Laws, Rules and Regulations - The National Board of Boiler and ...

More documents

Recommendations

Info

114 2. Boilers and pressure vessels located on farms and used solely for agricultural purposes. 3. Heating boilers which are located in private residences or in apartment houses of fewer than six family units. 4. Hot-water supply boilers, not exceeding the following: a. 200,000 BTU per hour input; b. 160 psig; c. 250°F. 5. Portable steam cleaners of the type commonly used in garages. 6. Miniature hobby boilers not exceeding an inside diameter of 10 inches and a grate area not exceeding 1-1/2 square feet (properly equipped with a safety valve, water level indicator, and pressure gage). 7. Electric boilers used as an integral part of an espresso coffee machine, provided the boiler does not exceed: a. 1-1/2 cubic feet in water capacity; b. 50 psi pressure. 8. All pressure vessels within the scope of ASME Code (2010 Edition), Section VIII, Divisions 1, 2, 3, with these exceptions: a. Pressure vessels under federal control; b. Pressure vessels that do not exceed: i. 30 water gallons in volume (4 cubic feet) and 250 psig in pressure; ii. 1-1/2 cubic feet in volume and 600 psig in pressure; iii. Inside diameter of 6 inches with no limitation on pressure. ObJeCtS SUbJeCt tO rUleS FOr FIelD InSpeCtIOn Same as OBJECTS SUBJECT TO RULES FOR CONSTRUCTION AND STAMPING. Field inspection of pressure vessels (other than anhydrous ammonia pressure vessels) is not required. InSpeCtIOnS reQUIreD Item Internal External High-pressure boilers 1 Year 1 Year* Low-pressure steam boilers, steel 2 Years 2 Years Cast-iron boilers — 2 Years Hot-water heating and hot-water supply boilers — 2 Years** Hot-water heating and hot-water supply boilers in apartments — 3 Years *External inspection while under pressure. **One annual external inspection for those located in nursing homes, schools, nursery schools, and kindergartens. InSUranCe InSpeCtIOn reQUIrementS 1. Inspections made by inspectors employed by National Board approved Authorized Inspection Agencies and commissioned by the department are accepted in lieu of inspections made by a department inspector with respect to boilers insured or inspected by their respective companies. 2. Inspections made by inspectors employed by owners/users and commissioned by the department are accepted in lieu of inspections made by a department inspector. 3. Reports of all inspections must be filed with the department on special state forms within 15 days after inspection. 4. The department must be notified within 30 days of suspension of insurance on account of dangerous conditions, discontinuance or refusal of insurance, and new business. 5. There is a $20.00 per year fee for each Certificate of Inspection issued. Payment of this fee is the responsibility of the owner/user. 6. Insurance companies are required to inspect those objects they insure. If an inspection report is not filed within 90 days of the certificate due date, the state may make the inspection and must bill the insuring company an inspection fee not to exceed $500.00 per day plus expenses. 7. The State of North Dakota will make all initial inspections. 2013 National Board Synopsis of Boiler and Pressure Vessel Laws, Rules and Regulations
115 8. Insurance inspectors must obtain new commissions in person following an oral interview. 9. Renewal of insurance inspector’s commission card is required by December of each year. Cost is $40.00 for a new or renewal card. CertIFICate OF InSpeCtIOn Certificate of Inspection, valid for 12 months for power boilers, and 24 months for low-pressure heating boilers and hot-water supply boilers, is issued by the department upon receipt of a satisfactory report of boiler inspection. A Certificate of Inspection is valid for 36 months for hot-water heating and hot-water supply boilers in apartments. State FeeS 1. High-pressure boilers – internal inspection: a. 50 square feet or less heating surface ................................................................................................................................. $80.00 b. More than 50 square feet to 500 square feet heating surface .....................................................................................$100.00 c. More than 500 square feet to 4,000 square feet heating surface ...............................................................................$120.00 d. More than 4,000 square feet heating surface ...................................................................................................................$150.00 2. High-pressure boilers – external inspection: a. 50 square feet or less heating surface ................................................................................................................................. $60.00 b. More than 50 square feet to 500 square feet heating surface .......................................................................................$80.00 c. More than 500 square feet to 4,000 square feet heating surface .................................................................................$80.00 d. More than 4,000 square feet heating surface ..................................................................................................................... $80.00 e. 100 kilowatts or less ............................................................................................................................................................... $60.00 f. More than 100 kilowatts ........................................................................................................................................................ $80.00 3. Low-pressure boilers – internal inspection: a. Without manway ...................................................................................................................................................................... $75.00 b. With manway ............................................................................................................................................................................ $85.00 4. Low-pressure boilers – external inspection: a. Hot-water heat and low-pressure steam ............................................................................................................................ $50.00 b. Hot-water supply ..................................................................................................................................................................... $35.00 5. Steam traction engines – internal inspection ............................................................................................................................. $60.00 6. Steam traction engines – external inspection ............................................................................................................................ $55.00 7. Steam traction engines and hydrostatic test .............................................................................................................................. $70.00 8. Steam traction engines and ultrasonic survey, per hour .......................................................................................................... $60.00 9. Portable Oil Field Boilers - Internal or External ................................................. $75.00 per hour, plus meals, mileage, lodging mISCellaneOUS 1. All welders welding pressure parts of boilers must be certified for ASME positions and registered with the department. Registration is renewed January 1 of each year. 2. The department requires all repairs and alterations be in accordance with the National Board Inspection Code or API-510 Inspection Code as applicable. 3. Any person or firm resetting, adjusting, or repairing safety valves must possess a valid “VR” Certificate of Authorization from the National Board. 4. A license is not required to operate a boiler or pressure vessel, except for hobby boilers. 5. A copy of North Dakota Boiler Rules and Regulations (includes pressure vessel regulations) may be obtained from North Dakota Insurance Department’s Web site: www.nd.gov/ndins/special/boiler-inspections/ 6. Boiler inspection blank forms available on Web site. 2013 National Board Synopsis of Boiler and Pressure Vessel Laws, Rules and Regulations
Page 1 and 2:
® N B B I Since 1919 The National
Page 3 and 4:
ii © 2013 The National Board of Bo
Page 5 and 6:
iv Table oF ConTenTs UniTed sTaTes
Page 7 and 8:
1 State Department G. Thomas Surtee
Page 9 and 10:
3 State FeeS 1. Power boilers and h
Page 11 and 12:
5 3. Air tanks located on vehicles
Page 13 and 14:
7 State Department Randall D. Austi
Page 15 and 16:
9 CertIFICate OF InSpeCtIOn Certifi
Page 17 and 18:
11 3. Boilers and unfired pressure
Page 19 and 20:
13 4. Certificate of Competency and
Page 21 and 22:
15 Stamping: Where appropriate, the
Page 23 and 24:
17 State Department Steve Nelson, C
Page 25 and 26:
19 InSUranCe InSpeCtIOn reQUIrement
Page 27 and 28:
21 d. Used solely for hot-water sup
Page 29 and 30:
23 3. Any air tank on any vehicle u
Page 31 and 32:
25 3. Examinations for Delaware ins
Page 33 and 34:
27 These exempt hot-water supply bo
Page 35 and 36:
29 6. Unfired pressure vessels havi
Page 37 and 38:
31 State Department Keith A. Rudolp
Page 39 and 40:
33 5. A pressure vessel — the con
Page 41 and 42:
35 State Department Idaho Division
Page 43 and 44:
37 2. Pressure vessels located on v
Page 45 and 46:
39 c. Over 150 square feet ........
Page 47 and 48:
41 4. Unfired pressure vessels meet
Page 49 and 50:
43 a. Prepare a boiler or pressure
Page 51 and 52:
45 State Department Michael Kloster
Page 53 and 54:
47 III. Internal inspections of cas
Page 55 and 56:
49 4. Hot-water supply boilers whic
Page 57 and 58:
51 c. Boilers of 500 square feet he
Page 59 and 60:
53 State Department Rodney J. Handy
Page 61 and 62:
55 3. Low-pressure boilers: a. Heat
Page 63 and 64:
57 3. Portable boilers used for agr
Page 65 and 66:
59 8. A copy of the boiler rules an
Page 67 and 68:
61 5. Steam-heating boilers, hot-wa
Page 69 and 70: 63 4. Renewal of Maine Authorized I
Page 71 and 72: 65 3. Air tanks installed on the ri
Page 73 and 74: 67 State FeeS 1. Certificate inspec
Page 75 and 76: 69 3. All air tanks, except when: a
Page 77 and 78: 71 State Department William Vallanc
Page 79 and 80: 73 2. Reports of internal inspectio
Page 81 and 82: 75 State Department Joel T. Amato,
Page 83 and 84: 77 ObJeCtS SUbJeCt tO rUleS FOr FIe
Page 85 and 86: 79 State Department Kenneth L.Watso
Page 87 and 88: 81 CertIFICate OF InSpeCtIOn Certif
Page 89 and 90: 83 Stamping: Where appropriate, the
Page 91 and 92: 85 State Department Keith Kelly, Co
Page 93 and 94: 87 State Department Christopher B.
Page 95 and 96: 89 4. Low-pressure boilers shall be
Page 97 and 98: 91 State Department Mechanical Unit
Page 99 and 100: 93 Mine Section jurisdiction: Same
Page 101 and 102: 95 State Department George Capadis,
Page 103 and 104: 97 CertIFICate OF InSpeCtIOn 1. Cer
Page 105 and 106: 99 Stamping: 1. Repairs and alterat
Page 107 and 108: 101 4. Shop Inspections, AIA Servic
Page 109 and 110: 103 4. Containers for liquified pet
Page 111 and 112: 105 State Department Matthew H. San
Page 113 and 114: 107 CertIFICate OF InSpeCtIOn Certi
Page 115 and 116: 109 1. Boilers and pressure vessels
Page 117 and 118: 111 InSUranCe InSpeCtIOn reQUIremen
Page 119: 113 State Department Robert Reetz,
Page 123 and 124: 117 3. Air tanks installed on the r
Page 125 and 126: 119 State Department Department of
Page 127 and 128: 121 State FeeS Annual Certificate o
Page 129 and 130: 123 State Department Michael D. Gra
Page 131 and 132: 125 InSUranCe InSpeCtIOn reQUIremen
Page 133 and 134: 127 6. Air tanks installed on the r
Page 135 and 136: 129 State Department Benjamin P. An
Page 137 and 138: 131 2. Hot-water heating boilers wh
Page 139 and 140: 133 State Department Adrienne Youma
Page 141 and 142: 135 State Department Ira Hinkle, Ch
Page 143 and 144: 137 mISCellaneOUS 1. Examinations f
Page 145 and 146: 139 ObJeCtS SUbJeCt tO rUleS FOr CO
Page 147 and 148: 141 State Department William H. Kun
Page 149 and 150: 143 CertIFICate OF InSpeCtIOn Certi
Page 151 and 152: 145 State Department Rick K. Sturm,
Page 153 and 154: 147 4. Steel steam boilers: a. Annu
Page 155 and 156: 149 4. Hot-water heaters and potabl
Page 157 and 158: 151 3. Boilers of railroad companie
Page 159 and 160: 153 3. An endorsement is required f
Page 161 and 162: 155 8. API-510 (9th Edition). 9. Sp
Page 163 and 164: 157 c. 500 square feet to 2,500 squ
Page 165 and 166: 159 State Department David W. Mulli
Page 167 and 168: 161 State Department Michael J. Ver
Page 169 and 170: 163 6. Reporting of periodic inspec
Page 171 and 172:
165 State Department J.D. Danni, OS
Page 173 and 174:
167 2. ASME Code: all (for boilers
Page 175 and 176:
169 1. National Board: R (accepted)
Page 177 and 178:
171 prOVInCIal Department Terry W.
Page 179 and 180:
173 prOVInCIal Department Eben L. C
Page 181 and 182:
175 prOVInCIal Department neWFOUnDl
Page 183 and 184:
177 mISCellaneOUS 1. Welders are su
Page 185 and 186:
179 ObJeCtS SUbJeCt tO rUleS FOr CO
Page 187 and 188:
181 2. Steam boilers on railway loc
Page 189 and 190:
183 terrItOrY Department E. William
Page 191 and 192:
185 prOVInCIal Department Anthony S
Page 193 and 194:
187 InSpeCtIOnS reQUIreD Annual or
Page 195 and 196:
189 e. All boilers, pressure vessel
Page 197 and 198:
191 prOVInCIal Department Madiha M.
Page 199 and 200:
193 b. Every time such an authorize
Page 201 and 202:
Page 203 and 204:
197 19. Periodic inspection or shop
Page 205 and 206:
Page 207 and 208:
201 InSUranCe InSpeCtIOn reQUIremen
Page 209 and 210:
203 b. Pressure vessels meeting req
Page 211 and 212:
205 mUnICIpal Department Michael J.
Page 213 and 214:
207 mUnICIpal Department Gary J. Ba
Page 215 and 216:
209 c. For each of the first five v
Page 217 and 218:
211 Exceptions: 1. Equipment owned
Page 219 and 220:
213 mUnICIpal Department Paul Herna
Page 221 and 222:
215 mUnICIpal Department mIamI-DaDe
Page 223 and 224:
217 mUnICIpal Department Randal S.
Page 225 and 226:
219 mISCellaneOUS 1. Repairs/altera
Page 227 and 228:
221 InSpeCtIOnS reQUIreD 1. Boilers
Page 229 and 230:
223 5. Hot-water boilers located in
Page 231 and 232:
225 mUnICIpal Department Thomas E.
Page 233 and 234:
227 2. City of Omaha requires all b
Page 235 and 236:
229 ObJeCtS SUbJeCt tO rUleS FOr FI
Page 237 and 238:
231 c. Nominal water-containing cap
Page 239 and 240:
233 mUnICIpal Department Alvin E. K
Page 241 and 242:
235 CertIFICate OF InSpeCtIOn Certi
Page 243 and 244:
237 mUnICIpal Department John McDon
Page 245 and 246:
239 mUnICIpal Department Linda Argo
Page 247 and 248:
241 mISCellaneOUS 1. Certificate of
Page 249 and 250:
243 Iowa Michael Klosterman, Chief
Page 251 and 252:
245 Washington Tony Oda, Chief Boil
Page 253 and 254:
247 Puerto Rico Edgar Hernandez Com
Page 255 and 256:
249 UNITED STATES continued . . . C
Page 257 and 258:
251 ASME STANDARDS continued . . .
Page 259 and 260:
253 UNITED STATES continued . . . J
Page 261 and 262:
255 STAMpINg REqUIREMENTS BY JURISD
Page 263 and 264:
257 CITIES, COUNTIES, AND TERRITORI
show all

Laws, Rules and Regulations - The National Board of Boiler and ...

Create successful ePaper yourself

Delete template?

Save as template?