Laws, Rules and Regulations - The National Board of Boiler and ...

More documents

Recommendations

Info

100 2. Pressure Vessels - Each pressure vessel, except for “UM” stamped pressure vessels, shall be subject to either initial in-service inspection (for a newly manufactured pressure vessel) or initial field certificate inspection (for an existing pressure vessel). a. The initial field certificate inspection of existing pressure vessels shall take place by October 6, 2011. b. Each pressure vessel, with the exception of pressure vessels that are under the supervision of a registered owner-user inspection agency, shall receive a certificate inspection triennially. 3. Pressure vessels and unfired boilers that are under the supervision of a registered owner-user inspection agency shall be inspected at intervals required by the National Board Inspection Code or API-510, as applicable. 4. The inspection of any pressure vessel(s) contained within a refrigeration system shall be conducted pursuant to the regulation on refrigeration systems and is not part of the pressure vessel inspection requirements. InSUranCe InSpeCtIOn reQUIrementS 1. Inspections made by commissioned inspectors employed by an authorized inspection agency licensed to do business in the state and holding a Certificate of Competency from the department are accepted in lieu of inspections made by department inspectors. 2. The department must be notified of any suspension of insurance. 3. The department must be notified of new business and discontinuance of insurance. 4. The department must be notified of rule violation(s). 5. The department must be notified of refusal of entry. CertIFICate OF InSpeCtIOn 1. A Certificate of Inspection for boilers, valid 12 months, is issued by the department upon payment of a $50.00 fee per boiler by the insurer to the department provided the inspection was satisfactory. 2. A Certificate of Inspection for refrigeration systems, valid 12 months, is issued by the department upon payment of a $40.00 fee per boiler by the insurer to the department provided the inspection was satisfactory. 3. The a Certificate of Inspection for pressure vessels is valid for the period indicated and in no case longer than 3-years and is issued by the department upon payment of a $30.00 fee per pressure vessel by the insurer to the department provided the inspection was satisfactory. 4. The certificate fee for a boiler, pressure vessel or a refrigeration system inspected by a state-employed inspector must be paid upon the owner receiving an invoice from the department. A certificate is not issued if there are unabated violations. State FeeS 1. Boilers: a. Greater than or equal to10 but not greater than 60 square feet.................................................................$80.00 per object b. Greater than or equal to 60 but not greater than 1,000 square feet ............................. ........................ $110.00 per object c. Greater than or equal to 1,000 square feet and above................................. .............................................. $150.00 per object 2. Pressure vessels: a. Less than or equal to 30 square feet in size ....................................... ..............................................................$20.00 per object b. Greater than 30 but not greater than 60 square feet ............................. .......................................................$40.00 per object c. Greater than 60 but not greater than 100 square feet ........................ .........................................................$60.00 per object d. Greater than 100 square feet ........................................... ...................................................................................$80.00 per object 3. Refrigeration Systems: a. Greater than 3 and less than 25 tons ........................ ................................................................ ....................$100.00 per system b. Greater than or equal to 25 tons, but less than 300 tons ....................... ........................................ .........$150.00 per system c. Greater than or equal to 300 tons .................................................. ............................................................... $200.00 per system 2013 National Board Synopsis of Boiler and Pressure Vessel Laws, Rules and Regulations
101 4. Shop Inspections, AIA Services: a. Boilers (the higher of the following shall apply): i. Inspection, per boiler ......................................................................................................................................................$100.00 ii. Daily visit of 4 hours or less .........................................................................................................................................$320.00 b. iii. Daily visit over 4 hours ..................................................................................................................................................$600.00 Pressure Vessels: i. Inspection, per specific vessel .......................................................................................................................................$100.00 ii. Daily visit of 4 hours or less .........................................................................................................................................$320.00 iii. Daily visit over 4 hours ..................................................................................................................................................$600.00 OWner-USer InSpeCtIOn aGenCY Owner-User Minimum Number Of Maximum Number Of Object Cost Per Pressure Vessels Pressure Vessels Pressure Vessel Inspected Inspected $15.00 1 Up to 25 $7.50 26 Up to 100 $6.00 101 Up to 500 $4.50 501 & Over mISCellaneOUS 1. Each object approved for use shall be assigned a registration number, which shall be located in the upper left hand corner of the certificate and shall also be affixed to the front of the object in such a manner as to be plainly visible. 2. Operators of boilers and specific refrigeration systems are licensed by the Bureau of Boiler and Pressure Vessel Compliance (BB&PVC) in accordance with state law requirements. 3. Pressure vessel repairs and alterations must be performed by an accredited shop holding appropriate code symbol stamp(s) (e.g., the National Board “R” stamp or New Jersey “R” stamp, as appropriate). 4. Both API and National Board Owner-User programs are recognized. API Owners-Users may register with the state, receive an audit, and receive a Certificate of Operation in recognition of their program. The BB&PVC conducts an audit of the API owner-user triennially. 5. Each unfired pressure vessel shall be registered with the BB&PVC and shall receive a jurisdiction number following inspection by a certified inspector, except for the following: a. UM pressure vessels exempt from inspection under N.J.A.C. 12:90-5.13(b), or b. Pressure vessels inspected by an Owner-User Inspection Agency which has registered with the BB&PVC under the provisions of the regulation. 6. When a facility has registered as an Owner-User Inspection Agency in accordance with the provision of the regulations the facility shall maintain a listing of each pressure vessel at that facility and shall, during the triennial audit, provide the listing of pressure vessels to the BB&PVC. 7. Those facilities not operating under the provisions established for owner-users shall be inspected initially and thereafter triennially unless otherwise warranted by the condition of the pressure vessel. 2013 National Board Synopsis of Boiler and Pressure Vessel Laws, Rules and Regulations
Page 1 and 2:
® N B B I Since 1919 The National
Page 3 and 4:
ii © 2013 The National Board of Bo
Page 5 and 6:
iv Table oF ConTenTs UniTed sTaTes
Page 7 and 8:
1 State Department G. Thomas Surtee
Page 9 and 10:
3 State FeeS 1. Power boilers and h
Page 11 and 12:
5 3. Air tanks located on vehicles
Page 13 and 14:
7 State Department Randall D. Austi
Page 15 and 16:
9 CertIFICate OF InSpeCtIOn Certifi
Page 17 and 18:
11 3. Boilers and unfired pressure
Page 19 and 20:
13 4. Certificate of Competency and
Page 21 and 22:
15 Stamping: Where appropriate, the
Page 23 and 24:
17 State Department Steve Nelson, C
Page 25 and 26:
19 InSUranCe InSpeCtIOn reQUIrement
Page 27 and 28:
21 d. Used solely for hot-water sup
Page 29 and 30:
23 3. Any air tank on any vehicle u
Page 31 and 32:
25 3. Examinations for Delaware ins
Page 33 and 34:
27 These exempt hot-water supply bo
Page 35 and 36:
29 6. Unfired pressure vessels havi
Page 37 and 38:
31 State Department Keith A. Rudolp
Page 39 and 40:
33 5. A pressure vessel — the con
Page 41 and 42:
35 State Department Idaho Division
Page 43 and 44:
37 2. Pressure vessels located on v
Page 45 and 46:
39 c. Over 150 square feet ........
Page 47 and 48:
41 4. Unfired pressure vessels meet
Page 49 and 50:
43 a. Prepare a boiler or pressure
Page 51 and 52:
45 State Department Michael Kloster
Page 53 and 54:
47 III. Internal inspections of cas
Page 55 and 56: 49 4. Hot-water supply boilers whic
Page 57 and 58: 51 c. Boilers of 500 square feet he
Page 59 and 60: 53 State Department Rodney J. Handy
Page 61 and 62: 55 3. Low-pressure boilers: a. Heat
Page 63 and 64: 57 3. Portable boilers used for agr
Page 65 and 66: 59 8. A copy of the boiler rules an
Page 67 and 68: 61 5. Steam-heating boilers, hot-wa
Page 69 and 70: 63 4. Renewal of Maine Authorized I
Page 71 and 72: 65 3. Air tanks installed on the ri
Page 73 and 74: 67 State FeeS 1. Certificate inspec
Page 75 and 76: 69 3. All air tanks, except when: a
Page 77 and 78: 71 State Department William Vallanc
Page 79 and 80: 73 2. Reports of internal inspectio
Page 81 and 82: 75 State Department Joel T. Amato,
Page 83 and 84: 77 ObJeCtS SUbJeCt tO rUleS FOr FIe
Page 85 and 86: 79 State Department Kenneth L.Watso
Page 87 and 88: 81 CertIFICate OF InSpeCtIOn Certif
Page 89 and 90: 83 Stamping: Where appropriate, the
Page 91 and 92: 85 State Department Keith Kelly, Co
Page 93 and 94: 87 State Department Christopher B.
Page 95 and 96: 89 4. Low-pressure boilers shall be
Page 97 and 98: 91 State Department Mechanical Unit
Page 99 and 100: 93 Mine Section jurisdiction: Same
Page 101 and 102: 95 State Department George Capadis,
Page 103 and 104: 97 CertIFICate OF InSpeCtIOn 1. Cer
Page 105: 99 Stamping: 1. Repairs and alterat
Page 109 and 110: 103 4. Containers for liquified pet
Page 111 and 112: 105 State Department Matthew H. San
Page 113 and 114: 107 CertIFICate OF InSpeCtIOn Certi
Page 115 and 116: 109 1. Boilers and pressure vessels
Page 117 and 118: 111 InSUranCe InSpeCtIOn reQUIremen
Page 119 and 120: 113 State Department Robert Reetz,
Page 121 and 122: 115 8. Insurance inspectors must ob
Page 123 and 124: 117 3. Air tanks installed on the r
Page 125 and 126: 119 State Department Department of
Page 127 and 128: 121 State FeeS Annual Certificate o
Page 129 and 130: 123 State Department Michael D. Gra
Page 131 and 132: 125 InSUranCe InSpeCtIOn reQUIremen
Page 133 and 134: 127 6. Air tanks installed on the r
Page 135 and 136: 129 State Department Benjamin P. An
Page 137 and 138: 131 2. Hot-water heating boilers wh
Page 139 and 140: 133 State Department Adrienne Youma
Page 141 and 142: 135 State Department Ira Hinkle, Ch
Page 143 and 144: 137 mISCellaneOUS 1. Examinations f
Page 145 and 146: 139 ObJeCtS SUbJeCt tO rUleS FOr CO
Page 147 and 148: 141 State Department William H. Kun
Page 149 and 150: 143 CertIFICate OF InSpeCtIOn Certi
Page 151 and 152: 145 State Department Rick K. Sturm,
Page 153 and 154: 147 4. Steel steam boilers: a. Annu
Page 155 and 156: 149 4. Hot-water heaters and potabl
Page 157 and 158:
151 3. Boilers of railroad companie
Page 159 and 160:
153 3. An endorsement is required f
Page 161 and 162:
155 8. API-510 (9th Edition). 9. Sp
Page 163 and 164:
157 c. 500 square feet to 2,500 squ
Page 165 and 166:
159 State Department David W. Mulli
Page 167 and 168:
161 State Department Michael J. Ver
Page 169 and 170:
163 6. Reporting of periodic inspec
Page 171 and 172:
165 State Department J.D. Danni, OS
Page 173 and 174:
167 2. ASME Code: all (for boilers
Page 175 and 176:
169 1. National Board: R (accepted)
Page 177 and 178:
171 prOVInCIal Department Terry W.
Page 179 and 180:
173 prOVInCIal Department Eben L. C
Page 181 and 182:
175 prOVInCIal Department neWFOUnDl
Page 183 and 184:
177 mISCellaneOUS 1. Welders are su
Page 185 and 186:
179 ObJeCtS SUbJeCt tO rUleS FOr CO
Page 187 and 188:
181 2. Steam boilers on railway loc
Page 189 and 190:
183 terrItOrY Department E. William
Page 191 and 192:
185 prOVInCIal Department Anthony S
Page 193 and 194:
187 InSpeCtIOnS reQUIreD Annual or
Page 195 and 196:
189 e. All boilers, pressure vessel
Page 197 and 198:
191 prOVInCIal Department Madiha M.
Page 199 and 200:
193 b. Every time such an authorize
Page 201 and 202:
Page 203 and 204:
197 19. Periodic inspection or shop
Page 205 and 206:
Page 207 and 208:
201 InSUranCe InSpeCtIOn reQUIremen
Page 209 and 210:
203 b. Pressure vessels meeting req
Page 211 and 212:
205 mUnICIpal Department Michael J.
Page 213 and 214:
207 mUnICIpal Department Gary J. Ba
Page 215 and 216:
209 c. For each of the first five v
Page 217 and 218:
211 Exceptions: 1. Equipment owned
Page 219 and 220:
213 mUnICIpal Department Paul Herna
Page 221 and 222:
215 mUnICIpal Department mIamI-DaDe
Page 223 and 224:
217 mUnICIpal Department Randal S.
Page 225 and 226:
219 mISCellaneOUS 1. Repairs/altera
Page 227 and 228:
221 InSpeCtIOnS reQUIreD 1. Boilers
Page 229 and 230:
223 5. Hot-water boilers located in
Page 231 and 232:
225 mUnICIpal Department Thomas E.
Page 233 and 234:
227 2. City of Omaha requires all b
Page 235 and 236:
229 ObJeCtS SUbJeCt tO rUleS FOr FI
Page 237 and 238:
231 c. Nominal water-containing cap
Page 239 and 240:
233 mUnICIpal Department Alvin E. K
Page 241 and 242:
235 CertIFICate OF InSpeCtIOn Certi
Page 243 and 244:
237 mUnICIpal Department John McDon
Page 245 and 246:
239 mUnICIpal Department Linda Argo
Page 247 and 248:
241 mISCellaneOUS 1. Certificate of
Page 249 and 250:
243 Iowa Michael Klosterman, Chief
Page 251 and 252:
245 Washington Tony Oda, Chief Boil
Page 253 and 254:
247 Puerto Rico Edgar Hernandez Com
Page 255 and 256:
249 UNITED STATES continued . . . C
Page 257 and 258:
251 ASME STANDARDS continued . . .
Page 259 and 260:
253 UNITED STATES continued . . . J
Page 261 and 262:
255 STAMpINg REqUIREMENTS BY JURISD
Page 263 and 264:
257 CITIES, COUNTIES, AND TERRITORI
show all

Laws, Rules and Regulations - The National Board of Boiler and ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?