Laws, Rules and Regulations - The National Board of Boiler and ...

More documents

Recommendations

Info

104 State FeeS 1. Power boilers and high-temperature water boilers: a. External inspection .................................................................................................................................................................. $30.00 b. 4,000 square feet or less heating surface ........................................................................................................................... $60.00 c. More than 4,000 to 10,000 square feet heating surface .................................................................................................. $70.00 d. More than 10,000 square feet heating surface .................................................................................................................. $90.00 2. Heating boilers: a. External inspection .................................................................................................................................................................. $30.00 b. Internal without manhole ....................................................................................................................................................... $30.00 c. Internal with manhole ............................................................................................................................................................. $50.00 d. Hot-water supply boilers ....................................................................................................................................................... $30.00 3. Administration fee (one time only) .............................................................................................................................................. $37.50 mISCellaneOUS 1. Cities of 100,000 or greater population that have adopted a boiler code, in substantial compliance with the state boiler code, may enforce the provisions of the city code within their jurisdictions. 2. A Certificate of Competency is required to operate boilers in New Mexico. There are five levels: Boiler Operator Trainee, Boiler Operator Class I, II, and III, and Chief Boiler Technician. 3. A New Mexico commission and identification card can be obtained from the bureau by full-time employees of a National Board-authorized inspection agency. The request shall be initiated by the applicant’s employer and shall be accompanied by a facsimile of the applicant’s National Board Commission and commission card. Initial registration fee is $75.00. Renewal fee is $50.00 per year. 4. Repair organizations must hold a valid National Board “R,” “VR”, or “NR” stamp or be authorized by the Boiler Bureau. 5. Boilers must be marked with a tag bearing the New Mexico registration and serial numbers. 2013 National Board Synopsis of Boiler and Pressure Vessel Laws, Rules and Regulations
105 State Department Matthew H. Sansone, Supervising Boiler Inspector New York Department of Labor Boiler Safety Bureau State Campus, Building 12, Room 165 Albany, NY 12240-0102 Telephone — 518.457.2722 Email — matthew.sansone@labor.ny.gov Fax — 518.485.9077 empOWerment The state legislature empowered to make, alter, and amend rules and regulations. Boiler Board: Yes. (Contact above official for more information.) Date OF laW paSSaGe: 1911 Date of latest amendment to law: August 2004. Date rules and regulations implemented: 1911 for high-pressure boilers and 1964 for low-pressure boilers. Date of latest rules and regulations: April 1992. State statute: New York State Laws, Labor, Chapter 31. Boilers. neW YOrK rUleS FOr COnStrUCtIOn anD StampInG Construction: 1. New York Industrial Code, Rules 4 and 14. 2. ASME Code (Current Edition, Current Addendum), Sections I, II, IV, V, VIII (Division 1), and code cases. 3. Boilers built to ASME Code are acceptable, but must be shop-inspected by an inspector holding a National Board Commission. 4. Code addenda and case interpretations accepted automatically. 5. Manufacturers must file a copy of Manufacturer’s Data Report with the department on ASME forms for boilers stamped ASME, NEW YORK STANDARD, or NATIONAL BOARD. 6. National Board Inspection Code (Current Edition, Current Addendum). 7. National Board registration required for high-pressure boilers and pressure vessels. 8. Special design or construction requires approval of the department. Stamping: Where appropriate, the following National Board stamps or ASME Code symbol stamps are required: 1. National Board: R, VR. 2. ASME Code: A, E, H, M, PP, S, U, V. ObJeCtS SUbJeCt tO rUleS FOr COnStrUCtIOn anD StampInG All boilers, except the following: 1. Boilers subject to inspection by inspectors of boilers under the US Department of Transportation. 2. Boilers located on farms and used solely for agricultural purposes. 3. Steam or vapor boilers operating at a gage pressure of not more than 15 psi and which are located in dwellings occupied by fewer than six families. 4. Hot-water boilers which are located in dwellings occupied by fewer than six families. 5. Boilers subject to inspection or control of a federal agency. IMPORTANT NOTICE: Every effort has been made to make this synopsis as accurate and complete as possible. However, jurisdictional laws, regulations and rules are subject to change without notice. As a result, the information contained herein is neither guaranteed nor warranted. User is advised to consult the jurisdiction’s chief inspector before reaching any decision that may have critical impact or significant financial consequences. MEMBER JURISDICTION 2013 National Board Synopsis of Boiler and Pressure Vessel Laws, Rules and Regulations
Page 1 and 2:
® N B B I Since 1919 The National
Page 3 and 4:
ii © 2013 The National Board of Bo
Page 5 and 6:
iv Table oF ConTenTs UniTed sTaTes
Page 7 and 8:
1 State Department G. Thomas Surtee
Page 9 and 10:
3 State FeeS 1. Power boilers and h
Page 11 and 12:
5 3. Air tanks located on vehicles
Page 13 and 14:
7 State Department Randall D. Austi
Page 15 and 16:
9 CertIFICate OF InSpeCtIOn Certifi
Page 17 and 18:
11 3. Boilers and unfired pressure
Page 19 and 20:
13 4. Certificate of Competency and
Page 21 and 22:
15 Stamping: Where appropriate, the
Page 23 and 24:
17 State Department Steve Nelson, C
Page 25 and 26:
19 InSUranCe InSpeCtIOn reQUIrement
Page 27 and 28:
21 d. Used solely for hot-water sup
Page 29 and 30:
23 3. Any air tank on any vehicle u
Page 31 and 32:
25 3. Examinations for Delaware ins
Page 33 and 34:
27 These exempt hot-water supply bo
Page 35 and 36:
29 6. Unfired pressure vessels havi
Page 37 and 38:
31 State Department Keith A. Rudolp
Page 39 and 40:
33 5. A pressure vessel — the con
Page 41 and 42:
35 State Department Idaho Division
Page 43 and 44:
37 2. Pressure vessels located on v
Page 45 and 46:
39 c. Over 150 square feet ........
Page 47 and 48:
41 4. Unfired pressure vessels meet
Page 49 and 50:
43 a. Prepare a boiler or pressure
Page 51 and 52:
45 State Department Michael Kloster
Page 53 and 54:
47 III. Internal inspections of cas
Page 55 and 56:
49 4. Hot-water supply boilers whic
Page 57 and 58:
51 c. Boilers of 500 square feet he
Page 59 and 60: 53 State Department Rodney J. Handy
Page 61 and 62: 55 3. Low-pressure boilers: a. Heat
Page 63 and 64: 57 3. Portable boilers used for agr
Page 65 and 66: 59 8. A copy of the boiler rules an
Page 67 and 68: 61 5. Steam-heating boilers, hot-wa
Page 69 and 70: 63 4. Renewal of Maine Authorized I
Page 71 and 72: 65 3. Air tanks installed on the ri
Page 73 and 74: 67 State FeeS 1. Certificate inspec
Page 75 and 76: 69 3. All air tanks, except when: a
Page 77 and 78: 71 State Department William Vallanc
Page 79 and 80: 73 2. Reports of internal inspectio
Page 81 and 82: 75 State Department Joel T. Amato,
Page 83 and 84: 77 ObJeCtS SUbJeCt tO rUleS FOr FIe
Page 85 and 86: 79 State Department Kenneth L.Watso
Page 87 and 88: 81 CertIFICate OF InSpeCtIOn Certif
Page 89 and 90: 83 Stamping: Where appropriate, the
Page 91 and 92: 85 State Department Keith Kelly, Co
Page 93 and 94: 87 State Department Christopher B.
Page 95 and 96: 89 4. Low-pressure boilers shall be
Page 97 and 98: 91 State Department Mechanical Unit
Page 99 and 100: 93 Mine Section jurisdiction: Same
Page 101 and 102: 95 State Department George Capadis,
Page 103 and 104: 97 CertIFICate OF InSpeCtIOn 1. Cer
Page 105 and 106: 99 Stamping: 1. Repairs and alterat
Page 107 and 108: 101 4. Shop Inspections, AIA Servic
Page 109: 103 4. Containers for liquified pet
Page 113 and 114: 107 CertIFICate OF InSpeCtIOn Certi
Page 115 and 116: 109 1. Boilers and pressure vessels
Page 117 and 118: 111 InSUranCe InSpeCtIOn reQUIremen
Page 119 and 120: 113 State Department Robert Reetz,
Page 121 and 122: 115 8. Insurance inspectors must ob
Page 123 and 124: 117 3. Air tanks installed on the r
Page 125 and 126: 119 State Department Department of
Page 127 and 128: 121 State FeeS Annual Certificate o
Page 129 and 130: 123 State Department Michael D. Gra
Page 131 and 132: 125 InSUranCe InSpeCtIOn reQUIremen
Page 133 and 134: 127 6. Air tanks installed on the r
Page 135 and 136: 129 State Department Benjamin P. An
Page 137 and 138: 131 2. Hot-water heating boilers wh
Page 139 and 140: 133 State Department Adrienne Youma
Page 141 and 142: 135 State Department Ira Hinkle, Ch
Page 143 and 144: 137 mISCellaneOUS 1. Examinations f
Page 145 and 146: 139 ObJeCtS SUbJeCt tO rUleS FOr CO
Page 147 and 148: 141 State Department William H. Kun
Page 149 and 150: 143 CertIFICate OF InSpeCtIOn Certi
Page 151 and 152: 145 State Department Rick K. Sturm,
Page 153 and 154: 147 4. Steel steam boilers: a. Annu
Page 155 and 156: 149 4. Hot-water heaters and potabl
Page 157 and 158: 151 3. Boilers of railroad companie
Page 159 and 160: 153 3. An endorsement is required f
Page 161 and 162:
155 8. API-510 (9th Edition). 9. Sp
Page 163 and 164:
157 c. 500 square feet to 2,500 squ
Page 165 and 166:
159 State Department David W. Mulli
Page 167 and 168:
161 State Department Michael J. Ver
Page 169 and 170:
163 6. Reporting of periodic inspec
Page 171 and 172:
165 State Department J.D. Danni, OS
Page 173 and 174:
167 2. ASME Code: all (for boilers
Page 175 and 176:
169 1. National Board: R (accepted)
Page 177 and 178:
171 prOVInCIal Department Terry W.
Page 179 and 180:
173 prOVInCIal Department Eben L. C
Page 181 and 182:
175 prOVInCIal Department neWFOUnDl
Page 183 and 184:
177 mISCellaneOUS 1. Welders are su
Page 185 and 186:
179 ObJeCtS SUbJeCt tO rUleS FOr CO
Page 187 and 188:
181 2. Steam boilers on railway loc
Page 189 and 190:
183 terrItOrY Department E. William
Page 191 and 192:
185 prOVInCIal Department Anthony S
Page 193 and 194:
187 InSpeCtIOnS reQUIreD Annual or
Page 195 and 196:
189 e. All boilers, pressure vessel
Page 197 and 198:
191 prOVInCIal Department Madiha M.
Page 199 and 200:
193 b. Every time such an authorize
Page 201 and 202:
Page 203 and 204:
197 19. Periodic inspection or shop
Page 205 and 206:
Page 207 and 208:
201 InSUranCe InSpeCtIOn reQUIremen
Page 209 and 210:
203 b. Pressure vessels meeting req
Page 211 and 212:
205 mUnICIpal Department Michael J.
Page 213 and 214:
207 mUnICIpal Department Gary J. Ba
Page 215 and 216:
209 c. For each of the first five v
Page 217 and 218:
211 Exceptions: 1. Equipment owned
Page 219 and 220:
213 mUnICIpal Department Paul Herna
Page 221 and 222:
215 mUnICIpal Department mIamI-DaDe
Page 223 and 224:
217 mUnICIpal Department Randal S.
Page 225 and 226:
219 mISCellaneOUS 1. Repairs/altera
Page 227 and 228:
221 InSpeCtIOnS reQUIreD 1. Boilers
Page 229 and 230:
223 5. Hot-water boilers located in
Page 231 and 232:
225 mUnICIpal Department Thomas E.
Page 233 and 234:
227 2. City of Omaha requires all b
Page 235 and 236:
229 ObJeCtS SUbJeCt tO rUleS FOr FI
Page 237 and 238:
231 c. Nominal water-containing cap
Page 239 and 240:
233 mUnICIpal Department Alvin E. K
Page 241 and 242:
235 CertIFICate OF InSpeCtIOn Certi
Page 243 and 244:
237 mUnICIpal Department John McDon
Page 245 and 246:
239 mUnICIpal Department Linda Argo
Page 247 and 248:
241 mISCellaneOUS 1. Certificate of
Page 249 and 250:
243 Iowa Michael Klosterman, Chief
Page 251 and 252:
245 Washington Tony Oda, Chief Boil
Page 253 and 254:
247 Puerto Rico Edgar Hernandez Com
Page 255 and 256:
249 UNITED STATES continued . . . C
Page 257 and 258:
251 ASME STANDARDS continued . . .
Page 259 and 260:
253 UNITED STATES continued . . . J
Page 261 and 262:
255 STAMpINg REqUIREMENTS BY JURISD
Page 263 and 264:
257 CITIES, COUNTIES, AND TERRITORI
show all

Laws, Rules and Regulations - The National Board of Boiler and ...

Create successful ePaper yourself

Delete template?

Save as template?