Controls, Start-Up, Operation, Service and ... - Climayoreo

More documents

Recommendations

Info

AIRFLOW (cfm) Table 13 — Fan Performance — 50P2,P3050 Units with Discharge Plenum and 50P4,P5050 Units LEGEND AVAILABLE EXTERNAL STATIC PRESSURE (in. wg) 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp 9,000 324 2.15 369 2.67 412 3.23 452 3.83 488 4.44 523 5.08 556 5.73 587 6.40 10,000 349 2.74 392 3.28 431 3.87 469 4.48 504 5.12 537 5.78 569 6.46 599 7.16 12,000 403 4.23 439 4.82 474 5.45 507 6.11 539 6.80 570 7.51 599 8.23 627 8.98 14,000 459 6.17 490 6.83 521 7.50 550 8.20 579 8.93 607 9.69 634 10.46 660 11.25 16,000 515 8.63 544 9.34 571 10.07 597 10.82 623 11.59 649 12.38 674 13.20 698 14.03 18,000 573 11.65 599 12.44 623 13.21 647 14.00 671 14.82 694 15.65 716 16.50 739 17.37 20,000 630 15.28 654 16.14 677 16.97 699 17.81 720 18.66 741 19.53 762 20.43 783 21.34 AIRFLOW (cfm) AVAILABLE EXTERNAL STATIC PRESSURE (in. wg) 1.8 2.0 2.2 2.4 2.6 2.8 3.0 3.2 Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp 9,000 617 7.08 645 7.77 672 8.47 698 9.18 723 9.90 747 10.62 770 11.34 793 12.07 10,000 628 7.87 656 8.59 682 9.33 708 10.07 733 10.82 757 11.58 780 12.35 802 13.12 12,000 654 9.74 680 10.51 706 11.30 730 12.10 754 12.90 778 13.73 800 14.56 822 15.39 14,000 686 12.06 710 12.88 734 13.71 757 14.55 780 15.41 802 16.27 824 17.15 845 18.04 16,000 721 14.88 744 15.74 767 16.62 789 17.51 810 18.41 831 19.32 852 20.24 872 21.17 18,000 761 18.27 782 19.17 803 20.09 824 21.02 844 21.96 864 22.92 884 23.88 — — 20,000 803 22.27 823 23.21 — — — — — — — — — — — — AIRFLOW (cfm) AVAILABLE EXTERNAL STATIC PRESSURE (in. wg) 3.4 3.6 3.8 4.0 Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp 9,000 814 12.79 835 13.52 855 14.25 875 14.99 10,000 824 13.89 845 14.67 866 15.45 886 16.23 12,000 844 16.24 865 17.09 885 17.95 — — 14,000 866 18.94 886 19.85 — — — — 16,000 892 22.12 — — — — — — 18,000 — — — — — — — — 20,000 — — — — — — — — 50P3,P5 units only. Bhp — Brake Horsepower NOTES: 1. Fan performance is based on wet coils and clean 2-in. filters. 18 2. See Component Pressure Drop data table before using Fan Performance tables. 3. Conversion — Bhp to kW: Kilowatts = Bhp x .746 Motor efficiency See Physical Data table for motor efficiency.
AIRFLOW (cfm) Table 14 — Fan Performance — 50P2,P3055 Units with Discharge Plenum and 50P4,P5055 Units LEGEND AVAILABLE EXTERNAL STATIC PRESSURE (in. wg) 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp 10,000 217 1.21 258 1.71 296 2.29 334 2.97 371 3.76 407 4.63 440 5.56 471 6.51 12,500 248 2.01 286 2.63 319 3.26 349 3.95 380 4.71 410 5.58 440 6.52 469 7.54 15,000 281 3.13 317 3.90 347 4.64 374 5.38 400 6.18 425 7.03 450 7.95 476 8.95 17,500 315 4.64 348 5.55 378 6.43 403 7.29 426 8.16 449 9.05 471 10.00 493 10.99 20,000 351 6.64 381 7.64 409 8.68 433 9.68 456 10.66 477 11.64 497 12.65 516 13.68 22,500 389 9.20 414 10.25 440 11.43 464 12.59 486 13.71 506 14.81 525 15.91 543 17.03 25,000 427 12.39 449 13.48 473 14.75 496 16.06 517 17.34 537 18.59 555 19.82 573 21.04 AIRFLOW (cfm) AVAILABLE EXTERNAL STATIC PRESSURE (in. wg) 1.8 2.0 2.2 2.4 2.6 2.8 3.0 3.2 Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp 10,000 500 7.48 527 8.46 552 9.45 576 10.44 598 11.42 619 12.41 639 13.41 659 14.41 12,500 498 8.63 525 9.76 552 10.93 577 12.12 601 13.32 624 14.54 646 15.76 667 16.99 15,000 501 10.03 526 11.17 550 12.38 575 13.65 598 14.97 621 16.32 644 17.71 666 19.11 17,500 514 12.05 536 13.17 557 14.35 579 15.60 600 16.91 621 18.28 643 19.70 663 21.18 20,000 535 14.76 554 15.88 573 17.06 592 18.29 611 19.58 630 20.91 649 22.31 668 23.77 22,500 561 18.17 579 19.34 596 20.54 613 21.78 629 23.06 646 24.40 663 25.78 680 27.20 25,000 590 22.27 606 23.51 622 24.78 637 26.07 653 27.39 668 28.75 683 30.13 699 31.56 AIRFLOW (cfm) AVAILABLE EXTERNAL STATIC PRESSURE (in. wg) 3.4 3.6 3.8 4.0 Rpm Bhp Rpm Bhp Rpm Bhp Rpm Bhp 10,000 677 15.40 695 16.40 712 17.40 728 18.41 12,500 687 18.22 706 19.45 725 20.69 742 21.92 15,000 687 20.54 707 21.98 727 23.43 746 24.89 17,500 684 22.69 704 24.24 724 25.83 743 27.43 20,000 686 25.27 705 26.84 723 28.44 742 30.09 22,500 697 28.68 713 30.21 730 31.79 747 33.42 25,000 714 33.04 729 34.55 — — — — 50P3,P5 units only. Bhp — Brake Horsepower NOTES: 1. Fan performance is based on wet coils and clean 2-in. filters. 19 2. See Component Pressure Drop data table before using Fan Performance tables. 3. Conversion — Bhp to kW: Kilowatts = Bhp x .746 Motor efficiency See Physical Data table for motor efficiency.
Page 1 and 2: Controls, Start-Up, Operation, Serv
Page 3 and 4: WARNING What to do if you smell gas
Page 5 and 6: and the ENTER keys until the desire
Page 7 and 8: START-UP IMPORTANT: Do not attempt
Page 9 and 10: Table 4 — Fan Performance — 48P
Page 15 and 16: AIRFLOW (cfm) Table 10 — Fan Perf
Page 17: AIRFLOW (cfm) Table 12 — Fan Perf
Page 21 and 22: AIRFLOW (cfm) Table 16 — Fan Perf
Page 23 and 24: AIRFLOW (Cfm) LEGEND Table 18 — F
Page 29 and 30: AIRFLOW (cfm) LEGEND Bhp — Brake
Page 31 and 32: HIGH-EFFICIENCY MOTORS Nominal Maxi
Page 33 and 34: 2. Under the Setpoints menu, set th
Page 35 and 36: would use Period 2 and set days Sat
Page 37 and 38: there is a loss of communication be
Page 39 and 40: and when ON, the control sets a cap
Page 41 and 42: System Mode Test — When the syste
Page 43 and 44: Table 31 — Unit Configuration ITE
Page 45 and 46: SETTING UP THE SYSTEM Machine Contr
Page 47 and 48: High SST Alert Delay Time (H.SST)
Page 49 and 50: Table 36 — Cool/Heat Set Point Of
Page 51 and 52: Table 38 — Run Status Cool Displa
Page 53 and 54: To use Demand Limiting, select the
Page 55 and 56: Size 050, 055, 060 Contactor OFM(s)
Page 57 and 58: Whenever the outdoor ambient temper
Page 59 and 60: Demand Level Low Heat Off Offset (L
Page 61 and 62: Limit Switch Low Temp (SW.L.T) —
Page 63 and 64: STAGE Table 49 — IGC LED Indicato
Page 65 and 66: Table 50 — Static Pressure Contro
Page 67 and 68: Table 53 — Dirty Filter Switch Po
Page 69 and 70:
NOTE: If the user wishes to disable
Page 71 and 72:
the economizer modulates when attem
Page 73 and 74:
P = K * BP.P * (error) I = K * BP.I
Page 75 and 76:
its smoke. Closing the economizer (
Page 77 and 78:
Table 57 — Indoor Air Quality Con
Page 79 and 80:
Table 58 — Humidity Configuration
Page 81 and 82:
The default sensor is the return ai
Page 83 and 84:
TEMPERATURE COMPENSATED START LOGIC
Page 85 and 86:
Sensor Trim Configuration — The T
Page 87 and 88:
SUPPLY FAN VFD CONFIGURATION — Th
Page 89 and 90:
REMOTE SWITCH LOGIC CONFIGURATION (
Page 91 and 92:
Alarms and Alarm History for for an
Page 93 and 94:
Transducer Troubleshooting — The
Page 95 and 96:
Table 75 — 10K Thermistor vs Resi
Page 97 and 98:
TEMP RESISTANCE (F) (Ohms) -25 98,0
Page 99 and 100:
PRESSURE (PSIG) Table 80 — Suctio
Page 101 and 102:
Table 81 — Discharge Pressure Tra
Page 103 and 104:
Table 82 — Auto View of Run Statu
Page 105 and 106:
Table 84 — Cooling Information Di
Page 107 and 108:
equalize compressor oil levels. If
Page 109 and 110:
Table 91 — Alert and Alarm Codes
Page 111 and 112:
T072 (Evaporator Discharge Reset Se
Page 113 and 114:
This alarm will disable mechanical
Page 115 and 116:
This is the reverse of the Pressuri
Page 117 and 118:
117 a48-8408 Fig. 19 — Typical Po
Page 119 and 120:
OD ENTHALPY SWITCH LOW REMOTE OCCUP
Page 121 and 122:
Fig. 23 — Typical Electric Heat U
Page 123 and 124:
123 Fig. 25 — Typical Gas Heat Se
Page 125 and 126:
125 Fig. 27 — Component Arrangeme
Page 127 and 128:
ACCSY — Accessory ACC’Y — Acc
Page 129 and 130:
Table 93 — Rooftop Control Board
Page 131 and 132:
Table 96 — Control Expansion Modu
Page 133 and 134:
LEGEND IAQ — Indoor Air Quality V
Page 135 and 136:
the motor position to be configured
Page 137 and 138:
TIME EWT LWT SETP Run Status Servic
Page 139 and 140:
Fig. 37 — Door Latch Fig. 38 —
Page 141 and 142:
SUPPLY FAN AND POWER EXHAUST MOTOR
Page 143 and 144:
Routine cleaning of coil surfaces i
Page 145 and 146:
Saturated Discharge Temperature (de
Page 147 and 148:
Page 149 and 150:
Page 151 and 152:
Page 153 and 154:
Page 155 and 156:
Page 157 and 158:
Page 159 and 160:
Page 161 and 162:
Page 163 and 164:
Gas System Adjustment (48P Only) GA
Page 165 and 166:
APPENDIX A — LOCAL DISPLAY TABLES
Page 167 and 168:
Page 169 and 170:
Page 171 and 172:
Page 173 and 174:
Page 175 and 176:
Page 177 and 178:
APPENDIX B — CCN TABLES (cont) ST
Page 179 and 180:
APPENDIX B — CCN TABLES (cont) ST
Page 181 and 182:
APPENDIX B — CCN TABLES (cont) SE
Page 183 and 184:
Page 185 and 186:
Page 187 and 188:
APPENDIX B — CCN TABLES (cont) MA
Page 189 and 190:
APPENDIX B — CCN TABLES (cont) MA
Page 191 and 192:
TESTACTC TESTCOOL TESTFANS TESTHEAT
Page 193 and 194:
APPENDIX C — UNIT STAGING TABLES
Page 195 and 196:
* 41 for Supply Fan Motor VFD, 42 f
Page 197 and 198:
Fig. B — VFD Keypad START UP WITH
Page 199 and 200:
Upload All Parameters — To upload
Page 201 and 202:
To replace the main fan for frame s
Page 203 and 204:
ALARM CODE ALARM NAME IN PANEL 2001
Page 205 and 206:
APPENDIX E — MODE SELECTION PROCE
Page 207 and 208:
CONTROLS SET POINT AND CONFIGURATIO
Page 209 and 210:
Page 211 and 212:
Page 213 and 214:
show all

Controls, Start-Up, Operation, Service and ... - Climayoreo

Create successful ePaper yourself

Delete template?

Save as template?