Models 5E, 5F, 5G & 5H Electric Switch Machines: Single ... - Alstom

More documents

Recommendations

Info

TroubleshootingTable 5–1. Symptoms Noticed from the Control Locations (Cont.)Symptom8) Switch flashing out ofcorrespondence, RWC or NWC relaydown (per switch position request).Corrective Action1) Check that RWP or NWP relay is up.2) Check for 12V DC at relay.3) Check for loose hardware andconnections.4) Check for faulty relay.P1293, Rev. Jun/07 5–3 Alstom Signaling Inc.
TroubleshootingTable 5–2. Trackside Noted SymptomsSymptomCorrective Action1) Motor runs but points do not move. 1) Clutch slips - see friction clutch andadjustment.2) Object in points - remove object.3) Linkage disconnected - reconnect throwrod to switch points.2) Points move but switch machine does 1) Reconnect and/or readjust lock rod.not lock and indicate.3) Motor will not run. 1) Verify hand crank cut-out contact is closed.2) Check motor control contacts in pointdetector.3) Check for power to switch, NW to A5, RWto B4, CW to B8.4) Check power to motor. Find cause of opencircuit.5) Check condition of motor brushes.4) Bent or cracked rods, couplings orlugs caused by a train running throughclosed points of layout. (Note: any trainspeed will bend or break fittings.)5) Switch circuit controller will notindicate.1) Inspect for damage to layout andcomponents.2) Inspect point-detector movement fordamage. Replace as necessary.1) Obstruction in points or under flange ofpoint - remove.2) Linkage disconnected, reconnect asnecessary.3) If no signal energy present, check wiringfrom control location.4) If signal return is interrupted, check wiringback to control location.P1293, Rev. Jun/07 5–4 Alstom Signaling Inc.
Page 1 and 2:
Models 5E, 5F, 5G &5H Electric Swit
Page 3 and 4:
LIST OF EFFECTIVE PAGESP1293, Model
Page 5 and 6:
PREFACENOTICE OF CONFIDENTIAL INFOR
Page 7 and 8:
ABOUT THE MANUALThis manual is inte
Page 9 and 10:
MANUAL SPECIAL NOTATIONSIn the Alst
Page 11 and 12:
TopicTABLE OF CONTENTSPage1. SECTIO
Page 13 and 14:
TopicTABLE OF CONTENTSPage4. SECTIO
Page 15 and 16:
TopicTABLE OF CONTENTSPage6.5.32. C
Page 17 and 18:
DescriptionLIST OF FIGURES (CONT.)P
Page 19 and 20:
DescriptionLIST OF TABLESPageTable
Page 21 and 22:
DescriptionLIST OF TABLES (CONT.)Pa
Page 23 and 24:
General Description1. SECTION 1 - G
Page 25 and 26:
General Description1.3. MODEL 5E, 5
Page 27 and 28:
General Description1.4. MODEL 5 SER
Page 29 and 30:
General DescriptionThe components i
Page 31 and 32:
General Description1.5.2. Proper At
Page 33 and 34:
General Description1.5.7. Safety at
Page 35 and 36:
Theory of Operation2. SECTION 2 - T
Page 37 and 38:
Theory of OperationFigure 2-3. Hand
Page 39 and 40:
Theory of OperationFigure 2-5. Inse
Page 41 and 42:
Theory of OperationThe locations of
Page 43 and 44:
Theory of Operation2.5.1. MotorThe
Page 45 and 46:
Theory of Operation2.5.1.1. Commuta
Page 47 and 48:
Theory of OperationWhen the motor i
Page 49 and 50:
Theory of OperationTHROWBARHAND CRA
Page 51 and 52:
Theory of Operation2.5.3.1. Frictio
Page 53 and 54:
Theory of OperationFinal cam bar mo
Page 55 and 56:
Theory of Operation2.5.5. Lock RodT
Page 57 and 58:
Theory of Operation2.5.6. Point Det
Page 59 and 60:
Theory of Operation2.5.7. Box Style
Page 61 and 62:
Theory of OperationFigure 2-27. Poi
Page 63 and 64:
Theory of Operation2.5.8.3. Shunt C
Page 65 and 66:
Theory of OperationWARNINGADHERE TO
Page 67 and 68:
Theory of Operation46POINT DETECTOR
Page 69 and 70:
Theory of Operation2.5.9.1. Switch
Page 71 and 72:
Theory of Operation2.5.9.3. Example
Page 73 and 74:
Installation3. SECTION - INSTALLATI
Page 75 and 76:
Installation3.3.1. Left- or Right-H
Page 77 and 78:
InstallationMIN. FOR 5E, 5F ONLYFig
Page 79 and 80:
Installation3.3.5. Hand-Throw Lever
Page 81 and 82:
Installation3.3.8. Connect and Init
Page 83 and 84:
Installation3.3.9. Connect and Init
Page 85 and 86:
Installation3.4.1. Point Detector R
Page 87 and 88:
Page 89 and 90:
Page 91 and 92:
Installation3.5. BEFORE REPLACING M
Page 93 and 94:
Installation3.5.3. Temperature Cons
Page 95 and 96:
Installation3.6.2.1. Changing Over
Page 97 and 98:
InstallationTable 3-12. Changing Ov
Page 99 and 100:
Installation3.6.2.2. Changing Over
Page 101 and 102:
Page 103 and 104:
Installation3.6.3. Changing Over th
Page 105 and 106:
Page 107 and 108:
InstallationFigure 3-5. 5H Switch M
Page 109 and 110:
InstallationTable 3-15. Throw Rod P
Page 111 and 112:
InstallationTHIS PAGE INTENTIONALLY
Page 113 and 114:
Scheduled Maintenance4.4. SPECIAL T
Page 115 and 116: Scheduled Maintenance4.6. PREVENTIV
Page 117 and 118: Scheduled MaintenanceTable 4-2. Sit
Page 119 and 120: Scheduled MaintenanceTable 4-3. Lub
Page 121 and 122: Scheduled MaintenanceOIL PER ALSTOM
Page 123 and 124: Scheduled MaintenanceOIL PER ALSTOM
Page 125 and 126: Scheduled Maintenance4.9. QUARTERLY
Page 127 and 128: Scheduled MaintenanceTable 4-8. Obs
Page 129 and 130: Scheduled Maintenance4.9.3. Motor B
Page 131 and 132: Scheduled Maintenance4.9.4. Box-Sty
Page 133 and 134: Scheduled MaintenanceTable 4-11. Bo
Page 135 and 136: Scheduled MaintenanceTable 4-12. Th
Page 137 and 138: Scheduled MaintenanceTable 4-13. Lo
Page 139 and 140: Scheduled MaintenanceTable 4-14. Po
Page 141 and 142: Scheduled MaintenanceTable 4-15. Po
Page 143 and 144: Scheduled Maintenance4.9.9. Shunt C
Page 145 and 146: Scheduled Maintenance4.9.9.2. Model
Page 147 and 148: Scheduled MaintenanceTable 4-18. Mo
Page 149 and 150: Scheduled MaintenanceTable 4-19. Co
Page 151 and 152: Scheduled Maintenance4.9.12. Fricti
Page 157 and 158: Scheduled Maintenance4.9.15. Crank
Page 159 and 160: Scheduled Maintenance4.10. SEMI-ANN
Page 161 and 162: Scheduled MaintenanceTable 4-26. Ma
Page 163 and 164: Scheduled MaintenanceTHIS PAGE INTE
Page 165: TroubleshootingTable 5-1. Symptoms
Page 169 and 170: Corrective Maintenance6.2. TEST EQU
Page 171 and 172: Corrective MaintenanceTable 6-2. Sw
Page 175 and 176: Corrective MaintenanceTable 6-6. Cl
Page 177 and 178: Corrective Maintenance6.4.1. Switch
Page 203 and 204: Corrective Maintenance6.4.2. MotorT
Page 205 and 206: Corrective MaintenanceTable 6-8. Mo
Page 217 and 218:
Corrective MaintenanceTable 6-8. Mo
Page 219 and 220:
Corrective Maintenance6.4.3. Clutch
Page 221 and 222:
Corrective Maintenance6.4.4. Point
Page 223 and 224:
Corrective MaintenanceTable 6-10. P
Page 225 and 226:
Corrective MaintenanceTable 6-12. C
Page 227 and 228:
Corrective Maintenance6.5.2. Brush
Page 229 and 230:
Corrective Maintenance6.5.4. Motor
Page 231 and 232:
Corrective Maintenance6.5.6. Motor
Page 233 and 234:
Corrective Maintenance6.5.8. Throw
Page 235 and 236:
Corrective Maintenance6.5.12. Lock
Page 237 and 238:
Corrective Maintenance6.5.14. Cutou
Page 239 and 240:
Corrective Maintenance6.5.17. Inter
Page 241 and 242:
Corrective Maintenance6.5.19. Recti
Page 243 and 244:
Corrective Maintenance6.5.22. Conta
Page 245 and 246:
Corrective Maintenance6.5.24. Arm (
Page 247 and 248:
Corrective Maintenance6.5.27. Throw
Page 249 and 250:
Corrective Maintenance6.5.31. Cam B
Page 251 and 252:
Corrective Maintenance6.6. SWITCH M
Page 253 and 254:
Corrective MaintenanceTable 6-47. M
Page 255 and 256:
Page 257 and 258:
Page 259 and 260:
Page 261 and 262:
Page 263 and 264:
Page 265 and 266:
Corrective MaintenanceTHIS PAGE INT
Page 267 and 268:
Parts CatalogFigure 7-1. Model 5E S
Page 269 and 270:
Parts CatalogTable 7-1. Main Parts
Page 271 and 272:
Parts CatalogFigure 7-3. Model 5F S
Page 273 and 274:
Parts CatalogTable 7-2. Main Parts
Page 275 and 276:
Parts CatalogFigure 7-5. Detail Par
Page 277 and 278:
Parts CatalogTable 7-3. Detail Part
Page 279 and 280:
Parts CatalogTable 7-3. Detail Part
Page 281 and 282:
Parts CatalogFigure 7-6. Bars, Coup
Page 283 and 284:
Parts CatalogFigure 7-7. Brackets,
Page 285 and 286:
Parts CatalogTable 7-5. Brackets, P
Page 287 and 288:
Parts CatalogTable 7-6. Selector-Le
Page 289 and 290:
Parts CatalogTable 7-6. Selector-Le
Page 291 and 292:
Parts CatalogFigure 7-9. FramesP129
Page 293 and 294:
Parts CatalogTable 7-7. Frames (Con
Page 295 and 296:
Parts CatalogTable 7-7. Frames (Con
Page 297 and 298:
Parts CatalogFigure 7-10. Point-Det
Page 299 and 300:
Parts CatalogTable 7-8. Point-Detec
Page 301 and 302:
Parts CatalogFigure 7-11. Lock Rods
Page 303 and 304:
Parts Catalog67381245ALink MotionFi
Page 305 and 306:
Parts CatalogFigure 7-13. Biased-Ne
Page 307 and 308:
Parts CatalogTable 7-11. Biased-Neu
Page 309 and 310:
Parts CatalogFigure 7-14. Contactor
Page 311 and 312:
Parts CatalogTable 7-12. Contactor
Page 313 and 314:
Parts CatalogTable 7-12. Contactor
Page 315 and 316:
Parts CatalogTable 7-13. Switch Mac
Page 317 and 318:
Parts CatalogTable 7-13. Switch Mac
Page 319 and 320:
Parts CatalogTable 7-14. Terminal B
Page 321 and 322:
Parts CatalogTable 7-15. Wire Entra
Page 323 and 324:
Parts CatalogTable 7-16. ToolsRefNo
Page 325 and 326:
DrawingsNWRLRWZR6POINT DETECTOR(NOT
Page 327 and 328:
DrawingsPOINT DETECTORD8 7 6 5 4 3
Page 329 and 330:
DrawingsPOINT DETECTORD8 7 6 5 4 3
Page 331 and 332:
DrawingsTERMINAL BOARDR.H. POINTNOR
Page 333 and 334:
DrawingsTERMINAL BOARD1 2 3 4 5 6 7
Page 335:
DrawingsTHIS PAGE INTENTIONALLY LEF
show all

Models 5E, 5F, 5G & 5H Electric Switch Machines: Single ... - Alstom

Create successful ePaper yourself

Delete template?

Save as template?