MULTI TYPE

More documents

Recommendations

Info

EEPROM Location Diagram The EEPROM (IC503, IC10) is mounted on an IC socket. Use a pair of tweezers, etc. to remove it. When installing it, adjust its orientation as shown in the diagram below. During EEPROM removal/installation, take care not to bend IC leads. P.C. board (MCC-1402) P.C. board (MCC-1403) EEPROM(IC10) When installing the EEPROM, align its notch with that of the IC socket. Notch EEPROM(IC10) P.C. board (MCC-1570) IC503 IC socket Notch EEPROM EEPROM(IC503) 281
CODE No. list (Example) CODE No. (DN) Item Setting data Factory-set value 01 Filter sign lighting time Depending on Type 02 Filter pollution leve 0000: standard 03 Central control address 0099: Not determined 06 Heating suction temperature shift 0002: +2°C (Floor standing type: 0) 0d Existence of automatic COOL/HEAT mode 0001: No auto mode cooling/heating * Automatically selection 0F Cooling only 0000: Heat pump by connected outdoor unit 10 Type Depending on model type 11 Indoor unit capacity Depending on capacity type 12 System address 0099: Not determined 13 Indoor unit address 0099: Not determined 14 Group address 0099: Not determined 19 Louver type (wind direction adjustment) Depending on Type. 1E Temperature range of cooling/heating 0003: 3 deg (Ts ± 1.5) automatic SW control point 28 Power failure automatic recovery 0000: None 32 Sensor SW (Selection of static pressure) 0000: Body sensor 5d High ceiling select 0000: Standard 60 Timer setting (wired remote controller) 0000: Available F0 Swing mode 0001: Standard F1 Louver fixing position (Flap No. 1) 0000: Not fixed (4-way type only) F2 Louver fixing position (Flap No. 2) 0000: Not fixed (4-way type only) F3 Louver fixing position (Flap No. 3) 0000: Not fixed (4-way type only) F4 Louver fixing position (Flap No. 4) 0000: Not fixed (4-way type only) Type Code No. [10] Setup data Type Model abb. name 0000 1-way Air Discharge Cassette MMU-APSH 0001 *1, *2 4-way Air Discharge Cassette MMU-AP2H 0002 2-way Air Discharge Cassette MMU-APWH 1-way Air Discharge Cassette MMU-APYH 0003 (Compact type) 0004 Concealed Duct Standard MMD-APBH 0005 Slim Duct MMD-APSPH MMD-APSH 0006 Concealed Duct High Static Pressure MMD-APH 0007 Under Ceiling MMC-APH 0008 High Wall MMK-APH 0009 — — 0010 Floor Standing Cabinet MML-APH 0011 Floor Standing Concealed MML-APBH 0012 — — 0013 Floor Standing (Below 6HP) MMF-APH 0014 Compact 4-way Air Discharge Cassette MMU-APMH 0016 Fresh air intake unit (Duct type) MMD-APHFE Indoor unit capacity CODE No. [11] Setup data Model Setup data Model 0000* Invalid 0016 — 0001 007 type 0017 048 type 0002 — 0018 056 type 0003 009 type 0019 — 0004 — 0020 — 0005 012 type 0021 072 type 0006 — 0022 — 0007 015 type 0023 096 type 0008 — 0024 — 0009 018 type 0025 — 0010 — 0026 — 0011 024 type 0027 — 0012 027 type 0028 — 0013 030 type ~ — 0014 — 0034 — 0015 036 type *1 The initial setup value of EEPROM installed on the service P.C. board *2 For the above models, set CODE No. to “ ” and the setting data 0000 (initial) to “0001”. 282
Page 1 and 2:
AIR CONDITIONER (MULTI TYPE) SERVIC
Page 3 and 4:
4-1. Normal Operation (COOL Mode /
Page 5 and 6:
9-4. Cooling-Season Outdoor Unit Ba
Page 7 and 8:
Definition of Protective Gear When
Page 9 and 10:
Precautions for Safety The manufact
Page 11 and 12:
Use specified parts. When any of th
Page 13 and 14:
Only a qualified installer (*1) or
Page 15 and 16:
Specifications Model MMY-MAP0804HT8
Page 17 and 18:
Carrying in the Outdoor Unit CAUTIO
Page 19 and 20:
Selection of Pipe Size Coupling siz
Page 21 and 22:
Table 2 Standard type High Efficien
Page 23 and 24:
4. Tools (1) Required Tools for R41
Page 25 and 26:
Models: MMY-MAP1404* and MAP1604 *
Page 27 and 28:
1-2-2. Compact 4-way Cassette Type
Page 29 and 30:
1-2-4. 1-way Air Discharge Cassette
Page 31 and 32:
1-2-6. 2-way Air Discharge Cassette
Page 33 and 34:
1-2-8. Concealed Duct High Static P
Page 35 and 36:
1-2-9. Slim Duct Type Models: MMD-A
Page 37 and 38:
1-2-11.High Wall Type 2 series Mode
Page 39 and 40:
1-2-13.Floor Standing Cabinet Type
Page 41 and 42:
1-2-15.Floor Standing Type Models:
Page 43 and 44:
Models: MMD-AP0721HFE and MMD-AP096
Page 45 and 46:
2-2. Outdoor Unit (60Hz model: MMY-
Page 47 and 48:
2-4. Outdoor Inverter (60Hz model:
Page 49 and 50:
2-way Air Discharge Cassette Type M
Page 51 and 52:
Concealed Duct High Static Pressure
Page 53 and 54:
Floor Standing Type Model MMF-AP 01
Page 55 and 56:
14, 16HP Model: MMY-MAP1404* , MAP1
Page 57 and 58:
Outdoor Unit (14, 16HP) Model: MMY-
Page 59 and 60:
2-8-2. Inverter P.C. board for comp
Page 61 and 62:
3 Refrigerant Piping Systematic Dra
Page 63 and 64:
Explanation of Functional Parts Fun
Page 65 and 66:
4 Combined Refrigerant Piping Syste
Page 67 and 68:
4-3. Normal Operation (HEAT Mode) H
Page 69 and 70:
4-5. Emergency Operation (Heating O
Page 71 and 72:
5 Control Outline Indoor Unit Cont
Page 73 and 74:
NO. Item Specification outline Rema
Page 75 and 76:
NO. Item Specification outline Rema
Page 77 and 78:
Outdoor Unit Item Description of op
Page 79 and 80:
Item Description of operation, nume
Page 81 and 82:
Page 83 and 84:
Page 85 and 86:
1 Cooling operation under low outsi
Page 87 and 88:
Central control remote controller (
Page 89 and 90:
6-1-2. When Wireless Remote Control
Page 91 and 92:
Central control remote controller (
Page 93 and 94:
X Y DC5V Power supply circuit Main
Page 95 and 96:
6-2. Indoor Printed Circuit Board M
Page 97 and 98:
MCC-1403 Power supply Power supply
Page 99 and 100:
6-4. Test Operation of Indoor Unit
Page 101 and 102:
Function CODE No. (DN Code) Table (
Page 103 and 104:
Type DN code “10” Value Type Mo
Page 105 and 106:
▼ Ventilating fan control from re
Page 107 and 108:
6-7. Applied control for Outdoor Un
Page 109 and 110:
(2) Indoor unit setup method for pr
Page 111 and 112:
6-8-1. Power peak-cut Control (Stan
Page 113 and 114:
6-8-3. Snowfall Fan Control Header
Page 115 and 116:
6-8-6. Operation Mode Selection Con
Page 117 and 118:
6-8-8. Compressor Operation Output
Page 119 and 120:
7 TEST OPERATION 7-1. Procedure and
Page 121 and 122:
(2) In the case that a central cont
Page 123 and 124:
• Check the additional amount of
Page 125 and 126:
7-4. Address Setup This product req
Page 127 and 128:
(Example) Controlling 2 or more ref
Page 129 and 130:
10 Set the central control address.
Page 131 and 132:
Manual address setup from the remot
Page 133 and 134:
To find an indoor unit’s position
Page 135 and 136:
4 Push the TIME / buttons repeatedl
Page 137 and 138:
2) Turn on dip switch 2 of SW30 on
Page 139 and 140:
7-4-4. Check after Address Setup wh
Page 141 and 142:
7-5-2. Operation from the indoor re
Page 143 and 144:
Miswiring example Figure Remote con
Page 145 and 146:
7-6-2. Cooling/Heating Test Operati
Page 147 and 148:
(2) Test operation START Test opera
Page 149 and 150:
7-7. Service Support Function 7-7-1
Page 151 and 152:
7-7-2. Function to Start/Stop (ON/O
Page 153 and 154:
(2) Heating test operation function
Page 155 and 156:
(4) Individual start/stop (ON/OFF)
Page 157 and 158:
(2)Clearing error by using switches
Page 159 and 160:
7-7-5. Pulse Motor Valve (PMV) Forc
Page 161 and 162:
7-7-8. Fan Operation Check in Outdo
Page 163 and 164:
7-7-10.Manual Adjustment Function o
Page 165 and 166:
7-7-11.Monitor Function of Remote C
Page 167 and 168:
8 TROUBLESHOOTING 8-1. Overview (1)
Page 169 and 170:
(Error detected by main remote cont
Page 171 and 172:
F12 - F12 ALT F15 - F15 ALT F16 - F
Page 173 and 174:
(Errors detected by IPDU featuring
Page 175 and 176:
Using TCC-LINK central control remo
Page 177 and 178:
Light block Check code Cause of fau
Page 179 and 180:
8-4. Check Codes Displayed on Remot
Page 181 and 182:
Main remote controller Check code O
Page 183 and 184:
Page 185 and 186:
Page 187 and 188:
Page 189 and 190:
Main remote controller P04 P05 P07
Page 191 and 192:
Page 193 and 194:
Errors Detected by TCC-LINK Central
Page 195 and 196:
8-5. Diagnosis procedure for each c
Page 197 and 198:
Check code Check code name Cause Ch
Page 199 and 200:
Check code Check code name Cause [E
Page 201 and 202:
Check code Check code name Cause [E
Page 203 and 204:
Check code Check code name Cause [F
Page 205 and 206:
Check code Check code name Cause [H
Page 207 and 208:
Page 209 and 210:
(*3) Check for solenoid valve of al
Page 211 and 212:
Page 213 and 214:
Page 215 and 216:
Check code Check code name Cause [L
Page 217 and 218:
Check code Check code name Cause [P
Page 219 and 220:
Page 221 and 222:
Page 223 and 224:
(C) Heating operation Does heating
Page 225 and 226:
Page 227 and 228:
(1)Display of System Information (D
Page 229 and 230:
(3)Display of Outdoor Cycle Data (D
Page 231 and 232: (5)Display of Indoor Unit Informati
Page 233 and 234: 8-8. Leakage/Clogging of Refrigerat
Page 235 and 236: List of Check Codes Generated upon
Page 237 and 238: 8-9. Sensor Characteristics Outdoor
Page 239 and 240: Indoor TC1 sensor 200 150 Resistanc
Page 241 and 242: 240 Outdoor Unit ▼ Ps sensor char
Page 243 and 244: 9-2. Compressor Backup Operation Se
Page 245 and 246: (6) Turn on the power supply to all
Page 247 and 248: (8) Set Bits 1 and 2 of SW30 on the
Page 249 and 250: 10OUTDOOR UNIT REFRIGERANT RECOVERY
Page 251 and 252: [Setup of failed outdoor unit] (13)
Page 253 and 254: [Setup of outdoor units other than
Page 255 and 256: 10-3.Work procedure after Repair Wh
Page 257 and 258: 11-2.Replacement of Compressors
Page 259 and 260: [When replacing normal as well as f
Page 261 and 262: 11-3.Check Procedure to Search Caus
Page 263 and 264: Check items and procedures to follo
Page 265 and 266: No. Part to be replaced Work proced
Page 277 and 278: 13P.C. BOARD EXCHANGE PROCEDURES I
Page 279 and 280: Procedure 1: Reading Setting Data f
Page 281: Procedure 3: Writing Setting Data i
Page 285 and 286: 13-2-3.Interface board (MCC-1606) r
Page 287 and 288: (6) Set the dip switch (SW800) sett
Page 289 and 290: 13-2-6.Noise Filter P.C. Board (MCC
Page 291 and 292: (7) Install the service P.C. boards
Page 293 and 294: 292
Page 295 and 296: SMMS-i OUTDOOR UNIT MMY-MAP1404HT8(
Page 297 and 298: REFRIGERATION CIRCUIT DIAGRAM M MOT
Page 299 and 300: Ref. No. Part No. Description MAP08
Page 301 and 302: SMMS-i INV SERVICE PARTS LIST MMY-M
Page 303 and 304: SMMS-i OUTDOOR UNIT MMY-MAP0804T8(Z
Page 307 and 308: 306
Page 315 and 316: 314
Page 317 and 318: SMMS-i OUTDOOR UNIT MMY-MAP1404HT8(
Page 325 and 326: SMMS-i OUTDOOR UNIT MMY-MAP0804T8(Z
Page 329 and 330: 328
Page 333 and 334:
SMMS-i INV SERVICE PARTS LIST MMY-M
Page 335 and 336:
Ref. No. Part No. Description MAP08
Page 337 and 338:
336
Page 339 and 340:
SMMS-i OUTDOOR UNIT MMY-MAP1404HT8(
Page 341 and 342:
REFRIGERATION CIRCUIT DIAGRAM M MOT
Page 343 and 344:
Page 345 and 346:
Page 347 and 348:
SMMS-i OUTDOOR UNIT MMY-MAP0804HT7(
Page 349 and 350:
Page 351 and 352:
350
Page 353 and 354:
Page 355 and 356:
Page 357 and 358:
Page 359 and 360:
358
Page 361 and 362:
SMMS-i OUTDOOR UNIT MMY-MAP1404T8-S
Page 363 and 364:
Page 365 and 366:
Page 367 and 368:
Page 369 and 370:
WARNINGS ON REFRIGERANT LEAKAGE Che
show all

MULTI TYPE

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?