 2547:
53 05 55 50 Rear cross panel, repla
Page 2548 and 2549:
53 16 55 00 End cross panel, replac
Page 2550 and 2551:
53 16 55 00 Outer wheel house, repl
Page 2552 and 2553:
53 29 55 70 Reinforcement for C-pil
Page 2554 and 2555:
53 48 55 50 Rear long member, repla
Page 2556 and 2557:
53 47 55 52 Long member, partial re
Page 2558 and 2559:
53 55 55 10 Quarter panel, partial
Page 2560 and 2561:
Page 2562 and 2563:
Page 2564 and 2565:
Page 2566 and 2567:
Page 2568 and 2569:
Page 2570 and 2571:
53 55 55 20 Side panel, partial rep
Page 2572 and 2573:
Page 2574 and 2575:
Page 2576 and 2577:
Page 2578 and 2579:
Page 2580 and 2581:
53 69 55 50 Wheel house connecting
Page 2582 and 2583:
53 36 55 50 Connecting panel, repla
Page 2584 and 2585:
53 69 55 70 Rear wheelhousing, oute
Page 2586 and 2587:
53 69 55 70 Rear wheelhousing, oute
Page 2588 and 2589:
53 80 55 50 Spare wheel well, repla
Page 2590 and 2591:
53 80 55 52 Spare wheel well, parti
Page 2592 and 2593:
Page 2594 and 2595:
Page 2596 and 2597:
Body Exterior Página 2 de 5 Front
Page 2598 and 2599:
Body Exterior Página 4 de 5 Windsh
Page 2600 and 2601:
Body, front Página 1 de 9 50 - 1 B
Page 2602 and 2603:
Body, front Página 3 de 9 carrier.
Page 2604 and 2605:
Body, front Página 5 de 9 Front fe
Page 2606 and 2607:
Body, front Página 7 de 9 Offset b
Page 2608 and 2609:
Body, front Página 9 de 9 2. Bolt
Page 2610 and 2611:
Hood Página 2 de 9 - and remove li
Page 2612 and 2613:
Hood Página 4 de 9 Bowden cable, r
Page 2614 and 2615:
Hood Página 6 de 9 - Release opera
Page 2616 and 2617:
Hood Página 8 de 9 3. Bumper ◦ R
Page 2618 and 2619:
Rear lid (Golf) Página 1 de 12 55
Page 2620 and 2621:
Rear lid (Golf) Página 3 de 12 adj
Page 2622 and 2623:
Rear lid (Golf) Página 5 de 12 - C
Page 2624 and 2625:
Rear lid (Golf) Página 7 de 12 - U
Page 2626 and 2627:
Rear lid (Golf) Página 9 de 12 Ite
Page 2628 and 2629:
Rear lid (Golf) Página 11 de 12 1.
Page 2630 and 2631:
Rear lid (Jetta) Página 1 de 11 55
Page 2632 and 2633:
Rear lid (Jetta) Página 3 de 11 3.
Page 2634 and 2635:
Rear lid (Jetta) Página 5 de 11
Page 2636 and 2637:
Rear lid (Jetta) Página 7 de 11 1.
Page 2638 and 2639:
Rear lid (Jetta) Página 9 de 11
Page 2640 and 2641:
Rear lid (Jetta) Página 11 de 11 -
Page 2642 and 2643:
Rear lid, (Jetta Wagon) Página 2 d
Page 2644 and 2645:
Page 2646 and 2647:
Page 2648 and 2649:
Page 2650 and 2651:
Rear lid, (Jetta Wagon) Página 10
Page 2652 and 2653:
Tank flap unit Página 2 de 4 ◦ I
Page 2654 and 2655:
Tank flap unit Página 4 de 4 - Ins
Page 2656 and 2657:
Front door Página 2 de 28 Front do
Page 2658 and 2659:
Front door Página 4 de 28 ◦ 20 N
Page 2660 and 2661:
Front door Página 6 de 28 - Remove
Page 2662 and 2663:
Front door Página 8 de 28 Tighteni
Page 2664 and 2665:
Front door Página 10 de 28 Batteri
Page 2666 and 2667:
Front door Página 12 de 28 - Now s
Page 2668 and 2669:
Front door Página 14 de 28 - Inser
Page 2670 and 2671:
Front door Página 16 de 28 - Lower
Page 2672 and 2673:
Front door Página 18 de 28 - Uncli
Page 2674 and 2675:
Front door Página 20 de 28 - Tight
Page 2676 and 2677:
Front door Página 22 de 28 - Remov
Page 2678 and 2679:
Front door Página 24 de 28 1. Door
Page 2680 and 2681:
Front door Página 26 de 28 Applica
Page 2682 and 2683:
Front door Página 28 de 28 dimensi
Page 2684 and 2685:
Central locking system Página 2 de
Page 2686 and 2687:
Page 2688 and 2689:
Page 2690 and 2691:
Page 2692 and 2693:
Central locking system Página 10 d
Page 2694 and 2695:
Page 2696 and 2697:
Page 2698 and 2699:
Page 2700 and 2701:
Rear doors Página 1 de 23 58 - 1 R
Page 2702 and 2703:
Rear doors Página 3 de 23 4. Bolt
Page 2704 and 2705:
Rear doors Página 5 de 23 ◦ Inst
Page 2706 and 2707:
Rear doors Página 7 de 23 1. Door
Page 2708 and 2709:
Rear doors Página 9 de 23 Removing
Page 2710 and 2711:
Rear doors Página 11 de 23 - Inser
Page 2712 and 2713:
Rear doors Página 13 de 23 If work
Page 2714 and 2715:
Rear doors Página 15 de 23 - Slide
Page 2716 and 2717:
Rear doors Página 17 de 23 - Remov
Page 2718 and 2719:
Rear doors Página 19 de 23 - Tight
Page 2720 and 2721:
Rear doors Página 21 de 23 Door se
Page 2722 and 2723:
Rear doors Página 23 de 23 http://
Page 2724 and 2725:
Sunroof Página 2 de 4 ignition is
Page 2726 and 2727:
Sunroof Página 4 de 4 rear corner
Page 2728 and 2729:
Sunroof with glass panel (Webasto)
Page 2730 and 2731:
Page 2732 and 2733:
Page 2734 and 2735:
Page 2736 and 2737:
Page 2738 and 2739:
Page 2740 and 2741:
Page 2742 and 2743:
Page 2744 and 2745:
Page 2746 and 2747:
Page 2748 and 2749:
Page 2750 and 2751:
Sunroof with glass panel (Meritor)
Page 2752 and 2753:
Page 2754 and 2755:
Page 2756 and 2757:
Page 2758 and 2759:
Page 2760 and 2761:
Page 2762 and 2763:
Page 2764 and 2765:
Page 2766 and 2767:
Page 2768 and 2769:
Page 2770 and 2771:
Front bumper Página 1 de 12 63 - 1
Page 2772 and 2773:
Front bumper Página 3 de 12 10. Ai
Page 2774 and 2775:
Front bumper Página 5 de 12 1. Bum
Page 2776 and 2777:
Front bumper Página 7 de 12 1. Bum
Page 2778 and 2779:
Front bumper Página 9 de 12 Removi
Page 2780 and 2781:
Front bumper Página 11 de 12 Insta
Page 2782 and 2783:
Rear bumper Página 1 de 14 63 - 2
Page 2784 and 2785:
Rear bumper Página 3 de 14 Removin
Page 2786 and 2787:
Rear bumper Página 5 de 14 3. Scre
Page 2788 and 2789:
Rear bumper Página 7 de 14 ◦ Rem
Page 2790 and 2791:
Rear bumper Página 9 de 14 of remo
Page 2792 and 2793:
Rear bumper Página 11 de 14 Removi
Page 2794 and 2795:
Rear bumper Página 13 de 14 order
Page 2796 and 2797:
Flush-bonded windows Página 1 de 3
Page 2798 and 2799:
Page 2800 and 2801:
Page 2802 and 2803:
Page 2804 and 2805:
Page 2806 and 2807:
Flush-bonded windows Página 11 de
Page 2808 and 2809:
Page 2810 and 2811:
Page 2812 and 2813:
Page 2814 and 2815:
Page 2816 and 2817:
Page 2818 and 2819:
Page 2820 and 2821:
Page 2822 and 2823:
Page 2824 and 2825:
Page 2826 and 2827:
Page 2828 and 2829:
Page 2830 and 2831:
Page 2832 and 2833:
Door windows Página 1 de 38 64 - 2
Page 2834 and 2835:
Door windows Página 3 de 38 instal
Page 2836 and 2837:
Door windows Página 5 de 38 holes.
Page 2838 and 2839:
Door windows Página 7 de 38 If wor
Page 2840 and 2841:
Door windows Página 9 de 38 - Pull
Page 2842 and 2843:
Door windows Página 11 de 38 1. Do
Page 2844 and 2845:
Door windows Página 13 de 38 Carri
Page 2846 and 2847:
Door windows Página 15 de 38 - Pul
Page 2848 and 2849:
Door windows Página 17 de 38 Bolt
Page 2850 and 2851:
Door windows Página 19 de 38 - Rem
Page 2852 and 2853:
Door windows Página 21 de 38 - Pul
Page 2854 and 2855:
Door windows Página 23 de 38 - Wit
Page 2856 and 2857:
Door windows Página 25 de 38 Switc
Page 2858 and 2859:
Door windows Página 27 de 38 rear
Page 2860 and 2861:
Door windows Página 29 de 38 - Rem
Page 2862 and 2863:
Door windows Página 31 de 38 ◦ W
Page 2864 and 2865:
Door windows Página 33 de 38 coupl
Page 2866 and 2867:
Door windows Página 35 de 38 - Ins
Page 2868 and 2869:
Door windows Página 37 de 38 as de
Page 2870 and 2871:
Wheelhousing liner, removing and in
Page 2872 and 2873:
Wheelhousing liner, removing and in
Page 2874 and 2875:
Outside rear view mirror Página 2
Page 2876 and 2877:
Outside rear view mirror Página 4
Page 2878 and 2879:
Roof moldings Página 1 de 2 66 - 3
Page 2880 and 2881:
Roof rail Página 1 de 3 66 - 4 Roo
Page 2882 and 2883:
Roof rail Página 3 de 3 locks in.
Page 2884 and 2885:
Trim Página 2 de 3 6. VW emblem
Page 2886 and 2887:
Protective side moldings Página 1
Page 2888 and 2889:
Rear spoiler with integrated stopli
Page 2890 and 2891:
Page 2892 and 2893:
Page 2894 and 2895:
Page 2896 and 2897:
Special components of Golf "GTI 337
Page 2898 and 2899:
Page 2900 and 2901:
Page 2902 and 2903:
Page 2904 and 2905:
Page 2906 and 2907:
Page 2908 and 2909:
Page 2910 and 2911:
Page 2912 and 2913:
Page 2914 and 2915:
Page 2916 and 2917:
Page 2918 and 2919:
Page 2920 and 2921:
Body Interior Página 2 de 6 Check
Page 2922 and 2923:
Body Interior Página 4 de 6 side c
Page 2924 and 2925:
Body Interior Página 6 de 6 Cover,
Page 2926 and 2927:
Seatbelts Página 2 de 15 Caution!
Page 2928 and 2929:
Seatbelts Página 4 de 15 Repair Ma
Page 2930 and 2931:
Seatbelts Página 6 de 15 1. Automa
Page 2932 and 2933:
Seatbelts Página 8 de 15 - Remove
Page 2934 and 2935:
Seatbelts Página 10 de 15 7. Belt
Page 2936 and 2937:
Seatbelts Página 12 de 15 Rear top
Page 2938 and 2939:
Seatbelts Página 14 de 15 Illustra
Page 2940 and 2941:
Seatbelts, inspecting Página 1 de
Page 2942 and 2943:
Page 2944 and 2945:
Page 2946 and 2947:
Airbag Página 1 de 55 69 - 4 Airba
Page 2948 and 2949:
Airbag Página 3 de 55 ◦ Removing
Page 2950 and 2951:
Airbag Página 5 de 55 Airbag syste
Page 2952 and 2953:
Airbag Página 7 de 55 driver and p
Page 2954 and 2955:
Airbag Página 9 de 55 special airb
Page 2956 and 2957:
Airbag Página 11 de 55 When replac
Page 2958 and 2959:
Airbag Página 13 de 55 4, Driver s
Page 2960 and 2961:
Airbag Página 15 de 55 Repair Manu
Page 2962 and 2963:
Airbag Página 17 de 55 - Disconnec
Page 2964 and 2965:
Airbag Página 19 de 55 1. Steering
Page 2966 and 2967:
Airbag Página 21 de 55 - Insert a
Page 2968 and 2969:
Airbag Página 23 de 55 1. Steering
Page 2970 and 2971:
Airbag Página 25 de 55 - Remove bo
Page 2972 and 2973:
Airbag Página 27 de 55 • Three-s
Page 2974 and 2975:
Airbag Página 29 de 55 - Disconnec
Page 2976 and 2977:
Airbag Página 31 de 55 ◦ 4 Nm 4.
Page 2978 and 2979:
Airbag Página 33 de 55 - Installat
Page 2980 and 2981:
Airbag Página 35 de 55 ◦ Qty. 4,
Page 2982 and 2983:
Airbag Página 37 de 55 Repair Manu
Page 2984 and 2985:
Airbag Página 39 de 55 1. Side cur
Page 2986 and 2987:
Airbag Página 41 de 55 removing an
Page 2988 and 2989:
Airbag Página 43 de 55 Make sure n
Page 2990 and 2991:
Airbag Página 45 de 55 • 04.01.
Page 2992 and 2993:
Airbag Página 47 de 55 . Side curt
Page 2994 and 2995:
Airbag Página 49 de 55 - Molded he
Page 2996 and 2997:
Airbag Página 51 de 55 . Driver an
Page 2998 and 2999:
Airbag Página 53 de 55 Therefore,
Page 3000 and 3001:
Airbag Página 55 de 55 - Press "Go
Page 3002 and 3003:
Crash sensors Página 2 de 7 4. Car
Page 3004 and 3005:
Crash sensors Página 4 de 7 . Cras
Page 3006 and 3007:
Crash sensors Página 6 de 7 Instal
Page 3008 and 3009:
Instrument panel Página 1 de 15 70
Page 3010 and 3011:
Instrument panel Página 3 de 15 -
Page 3012 and 3013:
Page 3014 and 3015:
Page 3016 and 3017:
Page 3018 and 3019:
Page 3020 and 3021:
Page 3022 and 3023:
Instrument panel Página 15 de 15 R
Page 3024 and 3025:
Door trim Página 2 de 13 1. Trim
Page 3026 and 3027:
Door trim Página 4 de 13 reach int
Page 3028 and 3029:
Door trim Página 6 de 13 1. Trim
Page 3030 and 3031:
Door trim Página 8 de 13 - Unclip
Page 3032 and 3033:
Door trim Página 10 de 13 7. locki
Page 3034 and 3035:
Door trim Página 12 de 13 - Remain
Page 3036 and 3037:
Pillar and side trim Página 1 de 7
Page 3038 and 3039:
Page 3040 and 3041:
Page 3042 and 3043:
Page 3044 and 3045:
Page 3046 and 3047:
Pillar and side trim Página 11 de
Page 3048 and 3049:
Page 3050 and 3051:
Page 3052 and 3053:
Page 3054 and 3055:
Page 3056 and 3057:
Page 3058 and 3059:
Page 3060 and 3061:
Page 3062 and 3063:
Page 3064 and 3065:
Page 3066 and 3067:
Page 3068 and 3069:
Page 3070 and 3071:
Page 3072 and 3073:
Page 3074 and 3075:
Page 3076 and 3077:
Page 3078 and 3079:
Page 3080 and 3081:
Page 3082 and 3083:
Page 3084 and 3085:
Page 3086 and 3087:
Page 3088 and 3089:
Page 3090 and 3091:
Page 3092 and 3093:
Page 3094 and 3095:
Page 3096 and 3097:
Page 3098 and 3099:
Page 3100 and 3101:
Page 3102 and 3103:
Page 3104 and 3105:
Page 3106 and 3107:
Luggage compartment trim Página 1
Page 3108 and 3109:
Page 3110 and 3111:
Page 3112 and 3113:
Page 3114 and 3115:
Page 3116 and 3117:
Page 3118 and 3119:
Page 3120 and 3121:
Page 3122 and 3123:
Page 3124 and 3125:
Page 3126 and 3127:
Page 3128 and 3129:
Page 3130 and 3131:
Page 3132 and 3133:
Rear lid trim Página 2 de 13 1. Lo
Page 3134 and 3135:
Rear lid trim Página 4 de 13 - Ins
Page 3136 and 3137:
Rear lid trim Página 6 de 13 Insta
Page 3138 and 3139:
Rear lid trim Página 8 de 13 - Loo
Page 3140 and 3141:
Rear lid trim Página 10 de 13 wago
Page 3142 and 3143:
Rear lid trim Página 12 de 13 - Un
Page 3144 and 3145:
Headliner Página 1 de 14 70 - 6 He
Page 3146 and 3147:
Headliner Página 3 de 14 Caution!
Page 3148 and 3149:
Headliner Página 5 de 14 - Remove
Page 3150 and 3151:
Headliner Página 7 de 14 - Unclip
Page 3152 and 3153:
Headliner Página 9 de 14 (Vehicles
Page 3154 and 3155:
Headliner Página 11 de 14 - Unclip
Page 3156 and 3157:
Headliner Página 13 de 14 lifting
Page 3158 and 3159:
Front seats Página 1 de 27 72 - 1
Page 3160 and 3161:
Front seats Página 3 de 27 - Push
Page 3162 and 3163:
Front seats Página 5 de 27 Repair
Page 3164 and 3165:
Front seats Página 7 de 27 ◦ for
Page 3166 and 3167:
Front seats Página 9 de 27 Front b
Page 3168 and 3169:
Front seats Página 11 de 27 - Remo
Page 3170 and 3171:
Page 3172 and 3173:
Page 3174 and 3175:
Front seats Página 17 de 27 1. Cov
Page 3176 and 3177:
Front seats Página 19 de 27 - Unho
Page 3178 and 3179:
Front seats Página 21 de 27 - Uncl
Page 3180 and 3181:
Page 3182 and 3183:
Page 3184 and 3185:
Page 3186 and 3187:
Rear seats Página 2 de 12 - Guide
Page 3188 and 3189:
Rear seats Página 4 de 12 1. Cover
Page 3190 and 3191:
Rear seats Página 6 de 12 - Remove
Page 3192 and 3193:
Rear seats Página 8 de 12 - Guide
Page 3194 and 3195:
Rear seats Página 10 de 12 Right b
Page 3196 and 3197:
Rear seats Página 12 de 12 Install
Page 3198 and 3199:
Front seat cushion and cover Págin
Page 3200 and 3201:
Page 3202 and 3203:
Page 3204 and 3205:
Page 3206 and 3207:
Page 3208 and 3209:
Page 3210 and 3211:
Page 3212 and 3213:
Seat heating elements Página 2 de
Page 3214 and 3215:
Rear seat upholstery and cover Pág
Page 3216 and 3217:
Page 3218 and 3219:
Page 3220 and 3221:
Body On Board Diagnostic (OBD) Pág
Page 3222 and 3223:
Page 3224 and 3225:
Page 3226 and 3227:
Airbag system, On Board Diagnostic
Page 3228 and 3229:
Page 3230 and 3231:
Page 3232 and 3233:
Page 3234 and 3235:
Page 3236 and 3237:
Page 3238 and 3239:
Page 3240 and 3241:
Page 3242 and 3243:
Page 3244 and 3245:
Page 3246 and 3247:
Page 3248 and 3249:
Page 3250 and 3251:
Page 3252 and 3253:
Page 3254 and 3255:
Page 3256 and 3257:
Page 3258 and 3259:
Page 3260 and 3261:
Page 3262 and 3263:
Page 3264 and 3265:
Page 3266 and 3267:
Page 3268 and 3269:
Page 3270 and 3271:
Page 3272 and 3273:
Page 3274 and 3275:
Page 3276 and 3277:
Page 3278 and 3279:
Page 3280 and 3281:
Page 3282 and 3283:
Page 3284 and 3285:
Page 3286 and 3287:
Page 3288 and 3289:
Page 3290 and 3291:
Page 3292 and 3293:
Page 3294 and 3295:
Page 3296 and 3297:
Page 3298 and 3299:
Page 3300 and 3301:
Page 3302 and 3303:
Page 3304 and 3305:
Page 3306 and 3307:
Page 3308 and 3309:
Page 3310 and 3311:
Convenience system (vehicles with p
Page 3312 and 3313:
Page 3314 and 3315:
Page 3316 and 3317:
Page 3318 and 3319:
Page 3320 and 3321:
Page 3322 and 3323:
Page 3324 and 3325:
Page 3326 and 3327:
Page 3328 and 3329:
Page 3330 and 3331:
Page 3332 and 3333:
Page 3334 and 3335:
Page 3336 and 3337:
Page 3338 and 3339:
Page 3340 and 3341:
Page 3342 and 3343:
Page 3344 and 3345:
Page 3346 and 3347:
Page 3348 and 3349:
Page 3350 and 3351:
Page 3352 and 3353:
Page 3354 and 3355:
Page 3356 and 3357:
Page 3358 and 3359:
Page 3360 and 3361:
Page 3362 and 3363:
Page 3364 and 3365:
Page 3366 and 3367:
Page 3368 and 3369:
Page 3370 and 3371:
Page 3372 and 3373:
Page 3374 and 3375:
Page 3376 and 3377:
Page 3378 and 3379:
Page 3380 and 3381:
Page 3382 and 3383:
Page 3384 and 3385:
Page 3386 and 3387:
Page 3388 and 3389:
Page 3390 and 3391:
Page 3392 and 3393:
Page 3394 and 3395:
Page 3396 and 3397:
Page 3398 and 3399:
Page 3400 and 3401:
Page 3402 and 3403:
Page 3404 and 3405:
Page 3406 and 3407:
Page 3408 and 3409:
Page 3410 and 3411:
Page 3412 and 3413:
Page 3414 and 3415:
Page 3416 and 3417:
Page 3418 and 3419:
Page 3420 and 3421:
Page 3422 and 3423:
Page 3424 and 3425:
Page 3426 and 3427:
Page 3428 and 3429:
Page 3430 and 3431:
Page 3432 and 3433:
Page 3434 and 3435:
Page 3436 and 3437:
Page 3438 and 3439:
Page 3440 and 3441:
Page 3442 and 3443:
Page 3444 and 3445:
Page 3446 and 3447:
Page 3448 and 3449:
Page 3450 and 3451:
Page 3452 and 3453:
Page 3454 and 3455:
Page 3456 and 3457:
Page 3458 and 3459:
Page 3460 and 3461:
Page 3462 and 3463:
Page 3464 and 3465:
Page 3466 and 3467:
Page 3468 and 3469:
Page 3470 and 3471:
Page 3472 and 3473:
Page 3474 and 3475:
Page 3476 and 3477:
Page 3478 and 3479:
Page 3480 and 3481:
Page 3482 and 3483:
Page 3484 and 3485:
Page 3486 and 3487:
Page 3488 and 3489:
Page 3490 and 3491:
Page 3492 and 3493:
Page 3494 and 3495:
Page 3496 and 3497:
Page 3498 and 3499:
Page 3500 and 3501:
Page 3502 and 3503:
Page 3504 and 3505:
Page 3506 and 3507:
Page 3508 and 3509:
Page 3510 and 3511:
Page 3512 and 3513:
Page 3514 and 3515:
Page 3516 and 3517:
Page 3518 and 3519:
Page 3520 and 3521:
Page 3522 and 3523:
Page 3524 and 3525:
Central locking system (vehicles wi
Page 3526 and 3527:
Page 3528 and 3529:
Page 3530 and 3531:
Page 3532 and 3533:
Page 3534 and 3535:
Page 3536 and 3537:
Page 3538 and 3539:
Page 3540 and 3541:
Page 3542 and 3543:
Page 3544 and 3545:
Page 3546 and 3547:
Page 3548 and 3549:
Page 3550 and 3551:
Page 3552 and 3553:
Page 3554 and 3555:
Page 3556 and 3557:
Page 3558 and 3559:
Page 3560 and 3561:
Page 3562 and 3563:
Page 3564 and 3565:
Page 3566 and 3567:
Page 3568 and 3569:
Page 3570 and 3571:
Page 3572 and 3573:
Page 3574 and 3575:
Page 3576 and 3577:
Page 3578 and 3579:
Page 3580 and 3581:
Page 3582 and 3583:
Page 3584 and 3585:
Page 3586 and 3587:
Page 3588 and 3589:
Page 3590 and 3591:
Page 3592 and 3593:
Page 3594 and 3595:
Page 3596 and 3597:
Page 3598 and 3599:
Page 3600 and 3601:
Page 3602 and 3603:
Page 3604 and 3605:
Page 3606 and 3607:
Driver's side seat adjustment, On B
Page 3608 and 3609:
Page 3610 and 3611:
Page 3612 and 3613:
Page 3614 and 3615:
Page 3616 and 3617:
Page 3618 and 3619:
Page 3620 and 3621:
Page 3622 and 3623:
Page 3624 and 3625:
Page 3626 and 3627:
Page 3628 and 3629:
Page 3630 and 3631:
Page 3632 and 3633:
Page 3634 and 3635:
Page 3636 and 3637:
Page 3638 and 3639:
Page 3640 and 3641:
Page 3642 and 3643:
Page 3644 and 3645:
Page 3646 and 3647:
Page 3648 and 3649:
Page 3650 and 3651:
Page 3652 and 3653:
Page 3654 and 3655:
Page 3656 and 3657:
Page 3658 and 3659:
Page 3660 and 3661:
Heating and Air Conditioning Págin
Page 3662 and 3663:
On Board Diagnostic (OBD) through m
Page 3664 and 3665:
Page 3666 and 3667:
Climatronic On Board Diagnostic (OB
Page 3668 and 3669:
Page 3670 and 3671:
Page 3672 and 3673:
Page 3674 and 3675:
Page 3676 and 3677:
Page 3678 and 3679:
Page 3680 and 3681:
Page 3682 and 3683:
Page 3684 and 3685:
Page 3686 and 3687:
Page 3688 and 3689:
Page 3690 and 3691:
Page 3692 and 3693:
Page 3694 and 3695:
Page 3696 and 3697:
Page 3698 and 3699:
Page 3700 and 3701:
Page 3702 and 3703:
Page 3704 and 3705:
Page 3706 and 3707:
Page 3708 and 3709:
Page 3710 and 3711:
Page 3712 and 3713:
Page 3714 and 3715:
Page 3716 and 3717:
Page 3718 and 3719:
Heating and ventilation system, ser
Page 3720 and 3721:
Page 3722 and 3723:
Page 3724 and 3725:
Page 3726 and 3727:
Page 3728 and 3729:
Page 3730 and 3731:
Page 3732 and 3733:
Page 3734 and 3735:
Page 3736 and 3737:
Page 3738 and 3739:
Page 3740 and 3741:
Page 3742 and 3743:
Page 3744 and 3745:
Page 3746 and 3747:
Page 3748 and 3749:
Page 3750 and 3751:
Page 3752 and 3753:
Page 3754 and 3755:
Manual A/C Página 1 de 34 87-1 Man
Page 3756 and 3757:
Manual A/C Página 3 de 34 87-2 3 -
Page 3758 and 3759:
Manual A/C Página 5 de 34 87-3 8 -
Page 3760 and 3761:
Manual A/C Página 7 de 34 87-5 18
Page 3762 and 3763:
Manual A/C Página 9 de 34 87-6 Ser
Page 3764 and 3765:
Manual A/C Página 11 de 34 87-8 Re
Page 3766 and 3767:
Manual A/C Página 13 de 34 87-10 -
Page 3768 and 3769:
Manual A/C Página 15 de 34 fuel ho
Page 3770 and 3771:
Manual A/C Página 17 de 34 87-13 C
Page 3772 and 3773:
Page 3774 and 3775:
Manual A/C Página 21 de 34 87-15 F
Page 3776 and 3777:
Manual A/C Página 23 de 34 87-17 F
Page 3778 and 3779:
Manual A/C Página 25 de 34 safety
Page 3780 and 3781:
Page 3782 and 3783:
Manual A/C Página 29 de 34 system
Page 3784 and 3785:
Manual A/C Página 31 de 34 Note: h
Page 3786 and 3787:
Page 3788 and 3789:
Climatronic Página 1 de 61 87-25 C
Page 3790 and 3791:
Climatronic Página 3 de 61 87-27 N
Page 3792 and 3793:
Climatronic Página 5 de 61 87-29 C
Page 3794 and 3795:
Climatronic Página 7 de 61 87-31 A
Page 3796 and 3797:
Climatronic Página 9 de 61 87-32 4
Page 3798 and 3799:
Climatronic Página 11 de 61 17 -.
Page 3800 and 3801:
Climatronic Página 13 de 61 87-35
Page 3802 and 3803:
Page 3804 and 3805:
Page 3806 and 3807:
Page 3808 and 3809:
Page 3810 and 3811:
Page 3812 and 3813:
Page 3814 and 3815:
Page 3816 and 3817:
Climatronic Página 29 de 61 Page 8
Page 3818 and 3819:
Climatronic Página 31 de 61 code C
Page 3820 and 3821:
Climatronic Página 33 de 61 Findin
Page 3822 and 3823:
Page 3824 and 3825:
Page 3826 and 3827:
Page 3828 and 3829:
Page 3830 and 3831:
Page 3832 and 3833:
Page 3834 and 3835:
Page 3836 and 3837:
Page 3838 and 3839:
Climatronic Página 51 de 61 measur
Page 3840 and 3841:
Page 3842 and 3843:
Climatronic Página 55 de 61 pressu
Page 3844 and 3845:
Climatronic Página 57 de 61 F). No
Page 3846 and 3847:
Climatronic Página 59 de 61 in mod
Page 3848 and 3849:
Page 3850 and 3851:
A/C refrigerant system Página 2 de
Page 3852 and 3853:
Page 3854 and 3855:
Page 3856 and 3857:
Page 3858 and 3859:
A/C refrigerant system Página 10 d
Page 3860 and 3861:
Page 3862 and 3863:
Page 3864 and 3865:
Page 3866 and 3867:
Page 3868 and 3869:
Page 3870 and 3871:
A/C refrigerant system, servicing P
Page 3872 and 3873:
Page 3874 and 3875:
Page 3876 and 3877:
Page 3878 and 3879:
Page 3880 and 3881:
Page 3882 and 3883:
Page 3884 and 3885:
Page 3886 and 3887:
Page 3888 and 3889:
Page 3890 and 3891:
Page 3892 and 3893:
Page 3894 and 3895:
Page 3896 and 3897:
Page 3898 and 3899:
Page 3900 and 3901:
Page 3902 and 3903:
Page 3904 and 3905:
Page 3906 and 3907:
Page 3908 and 3909:
Page 3910 and 3911:
Page 3912 and 3913:
Page 3914 and 3915:
Page 3916 and 3917:
Page 3918 and 3919:
Page 3920 and 3921:
Page 3922 and 3923:
A/C refrigerant system, troubleshoo
Page 3924 and 3925:
Page 3926 and 3927:
Page 3928 and 3929:
Page 3930 and 3931:
Page 3932 and 3933:
A/C refrigerant system, capacities
Page 3934 and 3935:
A/C refrigerant system, capacities
Page 3936 and 3937:
Compressor bracket, removing and in
Page 3938 and 3939:
Page 3940 and 3941:
Page 3942 and 3943:
Page 3944 and 3945:
Page 3946 and 3947:
Page 3948 and 3949:
Page 3950 and 3951:
Page 3952 and 3953:
Page 3954 and 3955:
Page 3956 and 3957:
Page 3958 and 3959:
Page 3960 and 3961:
Page 3962 and 3963:
Page 3964 and 3965:
Page 3966 and 3967:
Page 3968 and 3969:
Page 3970 and 3971:
Refrigerant R134a - Servicing Pági
Page 3972 and 3973:
General information for A/C system
Page 3974 and 3975:
Page 3976 and 3977:
Page 3978 and 3979:
Page 3980 and 3981:
Page 3982 and 3983:
Page 3984 and 3985:
Page 3986 and 3987:
Page 3988 and 3989:
Page 3990 and 3991:
Page 3992 and 3993:
General information on refrigerant
Page 3994 and 3995:
Page 3996 and 3997:
Page 3998 and 3999:
Page 4000 and 4001:
Page 4002 and 4003:
Page 4004 and 4005:
Page 4006 and 4007:
Page 4008 and 4009:
Page 4010 and 4011:
Page 4012 and 4013:
Laws and regulations Página 1 de 6
Page 4014 and 4015:
Page 4016 and 4017:
Page 4018 and 4019:
Refrigerant circuit Página 1 de 11
Page 4020 and 4021:
Page 4022 and 4023:
Page 4024 and 4025:
Page 4026 and 4027:
Page 4028 and 4029:
Page 4030 and 4031:
Complaints Página 2 de 2 A/C compr
Page 4032 and 4033:
Pressures, checking on vehicles Pá
Page 4034 and 4035:
Page 4036 and 4037:
Page 4038 and 4039:
Page 4040 and 4041:
Page 4042 and 4043:
Page 4044 and 4045:
Page 4046 and 4047:
Page 4048 and 4049:
Page 4050 and 4051:
Page 4052 and 4053:
Page 4054 and 4055:
Page 4056 and 4057:
Page 4058 and 4059:
Page 4060 and 4061:
Page 4062 and 4063:
Page 4064 and 4065:
Page 4066 and 4067:
Components, replacing Página 2 de
Page 4068 and 4069:
Page 4070 and 4071:
Page 4072 and 4073:
Testing equipment and tools Página
Page 4074 and 4075:
Page 4076 and 4077:
Page 4078 and 4079:
Page 4080 and 4081:
Electrical Equipment On Board Diagn
Page 4082 and 4083:
Page 4084 and 4085:
Page 4086 and 4087:
On Board Diagnostic (OBD) from m.y.
Page 4088 and 4089:
Instrument cluster through m.y. 199
Page 4090 and 4091:
Page 4092 and 4093:
Page 4094 and 4095:
Page 4096 and 4097:
Page 4098 and 4099:
Page 4100 and 4101:
Page 4102 and 4103:
Page 4104 and 4105:
Page 4106 and 4107:
Page 4108 and 4109:
Page 4110 and 4111:
Page 4112 and 4113:
Page 4114 and 4115:
Page 4116 and 4117:
Page 4118 and 4119:
Page 4120 and 4121:
Page 4122 and 4123:
Page 4124 and 4125:
Page 4126 and 4127:
Page 4128 and 4129:
Page 4130 and 4131:
Page 4132 and 4133:
Page 4134 and 4135:
Page 4136 and 4137:
Page 4138 and 4139:
Page 4140 and 4141:
Page 4142 and 4143:
Page 4144 and 4145:
Page 4146 and 4147:
Page 4148 and 4149:
Page 4150 and 4151:
Instrument cluster m.y. 2000 throug
Page 4152 and 4153:
Page 4154 and 4155:
Page 4156 and 4157:
Page 4158 and 4159:
Page 4160 and 4161:
Page 4162 and 4163:
Page 4164 and 4165:
Page 4166 and 4167:
Page 4168 and 4169:
Page 4170 and 4171:
Page 4172 and 4173:
Page 4174 and 4175:
Page 4176 and 4177:
Page 4178 and 4179:
Page 4180 and 4181:
Page 4182 and 4183:
Page 4184 and 4185:
Page 4186 and 4187:
Page 4188 and 4189:
Page 4190 and 4191:
Page 4192 and 4193:
Page 4194 and 4195:
Page 4196 and 4197:
Page 4198 and 4199:
Page 4200 and 4201:
Page 4202 and 4203:
Page 4204 and 4205:
Page 4206 and 4207:
Page 4208 and 4209:
Page 4210 and 4211:
Page 4212 and 4213:
Page 4214 and 4215:
Page 4216 and 4217:
Page 4218 and 4219:
Page 4220 and 4221:
Page 4222 and 4223:
Page 4224 and 4225:
Page 4226 and 4227:
Data Bus On Board Diagnostic Interf
Page 4228 and 4229:
Page 4230 and 4231:
Page 4232 and 4233:
Page 4234 and 4235:
Page 4236 and 4237:
Page 4238 and 4239:
Page 4240 and 4241:
Page 4242 and 4243:
Page 4244 and 4245:
Page 4246 and 4247:
Anti-theft immobilizer, On Board Di
Page 4248 and 4249:
Electrical Equipment Página 2 de 6
Page 4250 and 4251:
Page 4252 and 4253:
Page 4254 and 4255:
Battery Página 2 de 7 27-2 A new g
Page 4256 and 4257:
Battery Página 4 de 7 27-4 Warning
Page 4258 and 4259:
Battery Página 6 de 7 27-5 Battery
Page 4260 and 4261:
Battery, checking Página 1 de 28 2
Page 4262 and 4263:
Page 4264 and 4265:
Page 4266 and 4267:
Page 4268 and 4269:
Page 4270 and 4271:
Battery, checking Página 11 de 28
Page 4272 and 4273:
Page 4274 and 4275:
Page 4276 and 4277:
Page 4278 and 4279:
Page 4280 and 4281:
Page 4282 and 4283:
Page 4284 and 4285:
Page 4286 and 4287:
Page 4288 and 4289:
Battery, charging Página 1 de 5 27
Page 4290 and 4291:
Page 4292 and 4293:
Page 4294 and 4295:
Battery, disconnecting and reconnec
Page 4296 and 4297:
Page 4298 and 4299:
Page 4300 and 4301:
Page 4302 and 4303:
Page 4304 and 4305:
Page 4306 and 4307:
Battery, removing and installing P
Page 4308 and 4309:
Page 4310 and 4311:
Page 4312 and 4313:
Page 4314 and 4315:
Page 4316 and 4317:
Starter Página 1 de 9 27-61 Starte
Page 4318 and 4319:
Starter Página 3 de 9 27-63 Specia
Page 4320 and 4321:
Starter Página 5 de 9 27-65 - Remo
Page 4322 and 4323:
Starter Página 7 de 9 27-67 Starte
Page 4324 and 4325:
Starter Página 9 de 9 27-69 - Remo
Page 4326 and 4327:
Generator (GEN) Página 1 de 1 27-7
Page 4328 and 4329:
Generator (GEN) through 04.99 Pági
Page 4330 and 4331:
Generator (GEN) through 04.99 Pági
Page 4332 and 4333:
Generator (GEN) from 05.99 Página
Page 4334 and 4335:
Page 4336 and 4337:
Page 4338 and 4339:
Generator (GEN) - 4-cylinder gasoli
Page 4340 and 4341:
Page 4342 and 4343:
Page 4344 and 4345:
Page 4346 and 4347:
Page 4348 and 4349:
Page 4350 and 4351:
Page 4352 and 4353:
Page 4354 and 4355:
Page 4356 and 4357:
Page 4358 and 4359:
Page 4360 and 4361:
Generator (GEN) - 4-cylinder TDI en
Page 4362 and 4363:
Page 4364 and 4365:
Page 4366 and 4367:
Page 4368 and 4369:
Page 4370 and 4371:
Page 4372 and 4373:
Page 4374 and 4375:
Page 4376 and 4377:
Page 4378 and 4379:
Generator (GEN) - 4-cylinder TDI -
Page 4380 and 4381:
Page 4382 and 4383:
Page 4384 and 4385:
Page 4386 and 4387:
Page 4388 and 4389:
Page 4390 and 4391:
Generator (GEN), tightening torques
Page 4392 and 4393:
Page 4394 and 4395:
Page 4396 and 4397:
Cruise Control System (CCS) through
Page 4398 and 4399:
Page 4400 and 4401:
Page 4402 and 4403:
Page 4404 and 4405:
Page 4406 and 4407:
Page 4408 and 4409:
Page 4410 and 4411:
Instrument cluster Página 1 de 20
Page 4412 and 4413:
Page 4414 and 4415:
Page 4416 and 4417:
Page 4418 and 4419:
Page 4420 and 4421:
Page 4422 and 4423:
Page 4424 and 4425:
Page 4426 and 4427:
Page 4428 and 4429:
Page 4430 and 4431:
Windshield wiper system Página 1 d
Page 4432 and 4433:
Page 4434 and 4435:
Page 4436 and 4437:
Page 4438 and 4439:
Page 4440 and 4441:
Windshield wiper system Página 11
Page 4442 and 4443:
Page 4444 and 4445:
Page 4446 and 4447:
Page 4448 and 4449:
Windshield wiper system, tightening
Page 4450 and 4451:
Washer system Página 2 de 10 Remov
Page 4452 and 4453:
Washer system Página 4 de 10 92-22
Page 4454 and 4455:
Page 4456 and 4457:
Page 4458 and 4459:
Page 4460 and 4461:
Rear window wiper [amp] washer syst
Page 4462 and 4463:
Page 4464 and 4465:
Page 4466 and 4467:
Page 4468 and 4469:
Page 4470 and 4471:
Washer hoses, repairing Página 1 d
Page 4472 and 4473:
Washer hoses, repairing Página 3 d
Page 4474 and 4475:
Headlights - Golf Página 1 de 20 9
Page 4476 and 4477:
Headlights - Golf Página 3 de 20 L
Page 4478 and 4479:
Page 4480 and 4481:
Page 4482 and 4483:
Page 4484 and 4485:
Headlights - Golf Página 11 de 20
Page 4486 and 4487:
Page 4488 and 4489:
Page 4490 and 4491:
Page 4492 and 4493:
Page 4494 and 4495:
Headlights - Jetta Página 1 de 17
Page 4496 and 4497:
Page 4498 and 4499:
Page 4500 and 4501:
Page 4502 and 4503:
Page 4504 and 4505:
Page 4506 and 4507:
Page 4508 and 4509:
Page 4510 and 4511:
Page 4512 and 4513:
Side mounted turn signals Página 2
Page 4514 and 4515:
Rear lights Página 2 de 11 94-37 5
Page 4516 and 4517:
Page 4518 and 4519:
Page 4520 and 4521:
Rear lights Página 8 de 11 94-43 R
Page 4522 and 4523:
Rear lights Página 10 de 11 94-45
Page 4524 and 4525:
Rear lights, tightening torques Pá
Page 4526 and 4527:
High-mount brake light Página 1 de
Page 4528 and 4529:
Page 4530 and 4531:
Page 4532 and 4533:
Steering column switches Página 1
Page 4534 and 4535:
Page 4536 and 4537:
Page 4538 and 4539:
Page 4540 and 4541:
Ignition/starter switch and lock cy
Page 4542 and 4543:
Page 4544 and 4545:
Page 4546 and 4547:
Page 4548 and 4549:
Interior lights and switches Págin
Page 4550 and 4551:
Page 4552 and 4553:
Page 4554 and 4555:
Page 4556 and 4557:
Page 4558 and 4559:
Page 4560 and 4561:
Page 4562 and 4563:
Page 4564 and 4565:
Page 4566 and 4567:
Page 4568 and 4569:
Page 4570 and 4571:
Page 4572 and 4573:
Page 4574 and 4575:
Anti-theft Immobilizer Página 1 de
Page 4576 and 4577:
Page 4578 and 4579:
Page 4580 and 4581:
Page 4582 and 4583:
Fuse holder and relay carriers Pág
Page 4584 and 4585:
Page 4586 and 4587:
Page 4588 and 4589:
Page 4590 and 4591:
Page 4592 and 4593:
Wiring harnesses and connectors, re
Page 4594 and 4595:
Page 4596 and 4597:
Page 4598 and 4599:
Page 4600 and 4601:
Antenna cables, replacing Página 2
Page 4602 and 4603:
Antenna cables, replacing Página 4
Page 4604 and 4605:
Communication Página 2 de 3 Genera
Page 4606 and 4607:
Radio system - Premium IV and Premi
Page 4608 and 4609:
Page 4610 and 4611:
Page 4612 and 4613:
Page 4614 and 4615:
Page 4616 and 4617:
Page 4618 and 4619:
Page 4620 and 4621:
Page 4622 and 4623:
Page 4624 and 4625:
Page 4626 and 4627:
Page 4628 and 4629:
Page 4630 and 4631:
Page 4632 and 4633:
Radio system - Premium VI (includin
Page 4634 and 4635:
Page 4636 and 4637:
Page 4638 and 4639:
Page 4640 and 4641:
Page 4642 and 4643:
Page 4644 and 4645:
Page 4646 and 4647:
Page 4648 and 4649:
Page 4650 and 4651:
Page 4652 and 4653:
Page 4654 and 4655:
Page 4656 and 4657:
Page 4658 and 4659:
Page 4660 and 4661:
Page 4662 and 4663:
Multi-function steering wheel throu
Page 4664 and 4665:
Page 4666 and 4667:
Page 4668 and 4669:
Page 4670 and 4671:
Page 4672 and 4673:
Page 4674 and 4675:
Page 4676 and 4677:
Page 4678 and 4679:
Page 4680 and 4681:
Page 4682 and 4683:
Page 4684 and 4685:
Page 4686 and 4687:
Page 4688 and 4689:
Multi-function steering wheel from
Page 4690 and 4691:
Multi-function steering wheel from
Page 4692 and 4693:
Communication Página 2 de 3 91-2 O
Page 4694 and 4695:
Radio systems Página 1 de 1 91-4 R
Page 4696 and 4697:
Radio, Premium IV' Página 2 de 10
Page 4698 and 4699:
Page 4700 and 4701:
Page 4702 and 4703:
Page 4704 and 4705:
Page 4706 and 4707:
Radio, Premium V and Premium V - Mo
Page 4708 and 4709:
Page 4710 and 4711:
Page 4712 and 4713:
Page 4714 and 4715:
Page 4716 and 4717:
Radio, Premium VI and Premium VI -
Page 4718 and 4719:
Page 4720 and 4721:
Page 4722 and 4723:
Page 4724 and 4725:
Page 4726 and 4727:
Page 4728 and 4729:
Amplifier system - Monsoon Página
Page 4730 and 4731:
Page 4732 and 4733:
Page 4734 and 4735:
Speaker system Página 2 de 4 91-43
Page 4736 and 4737:
Speaker system Página 4 de 4 91-45
Page 4738 and 4739:
Antenna systems Página 2 de 11 91-
Page 4740 and 4741:
Page 4742 and 4743:
Page 4744 and 4745:
Page 4746 and 4747:
Antenna systems Página 10 de 11 91
Page 4748 and 4749:
CD Changer / CD Player Página 1 de
Page 4750 and 4751:
Page 4752 and 4753:
Page 4754 and 4755:
Page 4756 and 4757:
Page 4758 and 4759:
Multi-function steering wheel Pági
Page 4760 and 4761:
Page 4762 and 4763:
Page 4764 and 4765:
Page 4766 and 4767:
Page 4768 and 4769:
Page 4770 and 4771:
Telematics Página 2 de 35 91-77 Du
Page 4772 and 4773:
Telematics Página 4 de 35 91-79 Te
Page 4774 and 4775:
Telematics Página 6 de 35 91-80 4
Page 4776 and 4777:
Page 4778 and 4779:
Telematics Página 10 de 35 91-82 T
Page 4780 and 4781:
Page 4782 and 4783:
Telematics Página 14 de 35 91-86 -
Page 4784 and 4785:
Page 4786 and 4787:
Page 4788 and 4789:
Page 4790 and 4791:
Telematics Página 22 de 35 - Enter
Page 4792 and 4793:
Page 4794 and 4795:
Telematics Página 26 de 35 91-97 C
Page 4796 and 4797:
Telematics Página 28 de 35 91-99 -
Page 4798 and 4799:
Telematics Página 30 de 35 91-101
Page 4800 and 4801:
Page 4802 and 4803:
Page 4804 and 4805:
Mobile telephone and two-way radio
Page 4806 and 4807:
Page 4808 and 4809:
Page 4810 and 4811:
Page 4812 and 4813:
Page 4814 and 4815:
Page 4816 and 4817:
Página 2 de 3 Transportation wiper
Page 4818 and 4819:
Engine overview Página 1 de 1 1 En
Page 4820 and 4821:
Oil change service Página 1 de 1 3
Page 4822 and 4823:
Maintenance service Página 1 de 1
Page 4824 and 4825:
General Página 2 de 23 Installing
Page 4826 and 4827:
General Página 4 de 23 Front valan
Page 4828 and 4829:
General Página 6 de 23 Assembly to
Page 4830 and 4831:
General Página 8 de 23 in. Thereaf
Page 4832 and 4833:
General Página 10 de 23 - Set spri
Page 4834 and 4835:
General Página 12 de 23 Vehicle Di
Page 4836 and 4837:
General Página 14 de 23 The vehicl
Page 4838 and 4839:
General Página 16 de 23 - - 2 - PR
Page 4840 and 4841:
General Página 18 de 23 Stamped in
Page 4842 and 4843:
General Página 20 de 23 Front: Beh
Page 4844 and 4845:
General Página 22 de 23 Driver of
Page 4846 and 4847:
Description of work (part 1 of 2) P
Page 4848 and 4849:
Page 4850 and 4851:
Page 4852 and 4853:
Page 4854 and 4855:
Page 4856 and 4857:
Page 4858 and 4859:
Page 4860 and 4861:
Page 4862 and 4863:
Page 4864 and 4865:
Page 4866 and 4867:
Page 4868 and 4869:
Page 4870 and 4871:
Page 4872 and 4873:
Page 4874 and 4875:
Page 4876 and 4877:
Page 4878 and 4879:
Page 4880 and 4881:
Page 4882 and 4883:
Page 4884 and 4885:
Page 4886 and 4887:
Page 4888 and 4889:
Page 4890 and 4891:
Page 4892 and 4893:
Page 4894 and 4895:
Page 4896 and 4897:
Page 4898 and 4899:
Page 4900 and 4901:
Page 4902 and 4903:
Page 4904 and 4905:
Page 4906 and 4907:
Page 4908 and 4909:
Page 4910 and 4911:
Page 4912 and 4913:
Page 4914 and 4915:
Page 4916 and 4917:
Page 4918 and 4919:
Page 4920 and 4921:
Page 4922 and 4923:
Page 4924 and 4925:
Page 4926 and 4927:
Page 4928 and 4929:
Page 4930 and 4931:
Page 4932 and 4933:
Page 4934 and 4935:
Page 4936 and 4937:
Page 4938 and 4939:
Page 4940 and 4941:
Page 4942 and 4943:
Page 4944 and 4945:
Page 4946 and 4947:
Page 4948 and 4949:
Page 4950 and 4951:
Page 4952 and 4953:
Page 4954:
show all

Bentley Volkswagen.Golf.Jetta.R32.Official.Factory.Repair.Manual.1999-2005

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?