MULTI TYPE

More documents

Recommendations

Info

M Right-side Fan motor Fan Main heat exchanger (TO) A PMV1 PMV2 Right-side sub-heat exchanger Left-side B PMV4 (TE2) (TE1) Main heat exchanger Left-side sub-heat exchanger Check valve Check valve 4-way valve C High-pressure sensor (TS1) (SV6) SV H SV Fusible plug (TL) (SV3D) Oil separator SV (SV2) Low-pressure sensor Liquid tank (SV41) SV SV (SV42) SV Accumulator D G (TD1) (SV3C) Highpressure SW SV Highpressure SW (TD2) High-pressure SW (SV43) (TD3) L Compressor 1 (inverter) (TK4) Compressor 2 (inverter) Compressor 3 (inverter) J I (TK1) (TK2) (TK3) F SV (TK5) Oil pipe (SV3E) SV (SV3F) E (SV3A) SV Check valve SV (SV3B) Check valve Liquid-side service valve Gas-side service valve Balance pipe packed valve K 235
8-9. Sensor Characteristics Outdoor Unit ▼ Temperature sensor characteristics Outdoor TS1, TE1, TE2, TL and TO sensors 200 150 Resistance [kΩ] 15 (10 °C or below) Resistance 100 [kΩ] (10 °C or above) 10.0kΩ 10 50 0 -30 35.2kΩ -20 -10 0 10 20 30 40 50 60 70 Temperature [°C] 25 20 5 0 80 90 100 Temperature [°C] -20 -15 -10 -5 0 5 10 15 20 25 30 35 40 45 50 55 60 65 70 75 80 Resistance [kΩ] 114.8 83.9 62.1 46.5 35.2 26.9 20.7 16.1 12.7 10.0 8.0 6.4 5.2 4.2 3.5 2.9 2.4 2.0 1.7 1.4 1.2 Outdoor TD1,TD2,TD3,TK1,TK2,TK3,TK4 and TK5 sensors 200 150 Resistance [kΩ] (10 °C or below) 100 50 0 52.0kΩ 3.3kΩ 0 10 20 30 40 50 60 70 80 90 100 110 120 130 Temperature [°C] 20 15 Resistance [kΩ] (10 °C or above) 10 5 Temperature [°C] 0 5 10 15 20 25 30 35 40 45 50 55 60 65 70 75 80 85 90 95 100 105 110 115 120 Resistance [kΩ] 181.5 138.5 107.2 83.6 65.7 52.0 41.5 33.4 27.1 22.1 18.1 14.9 12.4 10.4 8.7 7.3 6.2 5.3 4.5 3.9 3.3 2.9 2.5 2.2 1.9 236
Page 1 and 2:
AIR CONDITIONER (MULTI TYPE) SERVIC
Page 3 and 4:
4-1. Normal Operation (COOL Mode /
Page 5 and 6:
9-4. Cooling-Season Outdoor Unit Ba
Page 7 and 8:
Definition of Protective Gear When
Page 9 and 10:
Precautions for Safety The manufact
Page 11 and 12:
Use specified parts. When any of th
Page 13 and 14:
Only a qualified installer (*1) or
Page 15 and 16:
Specifications Model MMY-MAP0804HT8
Page 17 and 18:
Carrying in the Outdoor Unit CAUTIO
Page 19 and 20:
Selection of Pipe Size Coupling siz
Page 21 and 22:
Table 2 Standard type High Efficien
Page 23 and 24:
4. Tools (1) Required Tools for R41
Page 25 and 26:
Models: MMY-MAP1404* and MAP1604 *
Page 27 and 28:
1-2-2. Compact 4-way Cassette Type
Page 29 and 30:
1-2-4. 1-way Air Discharge Cassette
Page 31 and 32:
1-2-6. 2-way Air Discharge Cassette
Page 33 and 34:
1-2-8. Concealed Duct High Static P
Page 35 and 36:
1-2-9. Slim Duct Type Models: MMD-A
Page 37 and 38:
1-2-11.High Wall Type 2 series Mode
Page 39 and 40:
1-2-13.Floor Standing Cabinet Type
Page 41 and 42:
1-2-15.Floor Standing Type Models:
Page 43 and 44:
Models: MMD-AP0721HFE and MMD-AP096
Page 45 and 46:
2-2. Outdoor Unit (60Hz model: MMY-
Page 47 and 48:
2-4. Outdoor Inverter (60Hz model:
Page 49 and 50:
2-way Air Discharge Cassette Type M
Page 51 and 52:
Concealed Duct High Static Pressure
Page 53 and 54:
Floor Standing Type Model MMF-AP 01
Page 55 and 56:
14, 16HP Model: MMY-MAP1404* , MAP1
Page 57 and 58:
Outdoor Unit (14, 16HP) Model: MMY-
Page 59 and 60:
2-8-2. Inverter P.C. board for comp
Page 61 and 62:
3 Refrigerant Piping Systematic Dra
Page 63 and 64:
Explanation of Functional Parts Fun
Page 65 and 66:
4 Combined Refrigerant Piping Syste
Page 67 and 68:
4-3. Normal Operation (HEAT Mode) H
Page 69 and 70:
4-5. Emergency Operation (Heating O
Page 71 and 72:
5 Control Outline Indoor Unit Cont
Page 73 and 74:
NO. Item Specification outline Rema
Page 75 and 76:
NO. Item Specification outline Rema
Page 77 and 78:
Outdoor Unit Item Description of op
Page 79 and 80:
Item Description of operation, nume
Page 81 and 82:
Page 83 and 84:
Page 85 and 86:
1 Cooling operation under low outsi
Page 87 and 88:
Central control remote controller (
Page 89 and 90:
6-1-2. When Wireless Remote Control
Page 91 and 92:
Central control remote controller (
Page 93 and 94:
X Y DC5V Power supply circuit Main
Page 95 and 96:
6-2. Indoor Printed Circuit Board M
Page 97 and 98:
MCC-1403 Power supply Power supply
Page 99 and 100:
6-4. Test Operation of Indoor Unit
Page 101 and 102:
Function CODE No. (DN Code) Table (
Page 103 and 104:
Type DN code “10” Value Type Mo
Page 105 and 106:
▼ Ventilating fan control from re
Page 107 and 108:
6-7. Applied control for Outdoor Un
Page 109 and 110:
(2) Indoor unit setup method for pr
Page 111 and 112:
6-8-1. Power peak-cut Control (Stan
Page 113 and 114:
6-8-3. Snowfall Fan Control Header
Page 115 and 116:
6-8-6. Operation Mode Selection Con
Page 117 and 118:
6-8-8. Compressor Operation Output
Page 119 and 120:
7 TEST OPERATION 7-1. Procedure and
Page 121 and 122:
(2) In the case that a central cont
Page 123 and 124:
• Check the additional amount of
Page 125 and 126:
7-4. Address Setup This product req
Page 127 and 128:
(Example) Controlling 2 or more ref
Page 129 and 130:
10 Set the central control address.
Page 131 and 132:
Manual address setup from the remot
Page 133 and 134:
To find an indoor unit’s position
Page 135 and 136:
4 Push the TIME / buttons repeatedl
Page 137 and 138:
2) Turn on dip switch 2 of SW30 on
Page 139 and 140:
7-4-4. Check after Address Setup wh
Page 141 and 142:
7-5-2. Operation from the indoor re
Page 143 and 144:
Miswiring example Figure Remote con
Page 145 and 146:
7-6-2. Cooling/Heating Test Operati
Page 147 and 148:
(2) Test operation START Test opera
Page 149 and 150:
7-7. Service Support Function 7-7-1
Page 151 and 152:
7-7-2. Function to Start/Stop (ON/O
Page 153 and 154:
(2) Heating test operation function
Page 155 and 156:
(4) Individual start/stop (ON/OFF)
Page 157 and 158:
(2)Clearing error by using switches
Page 159 and 160:
7-7-5. Pulse Motor Valve (PMV) Forc
Page 161 and 162:
7-7-8. Fan Operation Check in Outdo
Page 163 and 164:
7-7-10.Manual Adjustment Function o
Page 165 and 166:
7-7-11.Monitor Function of Remote C
Page 167 and 168:
8 TROUBLESHOOTING 8-1. Overview (1)
Page 169 and 170:
(Error detected by main remote cont
Page 171 and 172:
F12 - F12 ALT F15 - F15 ALT F16 - F
Page 173 and 174:
(Errors detected by IPDU featuring
Page 175 and 176:
Using TCC-LINK central control remo
Page 177 and 178:
Light block Check code Cause of fau
Page 179 and 180:
8-4. Check Codes Displayed on Remot
Page 181 and 182:
Main remote controller Check code O
Page 183 and 184:
Main remote controller Check code O
Page 185 and 186: Main remote controller Check code O
Page 189 and 190: Main remote controller P04 P05 P07
Page 193 and 194: Errors Detected by TCC-LINK Central
Page 195 and 196: 8-5. Diagnosis procedure for each c
Page 197 and 198: Check code Check code name Cause Ch
Page 199 and 200: Check code Check code name Cause [E
Page 201 and 202: Check code Check code name Cause [E
Page 203 and 204: Check code Check code name Cause [F
Page 205 and 206: Check code Check code name Cause [H
Page 209 and 210: (*3) Check for solenoid valve of al
Page 215 and 216: Check code Check code name Cause [L
Page 217 and 218: Check code Check code name Cause [P
Page 223 and 224: (C) Heating operation Does heating
Page 227 and 228: (1)Display of System Information (D
Page 229 and 230: (3)Display of Outdoor Cycle Data (D
Page 231 and 232: (5)Display of Indoor Unit Informati
Page 233 and 234: 8-8. Leakage/Clogging of Refrigerat
Page 235: List of Check Codes Generated upon
Page 239 and 240: Indoor TC1 sensor 200 150 Resistanc
Page 241 and 242: 240 Outdoor Unit ▼ Ps sensor char
Page 243 and 244: 9-2. Compressor Backup Operation Se
Page 245 and 246: (6) Turn on the power supply to all
Page 247 and 248: (8) Set Bits 1 and 2 of SW30 on the
Page 249 and 250: 10OUTDOOR UNIT REFRIGERANT RECOVERY
Page 251 and 252: [Setup of failed outdoor unit] (13)
Page 253 and 254: [Setup of outdoor units other than
Page 255 and 256: 10-3.Work procedure after Repair Wh
Page 257 and 258: 11-2.Replacement of Compressors
Page 259 and 260: [When replacing normal as well as f
Page 261 and 262: 11-3.Check Procedure to Search Caus
Page 263 and 264: Check items and procedures to follo
Page 265 and 266: No. Part to be replaced Work proced
Page 277 and 278: 13P.C. BOARD EXCHANGE PROCEDURES I
Page 279 and 280: Procedure 1: Reading Setting Data f
Page 281 and 282: Procedure 3: Writing Setting Data i
Page 283 and 284: CODE No. list (Example) CODE No. (D
Page 285 and 286: 13-2-3.Interface board (MCC-1606) r
Page 287 and 288:
(6) Set the dip switch (SW800) sett
Page 289 and 290:
13-2-6.Noise Filter P.C. Board (MCC
Page 291 and 292:
(7) Install the service P.C. boards
Page 293 and 294:
292
Page 295 and 296:
SMMS-i OUTDOOR UNIT MMY-MAP1404HT8(
Page 297 and 298:
REFRIGERATION CIRCUIT DIAGRAM M MOT
Page 299 and 300:
Ref. No. Part No. Description MAP08
Page 301 and 302:
SMMS-i INV SERVICE PARTS LIST MMY-M
Page 303 and 304:
SMMS-i OUTDOOR UNIT MMY-MAP0804T8(Z
Page 305 and 306:
Page 307 and 308:
306
Page 309 and 310:
Page 311 and 312:
Page 313 and 314:
Page 315 and 316:
314
Page 317 and 318:
Page 319 and 320:
Page 321 and 322:
Page 323 and 324:
Page 325 and 326:
SMMS-i OUTDOOR UNIT MMY-MAP0804T8(Z
Page 327 and 328:
Page 329 and 330:
328
Page 331 and 332:
Page 333 and 334:
Page 335 and 336:
Page 337 and 338:
336
Page 339 and 340:
Page 341 and 342:
Page 343 and 344:
Page 345 and 346:
Page 347 and 348:
Page 349 and 350:
Page 351 and 352:
350
Page 353 and 354:
Page 355 and 356:
Page 357 and 358:
Page 359 and 360:
358
Page 361 and 362:
SMMS-i OUTDOOR UNIT MMY-MAP1404T8-S
Page 363 and 364:
Page 365 and 366:
Page 367 and 368:
Page 369 and 370:
WARNINGS ON REFRIGERANT LEAKAGE Che
show all

MULTI TYPE

Create successful ePaper yourself

Delete template?

Save as template?