closure project manager - Document Request - U.S. Department of ...

More documents

Recommendations

Info

2.3.5.2 Steam and Condensate System The steam and condensate system is no longer operable in Building 991. The function has been replace by weatherproof boilers located outside Building 99 1, Room 166. The steam and condensate lines were removed from inside Room 137 of Building 99 1 out to the northeast comer of Building 99 1. 2.3.5.3 Sanitary Process Waste Systems All sanitary drains leave the building at the east side and into a manhole located by the northeast corner of Room 166. The basement tunnel floor drains are connected to a lift station at the southeast corner of the basement and two pumps, each controlled by a float switch, discharge into the sanitary drain line leaving the building. The Building 991 sewer line connects to the main sewer line at a manhole northeast of Building 99 1 just inside the PA. There are process waste tanks located outside the south wall of Building 991 by Room 1 10 that are used to collect process waste from Room 1 10 and spray down water from the hood exhaust ducts. The tanks have high level alarms and are normally operated by metallography laboratory personnel. These process waste tanks are currently out of service and no hazardous materials are generated in the metallography laboratory. Revision 1 Smtcmber I939 Building 991 Complex FS-
EMCClE-9 Table 2-4 Loads on Diesel Generator EMCC I Load EMCClA-3 I Lighting Transformer. 30 kVA. 480 V-12Of208 V Breathing Air Receptacle Welding Receptacle Instrument Air Comuressor Vacuum Pump P601B Pit Sump Pump P601 Transfer Pump P602 Vacuum Pump P601A & P601B Building 985 Smlv Fan F602 Plenum Exbaust Fan F601A Plenum Exhaust Fan F601B Health Phvsics Air Sam~lers EMCClD-4 Lighting transformer, 30 kVA 480V-12Of208V Breathbe Air ReceDtacle Welding Receptacle ~ Instrument Air Compressor, AC-601 Pit sum^ PUmD P601 Transfer Pmnp P602 Vacuum Pum~ P601A & P601B West Hot Water circulation Pump, P604A West Hot Water circulation Pump, P604B East Buildine; 985 Smlv Fan. F602 Plumm Exhaust Fan F601A Plumm Exhaust Fan F60 1B Health Physics Vacuum Pump A Health Physics Vacuum Pump B Vacuum Pump Plenum Exhaust Fan #1 Plenum Exhaust Fan #2 Plenum Exhaust Fan #3 15 kVA Panel I 25 kVA Panel 1 L I Genexator Building 989 Air sampling system . I I circulating Pump P-5 1 A fire water holding tank is located in a pit at the east end of Building 985. The tank IS designed to collect the drains from the exhaust plenum in the event the plenum fire sprinklers are activated. If water is introduced into this tank, Waste Management is contacted for assistance ui the disposal of the water. The system has a recirculating system for sampling the water and a pump that discharges to a hose connection by the east door of the building. By utilizing the pump and hose connection the contents could be transferred to a mobile tank by hose and transported to a disposal site. The fire water holding tank does not contain Raschig rings In addition to the plenum drains, a sump pump in the fire water holding tank also discharges to the tank. Revision 1 Building 991 Complex FSAR Scptcmher 1999 I ~ ~
Page 2 and 3:
,._I REVIEW AND APPROVAL FOR BUILDI
Page 4 and 5:
i L- FACILITY OVERWEW The Building
Page 6 and 7:
Based on the information in Table 1
Page 8 and 9:
i ,: - DF 1 - DF 3 - DF 3 DFJ - DF
Page 10 and 11:
AB AC ACI ALARA Am AOL ARCIE ASME B
Page 12 and 13:
j ?,.- LCO L.L.C. LLW LSDW MAL MAR
Page 14 and 15:
V Volt WAD Work Authorization Docum
Page 16 and 17:
. 2.3.1 Fire Suppression. Detection
Page 18 and 19:
Figure 2-2 Building 991 and Associa
Page 20 and 21:
THIS PAGE INTENTIONALLY LEFT BLANK
Page 22 and 23:
Page 24 and 25:
Chapter 6 Derivation of Technical S
Page 26 and 27:
Table 1-1 DOE-STD-3009 and Building
Page 28 and 29:
identified along with the change in
Page 30 and 31:
area), and other types of hazardous
Page 32 and 33:
Conduct of receipt, staging and shi
Page 34 and 35:
contamen received Accuracy Report &
Page 36 and 37:
1.2.6.2 Safety Analysis Summary Pot
Page 38 and 39:
polishing equipment. The Metallogra
Page 40 and 41:
under this set of documents include
Page 42 and 43:
specified in HSP 11.03 were met by
Page 44 and 45:
USQD-991-98.0900-MIU (Ref. 20) was
Page 46 and 47:
17 18 19 20 21 22 23 24 25 26 27 28
Page 48 and 49: a THIS PAGE INTENTIONALLY LEFT BLAN
Page 50 and 51: During the 1980s, Final Quality Cer
Page 52 and 53: Revision L September 1990 Figure 2-
Page 54 and 55: Building 989 - Diesel Generator Bui
Page 56 and 57: THIS PAGE HAS BEEN LEFT BLANK DUE-T
Page 58 and 59: Bearing walls and intermediate conc
Page 60 and 61: concrete structure with exterior di
Page 62 and 63: 1 ,j I Minor cracks and leaking hav
Page 64 and 65: uilding. Differential displacement
Page 66 and 67: in wooden waste containers and stor
Page 72 and 73: Table 2-1 Fire Suppression Systems
Page 74 and 75: The sprinkler system consists of a
Page 76 and 77: connect hoses to a hydrant and flow
Page 78 and 79: Revision I Scptcmber 1999 Figure 2-
Page 80 and 81: filters against the impacts of larg
Page 82 and 83: 2.3.2 Heating, Ventilation, and Air
Page 84 and 85: The S-1 system has outside air damp
Page 86 and 87: Supplv Zone 4 (S-4) The S-4 supply
Page 88 and 89: Table 2-2 Building 991 Complex Exha
Page 92 and 93: system contains an untested HEPA st
Page 94 and 95: The burners are Model LNR 8.4-G-20
Page 96 and 97: LSDW speakers are located throughou
Page 100 and 101: 2.3.5.4 Domestic Process Water Syst
Page 102 and 103: component (Schedule 40 pipe with 6-
Page 104 and 105: 18 19 20 21 22 23 24 25 Building 99
Page 106 and 107: i THIS PAGE INTENTIONALLY LEFT BLAN
Page 108 and 109: the successful completion of a PSC'
Page 110 and 111: hazards analysis approach to be use
Page 112 and 113: Site Integrating Management Contrac
Page 114 and 115: The Criticality Safety program is e
Page 116 and 117: safety SSCs relies on the developme
Page 118 and 119: 3.14 RADIATION PROTECTION The Radia
Page 120 and 121: activities and hazard assessment an
Page 122 and 123: 18 19 20 21 22 23 24 25 26 27 28 29
Page 124 and 125: *I L\ '. '/ CHAPTER 4 HAZARD AND AC
Page 126 and 127: c THIS PAGE INTENTIONALLY LEFT BLAN
Page 128 and 129: pertinent to FSAR preparation, haza
Page 130 and 131: Facilities, DOE-HDBK-30 10-94 (Ref.
Page 132 and 133: PDC is the plume duration correctio
Page 134 and 135: 0 Hazard Warning - The availability
Page 136 and 137: For hazardous materials that did no
Page 138 and 139: 4.4.2 Hazard Classification The DOE
Page 140 and 141: scenarios. A total of 37 event tree
Page 142 and 143: Revision 1 Scpinnher 19% (2) extrem
Page 144 and 145: determined to represent a Standard
Page 146 and 147: The extremely unlikely impact of a
Page 148 and 149:
750 Pad tank farm that migrates to
Page 150 and 151:
4 3 M a p: X - a E 0 U N U
Page 153 and 154:
4.6 RISK DOMINANT ACCIDENT SCENARIO
Page 155 and 156:
A"" and Room 170 (including connect
Page 157 and 158:
area, or the Building 996 waste sto
Page 159 and 160:
consequence is low (0.084rem). If'
Page 161 and 162:
! Movernent of waste containers fro
Page 163 and 164:
The risk and conseauences of Punctu
Page 165 and 166:
i ’ i, ! U” In summary, removal
Page 167:
4 2 3 k J M fi .I 4 2 n
Page 171:
ch ch
Page 174 and 175:
I 1 I a rj i Y 4 d L J
Page 178 and 179:
3 ci 3 N n i
Page 180 and 181:
4.8 SAFETY ANALYSIS ASSUMPTIONS AND
Page 182 and 183:
W 3
Page 184 and 185:
c: --c m m 3
Page 186 and 187:
I f dl
Page 188:
c 3
Page 192:
I I I
Page 199 and 200:
, UI
Page 201 and 202:
~ 16 17 18 19 20 21 22 23 24 Revisi
Page 203 and 204:
It Tip: 3 *-- Revision 1 September
Page 205 and 206:
6.1 INTRODUCTION 6. DERIVATION OF T
Page 207 and 208:
4 7 : i Maintenance of this Design
Page 209 and 210:
NI -1 -4 Y) d
Page 211 and 212:
-I I I c? 8 3 rA \ \ I I
Page 213 and 214:
6.4 ADMINISTRATIVE CONTROLS 6.4.1 I
Page 215 and 216:
; c .- > c .s cat 0 0 P d Q ?- VI 0
Page 217 and 218:
H .I L * m CII 0 L c, El s .- c, E
Page 219 and 220:
x .I L Y m 0 L E I Y 6 P) m L Y m .
Page 221 and 222:
P d
Page 223 and 224:
I ea 0 " E3 O Q zs P I .- 3 " 5 2 d
Page 225 and 226:
n L .I c, 5! c! U
Page 227 and 228:
6.5 TSR DERIVATION The TSRs were de
Page 229 and 230:
6.6 REFERENCES 1 Safety Analysis fo
Page 231 and 232:
Revision 1 September 1999 CHAPTER 5
Page 233 and 234:
5.1 INTRODUCTION 5. SAFETY STRUCTUR
Page 235 and 236:
Conditions for Operations (LCOs) in
Page 237 and 238:
.-. g: ai cej ?i i:
Page 239:
EI .- .- 4 3 I
Page 245 and 246:
5.2.2 SC-3 SSCS This section summar
Page 247 and 248:
5.3 SSC SAFETY CATEGORY DESfGNATIUl
Page 250 and 251:
-I i
Page 252 and 253:
0 N n
Page 254 and 255:
Page 256 and 257:
APPENDIX A BUILDING 991 COMPLEX TEC
Page 258 and 259:
5B.4.2 CREDITED PROGRAMMATIC ELEMEN
Page 260 and 261:
TERM ' AFFECTED AREA BASISBASES BUI
Page 262 and 263:
TERM OUT-OF-SERVICE OUT-OF-TOLERANC
Page 264 and 265:
1.2 ACRONYMS AC AOL CSE DOE DOT FEV
Page 266 and 267:
limits on container radioactive mat
Page 268 and 269:
1.2 LOGICAL CONNECTORS (continued)
Page 270 and 271:
2. SAFETY LIMITS AND LIMlTING CONTR
Page 272 and 273:
LCO 3.0.7 LCO 3.0.8 LCO 3.0.9 LCO 3
Page 274 and 275:
LCO 3.0.6 (cont.) Calibration that
Page 276 and 277:
LCO 3.0.8 Planned OUT-OF-TOLERANCES
Page 278 and 279:
3./4. LIMITING CONDITIONS FOR OPERA
Page 280 and 281:
3./4. LIMITING CONDITIONS FOR OPERA
Page 282 and 283:
BASES BACKGROUND The BUILDING 991 C
Page 284 and 285:
BASES REQUIRED ACTION A. 1 LCO 3.1
Page 286 and 287:
BASES ~ ~~~ ~ REQUIRED ACTION A.2 (
Page 288 and 289:
BASES REQUIRED The four-hour COMPLE
Page 290 and 291:
BASES REQUIRED ACTION C.2 (continue
Page 292 and 293:
7 ;' LT 6, BASES REQUDRED ACTION D.
Page 294 and 295:
BASES RE0UIKE.D ACTION E. 1 Revisio
Page 296 and 297:
SURVEILLANCE REQUIREMENTS ]BASES SR
Page 298 and 299:
3.2 LIMITING CONDITION FOR OPERATEO
Page 300 and 301:
S LRkEIL LANCE REQLZEMEhT SR 4.2.1
Page 302 and 303:
BASES BACKGROChD (continued) The Bu
Page 304 and 305:
BASES BACGGROVhD (continued) APPLIC
Page 306 and 307:
BASES APPLICA'TION TO SAFETY rzN At
Page 308 and 309:
BASES REOUIRED ACTION A. I [continu
Page 310 and 311:
BASES REO U1RE.D ACTION C 1 [contin
Page 312 and 313:
BASES REQUIRED ACTION E. I REQUIRED
Page 314 and 315:
?I 1i-l ~~ ~ ~ SR 4.2.1 The verific
Page 316 and 317:
3J4. LIILlXTfNG CONDXTlUKS FOR OPER
Page 318 and 319:
3.M. IJIR/EITXNG COLWXTIONS FOR OPE
Page 320 and 321:
BASES BA4CKGRO'L'KD (continued) Rev
Page 322 and 323:
BASES APPLICABILITY Jlis LCO is app
Page 324 and 325:
BASES REO UIRED ACTIONB 1 The Build
Page 326 and 327:
BASES REQUIRED ACTION B.2.2 {contin
Page 328 and 329:
SK4 3.1 Thc verification of the com
Page 330 and 331:
SURVEILLANCE RE 0 UIREMENTS 3A SE S
Page 332 and 333:
, -I ,.i ’-, \ 5.0.3 AC Programma
Page 334 and 335:
5.1 5.1.1 5.1.2 5.1.3 ORGANIZATION
Page 336 and 337:
5.2 5.2.1 5.2.2 INVENTORY CONTROL A
Page 338 and 339:
AOL 2 SNM containers staged in the
Page 340 and 341:
AOL 4 The quantities of radioactive
Page 342 and 343:
AOL 5 Wooden LLW crates stored at t
Page 344 and 345:
AOL 7 All pallets of waste containe
Page 346 and 347:
2 4’1 ACTIONS: CONDITION 1. ODmti
Page 348 and 349:
5.3 CONTROL OF COMBUSTIBLE MATERIAL
Page 350 and 351:
ACTIONS: CONDITION 1. High heat rel
Page 352 and 353:
AOL 10 A flammable gas use control
Page 354 and 355:
5.4 5.4.1 5.4.2 5.4.3 Revision 1 Sc
Page 356 and 357:
Revision 1 Szptcrnber 1999 Table 2
Page 358 and 359:
5.6 5.6.1 Revision I Sntcrnher t999
Page 360 and 361:
-I -)y 5.8.1 fieauirenients for Wor
Page 362 and 363:
5B.0 GENERAL APPLICATION BASES Revi
Page 364 and 365:
5B. 1 ORGANIZATION AND MANAGEMENT B
Page 366 and 367:
5B.2 INVENTORY CONTROL AND MATERIAL
Page 368 and 369:
AOL 1 POC and waste containers are
Page 370 and 371:
, 1 \,?i AOL 3 BASIS (cont'd) AOL 4
Page 372 and 373:
AOL 5 This AQL applies to wooden LL
Page 374 and 375:
AOL 7 BASIS (cont'd) AOL 8 BASIS: R
Page 376 and 377:
AOL 8 BASIS [cont'dj Revision 1 Sep
Page 378 and 379:
5B.3 CONTROL OF COMBUSTIBLE MATERIA
Page 380 and 381:
-7 “q Y AOL 9 BASIS Combustible m
Page 382 and 383:
5B.4 MAINTENANCE AND SURVEILLANCE O
Page 384 and 385:
' I *r- ;:x 5B.5 EMERGENCY RESPONSE
Page 386 and 387:
5B.S WORK COYTROL BASES 5B.S.l Requ
Page 388 and 389:
6 DESIGN FEATURES The purpose of th
Page 390:
7 REFERENCES A- 1 A-2 A-3 A4 A-5 A4
Page 396 and 397:
k e- .. _. . .~,
Page 398 and 399:
' Building 991 Complex FSAR/NSTR Ch
Page 400:
1 Revisions NSTR-011-98. Safety Ana
show all

closure project manager - Document Request - U.S. Department of ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?