Controls, Start-Up, Operation, Service and ... - Climayoreo

More documents

Recommendations

Info

Table 9 — Fan Performance — 48P2,P3,P4,P5070 and 50P2,P3070 Units without Discharge Plenum* AIRFLOW (cfm) LEGEND AVAILABLE EXTERNAL STATIC PRESSURE (in. wg) 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp 14,000 258 2.23 297 2.80 330 3.38 362 4.02 392 4.73 422 5.53 451 6.42 480 7.37 17,500 302 3.92 338 4.67 368 5.39 395 6.10 421 6.84 446 7.64 471 8.50 495 9.42 21,000 348 6.36 380 7.29 408 8.18 434 9.04 457 9.88 479 10.74 501 11.64 522 12.57 24,500 397 9.74 424 10.80 450 11.88 475 12.91 497 13.91 517 14.89 537 15.88 556 16.89 28,000 447 14.18 470 15.35 494 16.60 516 17.82 538 19.01 558 20.16 576 21.29 594 22.41 30,000 476 17.29 497 18.50 519 19.82 541 21.15 562 22.45 581 23.70 599 24.93 617 26.14 AIRFLOW (cfm) AVAILABLE EXTERNAL STATIC PRESSURE (in. wg) 1.8 2.0 2.2 2.4 2.6 2.8 3.0 3.2 Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp 14,000 507 8.39 533 9.46 558 10.57 582 11.71 605 12.89 627 14.08 648 15.29 668 16.52 17,500 519 10.42 542 11.48 565 12.60 588 13.78 610 15.02 632 16.30 653 17.62 674 18.99 21,000 543 13.56 563 14.60 583 15.69 603 16.84 623 18.05 643 19.31 662 20.63 682 21.99 24,500 575 17.93 593 18.99 611 20.10 629 21.24 646 22.43 664 23.67 681 24.96 698 26.29 28,000 612 23.55 628 24.69 645 25.86 661 27.05 677 28.27 692 29.53 708 30.82 723 32.15 30,000 634 27.34 650 28.56 666 29.78 681 31.02 696 32.28 711 33.56 726 34.88 — — AIRFLOW (cfm) AVAILABLE EXTERNAL STATIC PRESSURE (in. wg) 3.4 3.6 3.8 4.0 Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp 14,000 687 17.76 706 19.01 724 20.27 741 21.54 17,500 694 20.38 713 21.79 732 23.24 — — 21,000 701 23.41 719 24.87 738 26.38 — — 24,500 715 27.67 732 29.10 749 30.58 — — 28,000 739 33.51 — — — — — — 30,000 — — — — — — — — 48/50P3,P5 units only. Bhp — Brake Horsepower *If calculating static pressure for a 48 Series unit, be sure to add gas heat pressure drop from Component Pressure Drop table. NOTES: 1. Fan performance is based on wet coils and clean 2-in. filters. 14 2. See Component Pressure Drop data table before using Fan Performance tables. 3. Conversion — Bhp to kW: Kilowatts = Bhp x .746 Motor efficiency See Physical Data table for motor efficiency.
AIRFLOW (cfm) Table 10 — Fan Performance — 50P2,P3030 Units with Discharge Plenum and 50P4,P5030 Units LEGEND AVAILABLE EXTERNAL STATIC PRESSURE (in. wg) 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp 6,000 255 0.95 313 1.35 364 1.82 411 2.35 454 2.92 494 3.52 530 4.14 563 4.78 7,500 291 1.51 340 1.93 386 2.41 428 2.94 468 3.51 505 4.13 541 4.78 574 5.46 9,000 330 2.28 372 2.73 413 3.22 451 3.76 487 4.34 522 4.96 555 5.61 587 6.30 10,500 371 3.28 408 3.76 444 4.28 479 4.84 512 5.43 544 6.06 574 6.71 604 7.40 12,000 413 4.56 447 5.07 479 5.61 510 6.19 540 6.80 570 7.44 598 8.11 626 8.80 13,500 456 6.12 487 6.66 516 7.23 544 7.83 572 8.46 599 9.12 626 9.81 651 10.51 15,000 500 7.99 528 8.58 555 9.18 581 9.80 606 10.45 631 11.13 656 11.83 680 12.56 AIRFLOW (cfm) AVAILABLE EXTERNAL STATIC PRESSURE (in. wg) 1.8 2.0 2.2 2.4 2.6 2.8 3.0 3.2 Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp 6,000 594 5.43 623 6.09 651 6.75 676 7.41 701 8.08 725 8.75 747 9.42 769 10.10 7,500 605 6.16 635 6.88 664 7.62 691 8.36 716 9.11 741 9.88 765 10.64 787 11.41 9,000 617 7.02 646 7.76 674 8.52 702 9.31 728 10.11 753 10.93 777 11.76 800 12.60 10,500 633 8.12 660 8.86 687 9.64 713 10.43 739 11.25 764 12.09 788 12.95 811 13.82 12,000 652 9.52 679 10.27 704 11.04 729 11.84 753 12.66 777 13.50 800 14.37 823 15.26 13,500 676 11.25 701 12.00 725 12.78 748 13.58 771 14.40 794 15.24 816 16.11 838 16.99 15,000 703 13.30 726 14.07 749 14.86 771 15.66 793 16.49 814 17.34 835 18.20 856 19.09 AIRFLOW (cfm) AVAILABLE EXTERNAL STATIC PRESSURE (in. wg) 3.4 3.6 3.8 4.0 Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp 6,000 789 10.77 809 11.45 829 12.13 848 12.81 7,500 809 12.18 830 12.96 851 13.73 870 14.51 9,000 823 13.44 844 14.29 866 15.15 886 16.01 10,500 833 14.71 856 15.61 877 16.52 898 17.44 12,000 845 16.16 867 17.08 888 18.01 — — 13,500 859 17.90 880 18.82 — — — — 15,000 876 20.00 896 20.92 — — — — 50P3,P5 units only. Bhp — Brake Horsepower NOTES: 1. Fan performance is based on wet coils and clean 2-in. filters. 15 2. See Component Pressure Drop data table before using Fan Performance tables. 3. Conversion — Bhp to kW: Kilowatts = Bhp x .746 Motor efficiency See Physical Data table for motor efficiency.
Page 1 and 2: Controls, Start-Up, Operation, Serv
Page 3 and 4: WARNING What to do if you smell gas
Page 5 and 6: and the ENTER keys until the desire
Page 7 and 8: START-UP IMPORTANT: Do not attempt
Page 9 and 10: Table 4 — Fan Performance — 48P
Page 11 and 12: Table 6 — Fan Performance — 48P
Page 13: Table 8 — Fan Performance — 48P
Page 17 and 18: AIRFLOW (cfm) Table 12 — Fan Perf
Page 23 and 24: AIRFLOW (Cfm) LEGEND Table 18 — F
Page 29 and 30: AIRFLOW (cfm) LEGEND Bhp — Brake
Page 31 and 32: HIGH-EFFICIENCY MOTORS Nominal Maxi
Page 33 and 34: 2. Under the Setpoints menu, set th
Page 35 and 36: would use Period 2 and set days Sat
Page 37 and 38: there is a loss of communication be
Page 39 and 40: and when ON, the control sets a cap
Page 41 and 42: System Mode Test — When the syste
Page 43 and 44: Table 31 — Unit Configuration ITE
Page 45 and 46: SETTING UP THE SYSTEM Machine Contr
Page 47 and 48: High SST Alert Delay Time (H.SST)
Page 49 and 50: Table 36 — Cool/Heat Set Point Of
Page 51 and 52: Table 38 — Run Status Cool Displa
Page 53 and 54: To use Demand Limiting, select the
Page 55 and 56: Size 050, 055, 060 Contactor OFM(s)
Page 57 and 58: Whenever the outdoor ambient temper
Page 59 and 60: Demand Level Low Heat Off Offset (L
Page 61 and 62: Limit Switch Low Temp (SW.L.T) —
Page 63 and 64: STAGE Table 49 — IGC LED Indicato
Page 65 and 66:
Table 50 — Static Pressure Contro
Page 67 and 68:
Table 53 — Dirty Filter Switch Po
Page 69 and 70:
NOTE: If the user wishes to disable
Page 71 and 72:
the economizer modulates when attem
Page 73 and 74:
P = K * BP.P * (error) I = K * BP.I
Page 75 and 76:
its smoke. Closing the economizer (
Page 77 and 78:
Table 57 — Indoor Air Quality Con
Page 79 and 80:
Table 58 — Humidity Configuration
Page 81 and 82:
The default sensor is the return ai
Page 83 and 84:
TEMPERATURE COMPENSATED START LOGIC
Page 85 and 86:
Sensor Trim Configuration — The T
Page 87 and 88:
SUPPLY FAN VFD CONFIGURATION — Th
Page 89 and 90:
REMOTE SWITCH LOGIC CONFIGURATION (
Page 91 and 92:
Alarms and Alarm History for for an
Page 93 and 94:
Transducer Troubleshooting — The
Page 95 and 96:
Table 75 — 10K Thermistor vs Resi
Page 97 and 98:
TEMP RESISTANCE (F) (Ohms) -25 98,0
Page 99 and 100:
PRESSURE (PSIG) Table 80 — Suctio
Page 101 and 102:
Table 81 — Discharge Pressure Tra
Page 103 and 104:
Table 82 — Auto View of Run Statu
Page 105 and 106:
Table 84 — Cooling Information Di
Page 107 and 108:
equalize compressor oil levels. If
Page 109 and 110:
Table 91 — Alert and Alarm Codes
Page 111 and 112:
T072 (Evaporator Discharge Reset Se
Page 113 and 114:
This alarm will disable mechanical
Page 115 and 116:
This is the reverse of the Pressuri
Page 117 and 118:
117 a48-8408 Fig. 19 — Typical Po
Page 119 and 120:
OD ENTHALPY SWITCH LOW REMOTE OCCUP
Page 121 and 122:
Fig. 23 — Typical Electric Heat U
Page 123 and 124:
123 Fig. 25 — Typical Gas Heat Se
Page 125 and 126:
125 Fig. 27 — Component Arrangeme
Page 127 and 128:
ACCSY — Accessory ACC’Y — Acc
Page 129 and 130:
Table 93 — Rooftop Control Board
Page 131 and 132:
Table 96 — Control Expansion Modu
Page 133 and 134:
LEGEND IAQ — Indoor Air Quality V
Page 135 and 136:
the motor position to be configured
Page 137 and 138:
TIME EWT LWT SETP Run Status Servic
Page 139 and 140:
Fig. 37 — Door Latch Fig. 38 —
Page 141 and 142:
SUPPLY FAN AND POWER EXHAUST MOTOR
Page 143 and 144:
Routine cleaning of coil surfaces i
Page 145 and 146:
Saturated Discharge Temperature (de
Page 147 and 148:
Page 149 and 150:
Page 151 and 152:
Page 153 and 154:
Page 155 and 156:
Page 157 and 158:
Page 159 and 160:
Page 161 and 162:
Page 163 and 164:
Gas System Adjustment (48P Only) GA
Page 165 and 166:
APPENDIX A — LOCAL DISPLAY TABLES
Page 167 and 168:
Page 169 and 170:
Page 171 and 172:
Page 173 and 174:
Page 175 and 176:
Page 177 and 178:
APPENDIX B — CCN TABLES (cont) ST
Page 179 and 180:
APPENDIX B — CCN TABLES (cont) ST
Page 181 and 182:
APPENDIX B — CCN TABLES (cont) SE
Page 183 and 184:
Page 185 and 186:
Page 187 and 188:
APPENDIX B — CCN TABLES (cont) MA
Page 189 and 190:
APPENDIX B — CCN TABLES (cont) MA
Page 191 and 192:
TESTACTC TESTCOOL TESTFANS TESTHEAT
Page 193 and 194:
APPENDIX C — UNIT STAGING TABLES
Page 195 and 196:
* 41 for Supply Fan Motor VFD, 42 f
Page 197 and 198:
Fig. B — VFD Keypad START UP WITH
Page 199 and 200:
Upload All Parameters — To upload
Page 201 and 202:
To replace the main fan for frame s
Page 203 and 204:
ALARM CODE ALARM NAME IN PANEL 2001
Page 205 and 206:
APPENDIX E — MODE SELECTION PROCE
Page 207 and 208:
CONTROLS SET POINT AND CONFIGURATIO
Page 209 and 210:
Page 211 and 212:
Page 213 and 214:
show all

Controls, Start-Up, Operation, Service and ... - Climayoreo

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?